Series AMER150-AZ up to 6.3A | AC-DC / DC-DC | LED Driver / Converter Models Single output FEATURES: • AC-DC Constant Current or Constant Voltage LED Driver • Input range 90-305VAC/47-440Hz • High Efficiency up to 91% • Operating temperature -40 to 80°C • Dimming via analog/0-10V dimming • • • • • Max Output Power (W) ① Output Voltage Range ③ (V) Output Current ③ (A) Input Voltage (VAC/Hz) Input Voltage (VDC) 150 36-50 0-3 90-305/47-440 120-430 AMER150-36420AZ 150 24-36 0-4.16 90-305/47-440 120-430 AMER150-24630AZ 151.2 12-24 0-6.3 90-305/47-440 120-430 Model AMER150-50300AZ Over Voltage Protection Over Current Protection Waterproof Case rated IP68 Power Factor Correction Short Circuit Protection Mode of Operation Constant Current Constant Voltage ② Constant Current Constant Voltage ② Constant Current Constant Voltage ② Efficiency (%) 91 90 90 88 89 87 Add Suffix “-F” No dimming option Exceeding the maximum output power will permanently damage the converter. ② The dimming feature is not supported when units are used in Constant Voltage mode only, Aimtec suggests to order “-F” No dimming option in this case. ③ In constant current mode output current is maximum shown, in constant voltage mode output voltage is the maximum shown. NOTE: All specifications in this datasheet are measured at an ambient temperature of 25°C, humidity<75%, nominal input voltage and at rated output load unless otherwise specified. ① Input Specifications Parameters Inrush current <2ms Leakage current AC current Power Factor External fuse Start up time Surge voltage Output Specifications Parameters Conditions 115VAC 230VAC 115VAC 230VAC 115VAC 230VAC 115VAC 230VAC Typical 50 75 0.75 1 2.2 0.7 500 2sec Conditions Typical Current accuracy ±3 Line regulation LL-HL ±1 Load regulation 0-100% load ±3 20MHz Bandwidth 75 Ripple & Noise ④ Hold-up time (min) 45 Current adjustment range 100-0 ④ Tested with 0.1µF (C/C) or (M/C) and 47µF (E/C) parallel capacitors at the end. www.aimtec.com F 052.1e R3.T Tel: +1 514 620 2722 1 of 11 Maximum Units A mA A 0.98 0.94 250V/3.5A 440 ms V Maximum Units % % % mV p-p ms % Toll free: + 1 888 9 AIMTEC (924 6832) North America only Series AMER150-AZ up to 6.3A | AC-DC / DC-DC | LED Driver / Converter Isolation Specifications Parameters Tested I/O voltage Isolation Resistance Isolation Capacitance Conditions Typical 3sec 500VDC General Specifications Parameters Switching frequency Over current protection Over voltage protection Short circuit protection Short circuit restart Over temperature protection Operating temperature Maximum case temperature Storage temperature Temperature coefficient Cooling Humidity Case material Potting Wires Weight Dimensions (L X H X W) MTBF >1000 Conditions Maximum Units 3000 VAC MΩ pF 1000 Typical Maximum 100 95-110% of Iout 110% of Vout Continuous Auto recovery >105°C -40 to +80 See derating table Units KHz o 100 -40 to +95 ±0.02 Free air convection Aluminum Epoxy (IP67 rated) UL1015 18AWG input & 14AWG output *20CM 750 7.13 x 2.32 x 1.85 inches 181.00 x 59.00 x 47.00 mm >400,000 hrs (MIL-HDBK-217F at +25°C) 95 C C o C o %/ C o % RH g Safety Specifications Parameters Agency approvals Standards www.aimtec.com F 052.1e R3.T cULus, CE UL8750, UL60950-1, EN55022, class B, EN60529(IP68), EN61347-1, EN61347-2-13 Information Technology Equipment EN55022 Class B Harmonic Current Emissions IEC/EN 61000-3-2, Class C Voltage fluctuations and flicker IEC/EN 61000-3-3, (EN60555-3) Electrostatic Discharge Immunity IEC 61000-4-2 RF, Electromagnetic Field Immunity IEC 61000-4-3 Electrical Fast Transient / Burst Immunity IEC 61000-4-4 Surge Immunity IEC 61000-4-5 RF, Conducted Disturbance Immunity IEC 61000-4-6 Power frequency Magnetic Field Immunity IEC 61000-4-8 Voltage dips, Short Interruptions Immunity IEC 61000-4-11 Tel: +1 514 620 2722 2 of 11 Toll free: + 1 888 9 AIMTEC (924 6832) North America only Series AMER150-AZ up to 6.3A | AC-DC / DC-DC | LED