Product Catalog - Premier Magnetics

Products Catalog
Table Of Contents
DATABUS INTERFACE TRANSFORMER
Page
MIL-STD-1533 / MIL-T-21038 DataBus Interface Transformer ............................. pm-dbxxx ..... 2-9
AUDIO
Digital Audio Data Transmission ............................................................................ pm-adxxxx .... 10
New
New
NETWORKING & COMMUNICATION
DSL Line Isolation Transformers Thru Hole or SMD, UL/CSA Recognized ......... pm-dslxxx ..... 11-21
Coupled Inductor For Uses in ADSL Pots Low Pass Filters ................................... pm-indxxx ..... 22-23
T1/E1/ISDN-PRI 3KV-Reinforced SMD Transformers ......................................... pmt10xx ........ 24
T1/E1/ISDN-PRI 3KV-Reinforced Thru Hole Transformers ................................. pmis3xxx ....... 25-26
T1/E1 Dual Core SMD Isolation Transformers, SOIC Package .............................. pmis2_7x ..... 27-28
T1/E1/ISDN-PRI 1.5KV Dual Core SMD Isolation Transformers ......................... pmis8_9x ....... 29-30
T1/E1 Quad Port SMD Isolation Transformers ........................................................ pm-81_82 ..... 31-33
T1/E1/ISDN-PRI Quad Port SMD Transformers with IC Side Protection .............. pm-86xx ........ 34
New
T3/DS3/E3/STS-1 Interface Isolation Transformers ................................................. pmt3 .............. 35-37
10 Base-T Dual Interface Modules Transformers & Filters ..................................... pmbt .............. 38-46
10/100 Base-TX Quad Port Isolation Transformers with Filters .............................. pm-80xx ....... 47-51
10/100 Base-T Small Outline Isolation Transformers, SOIC Package ..................... pm-10_30 ...... 52-55
10/100 Base-TX Single Port SOIC Transformers ..................................................... pm-61xx ........ 56
10/100 Base-TX PC Card LAN & Cardbus Applications ........................................ pm-6xxx ........ 57-61
1000 Base-T Module Isolation Transformers with Filters ........................................ pm-9xxx ........ 62-63
Coupling Transformers for Networking & General Purpose ................................... pmnw ............. 64-65
Signal Line Filters/Common Mode Chokes, to 500 MH........................................... pm-sfxx ......... 66-68
Signal Line Filters/Common Mode Chokes, to 1 GHz.............................................. pm-sfxxx ....... 69-71
New
New
New
High Speed Voice/Data Coupling Transformers ...................................................... pm-mc ........... 72-74
FIBRE CHANNEL
Wideband RF Pulse Coupling Transformers ............................................................ pm-wt&wg ....
75
Fibre Channel Coupling Transformers, Cypress HOTLink................................... pm-wt&wg ....
76
Specifications subject to change without notice.
Unless otherwise specified, all tolerances are ± 0.010 (0.25)
20381 BARENTS SEA CIRCLE, LAKE FOREST, CA 92630 • TEL: (949) 452-0511 • FAX: (949) 452-0512 • http://www.premiermag.com
Products Catalog
Table Of Contents (continue)
POWER PRODUCTS
Page
SWITCH MODE
Current Sense Inductors, With Center Hole ......................................................... pm-ci ..............
Current Sense Transformers ................................................................................ pm-cs .............
77-78
79
DC/DC Power Conversion For Linear Technology ............................................. pmsm .............
DC/DC Push-Pull Power Conversion For Linear Technology ............................. pmsm15 .........
80-82
83
Low Cost Toroidal Power Inductors ..................................................................... vtp ..................
Sendust Toroidal Power Inductors, High frequency, Low Loss ........................... vtk ..................
84-85
86-87
Transformers, UL/CSA Recognized, TOP, PWM Designs .............................. pol ..................
Transformers, UL/CSA Recognized, TINY, PWM Designs ........................... pny .................
88-96
97-99
New
PMCE & PMCU EMI/RFI Common Mode AC Line Filters ............................... pmce, pmcu .... 100-105
Open Common Mode EMI Supression Inductors.................................................. pm-omxx ........
106
VERSA-PAC Transformers 1:1:1:1:1:1, SMD .................................................... pm-vxxxxx ..... 107-110
New
Gate & Base Drive Transformers, Single & Double Ended ................................. pmgd .............. 111-113
LINEAR - 60 Hz, 115/230V
(*) Parts are UL & CSA Recognized
Split Bobbin High Isolation 1.1VA to 36 VA, 2500 Vrm (*) ............................... psb .................. 114-115
Shrouded VDE Split Bobbin High Isolation, 2.5VA to 56VA, 4KVrms (*) ........ pvb ................. 116-117
Low Profile Dual Bobbin, 2.5VA to 48VA, 1500 Vrms....................................... plp .................. 118-119
TOROID - 60 Hz, 115V, 50-400 Hz or 115/230 Input
Designed to meet UL, CSA, VDE, 4000Vrms...................................................... pt-xxxx ........... 120-121
New
DC/DC CONVERTER MODULES
1.0 Watt Mini-SIP, 1000-3000V Isolation, Low Cost .......................................... s3_1watt ......... 122-123
2.0 Watt Mini-SIP, 500-1000V Isolation, Low Cost ............................................ s3_2watt, s4ax 124-125
1.5 & 3.0 Watt DIL, 500V Isolation, Low Cost ................................................... b3as-ad ........... 126-127
1.0 & 2.5 Watt DIL, 500V Isolation, Low Cost.................................................... b2ax ...............
128
2.2 Watt 2:1 Wide Input Range High Efficiency ................................................. PDCx0307x ... 129-130
New
3.0 Watt 2:1 Wide Input Range High Efficiency ................................................. PDCx0300xx .. 131-133
3.0 Watt 2:1 Wide Input Range High Efficiency Extended Temperature ............ PDCx0305x ....
134
3.0 Watt 2:1 Wide Input Range High Efficiency With Remote On/Off Option .. PDCx0302x .... 135-136
3.0 Watt 4:1 Wide Input Range High Efficiency, Copper Case .......................... PDCx0304x .... 137-138
High Current Adjustable Output, ON/OFF Control, Efficiency to 94% ............. PDCx5-6xxx ... 139-140
New
Unless otherwise specified, all tolerances are ± 0.010 (0.25)
Specifications subject to change without notice.
20381 BARENTS SEA CIRCLE, LAKE FOREST, CA 92630 • TEL: (949) 452-0511 • FAX: (949) 452-0512 • http://www.premiermag.com
1
MIL-STD-1553 / MIL-PRF-21038
DATABUS INTERFACE TRANSFORMERS
LOW PROFILE SINGLE/DUAL
Ê Designed to Meet MIL-STD-1553 A/B & MIL-PRF-21038
Ë Common Mode Rejection (CMR) Greater Than 45dB
Ì Impedance Test Frequency from 75Khz to 1MHz
Í Droop Less Than 20%
Î Overshoot & Ringing
Ï Pulse Width 2 µs
±1V Max
ELECTRICAL SPECIFICATIONS AT 25OC - OPERATING TEMPERATURE RANGE -55OC TO +125OC
PART
NUMBER
PM-DB2701
PM-DB2701EX
PM-DB2702
PM-DB2703
PM-DB2704
PM-DB2705
PM-DB2705EX
PM-DB2706
PM-DB2707
PM-DB2708
PM-DB2709
PM-DB2710
PM-DB2711
PM-DB2712
PM-DB2713
PM-DB2714
PM-DB2715
PM-DB2716
PM-DB2717
PM-DB2718
PM-DB2719
PM-DB2720
PM-DB2721
PM-DB2722
PM-DB2723
PM-DB2724
PM-DB2725
PM-DB2725EX
PM-DB2726
PM-DB2727
PM-DB2728
PM-DB2729
PM-DB2730
PM-DB2731
PM-DB2755
PM-DB2759 (1)
PM-DB2760 (1)
TERMINALS
1-3:4-8
1-3:4-8
1-3:4-8
1-3:4-8
4-8:1-3
1-2:4-3
1-2:3-4
1-5:6-2
1-5:6-2
1-5:6-2
1-5:6-2
1-3:4-8
1-3:4-8
1-3:4-8
1-3:4-8
4-8:1-3
1-3:4-8
1-3:4-8
1-3:4-8
1-3:4-8
4-8:1-3
1-3:4-8
1-3:4-8
1-3:4-8
1-3:4-8
1-3:4-8
1-3:4-8
1-3:4-8
1-3:4-8
1-3:4-8
1-5:6-2
1-5:6-2
1-5:6-2
1-3:4-8
1-3:4-8
1-5:6-2
1-5:6-2
/ RATIO ( ± 3%)
1:1
1:1
1.4:1
1.25 : 1
2.3:1
1:1.41
1:1.41
1:1
1:1.41
1:1.66
1:2
1:2.12
1:1
1.4:1
1.25:1
2.3:1
1:2.12
1:1
1.41:1
1.25:1
2.3:1
1:2.12
1:1
1.41:1
1.25:1
1:2.12
1:2.5
1:2.5
1:2.5
1:2.5
1:1.5
1:1.79
1:2.5
1:2.5
1:3.75
1:1.79
1:2.5
TERMINALS
/ RATIO ( ± 3%)
1-3:5-7
1-3:5-7
1-3:5-7
1-3:5-7
5-7:1-3
------------1-3:5-7
1-3:5-7
1-3:5-7
1-3:5-7
5-7:1-3
1-3:5-7
1-3:5-7
1-3:5-7
1-3:5-7
5-7:1-3
1-3:5-7
1-3:5-7
1-3:5-7
1-3:5-7
1-3:5-7
1-3:5-7
1-3:5-7
1-3:5-7
1-3:5-7
------1-3:5-7
1-3:5-7
-----
1:.707
1:.707
2:1
1.66:1
3.2:1
------------1:1.5
1:.707
2.1:1
1.66:1
3.2:1
1:1.5
1:.707
2:1
1.66:1
3.26:1
1:1.5
1:.707
2:1
1.66:1
1:1.5
1:1.79
1:1.79
1:1.79
1:1.79
------1:1.79
1:2.70
-----
DCR
(Ohms Max.)
