AL244-EVB-A1 Evaluation Board User Manual Version 1.0 INFORMATION FURNISHED BY AVERLOGIC IS BELIEVED TO BE ACCURATE AND RELIABLE. HOWEVER, NO RESPONSIBILITY IS ASSUMED BY AVERLOGIC FOR ITS USE, OR FOR ANY INFRINGEMENTS OF PATENTS, OR OTHER RIGHTS OF THIRD PARTIES THAT MAY RESULT FROM ITS USE. NO LICENSE IS GRANTED BY IMPLICATION OR OTHERWISE UNDER ANY PATENT OR PATENT RIGHTS OF AVERLOGIC. Document Number: 1-M-PMK344-0101 ©2006-2009 Copyright by AverLogic Technologies, Corp. Amendments 20090323 Release version 1.0 THE INFORMATION CONTAINED HEREIN IS SUBJECT TO CHANGE WIHOUT NOTICE. Disclaimer THE CONTENTS OF THIS DOCUMENT ARE SUBJECT TO CHANGE WITHOUT NOTICE. AVERLOGIC TECHNOLOGIES RESERVES THE RIGHT TO MAKE CHANGES WITHOUT FURTHER NOTICE TO ANY PRODUCTS HEREIN TO IMPROVE RELIABILITY, FUNCTION OR DESIGN. AVERLOGIC DOES NOT ASSUME ANY LIABILITY ARISING OUT OF THE APPLICATION OR USE OF ANY PRODUCT OR CIRCUIT DESCRIBED HEREIN; NEITHER DOES IT CONVEY ANY LICENSE UNDER ITS PATENT RIGHTS, NOR THE RIGHTS OF OTHERS. CUSTOMERS ARE ADVISED TO CONSULT WITH AVERLOGIC OR ITS COMMERCIAL DISTRIBUTORS BEFORE ORDERING. ©2006-2009 Copyright by AverLogic Technologies, Corp. Contents 1 Introduction ................................................................................................................................................. 4 1.1 Introduction ...................................................................................................................................... 4 1.2 Features ............................................................................................................................................ 4 1.3 Block Diagram................................................................................................................................. 5 2 Hardware Section ................................................................................................................................... 6 2.1 Main Board....................................................................................................................................... 6 2.2 Front side .......................................................................................................................................... 7 2.3 Rear side ......................................................................................................................................... 8 2.4 Switch definitions ............................................................................................................................. 9 2.5 Keypad definitions:........................................................................................................................... 9 2.6 Decoder output bus definitions......................................................................................................... 9 2.7 16-Channel Input.........................................................................................................................11 ©2006-2009 Copyright by AverLogic Technologies, Corp. 1 Introduction 1.1 Introduction AverLogic’s AL244 is a high quality 4-in-1 video decoder. It combines four stand alone multistandard video decoders and includes 2D Comb filter for high level video surveillance applications. The AL244 EVB supports CVBS, S-video and Component inputs. It decodes NTSC/PAL/SECAM from this input interface and converts it into YCbCr 4:2:2 or RGB- 565 digital video data through the programmable data bus. The EVB combines the AverLogic AL244 Decoder with the Philips SAA7105 Encoder. The input interfaces include four CVBS interfaces, two S-Video interfaces and one component interface. It also provides CVBS and S-Video output interfaces. The digital interface has an additional feature that allows it to interface through the AL244 decoder kernel. 1.2 Features Analog Input • Four 10-bit ADC, AGC & ACC (Automatic Clamping Control) • Supports Auto Multi-Standard NTSC/PAL/SECAM mode detection • Supports Weak & Non-Standard Signal mode detection • Adaptive 2D Comb-Filter video decoding for Y/C separation Digital video output • Supports four digital ITU-R 656 8-bit outputs with four-video-decoder mode. • Supports two ITU-R 601 16-bit outputs with two-video-decoder mode. • Supports RGB 565 16-bit output with two-video-decoder mode. Video Processing • Closed Caption/V-Chip/WSS/WSS-J VBI decoding. 4-Decoder Mode (A,B,C and D) • 4 analog CVBS inputs for each of the four video decoders • Standard ITU-R BT 656 format 8-bit outputs • 4 RTSO (Real Time Status Output) signals for each of the 4 video decoders • 2 Fast Channel-Switching I/O’s for each decoder 2-Decoder Mode ( AB and CD) • Each of the 2 video decoders support S-Video and Component inputs • Standard ITU-R BT 656 format 8-bit outputs • Standard ITU-R BT 601 format 16-bit outputs • Digital RGB output ( 8-bit for Green channel,6-bit for Red and Blue Channels ) • 4 RTSO (Real Time Status Output) signals for each of the 2 video decoders Miscellaneous • 1.8V core logic. 3.3V I/O with 5V tolerance • Controlled via 2-wire serial-bus interface. All 4 video decoders require only one serial bus and share one slave address • Requires only one crystal for all 4 video decoders • Supports interrupt output pin for hardware mode detection • Built-in Test Pattern Generator ©2006-2009 Copyright by AverLogic Technologies, Corp. • • Low power consumption Small-size and Lead Free Package LQFP-128 (14x14mm) and LQFP-80 (10x10mm) 1.3 Block Diagram Digital data outputx4 & signal output x4 CVBS X4 / S-Video X2 / Component X1 Test AL244LF1/2 Encoder CVBS / S-Video / Compon ent Encoder CVBS Encoder CVBS Encoder CVBS MCU Keypad/Sw Reserved ©2006-2009 Copyright by AverLogic Technologies, Corp. 2 Hardware Section 2.1 Main Board Component 1 CVBS S-VIDEO J5 S2 4 CON15 CON16 CON17 1 S1 SW3 CON1 1 2 1 S3 CON6 244-LF2 U2 244-LF1 U1 S4 J17 S6 S5 MCU U3 1 SW1 SW2 SW4 SW5 CON2 CON3 2 D9 D10 D11 U12 JDC1 PW CON13 CVBS D12 7105 7105 J3 Component Reserved ©2006-2009 Copyright by AverLogic Technologies, Corp. 7105 7105 CON18 CON9 CVBS S-VIDEO I/O Port Descriptions Main Board Power Jack Component In CVBS-Video In S-Video In Component Out CVBS-Video Out S-Video Out JDC1 12V DC power input port (recommended current more than 1A) J5 Component video signal input port CON15 CVBS Video signal input port CON16/17 S-VIDEO signal input port J3 Component video signal output port (reserved) CON18 CVBS Video signal output port CON9 S-VIDEO signal output port (reserved) Note: Power Jack: 2.2 Front side S-Video 1 S-Video 2 1 4 2 3 CVBS 1 2 3 Component Front side I/O Port Descriptions S-Video 1 S-Video 2 CVBS 1 IN CVBS 2 IN CVBS 3 IN CVBS 4 IN Component In CON17 CON16 CON15 CON15 CON15 CON15 J5 J5 J5 S-video signal to AL244-LF1 decoder A/B S-video signal to AL244-LF1 decoder C/D CVBS Video signal to decoder A CVBS Video signal to decoder B CVBS Video signal to decoder C CVBS Video signal to decoder D 1.Y to decoder A 2.Pb to decoder B 3.Pr to decoder B ©2006-2009 Copyright by AverLogic Technologies, Corp. 7 2.3 Rear side PW Component 4 2 3 1 CVBS S-Video 1 Rear side Descriptions Power JDC1 Component out J3 CVBS 1 out CVBS 2 out CVBS 3 out CVBS 4 out S-Video 1 out CON18 CON18 CON18 CON18 CON9 12V DC power input port (recommended current more than 1A) 1.Y to decoder A (reserved) 2.Pb to decoder B (reserved) 3.Pr to decoder B (reserved) Encoder 1 output Encoder 2 output (reserved) Encoder 3 output (reserved) Encoder 4 output (reserved) Encoder 1 S-video signal output (reserved) ©2006-2009 Copyright by AverLogic Technologies, Corp. 8 2.4 Switch definitions SW2: Video format / input source selector 0000= NTSC, 0001= PAL SW1: Video output signal selector 0001= Flip LLC 0010=Color bar 0100=Multi-burst 1000=Color Ramp SW3: Video quality selector 0000 : Contrast 0001 : Brightness 0010 : Saturation 0100 : Hue (input) (input) (input) (input) SW4: decoder function selector 0000 : PLL for decoder and LLC out 0001 : X’in for decoder and LLC 0010 : Double edge X’in for decoder and LLC 0100 : 54 MHz CIF out 1000 : 54 MHz D1 2 decoder mode 1111 : 54 MHz Ext’clock in 27 LLC out 2.5 Keypad definitions: SW5 : Up SW4 : Enter / Menu SW2 : Down SW1 : Store 2.6 Decoder output bus definitions CON2 PIN1 PIN2 PIN3 PIN4 PIN5 A D0 A D1 A D2 A D3 A D4 ©2006-2009 Copyright by AverLogic Technologies, Corp. 9 PIN6 PIN7 PIN8 PIN9 PIN10 PIN11 PIN12 PIN13 PIN14 PIN15 PIN16 PIN17 PIN18 PIN19 PIN20 PIN21 PIN22 PIN23 PIN24 PIN25 PIN26 PIN27 PIN28 PIN29 PIN30 PIN31 PIN32 PIN33 PIN34 PIN35 PIN36 PIN37 PIN38 PIN39 PIN40 A D5 A D6 A D7 GND GND A LLC A LLC2 GND GND A RTSO 0 A RTSO 1 A RTSO 2 A RTSO 3 GND GND B D0 B D1 B D2 B D3 B D4 B D5 B D6 B D7 GND GND NC B LLC GND GND B RTSO 0 B RTSO 1 B RTSO 2 B RTSO 3 +5V +5V CON3 PIN1 PIN2 PIN3 PIN4 PIN5 PIN6 PIN7 PIN8 PIN9 PIN10 PIN11 PIN12 PIN13 PIN14 PIN15 PIN16 C D0 C D1 C D2 C D3 C D4 C D5 C D6 C D7 GND GND C LLC C LLC2 GND GND C RTSO 0 C RTSO 1 ©2006-2009 Copyright by AverLogic Technologies, Corp. 10 PIN17 PIN18 PIN19 PIN20 PIN21 PIN22 PIN23 PIN24 PIN25 PIN26 PIN27 PIN28 PIN29 PIN30 PIN31 PIN32 PIN33 PIN34 PIN35 PIN36 PIN37 PIN38 PIN39 PIN40 2.7 C RTSO 2 C RTSO 3 GND GND D D0 D D1 D D2 D D3 D D4 D D5 D D6 D D7 GND GND NC D LLC GND GND D RTSO 0 D RTSO 1 D RTSO 2 D RTSO 3 +5V +5V 16-Channel Input (AL244C-LF1-PBF) CON1 PIN1 PIN2 PIN3 PIN4 PIN5 PIN6 PIN7 PIN8 PIN9 PIN10 PIN11 PIN12 PIN13 PIN14 PIN15 PIN16 PIN17 PIN18 PIN19 PIN20 PIN21 PIN22 PIN23 PIN24 AI3_A GND AI2_A GND AI2_A GND AI3_B GND AI2_B GND AI1_B GND AI1_D GND AI2_D GND AI3_D GND AI1_C GND AI2_C GND AI3_C GND ©2006-2009 Copyright by AverLogic Technologies, Corp. 11 CONTACT INFORMATION AverLogic Technologies, Corp. URL: http://www.averlogic.com ©2006-2009 Copyright by AverLogic Technologies, Corp. 12