Driver / Converter Dimensions www.aimtec.com F 052.1e R3.T Tel: +1 514 620 2722 3 of 11 Toll free: + 1 888 9 AIMTEC (924 6832) North America only Series AMER150-AZ up to 6.3A | AC-DC / DC-DC | LED Driver / Converter Analog (resistive) Dimming Application Circuit AC BROWN L GREEN +Vout AMER150-AZ BLUE N RED 1 Model Number 1st LED AMER150-50300AZ AMER150-36420AZ AMER150-24630AZ -Vout Maximum Pot Value (kΩ) 19.00 28.00 27.00 1 BLUE WHITE BLACK Pot \ 0-10V Dimming Application Circuit U1 +Vs (Blue) 0-10Vdc Pin 1 -Vs (White) R28 1K5, 0805 Pin 2 LTV-817C GND www.aimtec.com F 052.1e R3.T Tel: +1 514 620 2722 4 of 11 Toll free: + 1 888 9 AIMTEC (924 6832) North America only Series AMER150-AZ up to 6.3A | AC-DC / DC-DC | LED Driver / Converter Derating Free Air Convection CV mode CC Mode 50°C 50°C 100 Output Power (%) 230VAC 80 60 Safe Operating Area 40 20 - 40 80°C 80°C 0 - 20 0 20 40 60 80 100 Ambient Temperature º C www.aimtec.com F 052.1e R3.T Tel: +1 514 620 2722 5 of 11 Toll free: + 1 888 9 AIMTEC (924 6832) North America only Series AMER150-AZ up to 6.3A | AC-DC / DC-DC | LED Driver / Converter Efficiency vs. Input Voltage & Output Current (CC mode) AMER150-50300AZ AMER150-36420AZ www.aimtec.com F 052.1e R3.T Tel: +1 514 620 2722 6 of 11 Toll free: + 1 888 9 AIMTEC (924 6832) North America only Series AMER150-AZ up to 6.3A | AC-DC / DC-DC | LED Driver / Converter Efficiency vs. Input Voltage & Output Current (CC mode) Continued AMER150-24630AZ PFC value vs. Output Load Current (CC mode) AMER150-50300AZ www.aimtec.com F 052.1e R3.T Tel: +1 514 620 2722 7 of 11 Toll free: + 1 888 9 AIMTEC (924 6832) North America only Series AMER150-AZ up to 6.3A | AC-DC / DC-DC | LED Driver / Converter PFC value vs. Output Load Current (CC mode) Continued AMER150-36420AZ AMER150-24630AZ www.aimtec.com F 052.1e R3.T Tel: +1 514 620 2722 8 of 11 Toll free: + 1 888 9 AIMTEC (924 6832) North America only Series AMER150-AZ up to 6.3A | AC-DC / DC-DC | LED Driver / Converter Constant Current vs. Constant Voltage Mode AMER150-50300AZ AMER150-36420AZ www.aimtec.com F 052.1e R3.T Tel: +1 514 620 2722 9 of 11 Toll free: + 1 888 9 AIMTEC (924 6832) North America only Series AMER150-AZ up to 6.3A | AC-DC / DC-DC | LED Driver / Converter Constant Current vs. Constant Voltage Mode Continued AMER150-24630AZ Output Current vs. Radj AMER150-50300AZ www.aimtec.com F 052.1e R3.T Tel: +1 514 620 2722 10 of 11 Toll free: + 1 888 9 AIMTEC (924 6832) North America only Series AMER150-AZ up to 6.3A | AC-DC / DC-DC | LED Driver / Converter Output Current vs. Radj Continued AMER150-36420AZ AMER150-24630AZ NOTE: 1. Datasheets are updated as needed and as such, specifications are subject to change without notice. Once printed or downloaded, datasheets are no longer controlled by Aimtec; refer to www.aimtec.com for the most current product specifications. 2. Product labels shown, including safety agency certifications on labels, may vary based on the date manufactured. 3. Mechanical drawings and specifications are for reference only. 4. All specifications are measured at an ambient temperature of 25°C, humidity<75%, nominal input voltage and at rated output load unless otherwise specified. 5. Aimtec may not have conducted destructive testing or chemical analysis on all internal components and chemicals at the time of publishing this document. CAS numbers and other limited information are considered proprietary and may not be available for release. 6. This product is not designed for use in critical life support systems, equipment used in hazardous environments, nuclear control systems or other such applications which necessitate specific safety and regulatory standards other the ones listed in this datasheet. 7. Warranty is in accordance with Aimtec’s standard Terms of Sale available at www.aimtec.com. www.aimtec.com F 052.1e R3.T Tel: +1 514 620 2722 11 of 11 Toll free: + 1 888 9 AIMTEC (924 6832) North America only