1-3=3.0, 4-8=3.0
1-3=3.0, 4-8=3.0
1-3=3.5, 4-8=3.0
1-3=3.2, 4-8=3.0
1-3=1.2, 4-8=3.0
1-2=2.2, 3-4=2.7
1-2=2.2, 3-4=2.7
1-5=2.5, 6-2=2.8
1-5=2.2, 6-2=2.7
1-5=1.5, 6-2=2.4
1-5=1.3, 6-2=2.6
1-3=1.0, 4-8=3.5
1-3=3.0, 4-8=3.0
1-3=3.5, 4-8=3.0
1-3=3.2, 4-8=3.0
1-3=1.2, 4-8=3.0
1-3=1.0, 4-8=3.5
1-3=3.0, 4-8=3.0
1-3=3.5, 4-8=3.0
1-3=3.2, 4-8=3.0
1-3=1.2, 4-8=3.0
1-3=1.0, 4-8=3.5
1-3=3.0, 4-8=3.0
1-3=3.5, 4-8=3.0
1-3=3.2, 4-8=3.0
1-3=1.0, 4-8=3.5
1-3=1.0, 4-8=3.5
1-3=1.0, 4-8=3.5
1-3=1.0, 4-8=3.5
1-3=1.0, 4-8=3.5
1-5=0.9, 6-2=2.5
1-5=0.9, 6-2=2.5
1-5=1.0, 6-2=2.8
1-3=1.0, 4-8=3.5
1-3=1.0, 4-8=4.0
1-5=0.9, 6-2=2.5
1-5=1.0, 6-2=2.8
IMPEDANCE
(Ohms MIN.)
4000
4000
7200
4000
3000
3000
3000
3000
3000
3000
3000
4000
4000
7200
4000
3000
4000
4000
7200
4000
3000
3000
4000
7200
4000
4000
4000
4000
4000
4000
3000
3000
3000
4000
4000
3000
3000
SCHEMATICS
/
PACKAGE
1/A
1/G
1/A
1/A
4/A
3/C
5/C
2/B
2/B
2/B
2/B
1/A
1/D
1/D
1/D
4/D
1/D
1/E
1/E
1/E
1/E
1/E
1/A
1/A
1/A
1/A
1/A
1/G
1/A
1/D
2/B
2/B
2/B
1/E
1/G
2/U
2/U
(1) OPERATING TEMPERATURE RANGE FROM -40C TO +130C
pm-dbxxx 02/05/03
Specifications subject to change without notice.
20381 BARENTS SEA CIRCLE, LAKE FOREST, CA 92630 • TEL: (949) 452-0511 • FAX: (949) 452-0512 • http://www.premiermag.com
2
MIL-STD-1553 / MIL-PRF-21038
DATABUS INTERFACE TRANSFORMERS
LOW PROFILE SINGLE/DUAL
LOW PROFILE SINGLE RATIO HT= 0.155"
PART
NUMBER
PM-DB2741
PM-DB2742
PM-DB2743
PM-DB2744
PM-DB2745
PART
NUMBER
PM-DB2741L
PM-DB2742L
PM-DB2743L
PM-DB2744L
PM-DB2745L
PART
NUMBER
PM-DB2741M
PM-DB2742M
PM-DB2743M
PM-DB2744M
PM-DB2745M
PART
NUMBER
PM-DB2741N
PM-DB2742N
PM-DB2743N
PM-DB2744N
PM-DB2745N
TERMINALS
1-3:4-8
1-3:4-8
1-3:4-8
1-3:4-8
1-3:4-8
TERMINALS
1-3:4-8
1-3:4-8
1-3:4-8
1-3:4-8
1-3:4-8
TERMINALS
1-3:4-8
1-3:4-8
1-3:4-8
1-3:4-8
1-3:4-8
TERMINALS
1-3:4-8
1-3:4-8
1-3:4-8
1-3:4-8
1-3:4-8
/ RATIO ( ± 3%)
1:1
1.4:1
1.25:1
1:2.12
1:2.5
/ RATIO ( ± 3%)
1:1
1.4:1
1.25:1
1:2.12
1:2.5
/ RATIO ( ± 3%)
1:1
1.4:1
1.25:1
1:2.12
1:2.5
/ RATIO ( ± 3%)
1:1
1.4:1
1.25:1
1:2.12
1:2.5
DCR
(Ohms Max.)
IMPEDANCE
(Ohms MIN.)
SCHEMATICS
/
PACKAGE
TERMINALS
/ RATIO ( ± 3%)
1-3:5-7
1-3:5-7
1-3:5-7
1-3:5-7
1-3:5-7
1:.707
2:1
1.66:1
1:1.5
1:1.79
TERMINALS
/ RATIO ( ± 3%)
DCR
(Ohms Max.)
IMPEDANCE
(Ohms MIN.)
1:.707
2:1
1.66:1
1:1.5
1:1.79
1-3=3.0, 4-8=3.0
1-3=3.5, 4-8=3.0
1-3=3.2, 4-8=3.0
1-3=1.0, 4-8=3.5
1-3=1.0, 4-8=3.5
4000
7200
4000
4000
4000
/ RATIO ( ± 3%)
DCR
(Ohms Max.)
IMPEDANCE
(Ohms MIN.)
SCHEMATICS
/
PACKAGE
1:.707
2:1
1.66:1
1:1.5
1:1.79
1-3=3.0, 4-8=3.0
1-3=3.5, 4-8=3.0
1-3=3.2, 4-8=3.0
1-3=1.0, 4-8=3.5
1-3=1.0, 4-8=3.5
4000
7200
4000
4000
4000
1/M
1/M
1/M
1/M
1/M
/ RATIO ( ± 3%)
DCR
(Ohms Max.)
1:.707
2:1
1.66:1
1:1.5
1:1.79
1-3=3.0, 4-8=3.0
1-3=3.5, 4-8=3.0
1-3=3.2, 4-8=3.0
1-3=1.0, 4-8=3.5
1-3=1.0, 4-8=3.5
1-3:5-7
1-3:5-7
1-3:5-7
1-3:5-7
1-3:5-7
TERMINALS
1-3:5-7
1-3:5-7
1-3:5-7
1-3:5-7
1-3:5-7
TERMINALS
1-3:5-7
1-3:5-7
1-3:5-7
1-3:5-7
1-3:5-7
1-3=3.0, 4-8=3.0
1-3=3.5, 4-8=3.0
1-3=3.2, 4-8=3.0
1-3=1.0, 4-8=3.5
1-3=1.0, 4-8=3.5
4000
7200
4000
4000
4000
IMPEDANCE
(Ohms MIN.)
4000
7200
4000
4000
4000
1/K
1/K
1/K
1/K
1/K
SCHEMATICS
/
PACKAGE
1/L
1/L
1/L
1/L
1/L
SCHEMATICS
/
PACKAGE
1/N
1/N
1/N
1/N
1/N
pm-dbxxx 02/05/03
Specifications subject to change without notice.
20381 BARENTS SEA CIRCLE, LAKE FOREST, CA 92630 • TEL: (949) 452-0511 • FAX: (949) 452-0512 • http://www.premiermag.com
3
MIL-STD-1553 / MIL-PRF-21038
DATABUS INTERFACE TRANSFORMERS
LOW PROFILE SINGLE/DUAL
LOW PROFILE DUAL RATIO HT= 0.155"
PART
NUMBER
TERMINALS
/ RATIO ( ± 3%)
DCR
(Ohms Max.)
IMPEDANCE
(Ohms MIN.)
SCHEMATICS
/
PACKAGE
TERMINALS
/ RATIO ( ± 3%)
PM-DB2741D
1-3:16-13
5-7:12-9
1:1
1:1
1-3:15-14
5-7:11-10
1:.707
1:.707
1-3=3.0, 16-13=3.0
5-7=3.0, 12-9=3.0
4000
4000
6/R
PM-DB2742D
1-3:16-13
5-7:12-9
1.4:1
1.4:1
1-3:15-14
5-7:11-10
2:1
2:1
1-3=3.5, 16-13=3.0
5-7=3.5, 12-9=3.0
7200
7200
6/R
PM-DB2743D
1-3:16-13
5-7:12-9
1.25:1
1.25:1
1-3:15-14
5-7:11-10
1.66:1
1.66:1
1-3=3.2, 16-13=3.0
5-7=3.2, 12-9=3.0
4000
4000
6/R
PM-DB2744D
1-3:16-13
5-7:12-9
1:2.12
1:2.12
1-3:15-14
5-7:11-10
1:1.5
1:1.5
1-3=1.0, 16-13=3.1
5-7=1.0, 12-9=3.1
4000
4000
6/R
PM-DB2745D
1-3:16-13
5-7:12-9
1:2.5
1:2.5
1-3:15-14
5-7:11-10
1:1.79
1:1.79
1-3=1.0, 16-13=3.5
5-7=1.0, 12-9=3.5
4000
4000
6/R
PART
NUMBER
PM-DB2741S
TERMINALS
/ RATIO ( ± 3%)
TERMINALS
/ RATIO ( ± 3%)
DCR
(Ohms Max.)
IMPEDANCE
(Ohms MIN.)
