Competence in Mobile Computing TREK-510 ITS/Telematics NEW ARM-based, In-Vehicle Computing Box Features ST ARM based STA2062 333 MHz CPU with Win CE Automotive grade working temperature range (-30 to 70° C) Rich I/O such as CAN, multi-COMs, isolation 4DI/4DO, line out, Mic in, USB, SD Built-in RF communication modules, such as GPRS/HSDPA/CDMA Certifications: CE, FCC, E-mark and MIL-STD-810G, ISO7637-2, SAE J1113, SAE J1455 regulations Ignition on/off delay; SW detectable/controllable for car power management E Introduction The TREK-510 is a dedicated box computer for industrial vehicle fleets, transport trucks, buses and taxis. TREK-510 combined with a variety of I/O connectors can be connected to devices like OBD-II or TPMS (Tire Pressure Monitoring System). Built-in wireless communications-WWAN enable TREK-510 to send important driver/vehicle/location/car information back to the control center. TREK-510 can also operate in extreme environments with features like a wide working temperature range (-30 to 70 degrees) and anti-shock/vibration design. TREK-510 also uses a special design to handle the critical issue of in-vehicle power. Special power protection (ISO7637-2/SAE J1455 Class A/ SAE J1113) and car power management software (Ignition on/off, delay on/off, low battery monitor) prevent electrical noise and surges from impacting the system, guarding against damage from transient car power. Specifications System Physical Storage Soc System Memory Watchdog RTC Operating System Dimensions Weight On Board Flash SD slot Display Interface Smart Display Port I/O CAN USB Host USB Client Mic In Line-out COM Port Isolation DI/DO Communication GPS LED WWAN RF Receiver Type Cold Start Warm Start Hot Start AGPS Acquisition Protocol Antenna LED indicator STM industrial degree STA2062 ARM9-based 333 Mhz RISC SOC Mobile DDR 128 MB Yes Yes, with one time 200 mAh coin battery Win CE 5.0 English core version as default 261 x 125 x 59.1 mm 1.5 kg 2 GB on board flash for bootloader, image & Customer's AP 1 x (external accessible) Design compatible with TREK-303L, 7" smart display, the signal includes: 18-bit LVDS out 1 x RS-232 1 x audio line out 1 x USB Host 12 V @ 1 A output 1 x CAN 2.0 A/B by DB9 with J1939 protocal 1 x USB 2.0 host port by type A 1 x USB Client by Mini Type AB 1 x RCA jack 1 x RCA jack COM 1&2: 2 x Full Function RS-232, 5 V/12 V @ 0.5 A, ping9, by jumper selection COM3: 1 x 4-wire RS-232/485 (controlled by software), 5 V/12 V @ 0.5 A, ping9, by jumper selection 4 x Isolated dry contact digital inputs from DB9 connector (2500 Vrms protection) 4 x relay driver from DB9 connector GPRS - Cinterion MC55i: Support GPRS class 10 (Quad-band) CDMA - Sierra Wireless MC 5728V: Support EV-DO REV A, EV-DO,CDMA (1900 MHz, 800 MHz) HSDPA - Sierra Wireless MC 8790V: Support EDGE, GPRS, GSM, HSDPA, HSUPA (GPRS/EDGE class B, multislot class 12) (Quad-band) 32 Channels (built-in), GPS L1 frequency, C/A code 50 channels, GPS L1 frequency (option) 39 s 29 s 33 s 29 s <1s <1s 3s <5s 145dBm 160dBm NMEA Input/output, ASCII, 0183, 2.3 (compatible to 3.0) SMA connector for external antenna Power (Red), GPS operation (Blue), WWAN link (Green), Status (Green) http://www.advantech-dlog.com Regional contact: All product specifications are subject to change without notice Last updated : 29-May-2012 Competence in Mobile Computing TREK-510 Specifications Cont. DC-Input Car Power Design Power Management HW Reset IP rating Operating Temp. Storage Temp. Vibration/shock EMC Safety Vehicle Power Regulations Environment Certifications Mechanical Material Supports 12/24V car power systems (6V ~ 36V wide DC input, ISO 7637, SAE J1113) Power on/off delay, Power on delay, 2 sec by default Power off delay, 5 sec by default Delay time allow control by SW configuration Low voltage protection Yes, 1 reset button IP31 -30° C ~ +70° C -40° C ~ +85° C MIL-STD-810G, Method 516.5 CE, FCC CE, CB E-mark, SAE J1455, SAE J1113, ISO7637-2, compliance Top cover (Aluminum extrusion) Side cover (PC) Bottom & I/O cover (metal) Dimensions Unit: mm 117.50 125.10 40 5. Ø 261 54.10 59.10 250 Ordering Information Part Number Packing List Description Vehicle computing system with ST 2062 processor, 128 MB RAM and 2 GB NAND flash, GPS, GPRS, Win CE 5.0 7" vehicle display system, 480 x 234 resolution, with 4 wire resistive touchscreen, 2-watt speaker 2-meter cable (paired with TREK-510) TREK-510-GCEA0E TREK-303R-LA0E 1700018342 Part Number TREK-510-GCEA0E 1700018306 1750001380 1750006080 2068051000 Description ARM-based, in-vehicle computing box Power cable GPS Antenna WWAN Antenna Startup manual CD Cable clip for MIC in, line out, USB host, USB client 19900018848T000 Quantity x1 x1 x1 x1 x1 x4 Fully Integrated I/O Mic in Power Status Line out USB Host WWAN GPS Smart Display Power Reset USB client WWAN ant. Ground RS-485/ RS-232 DI/DO RS-232 RS-232 CAN GPS ant. http://www.advantech-dlog.com Regional contact: