SAFETY DATA SHEET Loctite Corporation Super Lube Grease with Teflon 0209000 1.00 IE EA 16.09.1998 MSDS_IE Environmental Health & Safety Affairs Health & Regulatory Affairs - Europe This safety data sheet has been prepared in accordance with the requirements of EC Directive 88/379/EEC and 91/155/EEC (and other related directives) and provides information relating to the safe handling and use of the product. 1. 2. PRODUCT AND COMPANY INFORMATION Product Code Trade Name Manufacturer/Supplier Address 0209000 Phone Number Fax Number Emergency Phone Number 01 707 358800 Loctite UK Watchmead, Welwyn Garden City, Herts., AL7IJB. 01 707 358900 +353-1-4599301/+353-1-87-2629625/+353-1-4046444 COMPOSITION / INFORMATION ON INGREDIENTS Nature 3. Super Lube Grease with Teflon Lubricant grease HAZARD IDENTIFICATION Not classified as hazardous. 4. FIRST AID MEASURES First Aid - Inhalation Should not be a problem as product is of low volatility. However, if feeling unwell remove patient to fresh air. First Aid - Skin Wash with plenty of soap and water. If irritation persists, seek medical advice. First Aid - Eyes Flush eyes with plenty of water for at least 15 minutes. If irritation persists seek medical attention. First Aid - Ingestion Rinse mouth with water then give plenty of water to drink. Do not induce vomiting. 5. FIRE FIGHTING MEASURES Non flammable product (flash point is greater than 150°C (CC)). If product is involved in fire extinguish with dry powder, foam or carbon dioxide. Wear self contained breathing apparatus. 6. ACCIDENTAL RELEASE MEASURES Contain spillage, and absorb onto an inert absorbent such as sand or multisorb and place in a sealed container for supervised disposal. Wash spillage site thoroughly with detergent and water. Try to prevent MSDS_IE Page 1 of 4 SAFETY DATA SHEET Loctite Corporation Super Lube Grease with Teflon 0209000 1.00 IE EA 16.09.1998 MSDS_IE Environmental Health & Safety Affairs Health & Regulatory Affairs - Europe 6. ACCIDENTAL RELEASE MEASURES the material from entering drains or water courses. 7. HANDLING AND STORAGE Handling Good industrial hygiene practices should be observed. In circumstances where there is a potential for prolonged or repeated skin contact, the use of disposable gloves (polyethylene, natural rubber or equivalent ester-resistant material) is recommended. Storage Keep in a cool, well-ventilated area. 8. EXPOSURE CONTROLS / PERSONAL PROTECTION Good industrial hygiene practices should be observed. In circumstances where there is a potential for prolonged or repeated skin contact, the use of disposable gloves (polyethylene, natural rubber or equivalent ester-resistant material) is recommended. 9. PHYSICAL AND CHEMICAL PROPERTIES Physical State Colour Odour pH Boiling Range/Point (°C) Flash Point (CC) (°C) Specific Gravity Solubility in Water (kg/m³) Solubility in Acetone Vapour Pressure (mmHg @25°C) Explosion Limits (%) 10. Grease White. None. Not applicable. No data. Exceeds 200°C. 0.89. Insoluble. Not listed. No data. No data. STABILITY AND REACTIVITY Stable under normal conditions. 11. TOXICOLOGICAL INFORMATION Inhalation Due to the low volatility of the product there are no hazards associated with inhalation under normal conditions of use. Skin Prolonged contact may cause some irritation. MSDS_IE Page 2 of 4 SAFETY DATA SHEET Loctite Corporation Super Lube Grease with Teflon 0209000 1.00 IE EA 16.09.1998 MSDS_IE Environmental Health & Safety Affairs Health & Regulatory Affairs - Europe 11. TOXICOLOGICAL INFORMATION Eyes May cause mild irritation to the eyes. Ingestion This product is considered to be of low toxicity having an acute oral LD50 (rat) >2000mg/kg by analogy to other similar products. 12. ECOLOGICAL INFORMATION Keep away from drains and open waters. 13. DISPOSAL CONSIDERATIONS Dispose of in accordance with local and national regulations. Standard procedures for 'water insoluble' non-toxic chemicals recommended. 14. TRANSPORT INFORMATION None UN Number Air (IATA) Sea (IMO) Road (ADR)/Rail (RID) 15. Not classified. Not classified. Not classified. REGULATORY INFORMATION N/A Contains Labelling Information None R phrases S phrases Voluntary Labelling 16. R - None None. N/A OTHER INFORMATION MSDS first issued 16 September 1998 Prepared by: Caroline Walsh MSc Health & Regulatory Affairs - Europe Further Information may be obtained from:Loctite Corporation, Health and Regulatory Affairs - Europe, Tallaght Business Park, Whitestown, Dublin 24, Ireland. MSDS_IE Page 3 of 4 SAFETY DATA SHEET Loctite Corporation Environmental Health & Safety Affairs Health & Regulatory Affairs - Europe 16. Super Lube Grease with Teflon 0209000 1.00 IE EA 16.09.1998 MSDS_IE OTHER INFORMATION Tel: +353-1-4046444. Fax: +353-1-4510806. The information in this safety data sheet was obtained from reputable sources and to the best of our knowledge is accurate and current at the mentioned date. Neither Loctite nor its subsidiary companies accept any liability arising out of the use of the information provided here or the use, application or processing of the product(s) described herein. Attention of users is drawn to the possible hazards from improper use of the product(s). Supersedes Safety Data Sheet No: 21033 dated 28th August 1998. MSDS_IE Page 4 of 4