SCHEMATICS
/
PACKAGE
1-3:16-13
5-7:12-9
1-3:16-13
5-7:12-9
1:1
1:1
1.4:1
1.4:1
1-3:15-14
5-7:11-10
1-3:15-14
5-7:11-10
1:.707
1:.707
2:1
2:1
1-3=3.0, 16-13=3.0
5-7=3.0, 12-9=3.0
1-3=3.5, 16-13=3.0
5-7=3.5, 12-9=3.0
4000
4000
7200
7200
PM-DB2743S
1-3:16-13
5-7:12-9
1.25:1
1.25:1
1-3:15-14
5-7:11-10
1.66:1
1.66:1
1-3=3.2, 16-13=3.0
5-7=3.2, 12-9=3.0
4000
4000
6/S
PM-DB2744S
1-3:16-13
5-7:12-9
1:2.12
1:2.12
1-3:15-14
5-7:11-10
1:1.5
1:1.5
1-3=1.0, 16-13=3.1
5-7=1.0, 12-9=3.1
4000
4000
6/S
PM-DB2745S
1-3:16-13
5-7:12-9
1:2.5
1:2.5
1-3:15-14
5-7:11-10
1:1.79
1:1.79
1-3=1.0, 16-13=3.5
5-7=1.0, 12-9=3.5
4000
4000
6/S
PM-DB2742S
6/S
6/S
pm-dbxxx 02/05/03
Specifications subject to change without notice.
20381 BARENTS SEA CIRCLE, LAKE FOREST, CA 92630 • TEL: (949) 452-0511 • FAX: (949) 452-0512 • http://www.premiermag.com
4
MIL-STD-1553 / MIL-PRF-21038
DATABUS INTERFACE TRANSFORMERS
LOW PROFILE SINGLE/DUAL
LOW PROFILE DUAL RATIO HT= 0.155"
PART
NUMBER
SCHEMATICS
/
PACKAGE
DCR
(Ohms Max.)
IMPEDANCE
(Ohms MIN.)
1:.707
1:.707
1-3=3.0, 16-13=3.0
5-7=3.0, 12-9=3.0
4000
4000
6/T
1-3:15-14
5-7:11-10
2:1
2:1
1-3=3.5, 16-13=3.0
5-7=3.5, 12-9=3.0
7200
7200
6/T
1.25:1
1.25:1
1-3:15-14
5-7:11-10
1.66:1
1.66:1
1-3=3.2, 16-13=3.0
5-7=3.2, 12-9=3.0
4000
4000
6/T
1-3:16-13
5-7:12-9
1:2.12
1:2.12
1-3:15-14
5-7:11-10
1:1.5
1:1.5
1-3=1.0, 16-13=3.1
5-7=1.0, 12-9=3.1
4000
4000
6/T
1-3:16-13
5-7:12-9
1:2.5
1:2.5
1-3:15-14
5-7:11-10
1:1.79
1:1.79
1-3=1.0, 16-13=3.5
5-7=1.0, 12-9=3.5
4000
4000
6/T
TERMINALS
TERMINALS
/ RATIO ( ± 3%)
PM-DB2741T
1-3:16-13
5-7:12-9
1:1
1:1
1-3:15-14
5-7:11-10
PM-DB2742T
1-3:16-13
5-7:12-9
1.4:1
1.4:1
PM-DB2743T
1-3:16-13
5-7:12-9
PM-DB2744T
PM-DB2745T
/ RATIO ( ± 3%)
DUAL RATIO HT= 0.250"
PART
NUMBER
TERMINALS / RATIO (±3%)
PM-DB27401 1-3:4-8
11-13:14-18
2:5
2:5
TERMINALS
/ RATIO (±3%)
DCR
(Ohms Max.)
IMPEDANCE
(Ohms MIN.)
SCHEMATICS
/
PACKAGE
1-3:5-7
11-13:15-17
4:7
4:7
1-3=3.5 11-13=3.5
4-8=3.0 14-18=3.0
3000
3000
7/H
PM-DB27402 1-3:4-8
1:0.83
11-13:14-18 1:0.83
1-3:5-7
11-13:15-17
1:0.6
1:0.6
1-3=3.0 11-13=3.0
4-8=3.0 14-18=3.0
3000
3000
7/H
PM-DB27403 1-3:4-8
11-13:14-18
1.4:1
1.4:1
1-3:5-7
11-13:15-17
2:1
2:1
1-3=3.5 11-13=3.5
4-8=3.0 14-18=3.0
7200
7200
7/H
PM-DB27404 1-3:4-8
11-13:14-18
1:1
1:1
1-3:5-7
11-13:15-17
1:0.707
1:0.707
1-3=3.0 11-13=3.0
4-8=3.0 14-18=3.0
4000
4000
7/H
PM-DB27405 1-3:4-8
1.25:1
11-13:14-18 1.25:1
1-3:5-7
11-13:15-17
1.66:1
1.66:1
1-3=3.2 11-13=3.2
4-8=3.0 14-18=3.0
4000
4000
7/H
PM-DB27406 4-8:1-3
14-18:11-13
2.3:1
2.3:1
5-7:1-3
15-17:11-13
3.2:1
3.2:1
1-3=1.2 11-13=1.2
5-7=3.0 15-17=3.0
3000
3000
8/H
PM-DB27407 4-8:1-3
2.12:1
14-18:11-13 2.12:1
5-7:1-3
15-17:11-13
1.5:1
1.5:1
1-3=1.1 11-13=1.1
4-8=3.0 14-18=3.0
4000
4000
7/H
PM-DB27408 1-3:4-8
11-13:14-18
1-3:5-7
11-13:15-17
1:1.79
1:1.79
1-3=1.0 11-13=1.0
4-8=3.5 14-18=3.5
4000
4000
7/H
1:2.5
1:2.5
pm-dbxxx 02/05/03
Specifications subject to change without notice.
20381 BARENTS SEA CIRCLE, LAKE FOREST, CA 92630 • TEL: (949) 452-0511 • FAX: (949) 452-0512 • http://www.premiermag.com
5
MIL-STD-1553 / MIL-PRF-21038
DATABUS INTERFACE TRANSFORMERS
LOW PROFILE SINGLE/DUAL
SCHEMATICS
SCHEMATIC "1"
1
SCHEMATIC "3"
SCHEMATIC "2"
4
1
2
3
4
1
3
2
4
5
2
6
7
3
8
5
6
SCHEMATIC "4"
1
SCHEMATIC "6"
SCHEMATIC "5"
1
5
(5) 1
4
16 (12)
4
2
15 (11)
(6) 2
6
2
8
3
3
(7) 3
7
SCHEMATIC "7"
13 (9)
SCHEMATIC "8"
(11) 1
4 (14)
(11) 1
(12) 2
6 (1 6 )
6 (1 6 )
8 (18)
7 (1 7 )
(13) 3
5 (1 5 )
4 (14)
5 (1 5 )
(12) 2
4 (8)
14 (10)
(13) 3
8 (18)
7 (1 7 )
pm-dbxxx 02/05/03
Specifications subject to change without notice.
20381 BARENTS SEA CIRCLE, LAKE FOREST, CA 92630 • TEL: (949) 452-0511 • FAX: (949) 452-0512 • http://www.premiermag.com
6
MIL-STD-1553 / MIL-PRF-21038
DATABUS INTERFACE TRANSFORMERS
LOW PROFILE SINGLE/DUAL
FIGURE #A
8
P PM-DB27XX
M YYWW
3
2
1
FIGURE #B
5
7
3
.6 25
(1 5.87)
M AX
6
.350
(8.89)
Max
4
1
5
2
.500
(12.70)
4
.6 25
(1 5.87)
M AX
.08
(2.03)
.250
(6.35)
MAX
.2 50
(6 .3 5)
M AX
.375
(9.52)
MIN
.3 75
(9 .5 2)
M IN
.5 00
(1 2.70)
φ
6
P PM-DB27XX
M YYWW
0.020 (0.508)
#24AWG
4 PLS
.400
(10.16)
.1 00 (2.54)
4 PL S
.2 00 (5.08)
4 PL S
.34
(8.64)
.200
(5.08)
FIGURE #C
FIGURE #D
.350
(8.89)
Max
P
M
PM-DB27XX
YYWW
.6 25
(1 5 .87 )
M AX
.2 00 (2 .5 4)
2
.2 00 (2 .5 4)
3
1
.500
(12.70)
.6 25
(1 5 .87 )
M AX
.08
(2.03)
.250
(6.35)
MAX
.375
(9.52)
MIN
P PM-DB27XX
M YYWW
3
4
2
1
8
7
6
.1 00
(2 .5 4)
TYP
5
4
φ
0 .02 0 (0 .5 08 )
R = .0 3 2 ( .8 1 ) T Y P
.2 50
(6 .3 5)
M AX
.34
(8.64)
#24AWG
4 PLS
.0 7 ( 1.7 8 )
.0 04
(.1 0 )
M IN
.2 20 - .2 8 0 (5 .59 -7 .1 1 )
.400
(10.16)
.200
(5.08)
FIGURE #E
.200(2.54)
2
.200(2.54)
FIGURE #F
4
8
P PM-DB27XX
M YYWW
3
.625
(15.87)
MAX
.100
(2.54)
PM-DB27XXEX
2P
M YYWW
7
6
5
1
.500
(12.70)
4
.625
(15.87)
MAX
φ
3
1
.100
(2.54)
TYP
.350
(8.89)
Max
.08
(2.03)
.250
(6.35)
MAX
0.020 (0.508)
.375
(9.52)
MIN
.250
(6.35)
MAX
.100
(2.54)
.34
(8.64)
#24AWG
4 PLS
.400
(10.16)
.200
(5.08)
pm-dbxxx 02/05/03
Specifications subject to change without notice.
