- HiTRON Electronics Corporation

H HiTRON
UNIVERSAL AC INPUT HARMONIC CORRECTION AC-DC HOT-SWAP
CompactPCI SERIAL SINGLE OUTPUT WITH STANDBY 312 WATTS
ACTIVE CURRENT SHARING SWITCHING POWER SUPPLIES
HAC300S SERIES
FEATURES:








312W 3U X 8HP EUROCARD PACKAGE
WIDE OPERATING TEMPERATURE RANGE
OF -40°C TO +70 °C
MEET IEC 61000-3-2 HARMONIC CORRECTION
N+1 REDUNDANCY/HOT-SWAPPABLE
80 Plus GOLD EFFICIENCY
ACTIVE CURRENT SHARING
PMBus COMMUNICATION
FULLY COMPLIANT WITH PICMG
SPECIFICATION
INPUT SPECIFICATION
OUTPUT SPECIFICATION
Input Voltage: Typ. 90-264Vac.
Power Factor Correction: Meet Harmonic Correction
IEC 61000-3-2.Power Factor typ. 0.98-0.99.
Input Connector: FCI 51939-667LF.
Input Frequency: 47-63Hz.
Inrush Current: 5.3Arms at 230Vac.
Input Current: 3A at 115Vac/1.5A at 230Vac.
Dielectric Withstand: Meet IEC 60950-1 regulation.
EMI: Meet EN 55022 / FCC Class B.
Hold-up Time: 18mS at 115 & 230Vac.
Leakage Current: Less than 0.7mA at 230Vac.
Power Fail Signal: Available at [FAL#] pin.
Remote ON/OFF: Available.
Status LED: <Green> means valid input voltage.
<Red> means a critical fault.
<Green> means DC OK.
Thermal Protection (OTP): Installed NTC and
thermostat for thermal sensor at [DEG#] pin.
Output Voltage: See Ratings Chart.
Output Current: See Ratings Chart.
Output Wattage: Typ. 312W continuous.
Output Connector: FCI 51939-667LF.
Line Regulation: Typ. 1%.
Load Regulation: VO1 Typ. ±1%./ Standby Typ. ±5%
Noise & Ripple: Typ. 1% peak to peak.
OVP: Built-in at all outputs.
Adjustability: Available for VO1.
Remote Sensing: Available for VO1.
DC OK: Available for VO1 & +5Vsb.
Hot-Swap: Available.
N+1 Redundancy: Installed with internal OR-ing diodes
at all outputs for N+1 redundancy operation.
Current Sharing: Active current sharing at VO1.
Overload Protection (OLP): Fully protected against output
overload or short circuit. OLP set at 120-130% peak
current at 115Vac. Consult the factory for special
OLP setting.
GENERAL SPECIFICATION
Efficiency: Typ. 90% at 230Vac.
Switching Frequency: 85-100K Hz.
Circuit Topology: LLC circuit.
Transient Response: Peak transient less than 134mV and
recovers within 0.5mS after 25% load-change.
Safety Standard: IEC 60950-1 Class I.
Construction: 3U X 8HP CompactPCI format.
Front Panel with Extractor handle.
Operating Temperature: -40 °C to +70 °C (see note 3),
derate linearly from 100% power at +50 °C to
60% power at +70 °C (Refer to derating curve).
Storage Temperature: -45 to +85 °C.
Cooling: At least 200 LFM moving air is required to achieve
full rating power 312W in a confined area.
Power Density: 5.7 Watts/ Cubic Inch.
NOTE: (1)All measurement are at nominal input, full load and +25°C unless otherwise specifications.
(2)Due to requests in market and advances in technology, specifications subject to change without notification.
(3)A warm-up time 10 minutes is required after cold start at temperature from -40 °C to +0°C.
(4)Tantalum capacitors connected to system is suggested for bettering Ripple & Noise against operating temperature from -40°C to +0°C.
(5)125 degree C OS-CON Long-life Solid capacitors are installed in secondary circuits.
Hitron Electronics Corporation. B4-11, P.O. Box 26-110 Kaohsiung Export Processing Zone Kaohsiung 806 Taiwan
TEL: 886-7-8210410/FAX: 886-7-8419917, 886-7-8210511/E-mail: [email protected]/Web-site: www.hitron-e.com
-1Edited on May 1, 2015 OUTPUT VOLTAGE / CURRENT RATINGS CHART
QUAD OUTPUT
MODEL NO.
HAC300S-D120E
MAIN [email protected]
Typ.
Max.
Volt.
25.0A
25.0A
12V
Min.
0A
Peak
28.0A
Min.
0A
STANDBY VO2★☉
Typ.
Max.
Volt.
2.5A
2.5A
5V
Peak
3.0A
Symbol: "★" OVP built-in. "@" Adjustable. "#" Remote sensing. "≡" Active Load Sharing. ."☉" Installed with Or-ing diode.
Remark: 1.Peak load less than 60sec. with duty cycle <10%.
2.Max. load is the continuous operating load of each rail. But the max. load of each rail can't be drawn from all outputs at the same time.
3.Please consult the factory if you have the special min load request of VO1.
WEIGHT: 710 g (25.1 Oz.)
MECHANICAL DIMENSIONS: MM [INCHES]
DERATING CURVE
INPUT & OUTPUT CONNECTORS PIN ASSIGNMENT
P1
LINE
P2
NEUTRAL
P3
GND
P4
N/A
P5
N.A
D1
D2
D3
D4
D5
D6
N/A
FAL
PS_P
COM
DEG
5Vsb
C1
C2
C3
C4
C5
C6
N/A
N/A
COM
A0
ALERT
5Vsb
B1
B2
B3
B4
B5
B6
N/A
12VCS
PSON
A1
SCL
COM
A1
A2
A3
A4
A5
A6
N/A
-VS
+VS
A2
SDA
EN
P6
P7
P8
P9
COM
COM
VO1
+12V
VO1
+12V
Remark: mating connector FCI 51940-350LF
Hitron Electronics Corporation. B4-11, P.O. Box 26-110 Kaohsiung Export Processing Zone Kaohsiung 806 Taiwan
TEL: 886-7-8210410/FAX: 886-7-8419917, 886-7-8210511/E-mail: [email protected]/Web-site: www.hitron-e.com
-2Edited on May 1, 2015