Ultra-Thin Fully Illuminated Paddles General Specifications B Electrical Capacity (Resistive Load) Logic Level: 0.4VA maximum @ 28V AC/DC maximum (Applicable Range 0.1mA ~ 0.1A @ 20mV ~ 28V) Note: Find additional explanation of operating range in Supplement section. Other Ratings Contact Resistance: 80 milliohms maximum Insulation Resistance: 500 megohms minimum @ 500V DC Dielectric Strength: 500V AC minimum for 1 minute minimum Mechanical Life: 50,000 operations minimum Electrical Life: 50,000 operations minimum Nominal Operating Force:1.0N Angle of Throw: 28° Materials & Finishes Actuator: Case: Sealing Ring: Base: Movable Contact: Stationary Contact: Terminals: Environmental Data Operating Temperature Range: Humidity: Vibration: Shock: Polycarbonate resin (UL94V-0) Glass fiber reinforced polyamide (UL94V-0) Nitrile butadiene rubber Glass fiber reinforced polyamide Phosphor bronze with gold plating Phosphor bronze with gold plating Phosphor bronze with gold plating –25°C through +55°C (–13°F through +131°F) 90 ~ 95% humidity for 240 hours @ 40°C (104°F) 10 ~ 55Hz with peak-to-peak amplitude of 1.5mm traversing the frequency range & returning in 5 minutes; 3 right angled directions for 2 hours 50G (490m/s2) acceleration (tested in 3 right angled directions, with 5 shocks in each direction) PCB Processing Soldering: Wave Soldering recommended. See Profile A in Supplement section. Manual Soldering: See Profile A in Supplement section. Cleaning: These devices are not process sealed. Hand clean locally using alcohol based solution. Standards & Certifications Flammability Standard: UL94V-0 actuator & case The GW Series illuminated paddles have not been tested for UL recognition or CSA certification. These switches are designed for use in a low-voltage, low-current, logic-level circuit. When used as intended in a logic-level circuit, the results do not produce hazardous energy. Supplement Accessories Indicators Touch Tilt Tactiles Slides Rotaries Keylocks Programmable Illuminated PB Pushbuttons Rockers Toggles Series GW B36 www.nkk.com Distinctive Characteristics B Pushbuttons World’s smallest fully illuminated paddles (patent pending) for highly visible status indication; LEDs available in red, green, or amber for single color and red/green for bicolor. Rockers Toggles Series GW Ultra-Thin Fully Illuminated Paddles Programmable Illuminated PB Specially designed switching mechanism provides crisp actuation feedback to positively indicate circuit transfer (patent pending). Keylocks Insert molded terminals prevent entry of flux and other contaminants. Slides Rotaries Award-winning STC contact mechanism with benefits unavailable in conventional mechanisms: smoother, positive detent actuation, increased contact stability, and unparalleled logic-level reliability. (Additional STC details in Terms & Acronyms; see Supplement section.) Indicators Touch Tilt Tactiles .100” x .100” (2.54mm x 2.54mm) terminal spacing conforms to standard PC board grid spacing for straight and angle mounting. Supplement Accessories Actual Size www.nkk.com B37 Series GW TYPICAL SWITCH ORDERING EXAMPLE GW B 1 2 L Pole 1 SPDT Circuit 2 ON L NONE D LED Colors PC Terminals Paddle ON J Clear Single Color P Straight C Red H Right Angle D Amber V Vertical F Green Bicolor CF DESCRIPTION FOR TYPICAL PADDLE ORDERING EXAMPLE Keylocks Clear Paddle Amber LED SPDT ON-NONE-ON Circuit Straight PC Terminals POLE & CIRCUIT Up Pole Center Down Connected Terminals Up Center Throw & Schematics Down Note: Terminal numbers are not actually on the switch. LED circuit is isolated and requires an external power source. Model (4) Red 2 (COM) SP GW12 ON NONE ON 2-3 OPEN 2-1 SPDT 3 (5) 1 (6) (5) Single Color Tilt Touch Indicators Accessories (6) Green Bicolor LED COLORS & SPECIFICATIONS Single Color Supplement Red/Green GW12LJPD Rotaries Slides P Actuator Color Paddle Position Tactiles J Actuator Programmable Illuminated PB Pushbuttons Rockers Toggles Ultra-Thin Fully Illuminated Paddles LEDs are an integral part of the the switch and not available separately. The electrical specifications shown are determined at a basic temperature of 25°C. If the source voltage exceeds the rated voltage, a ballast resistor is required. The resistor value can be calculated by using the formula in the Supplement section. B38 Colors Bicolor C D F CF Red Amber Green Red/Green Forward Peak Current I FM 25mA 25mA 25mA 25mA/25mA Typical Forward Current IF 20mA 20mA 20mA 20mA/20mA Forward Voltage VF 2.0V 2.1V 2.1V 2.0V/2.1V Reverse Peak Voltage VRM 4V 4V 4V 4V/4V Current Reduction Rate Above 25°C ∆I F 0.33mA/°C 0.33mA/°C 0.33mA/°C Ambient Temperature Range www.nkk.com –25°C ~ +55°C 0.33mA/°C Series GW Toggles Ultra-Thin Fully Illuminated Paddles TYPICAL SWITCH DIMENSIONS B (2.6) .102 (0.25) Typ .010 (2.54) .100 28° 1 4 2 5 3 6 4 1 5 2 6 3 (2.54) Typ .100 (0.6) Dia Typ .024 (2.54) Typ .100 (3.8) .150 (4.5) .177 (7.0) .276 (2.54) .100 (2.6) .102 5 & 6 are LED terminals; 4 is a support pin on single color models & an LED terminal on bicolor models. Right Angle PC Keylocks GW12LJPC 28° (7.0) .276 3 (2.75) .108 6 5 1 2 (2.54) Typ .100 (2.54) 3 .100 4 5 6 4 (0.5) .020 (2.54) .100 (5.08) .200 (0.4) Dia Typ .016 (2.54) Typ .100 (0.6) Dia Typ .024 5 & 6 are LED terminals; 4 is a support pin on single color models & an LED terminal on bicolor models. (0.25) Typ .010 (4.5) .177 (7.65) .301 (4.15) .163 Vertical PC Touch P/N This Side 28° 1 4 2 5 3 6 (2.75) .108 (0.5) Typ .020 (2.54) .100 (0.25) .010 (5.0) .197 GW12LJHD (3.8) .150 (5.08) .200 (12.76) .502 (0.5) Typ .020 (2.54) Typ .100 4 1 5 2 6 3 (2.54) .100 Indicators (0.25) .010 (5.08) .200 (10.22) .402 (5.08) .200 (7.5) .295 1 Tactiles (3.0) .118 (0.5) Typ .020 2 (4.5) .177 (2.6) .102 (5.15) .203 (2.9) .114 Slides P/N This Side (2.54) Typ .100 (5.08) .200 (0.4) Dia .016 (2.54) .100 (0.6) Dia Typ .024 5 & 6 are LED terminals; 4 is a support pin on single color models & an LED terminal on bicolor models. www.nkk.com Accessories (0.25) .010 Rotaries (3.8) .150 Tilt (7.0) .276 P/N This Side (0.4) Dia Typ .016 Pushbuttons (3.0) .118 GW12LJVCF B39 Supplement (0.25) Typ .010 Rockers Straight PC Programmable Illuminated PB