20381 BARENTS SEA CIRCLE, LAKE FOREST, CA 92630 • TEL: (949) 452-0511 • FAX: (949) 452-0512 • http://www.premiermag.com
7
MIL-STD-1553 / MIL-PRF-21038
DATABUS INTERFACE TRANSFORMERS
LOW PROFILE SINGLE/DUAL
FIGURE #G
3
2
1
P PM-DB27XX
M YYWW
4
FIGURE #H
8
7
.250
(6.35)
MAX
.400
(10.16)
MAX
6
5
.400
(10.16)
MAX
.250
(6.36)
MIN
.250
(6.36)
.625
(15.87)
MAX
.500
(12.7)
.240
(6.1)
MAX
1
18
.250
(6.35)
.375
(9.52)
MIN
.500
(12.7)
2
.100
(2.54)
3
.100 (2.54)
3 PLS
.200 (5.08)
3 PLS
0.020 (0.508)
4
17
5
16
6
15
.300
(7.62)
φ
φ 0.020 (0.508)
.200
(5.08)
.200
(5.08)
.400
(10.16)
7
14
13
12
11
8
FIGURE #L
FIGURE # K
3
3
8
8
7
2
P PM-DB27XX
M YYWW
.630
(16.0)
MAX
6
P PM-DB27XX
M YYWW
2
.200 (5 .08 )
2 PLS
5
1
4
.630
(16.0)
MAX
.680-.720
(17.27-18.29)
.100 (2 .54 )
4 PLS
.630
(1 6 .0)
M AX
R= .03 2(.81 ) TYP
.020
(508)
TYP
.630
(1 6 .0)
M AX
6
4
.020
(5 0 8)
TYP
.100
(2.54)
MIN
7
5
1
.155
(3.937)
MAX
.625
(15.87)
MAX
.155
(3 .9 37 )
M AX
.07 (1.7 8)
.200 (5.08)
4 PLS
.100 (2.54)
4 PLS
.004
(.1 0 )
M IN
.220 -.2 8 0 (5 .59-7.1 1 )
FIGURE #N
FIGURE # M
3
8
7
8
7
6
5
P PM-DB27XX
M YYWW
1
2
3
2
.430
(10.92)
MAX
.200 (5.08)
2 PLS
P PM-DB27XX
M YYWW
1
4
.630
(16.0)
MAX
6
5
4
.100 (2.54)
4 PLS
.630
(16.0)
MAX
.430
(10.92)
MAX
.020 x .010
(.508 x .254)
TYP
.250
(6.35)
TYP
.075
(1.9)
typ
.155
(3.937)
MAX
.155
(3.937)
MAX
.100 (2.54)
6 PLS
.220-.280 (5.59-7.11)
.07
(1.78)
TYP
.020x.010
(.508x.254)
TYP
pm-dbxxx 02/05/03
Specifications subject to change without notice.
20381 BARENTS SEA CIRCLE, LAKE FOREST, CA 92630 • TEL: (949) 452-0511 • FAX: (949) 452-0512 • http://www.premiermag.com
8
MIL-STD-1553 / MIL-PRF-21038
DATABUS INTERFACE TRANSFORMERS
LOW PROFILE SINGLE/DUAL
FIGURE # R
FIGURE # S
9
16
P PM-DB27XXX
M YYWW
P PM-DB27XXX
M YYWW
.630
(16.0)
MAX
8
1
9
16
.630
(16.0)
MAX
8
1
.930
(23.620)
MAX
.930
(23.620)
MAX
.155
(3.937)
MAX
.020
(508)
TYP
.100 (2.54)
14 PLS
.100
(2.54)
MIN
R= .032(.81) TYP
.020
(508)
TYP
.680-.720
(17.27-18.29)
.07 (1.78)
.220-.280 (5.59-7.11)
.100 (2.54)
14 PLS
P PM-DB27xxx
M YYWW
9
.930
(23.620)
MAX
.020 x .010
(.508 x .254)
TYP
.250
(6.35)
TYP
5
6
3
4
1
.430
(10.92)
MAX
.350
(8.89)
Max
2
.500
(12.70)
8
1
.004
(.10)
MIN
FIGURE # U
FIGURE # T
16
.155
(3.937)
MAX
.08
(2.03)
.182
(4.62)
MAX
.155
(3.937)
MAX
.375
(9.52)
MIN
.100 (2.54)
14 PLS
.34
(8.64)
#24AWG
4 PLS
.400
(10.16)
.200
(5.08)
.100
(2.54)
pm-dbxxx 02/05/03
Specifications subject to change without notice.
20381 BARENTS SEA CIRCLE, LAKE FOREST, CA 92630 • TEL: (949) 452-0511 • FAX: (949) 452-0512 • http://www.premiermag.com
9
TRANSFORMER FOR DIGITAL
AUDIO DATA TRANSMISSION
Ê Operating Transmission Rates:1 to 7 Mbps
Ë Controlled Rise Time: 25 nsec Maximum
Ì High Isolation Voltage: 2 KV Minimum
Í Inductance Test at 100KHz
ELECTRICAL SPECIFICATIONS AT 25OC - OPERATING TEMPERATURE RANGE 0OC TO +70OC
PART
NUMBER
PM-AD001
PM-AD001S
Turns
Ratio
(±42%)
PRI
Inductance
(mH ± 20%)
1:1
1:1
PRI
Rise Time
LL
nsec
µH Max)
(µ
( Max)
2.5
2.5
0.5
0.5
ET
V-µ
µsec
( Max)
25
25
Bandwidth
Return Loss
Isolation
Schematic
100KHz-55MHz 100KHz-10MHz
(Vrms MIN.)
(Typ)
(Min)
20
20
3 dB
3 dB
.250
(6.35)
MAX
.500
(12.70)
MAX
.080
(2.03)
TYP
#24 AWG
1
THT
SMT
.400
(10.16)
4
P PM-AD001
M YYWW
2000
2000
SCHEMATIC
PM-AD001
2
20 dB
20 dB
.350
(8.89)
MAX
2
4
1
3
.200
(5.08)
3
.130
(3.30)
.340
(8.64)
SCHEMATIC
PM-AD001S
.475
(12.06)
MAX
8
.120
(3.05)
5
P PM-AD001S
M YYWW
.400
(10.16)
MAX
.475
(12.06)
MAX
4
1
.100
(2.54)
.400
(10.16)
.640
(16.26)
8
5
1
4
.050
(1.27)
DOT FOR PIN 1
.100
(2.54)
.085
(2.16)
.340
(8.64)
MAX
.030
(.76)
.040-.050
(1.02-1.27)
.600
(15.24)
MAX
.010-.020
(.25-.51)
pm-adxxxx 03/02
Specifications subject to change without notice.
20381 BARENTS SEA CIRCLE, LAKE FOREST, CA 92630 • TEL: (949) 452-0511 • FAX: (949) 452-0512 • http://www.premiermag.com
10
DSL LINE ISOLATION
TRANSFORMERS
THRU HOLE OR SMD
Parts are UL1950 & CSA-950 Recognized Under UL File# E162344 or are Pending
Ê Thru Hole or SMD Package
Ë 1500Vrms Minimum Isolation Voltage
Ì UL, IEC & CSA Insulation System
Í Extended Temperature Range Version
ELECTRICAL SPECIFICATIONS AT 25OC - OPERATING TEMPERATURE RANGE -40OC TO +85OC
PART
NUMBER
PM-DSL10
PM-DSL11
PM-DSL11G
PM-DSL12
PM-DSL13
PM-DSL13G
PM-DSL14
PM-DSL15
PM-DSL16
PM-DSL17
PM-DSL18
PM-DSL19
PM-DSL20
PM-DSL20G
PM-DSL21G
PM-DSL22G
PM-DSL23
PM-DSL24
PM-DSL24G
PM-DSL25
PM-DSL25G
PM-DSL26
PM-DSL26G
PM-DSL27
PM-DSL27G
PM-DSL28
PM-DSL28G
PM-DSL29
PM-DSL29G
PM-DSL30
PM-DSL30G
PM-DSL31
PM-DSL31G
PM-DSL32
PM-DSL32G
PM-DSL33
PM-DSL33G
PM-DSL34
PM-DSL34G
PM-DSL35
Primary PRI - SEC
Ratio
OCL
LL
(SEC:PRI ± 3%)
(mH TYP.) (µ
µH Max.)
