DC-DC PCB MOUNTED CONVERTERS & POWER MODULES MAH 16 Series 166 1 7 - 3 0 W AT T S - D C / D C S I N G L E & M U LT I O U T P U T FEATURES • • • • • • • • 2:1 Input range Regulated ouutput Pi input filter External output trimming Efficiency to 85% 300 kHz switching frequency Remote ON/OFF control Six sided shield metal case SPECIFICATIONS TECHNICAL ILLUSTRATION INPUT Nominal voltage 12V, 24V, 48V. Voltage range 9-18V, 18-36V, 36-72V. Isolation 500VDC. Filter PI-type OUTPUT Power 17W, 25W, 30W. Regulation Line:Single/Dual ±0.5% max Triple ±1.0% max Load transient response <480µs. Setting accuracy Single: ±2.0 max Dual: ±2.0% & ±3% Triple:±2% & ±5% max Ripple and noise Max. 75 mVp-p. Short circuit protection Fold-back. Approx 80% of output current at short circuit. Temp coefficient ±0.02 %/°C. Efficiency 75% to 85%. ENVIRONMENTAL Operating temperature -25°C to +71°C. Storage temperature -55°C to +105°C. Cooling Convection. GENERAL MTTF 200 000 hours at 25°C ambient. Switching frequency Min. 300 kHz. Equivalent capacitance 1400 pF. Case Black coated copper with non-conductive base. Dimensions (H x W x L) 10.2 x 50.8 x 50.8 mm. Weight 65g. Doc. No. PBC9 Rev.C 28-4-11 MAH 16 Series SELECTION TABLE POWERBOX ARTICLE NUMBER INPUT VOLTAGE VDC OUTPUT VOLTAGE VDC OUTPUT CURRENT MA INPUT CURRENT NO LOAD MA INPUT CURRENT FULL LOAD MA MAH 16 003 9-18 3.3 5000 30 1860 MAH 16 006 9-18 5 5000 30 2675 MAH 16 009 9-18 12 2500 30 3050 MAH 16 012 9-18 15 2000 30 3050 MAH 16 015 9-18 ±5 2500 35 2675 MAH 16 018 9-18 ±12 1250 35 3050 MAH 16 021 9-18 ±15 1000 35 3050 MAH 16 024 9-18 5/ ±12 3500/310 35 2640 MAH 16 027 9-18 5/ ±15 3500/250 35 2640 MAH 16 030 18-36 3.3 5000 30 920 MAH 16 033 18-36 5 5000 30 1336 MAH 16 036 18-36 12 2500 30 1525 MAH 16 039 18-36 15 2000 30 1525 MAH 16 042 18-36 ±5 2500 30 1336 MAH 16 045 18-36 ±12 1250 30 1470 MAH 16 048 18-36 ±15 1000 30 1470 MAH 16 051 18-36 5/ ±12 3500/310 30 1320 MAH 16 054 18-36 5/ ±15 3500/250 30 1320 MAH 16 057 36-72 3.3 5000 20 460 MAH 16 060 36-72 5 5000 20 660 MAH 16 063 36-72 12 2500 20 765 MAH 16 066 36-72 15 2000 20 765 MAH 16 069 36-72 ±5 2500 25 660 MAH 16 072 36-72 ±12 1250 25 735 MAH 16 075 36-72 ±15 1000 25 735 MAH 16 078 36-72 5/ ±12 3500/310 25 655 MAH 16 081 36-72 5/ ±15 3500/250 25 655 EXTERNAL OUTPUT TRIMMING PIN CONNECTION PIN SINGLE OUTPUT DUAL OUTPUT 1 2 Remote On/Off Control NP NP NP 3 -V Input -V Input -V Input 4 +V Input +V Input +V Input 5 Trim Trim -Aux. Out 6 -V Output -V Output Common 7 +V Output Common +5V Output 8 NP +V Output +Aux. Out TRIPLEOUTPUT Output may optionally be externally trimmed (±10%) with a fixed resistor or an external trimpot as shown. DC-DC PCB MOUNTED CONVERTERS & POWER MODULES 1 7 - 3 0 W AT T S - D C / D C S I N G L E & M U LT I O U T P U T REMOTE ON/OFF CONTROL Logic compatibility CMOS or open collector TTL Output-On >5.5VDC or open circuit Output-Off <1.8VDC Shutdown idle current 10mA Input resistance 100K ohms (Ein 0 to 9VDC) Control common Referenced to input minus Doc. No. PBC9 Rev.C 28-4-11 Powering Progress – www.powerbox.com.au 167