Frontier Electronics Corp. 667 E. COCHRAN STREET, SIMI VALLEY, CA 93065 TEL: (805) 522-9998 FAX: (805) 522-9989 E-mail: [email protected] Web: http://www.frontierusa.com 1A GENERAL PURPOSE PLASTIC RECTIFIER 1N4007 (1300V) FEATURES z UL 94V0 FLAME RETARDANT EPOXY MOLDING COMPOUND z DIFFUSED JUNCTION z LOW COST z HIGH SURGE CURRENT CAPABILITY 1.0(25.4) MIN .034(0.9) .028(0.7) .205(5.2) .166(4.2) .107(2.7) .080(2.0) MECHANICAL DATA z CASE: TRANSFER MOLDED, DO41, DIMENSIONS IN INCHES AND (MILLIMETERS) z LEADS: SOLDERABLE PER MIL-STD-202, METHOD 208 z POLARITY CATHODE INDICATED BY COLOR BAND z WEIGHT: 0.34 GRAMS 1.0(25.4) MIN MAXIMUM RATINGS AND ELECTRICAL CHARACTERISTICS RATINGS AT 25°C AMBIENT TEMPERATURE UNLESS OTHERWISE SPECIFIED SINGLE PHASE, HALF WAVE, 60 HZ, RESISTIVE OR INDUCTIVE LOAD. FOR CAPACITIVE LOAD, DERATE CURRENT BY 20% RATINGS MAXIMUM RECURRENT PEAK REVERSE VOLTAGE MAXIMUM RMS VOLTAGE MAXIMUM DC BLOCKING VOLTAGE MAXIMUM AVERAGE FORWARD RECTIFIED CURRENT 0.375” (9.5mm) LEAD LENGTH AT TA=55°C PEAK FORWARD SURGE CURRENT, 8.3ms SINGLE HALF SINE-WAVE SUPERIMPOSED ON RATED LOAD TYPICAL JUNCTION CAPACITANCE (NOTE 1) STORAGE TEMPERATURE RANGE OPERATING TEMPERATURE RANGE SYMBOL VRRM VRMS VDC 1N4007 1300 910 1300 UNITS V V V IO 1.0 A IFSM 30 A CJ TSTG TOP 15 -55 TO + 175 -55 TO + 175 PF ºC ºC 1N4007 1.1 5 UNITS V μA ELECTRICAL CHARACTERISTICS (AT TA =25 ºC UNLESS OTHERWISE NOTED) CHARACTERISTICS SYMBOL MAXIMUM FORWARD VOLTAGE AT IO DC VF MAXIMUM REVERSE CURRENT AT 25 ºC IR NOTE: 1. MEASURED AT 1MHZ AND APPLIED REVERSE VOLTAGE OF 4.0 VOLTS 1N4007 (1300V) Page: 1 +6 +4 +2 VZ@IZT RANGE 0 -2 -4 2 3 4 5 6 7 8 9 10 11 12 100 70 50 30 20 ( mV/ºC) +8 θVZ, TEMPERATURE COEFFICIENT FIG.1B- Range for Units to 12 to 100 Volts +10 ( mV/ºC) θVZ, TEMPERATURE COEFFICIENT FIG.1A- Range for Units to 12 Volts +12 10 7 5 3 2 VZ@IZT RANGE 1 10 20 30 50 VZ, ZENER VOLTAGE (VOLTS) VZ, ZENER VOLTAGE (VOLTS) 70 100 Figure 2. Temperature Coefficients (-55ºC to+150ºC temperature change; 90% of the units are in the ranges indicated.) 125 100 75 50 25 0 0 0.1 0.2 VZ@IZ TA=25ºC +4 ( mV/ºC) θVZ, TEMPERATURE COEFFICIENT +6 150 RESISTANCE (mV/ºC/W) θJL, JUNCTION TO LEAD THERMAL 175 20mA +2 0.01mA 0 1mA -2 NOTE:BELOW 3 VOLTS AAND ABOCE 8 VOLTS CHANGES IN ZENER CURRENT DO NOT EFFECT TEMPERATURE COEFFICIENTS -4 3 0.3 0.4 0.5 0.6 0.7 0.8 0.9 1.0 4 L, LEAD LENGTH TO HEAT SINK (INCHES) 200 6 7 8 Figure 4. Effect of Zener Current 400 300 200 Tj=25ºC Iz(ms)=0.1Iz(do) f=60hz Iz=1mA C, CAPACITANCE (PF) 0VBIAS 100 70 50 20 5mA 20mA 10 7 5 2 1 1 2 3 5 7 10 20 30 50 70 100 100 0VBIAS 50 20 10 8 50%OF BREAKDOWNBIAS 4 VZ, ZENER CURRENT (mA) 1 2 5 10 20 50 VZ, NOMINAL VZ (VOLTS) Figure. 7 - Power Temperature Derating Curve PD ,MAXIMUM DISSIPATION (WATTS) ZZ DYNAMIC IMPEDANCE (OHNS) Figure 3. Typical Thermal Resistance versus Lead Length 1000 700 500 5 VZ, ZENER VOLTAGE (VOLTS) 1.25 1.0 0.75 0.5 0.25 0 1N4007 (1300V) 20 40 60 80 100 120 140 160 TL, LEAD TEMPERATURE (OC) 180 200 Page: 1 100