1 : 2.0
1 : 2.0
1 : 2.0
1 : 2.0
1 : 1.0
1 : 1.0
1 : 2.0
1 : 1.5
1 : 3.0
1 : 1.0
1 : 2.0ct
1 : 2.0
1 : 1.0
1 : 1.0
1 : 2.0
1 : 1.5
1 : 2.0
1 : 2.0
1 : 2.0
1 : 2.0
1 : 2.0
1 : 2.0
1 : 2.0
1 : 2.0
1 : 2.0
1 : 2.0
1 : 2.0
1 : 2.0
1 : 2.0
1 : 2.0
1 : 2.0
1 : 2.0
1 : 2.0
1 : 2.0
1 : 2.0
1 : 1.0
1 : 1.0
1 : 1.0
1 : 1.0
1 : 2.0
12.5
12.5
12.5
16.5
5.0
5.0
12.5
2.25
2.25
1.0
1.0
3.0
0.43
0.43
3.0
2.25
2.0
2.0
2.0
3.0
3.0
3.5
3.5
8.0
8.0
5.0
5.0
4.5
4.5
2.5
2.5
5.8
5.8
4.4
4.4
3.0
3.0
2.0
2.0
3.0
40.0
40.0
40.0
20.0
16
16
18.0
30.0
30.0
12.0
12.0
30.0
10.0
10.0
11.0
30.0
30.0
11.0
11.0
11.0
11.0
30.0
30.0
30.0
30.0
20.0
20.0
20.0
20.0
11.0
11.0
20.0
20.0
20.0
20.0
20.0
DCR
( Ω Max)
PRI
SEC
4.0
4.0
4.0
3.0
1.5
1.5
2.1
3.63
3.63
2.0
2.0
2.0
1.0
1.65
1.65
1.5
3.36
1.0
2.5
.45
.45
2.5
3.3
2.5
2.5
2.5
2.5
2.5
2.5
2.5
4
4
3.5
3.5
3.0
3.0
3.5
3.5
2.6
2.6
2.6
2.6
2.0
2.0
2.0
2.0
2.5
1.0
.35
.35
1.6
3.05
1.25
1.0
1.0
1.0
1.0
1.0
1.0
2.3
2.3
2.2
2.2
1.0
1.0
1.1
1.1
1.0
1.0
1.0
1.0
1.9
1.9
1.9
1.9
1.0
Package
/
Schematic
EP13/G
EP13/AC
EP13G/AC
EP13/AD
EP13/I
EP13G/I
EP13/D
EP13/E
EP13/C
R/F
R/F
EP13/A
EP13/B
EP13G/B
EP13G/A
EP13G/C
EP13/A
EP13/A
EP13G/A
EP13/A
EP13G/A
EP13/A
EP13G/A
EP13/A
EP13G/A
EP13/A
EP13G/A
EP13/A
EP13G/A
EP13/A
EP13G/A
EP13/A
EP13G/A
EP13/A
EP13G/A
EP13/A
EP13G/A
EP13/A
EP13G/A
EP13/A
IC
Manufacture
IC
P/N
Globespan
Globespan
Brooktree
BT8970
Brooktree
BT8970
Brooktree
Brooktree
Brooktree
Brooktree
Brooktree
Brooktree
Brooktree
Brooktree
Brooktree
Brooktree
Brooktree
Brooktree
Brooktree
Brooktree
Brooktree
Brooktree
Brooktree
Brooktree
Brooktree
Brooktree
Brooktree
Brooktree
Brooktree
Burr Brown
BT8921/8970
BT8921/8970
BT8921/8970
BT8921/8970
BT8921/8970
BT8960
BT8960
BT8960
BT8960
BT8960
BT8960
BT8960
BT8960
BT8960
BT8960
BT8970
BT8970
BT8970
BT8970
BT8952
BT8952
BT8952
BT8952
AFC1124
pm-dslxx 06/00
Specifications subject to change without notice.
20381 BARENTS SEA CIRCLE, LAKE FOREST, CA 92630 • TEL: (949) 452-0511 • FAX: (949) 452-0512 • http://www.premiermag.com
11
DSL LINE ISOLATION
TRANSFORMERS
THRU HOLE OR SMD
ELECTRICAL SPECIFICATIONS AT 25OC - OPERATING TEMPERATURE RANGE -40OC TO +85OC
PART
NUMBER
PM-DSL35G
PM-DSL36
PM-DSL36G
PM-DSL37G
PM-DSL38G
PM-DSL39
PM-DSL39G
PM-DSL40
PM-DSL41
PM-DSL41G
PM-DSL42
PM-DSL43
PM-DSL44
PM-DSL45
PM-DSL46
PM-DSL47
PM-DSL48
PM-DSL49G
PM-DSL50
PM-DSL51G
PM-DSL53
PM-DSL53G
PM-DSL54
PM-DSL54G
PM-DSL55
PM-DSL55G
PM-DSL56
PM-DSL56G
PM-DSL57
PM-DSL58
PM-DSL59
PM-DSL60
PM-DSL61
PM-DSL61G
PM-DSL62
PM-DSL62G
PM-DSL63
PM-DSL64
PM-DSL64G
PM-DSL65
PM-DSL66
PM-DSL67
PM-DSL67G
Ratio
Primary PRI - SEC
(SEC:PRI)
OCL
LL
(mH TYP.) (µ
µH Max.)
± 3%
1 : 2.0
1 : 1.8
1 : 1.8
1 : 1.08
1 : 2.0
1 : 4.0
1 : 4.0
1 : 2.0
1 : 4.0
1 : 4.0
1 : 4.0
1 : 4.0
1 : 3.1
1 : 4.0
1 : 4.0
1 : 1.41
1 : 1.8
1 : 1.0
1 : 5.0
1 : 4.0
1 : 1.0
1 : 1.0
1 : 1.0
1 : 1.0
1 : 1.0
1 : 1.0
1 : 2.0
1 : 2.0
1 : 1.0
1 : 1.0
1 : 1.0
1 : 2.0
1 : 1.2
1 : 1.2
1 : 1.0
1 : 1.0
1 : 1.42
1 : 1.8
1 : 1.8
1 : 1.0
1 : 1.27
1 : 1.41
1 : 1.41
3.0
2.95
2.95
0.480
0.530
2.0
2.0
0.800
2.0
2.0
2.0
4.0
3.0
3.0
4.0
0.800
2.75
0.470
2.0
2.0
200
200
200
200
40
40
.410
.410
.440
.50
.24
1.50
4.0
4.0
.40
.40
1.5
3.0
3.0
1.25
18
.475
.475
20.0
11.0
11.0
10.0
25.0
30.0
30.0
10.0
20.0
20.0
30.0
30.0
30.0
30.0
30.0
10.0
50.0
10.0
1.0
17.0
36
36
60
60
40
40
10
10
10
12
15
15
10
10
18
30
30
12
12
10
10
DCR
( Ω Max)
PRI
SEC
2.5
3.2
3.2
0.45
3.3
4.0
4.0
1.5
5.0
5.0
2.4
4.0
5.0
5.0
6.0
1.4
6.0
0.6
1.4
3.0
10
10
8.0
8.0
8.0
8.0
.84
.84
1.2
1.65
.70
2.0
5.5
5.5
1.4
1.4
4.0
3.0
3.0
1.3
1.3
1.1
1.1
1.0
1.8
1.8
0.35
1.4
0.3
0.3
0.8
0.5
0.5
0.25
0.4
0.5
1.0
0.5
1.7
3.2
0.7
0.35
0.35
5
5
16
16
8.0
8.0
.40
.40
1.0
1.65
.70
.55
5.5
5.5
1.3
1.3
.75
2.2
2.2
1.3
.85
.90
.90
Package
/
Schematic
EP13G/A
EP13/A
EP13G/A
EP13G/I
EP7G/J
EP13/A
EP13G/A
EP13/D
EP10/X
EP10G/X
EP13/C
EP13/C
EP13/K
EP13/K
EP13/L
EP13/D
P18-11/M
EP13G/I
EP13/L
EP13G/L
EP13/B
EP13G/B
EP13/N
EP13G/N
EP7/M
EP7/M
EP13/B
EP13G/B
EP13/B
EP7/O
EP13/P
EP13/Q
EP13/R
EP13G/R
EP13/I
EP13G/I
EP13/Q
EP13/S
EP13G/S
EP13/B
EP13/T
EP13/T
EP13G/T
IC
Manufacture
Burr Brown
Burr Brown
Burr Brown
Alcatel
Globespan
IC
P/N
AFC1124
AFC1124
AFC1124
MTK-20140
DLC
Globespan
Globespan
Globespan
Globespan
Globespan
Globespan
Globespan
Brooktree/LV1
SK70704/6
Globespan
Level One
Level One
Level One
Level One
Level One
Level One
Alcatel
Alcatel
Alcatel
Alcatel
Alcatel
Texas
Motorola
Motorola
Alcatel
Alcatel
Texas
Level One
Level One
Lucent
Analog Devices
Globespan
Globespan
LXT400/441
LXT400/441
LXT400/441
LXT400/441
LXT441
LXT/441
MTK-20150/140
MTK-20150/140
MTK-20141
1AB071110008
1AB01965-0026
THS6012
XS143462SK1
XS143462SK1
MTK-20141
MTK-20141
TNETD4000R
SK70704/706/
725/721
LEO1
AD20msp918
DMT IC
DMT IC
pm-dslxx 06/00
Specifications subject to change without notice.
20381 BARENTS SEA CIRCLE, LAKE FOREST, CA 92630 • TEL: (949) 452-0511 • FAX: (949) 452-0512 • http://www.premiermag.com
12
DSL LINE ISOLATION
TRANSFORMERS
THRU HOLE OR SMD
TEMP RANGE
ELECTRICAL
SPECIFICATIONS AT 25OC - OPERATING TEMPERATURE RANGE -40OC TO +85OC
PART
NUMBER
PM-DSL68G
PM-DSL69
PM-DSL70
PM-DSL70G
PM-DSL71
PM-DSL72G
PM-DSL73G
PM-DSL74G
PM-DSL75
PM-DSL75G
PM-DSL76G
PM-DSL77G
PM-DSL78
PM-DSL79G
PM-DSL80
PM-DSL81
PM-DSL82G
PM-DSL83G
PM-DSL84
PM-DSL84G
PM-DSL85
PM-DSL85G
PM-DSL86
PM-DSL87
PM-DSL88
PM-DSL89
PM-DSL89G
PM-DSL90
PM-DSL91
PM-DSL92
PM-DSL92G
PM-DSL93G
PM-DSL95G
PM-DSL96G
PM-DSL97G
PM-DSL98G
PM-DSL99
PM-DSL99G
PM-DSL102
PM-DSL102G
PM-DSL103
PM-DSL103G
PM-DSL105G
Ratio
Primary PRI - SEC
(SEC:PRI)
OCL
LL
(mH TYP.) (µ
µH Max.)
± 3%
1 : 1.27
1 : 2.2
1 : 3.3
1 : 3.3
1 : 1.41
1 : 2.0
1 : 4.0
1 : 5.4
1 : 1.1
1 : 1.1
1 : 1.0
1 : 1.8
1 : 2.0
1 : 1.0
1 : 1.27
1 : 2.3
1 : 5.4
1 : 1.0
1 : 7.48
1 : 7.48
1 : 5.4
1 : 5.4
1 : 4.0
1 : 2.14
1 : 4.0
1 : 2.0
1 : 2.0
1 : 1.0
1:1:1:1
1 : 5.4
1 : 5.4
1 : 3.4
1 : 1.8
1 : 2.0
1 : 2.0
1 : 3.4
1 : 5.4
1 : 5.4
1 : 2.76
1 : 2.76
1 : 4.4
1 : 4.4
1 : 4.0
17.6
3.0
.800
.800
.100
.100
2.0
3.0
2.0
2.0
.440
.450
.800
5.0
17.6
2.0
2.0
200
3.0
3.0
3.0
3.0
2.0
3.2
2.0
2.0
2.0
250
0.8
3.00
3.00
3.2
2.75
2.00
410
3.25
3.00
3.00
2.00
2.00
2.50
2.50
2.05
12
11
10
10
12
12
12
12
10
10
5
6
10
18
12
35
18
60
38
38
15
15
13
30
32
30
30
60
15
15
15
15
10
15
16
15
15
25
25
0.35
0.35
15
DCR
( Ω Max)
PRI
SEC
1.4
2.5
1.1
1.1
1.0
1.4
2.5
2.2
2.6
2.6
2.0
1.6
1.4
1.65
1.8
1.6
5.0
18.5
6.0
6.0
3.2
3.2
2.5
3.74
.85
1.0
.40
.40
1.0
.50
1.0
.44
2.4
2.4
1.0
.30
.80
1.65
1.0
.85
.30
18.5
0.30
0.30
0.35
0.35
0.35
2.0
5.2
5.2
20.0
5.0
4.0
4.0
3.1
5.0
2.5
1.4
3.0
1.50
1.50
3.2
3.2
1.46
1.46
20.0
5.0
0.35
0.35
0.44
2.3
1.4
0.70
0.44
0.35
0.35
1.6
1.6
3.0
0.45
Package
/
Schematic
EP13G/T
EP13/D
EP13/D
EP13G/D
EP13G/B
EP13G/B
EP13G/A
EP13G/A
EP13/T
EP13G/T
EP13G/T
EP13G/I
EP13/D
EP13G/T
EP13/T
EP13/D
EP10/X
EP13/N
EP13/V
EP13G/V
EP13/W
EP13G/W
EP13/W
EP13/Y
EP17/Z
EP13/V
EP13G/V
EP13/N
EP13/AA
EP13/V
EP13G/V
EP13G/V
EP13G/V
EP13G/AB
EP13G/B
EP13G/V
EP13/V
EP13G/V
EP13/R
EP13G/R
EP13/AE
EP13G/AE
EP13G/V
IC
P/N
IC
Manufacture
Analog Devices
Globespan
Conexant
Conexant
Globespan
Globespan
Globespan
Globespan
Analog Devices
Analog Devices
Centillium
Analog Devices
Conexant
Centillium
Analog Devices
Level One
Globespan
Level One
AD20msp918
HDSL2
20441
20441
DSL
DSL
MDSL
MDSL2
AD20msp930
AD20msp930
CT-L41SC04
CT-L50SC04
CN9001
CT-L41ST01
AD20msp918
SK 70740
Globespan
Globespan
GS 2237/GS3137
GS 2237/GS3137
Globespan
HDSL
Globespan
Globespan
METALINK
METALINK
GS 2237/GS3137
GS 2237/GS3137
LXT400
METALINK
Globespan
pm-dslxx 06/00
Specifications subject to change without notice.
20381 BARENTS SEA CIRCLE, LAKE FOREST, CA 92630 • TEL: (949) 452-0511 • FAX: (949) 452-0512 • http://www.premiermag.com
13
DSL LINE ISOLATION
TRANSFORMERS
THRU HOLE OR SMD
MECH. PKG. "EP13G"
MECH. PKG. "EP13"
RECOMMENDED PCB LAYOUT
B-014, 17mm TIPS ONLY
.730
(18.54)
.050
(1.27)
10
.550
(13.97)
M AX
CO RE
TAPED
.500
(12.70)
M AX
TERMINATION S
CA NNOT EXCEED
STANDO FFS
.024
(.61)
REM OVE PIN#3
5
4
3
2
7
1
2
1
3
4
.520
(1 3.20)
MAX
1
10
5
6
.100
(2.54)
6
.7 00
.52
(1 3.2) (1 7.7 8)
MAX
.394
(10.00)
.100
(2.54)
8
.550
(13.97)
M AX
.137
(3.5)
TYP
.024
(.61)
9
SPEC IAL LO W PROFILE BO BBIN
P IN # 1
W H ITE D O T
PIN #1
W HITE D O T
.070
(1.78)
N O TE:
THIS IS 17.0M M LEA D TIP
BO BBIN (B-014 O N LY)
5
.530
(1 3.4 6)
MAX
C O RE
TA PED
.4 85
(1 2.32)
M A X .0 10
(0 .25)
6
7
8
9
.590
(1 5.0 0)
M IN
.7 00
(1 7.7 8)
MAX
10
.1 00
(2.54 )
.0 28
(0 .70 )
.0 28
(0 .7)
M IN
MECH. PKG. "EP10"
5
6
7
MECH. PKG. " EP10G"
RECOMMENDED PCB LAYOUT
8
.600
(15.24)
8
4
3
2
1
7
6
5
P IN # 1
W H IT E D O T
.4 80
(1 2 .19 )
M AX
.4 40
(1 1 .18 )
M AX
.413
(10.5)
CO RE
TAPE
.4 75
(1 2 .07 )
M AX
3
.0 24
(.6 1 )
1
.2 95
(7 .4 9)
.0 98
(2 .4 9)
4
2
1
8
4
5
.098
(2.50)
.600
(15.24)
MAX
PIN #1
W HITE DOT
.1 20
(3 .8 1)
M IN
.0 24
(.6 1 )
.050
(1.27)
.100
(2.54)
PIN #1
W HITE DOT
1
2
3
4
.440
(11.18)
MAX
.490
(12.45)
MAX
CORE
TAPED
.440
(11.18)
MAX
5
6
7
.028
(0.70)
8
Specifications subject to change without notice.
.098
(2.50)
.010
(0.25)
.480
(12.19)
MIN
.600
(15.24)
MAX
pm-dslxx 06/00
20381 BARENTS SEA CIRCLE, LAKE FOREST, CA 92630 • TEL: (949) 452-0511 • FAX: (949) 452-0512 • http://www.premiermag.com
14
DSL LINE ISOLATION
TRANSFORMERS
THRU HOLE OR SMD
MECH. PKG. "EP7"
4
5
MECH. PKG. "EP7G"
6
RECOMMENDED PCB LAYOUT
.075
(1.91)
3
2
1
6
PIN #1
WHITE DOT
.394
(10.01)
MAX
.335
(8.51)
MAX
PIN
#1
(Dot)
.400
(10.16)
MAX
1
.098
(2.49)
2
.335
(8.51)
MAX
CORE
TAPED
.197
(5.00)
2
.365
(9.27)
MAX
.010
(0.25)
1
.197
(5.00)
5
.100
(2.54)
3
.394
(10.01)
MAX
.118
(3.00)
TYP
.024
SQ.
4
4
.050
(1.27)
CORES
TAPED
3
5
.375
(9.53)
.100
(2.54)
.024
(0.6)
6
.492 (12.5)
.508 (12.9)
MECH. PKG. "EP17"
MECH. PKG. "R"
5
3
PIN #1
WHITE DOT
1
2
.803
(20.4)
MAX
CORE CLIPS, 2EA
WHITE DOT DENOTES
PIN#1 SIDE OF BOBBIN
.024
.13
(.61)
(3.3)
DIA.
CORE
TAPED
.640
(16.26)
MAX
.165
(4.19)
MIN
.590
LEAD LENGTH IS
(14.99)
.165" MIN FROM
WIRE/SOLDER CONNECTION
TO LEAD TIPS.
.04
(1.02)
TYP
.764
(19.4)
MAX
.510
(12.95)
MAX
.014
(.356)
.760
(19.30)
MAX
.760
(19.30)
MAX
6
4
.197
(5.00)
.800
(20.32)
TYP
3
2
.024
(.61)
DIA
1
.028
(.71)
5
6
7
8
(8)
(7)
(6)
(5)
CUSTOMER PIN NUMBER (#)
pm-dslxx 06/00
Specifications subject to change without notice.
20381 BARENTS SEA CIRCLE, LAKE FOREST, CA 92630 • TEL: (949) 452-0511 • FAX: (949) 452-0512 • http://www.premiermag.com
15
DSL LINE ISOLATION
TRANSFORMERS
THRU HOLE OR SMD
MECH. PKG. "P18/11"
4
3
5
2
6
1
PIN #1
I.D.
.709
(18.0)
Max.
.940
(23.88)
Max
.094
(2.39)
.420
(11.0)
MAX.
.190
(4.83)
.015
.850
(21.59)
.140
.280
PM-DSLxx SCHEMATIC "B"
PM-DSLxx SCHEMATIC "A"
WHITE DOT
DENOTES PIN #1
WHITE DOT
DENOTES PIN #1
10
9
1
SEC #1B
PRI #1B
4
SECONDARY
8
(CHIP SIDE)
2
SEC #1B
SECONDARY
(CHIP SIDE)
PRIMARY
(LINE SIDE)
PRI #1A
7
5
4
9
2
PM-DSLxx SCHEMATIC "D"
WHITE DOT
DENOTES PIN #1
7
SECONDARY
or
(CHIP SIDE)
8
SEC #1A
PRI #1B
2) SECONDARY CENTER TAP IS FORMED
BY CONNECTING PIN#7 TO PIN#9
PM-DSLxx SCHEMATIC "C"
SEC #1B
PRIMARY
(LINE SIDE)
6
5
NOTE:
1) PRIMARY CENTER TAP IS FORMED
BY CONNECTING PIN#2 TO PIN#4
NOTE:
1) PRIM ARY CENTER TAP IS FORMED
BY CONNECTING PIN#4 TO PIN#2
10
PRI #1A
7
SEC #1A
SEC #1A
1
W HITE DO T
DEN OTES PIN #1
1
10
PRI #1B
5
2
PRI #1B
PRIMARY
(LINE SIDE)
PRIM ARY
(LINE SIDE)
SEC #1B
7
4
9
2
PRI #1A
PRI #1A
1
SECONDARY
(CHIP SIDE)
SEC #1A
6
5
NOTE:
1) PR IM ARY CENTER TAP IS FORMED
BY CONNECTING PIN#7 TO PIN #9
6
4
NOTE:
1) PRIMARY CENTER TAP IS FORMED
BY CONNECTING PIN#1 TO PIN#4
OR PIN#2 TO PIN#5
2) SECONDARY PIN #8 MAKES NO CONNECTION
2) SECONDARY CENTER TAP IS FORMED
BY CONNECTING PIN#2 TO PIN #4
pm-dslxx 06/00
Specifications subject to change without notice.
20381 BARENTS SEA CIRCLE, LAKE FOREST, CA 92630 • TEL: (949) 452-0511 • FAX: (949) 452-0512 • http://www.premiermag.com
16
DSL LINE ISOLATION
TRANSFORMERS
THRU HOLE OR SMD
PM-DSLxx SCHEMATIC "E"
PM-DSLxx SCHEMATIC "F"
W H ITE D O T
D EN O TES PIN # 1
10
WHITE DOT
DENOTES PIN #1
1
SEC # 1B
P R I # 1B
8
5
7
2
SEC # 1A
P R I # 1A
S EC O N DA RY
(C H IP S ID E )
1
P R IM A RY
(LIN E SIDE )
PRI #1A
2
6
4
N O TE:
1) PR IM A RY C EN T ER TA P IS F O R M ED
BY C O N N EC TIN G PIN # 2 TO PIN # 5
3
SECONDARY
5
PRI #1B
6
2) SEC O N DA RY C EN TER TA P IS F O R M ED
BY C O N N EC TIN G PIN # 8 TO PIN # 7
PM-DSLxx SCHEMATIC "G"
PM-DSLxx SCHEMATIC "H"
W H ITE D O T
D EN O TES PIN # 1
10
1
SEC # 1 B
SEC O N D A RY
(C H IP S ID E)
WHITE DOT
DENOTES PIN #1
PRI #1B
9
2
8
3
SEC # 1 A
1
8
PRI #1B
P R IM A RY
(L IN E SID E)
PRIMARY
(LINE SIDE)
7
2
6
3
PRI #1A
PRI #1A
SEC #1B
SECONDARY
(CHIP SIDE)
SEC #1A
6
5
N O T E:
1) PR IM A R Y C EN T ER TA P IS F O R M ED
BY C O N N EC TIN G PIN # 2 TO P IN # 3
4
5
NOTE:
1) PRIMARY CENTER TAP IS FORMED
BY CONNECTING PIN#6 TO PIN#7
2) SEC O N D A R Y C E N TER TA P IS F O R M E D
BY C O N N EC TIN G PIN # 9 TO P IN # 8
2) SECONDARY CENTER TAP IS FORMED
BY CONNECTING PIN#2 TO PIN#3
PM-DSLxx SCHEMATIC "I"
PM-DSLxx SCHEMATIC "J"
WHITE DOT
DENOTES PIN #1
SEC #1B
SECONDARY
(CHIP SIDE)
PRI #1A
3
9
2
6
PRIMARY
(LINE SIDE)
PRI #1B
7
4
NOTE:
1) PRIMARY CENTER TAP IS FORMED
BY CONNECTING PIN#2 TO PIN#4
PRIMARY
4
1
SECONDARY
IC SIDE
8
SEC #1A
WHITE DOT
DENOTES PIN #1
1
LINE SIDE
10
3
2) SECONDARY CENTER TAP IS FORMED
BY CONNECTING PIN#7 TO PIN#9
pm-dslxx 06/00
Specifications subject to change without notice.
20381 BARENTS SEA CIRCLE, LAKE FOREST, CA 92630 • TEL: (949) 452-0511 • FAX: (949) 452-0512 • http://www.premiermag.com
17
DSL LINE ISOLATION
TRANSFORMERS
THRU HOLE OR SMD
PM-DSLxx SCHEMATIC "K"
PM-DSLxx SCHEMATIC "L"
WHITE DOT
DENOTES PIN #1
1
WHITE DOT
DENOTES PIN #1
1
8
PRI #1A
PRI #1A
SEC #1A
PRIMARY 3
(LINE SIDE)
2
PRIMARY
(LINE SIDE) 2
SEC #1B
8
5
7
5
4
NOTE:
1) PRIMARY CENTER TAP IS FORMED
BY CONNECTING PIN#2 TO PIN#3
NOTE:
1) PRIMARY CENTER TAP IS FORMED
BY CONNECTING PIN#2 TO PIN#4
PM-DSLxx SCHEMATIC "N"
PM-DSLxx SCHEMATIC "M"
WHITE DOT
DENOTES PIN #1
PRI #1B
PRI #1A
WHITE DOT
DENOTES PIN #1
6
5
SEC #1B
SECONDARY
(CHIP SIDE)
WHITE DOT
DENOTES PIN #1
3
LINE SIDE
4
4
9
IC SIDE
SECONDARY
2
IC SIDE
LINE SIDE
6
PM-DSLxx SCHEMATIC "P"
WHITE DOT
DENOTES PIN #1
6
PRIMARY
(LINE SIDE)
PRI #1A
5
PM-DSLxx SCHEMATIC "O"
PRIMARY
8
SEC #1A
4
1
PRI #1B
SECONDARY
(CHIP SIDE) 3
SEC #1A
3
10
1
SEC #1B
PRIMARY
2
(LINE SIDE)
SECONDARY
(CHIP SIDE)
SEC #1B
PRI #1B
PRI #1B
1
SEC #1A
4
SECONDARY
(CHIP SIDE)
7
9
7
pm-dslxx 06/00
Specifications subject to change without notice.
20381 BARENTS SEA CIRCLE, LAKE FOREST, CA 92630 • TEL: (949) 452-0511 • FAX: (949) 452-0512 • http://www.premiermag.com
18
DSL LINE ISOLATION
TRANSFORMERS
THRU HOLE OR SMD
PM-DSLxx SCHEMATIC "Q"
PM-DSLxx SCHEMATIC "R"
WHITE DOT
DENO TES PIN #1
WHITE DOT
DENOTES PIN #1
PRI #1B
10
SECONDARY
4
PRIMARY
(LINE SIDE)
IC SIDE
LINE SIDE
1
PRIMARY
10
1
SEC #1B
4
6 SECONDARY
(CHIP SIDE)
9
2
PRI #1A
SEC #1A
5
7
NOTE:
1) PRIMARY CENTER TAP IS FO RMED
BY CONNECTING PIN#2 TO PIN#4
7
2) SECO NDARY CENTER TAP IS FORMED
BY CONNECTING PIN#6 TO PIN#9
PM-DSLxx SCHEMATIC "S"
PM-DSLxx SCHEMATIC "T"
WHITE DOT
DENO TES PIN #1
W HITE D O T
D E NO TE S PIN #1
10
PR I # 1B
4
9
PR I # 1A
PR IM A RY
(LIN E SID E )
SECONDAR Y
(C HIP S IDE)
2
1
PR I # 1 B
SEC #1B
6
PR IMARY
(LINE SIDE)
10
1
8
3
9
2
PR I # 1 A
SEC #1A
SE C #1 B
SE C O N D AR Y
(C HIP S ID E )
SE C #1 A
7
5
NOTE:
1) PRIMARY C ENTER TAP IS FO RM ED
BY C ONNEC TING PIN#6 TO PIN#9
7
5
N O T E:
1 ) PRIM AR Y C EN T E R TA P IS FO RM ED
BY C O N N EC T IN G PI N #8 T O PIN # 9
2) SECO NDAR Y CENTER TAP IS FORMED
BY C ONNEC TING PIN#2 TO PIN#4
2 ) SE CO ND A R Y C EN T ER TA P IS FO R M ED
BY C O N N EC T IN G PI N #2 T O PIN # 3
PM-DSLxx SCHEMATIC "V"
PM-DSLxx SCHEMATIC "U"
WHITE DOT
DENOTES PIN #1
4
PRI #1B
PRIMARY
(LINE SIDE)
WHITE DOT
DENOTES PIN #1
9
10
SEC #1B
2
7
5
1
PRI #1B
SECONDARY
(CHIP SIDE)
SECONDARY
(CHIP SIDE)
4
2
PRIMARY
(LINE SIDE)
SEC #1A
PRI #1A
1
PRI #1A
6
5
7
NOTE:
1) PRIMARY CENTER TAP IS FORMED
BY CONNECTING PIN#4 TO PIN#2
NOTE:
1) PRIMARY CENTER TAP IS FORMED
BY CONNECTING PIN#2 TO PIN#5
pm-dslxx 06/00
Specifications subject to change without notice.
20381 BARENTS SEA CIRCLE, LAKE FOREST, CA 92630 • TEL: (949) 452-0511 • FAX: (949) 452-0512 • http://www.premiermag.com
19
DSL LINE ISOLATION
TRANSFORMERS
THRU HOLE OR SMD
PM-DSLxx SCHEMATIC "X"
PM-DSLxx SCHEMATIC "W"
WHITE DOT
DENOTES PIN #1
WHITE DOT
DENOTES PIN #1
4
1
6
PRIMARY
(LINE SIDE)
2
PRIMARY 3
(LINE SIDE)
2
SECONDARY
(CHIP SIDE)
5
8
PRI #1A
PRI #1B
SECONDARY
(CHIP SIDE)
PRI #1B
PRI #1A
5
10
4
1
NOTE:
1) PRIMARY CENTER TAP IS FORMED
BY CONNECTING PIN#2 TO PIN#5
NOTE:
1) PRIMARY CENTER TAP IS FORMED
BY CONNECTING PIN#2 TO PIN#3
PM-DSLxx SCHEMATIC "Z"
PM-DSLxx SCHEMATIC "Y"
W H ITE D O T
D EN O TE S PIN # 1
W HITE D O T
D ENO TES PIN #1
PRIM ARY
(LINE SIDE)
S EC O N D A RY # 1
SEC #1B
PRI #1B
5
8
(8)
2
7
(9)
PRI #1A
SECO NDA RY
(C HIP SID E)
S EC O N D A RY
(C H IP S ID E )
6
(7 ) 6
3
(5 ) 8
2
(10)
4
C USTO M ER P IN N U M B ER (# )
N O T E:
1) PR IM A R Y C E N T ER TA P IS F O R M E D
B Y C O N N EC TIN G PIN # 2 TO P IN # 3
N OTE:
1) PR IM ARY CENTER TAP IS FORM ED
BY CON N ECTIN G PIN#5 TO PIN#2
PM-DSLxx SCHEMATIC "AB"
PM-DSLxx SCHEMATIC "AA"
WHITE DOT
DENOTES PIN #1
WHITE DOT
DENOTES PIN #1
PRI #1B
PRI #1A
SEC #1B
9
4
7
5
1
10
2
PRI #1A
P RIM A R Y
(L IN E SID E )
P RI # 1 B
(8 ) 5
C USTOM ER PIN (#)
1
P RI # 1 A
S EC O N D A RY # 2
SEC #1A
4
1
(6 ) 7
10 (6)
1
PRIMARY
(LINE SIDE)
8
2
9
5
6
SEC #1A
4
PRI #1B
SEC #1A
10
SEC #1B
7
NOTE:
1) PRIMARY CENTER TAP IS FORMED
BY CONNECTING PIN#4 TO PIN#2
Specifications subject to change without notice.
SECONDARY
(CHIP SIDE)
pm-dslxx 06/00
20381 BARENTS SEA CIRCLE, LAKE FOREST, CA 92630 • TEL: (949) 452-0511 • FAX: (949) 452-0512 • http://www.premiermag.com
20
DSL LINE ISOLATION
TRANSFORMERS
THRU HOLE OR SMD
PM-DSLxx SCHEMATIC "AD"
PM-DSLxx SCHEMATIC "AC"
W H ITE D O T
D EN O TES PIN # 1
WHITE DOT
DENOTES PIN #1
1
10
SEC #1B
8
PRI #1 B
PRI #1B
2
SECONDARY
(CHIP SIDE) 3
9
8
SEC #1A
PRIM ARY
(LIN E SIDE)
PRIMARY
(LINE SIDE)
SEC #1 B
7
2
6
3
PRI #1 A
PRI #1A
1
SEC O N DA RY
(C HIP SID E)
SEC #1 A
5
6
NOTE:
1) PRIMARY CENTER TAP IS FORMED
BY CONNECTING PIN#9 TO PIN#8
4
5
N O TE:
1) PR IM ARY C ENTER TAP IS F O R M ED
BY C O N N EC TIN G PIN# 6 TO PIN # 7
2) SECONDARY CENTER TAP IS FORMED
BY CONNECTING PIN#2 TO PIN#3
2) SEC O N DA RY C EN TER TA P IS F O R M ED
BY C O N N EC TIN G PIN# 2 TO PIN # 3
PM-DSLxx SCHEMATIC "AE"
WHITE DOT
DENOTES PIN #1
9
1
PRI #1A
SECONDARY #2
8
4
7
2
SECONDARY #1B
PRI #1B
5
10
SECONDARY #1A
6
pm-dslxx 06/00
Specifications subject to change without notice.
20381 BARENTS SEA CIRCLE, LAKE FOREST, CA 92630 • TEL: (949) 452-0511 • FAX: (949) 452-0512 • http://www.premiermag.com
21
COUPLED INDUCTOR
For Uses in ADSL POTS
Low Pass Filters
FEATURES
Ê
Ë
Ì
Í
Excellent Longitudinal Balance
1500V Isolation
Inductance Tolerance ± 5%
DC Current up to 100mA
ELECTRICAL SPECIFICATIONS AT 25OC - OPERATING TEMPERATURE RANGE -40OC TO +85OC
PART
NUMBER
PM-IND019
PM-IND019E
PM-IND020
PM-IND020E
PM-IND024
PM-IND024E
PM-IND025
PM-IND025E
PM-IND030
PM-IND040
PM-IND040E
PM-IND045
PM-IND045E
PM-IND050
PM-IND050E
PM-IND052
PM-IND052E
PM-IND055
PM-IND055E
PM-IND060
PM-IND090
DC R
Inductance
Isolation
(each wdg) (each wdg) (Vrms)
(Ω MAX)
(mH)
1.90±5%
1.90±5%
2.00±5%
2.00±5%
2.40±5%
2.40±5%
2.50±5%
2.50±5%
3.0±5%
4.0±5%
4.0±5%
4.5±5%
4.5±5%
5.00±5%
5.0±5%
5.25±5%
5.25±5%
5.5±5%
5.5±5%
6.0±5%
9.0±5%
1.8
2.3
1.9
2.4
2.1
2.7
2.2
2.8
3.0
3.0
4.0
3.6
4.5
4.0
5.4
4.5
5.8
4.7
6.0
5.0
6.0
1500
1500
1500
1500
1500
1500
1500
1500
1500
1500
1500
1500
1500
1500
1500
1500
1500
1500
1500
1500
1500
Function
Package
/
Schematics
Coupled Inductor for POTS Low Pass Filter
Coupled Inductor for POTS Low Pass Filter
Coupled Inductor for POTS Low Pass Filter
Coupled Inductor for POTS Low Pass Filter
Coupled Inductor for POTS Low Pass Filter
Coupled Inductor for POTS Low Pass Filter
Coupled Inductor for POTS Low Pass Filter
Coupled Inductor for POTS Low Pass Filter
Coupled Inductor for POTS Low Pass Filter
Coupled Inductor for POTS Low Pass Filter
Coupled Inductor for POTS Low Pass Filter
Coupled Inductor for POTS Low Pass Filter
Coupled Inductor for POTS Low Pass Filter
Coupled Inductor for POTS Low Pass Filter
Coupled Inductor for POTS Low Pass Filter
Coupled Inductor for POTS Low Pass Filter
Coupled Inductor for POTS Low Pass Filter
Coupled Inductor for POTS Low Pass Filter
Coupled Inductor for POTS Low Pass Filter
Coupled Inductor for POTS Low Pass Filter
Coupled Inductor for POTS Low Pass Filter
A
C
A
C
A
C
A
C
A
A
C
A
C
A
C
A
C
A
C
B
B
pm-indxxx 05/2001
Specifications subject to change without notice.
20381 BARENTS SEA CIRCLE, LAKE FOREST, CA 92630 • TEL: (949) 452-0511 • FAX: (949) 452-0512 • http://www.premiermag.com
22
COUPLED INDUCTOR
For Uses in ADSL POTS
Low Pass Filters
PACKAGE "A"
PACKAGE "B"
W HITE D O T
D ENO TES PIN #1
W H ITE D O T
D E N O TE S P IN # 1
8
7
6
PIN #1
NOTCH
5
3
5
4
P PM-INDXXX
M YYWW
1
10
2
9
3
8
4
5
PIN #1
NOTCH
1
2
3
P PM-INDXXX
M YYWW
.950
(24.13)
MAX
4
.760
(19.30)
MAX
.020
(.51)
.015
(.381)
TYP
.042
(1.07)
6
5
7
6
.930
(23.62)
MAX
.450
(11.43)
MAX
.110
(2.79)
MIN
.300
(7.62)
3
1.080
(27.43)
MAX
.760
(19.30)
MAX
.150
(3.81)
10
1
8
1
.800
(20.32)
.650
(16.51)
.210
(5.33)
TYP
.150
(3.81)
.300
(7.62)
.045
(1.14)
PACKAGE "C"
WHITE DOT
DENOTES PIN #1
1
P PM-INDXXX
M YYWW
10
PRI 3
PIN #1
WHITE DOT
.550
(13.97)
MAX
SEC
6
5
CORE
TAPED
.550
(13.97)
MAX
.530
(13.46)
MAX
.130
(3.3)
MIN
.024
(.61)
.024
(.61)
.394
(10.00)
.100
(2.54)
5
4
3
2
1
6
7
8
9
10
pm-indxxx 05/2001
Specifications subject to change without notice.
20381 BARENTS SEA CIRCLE, LAKE FOREST, CA 92630 • TEL: (949) 452-0511 • FAX: (949) 452-0512 • http://www.premiermag.com
23
T1/E1/ISDN-PRI
3KV - REINFORCED
SMD TRANSFORMERS
Ê For T1/CEPT/ISDN-PRI Telecommunications Applications
Ë Designed to Meet CCITT and FCC Requirments
Ì Designed for Majority of Line Interface Transceiver Chips
Í Package meets UL 94-V0 Flammability
º 3KV Reinforced Insulation to EN60950
» Dual Core SMD Package
EXTENDED TEMP RANGE
ELECTRICAL SPECIFICATIONS AT 25OC - OPERATING TEMPERATURE RANGE -40OC TO +85OC
TURNS RATIO
PRI : SEC (± 3%)
PART
NUMBER
PRIMARY
OCL
(mH Min.)
PM-T1030
1ct:1ct & 1ct:1ct
PM-T1031
1ct:1ct & 1ct:2ct
PM-T1032
1ct:1.15ct & 1ct:1ct
PM-T1033 1ct:1.15ct & 1ct:1.15ct
PM-T1034
1ct:1.15ct & 1ct:2ct
PM-T1036 1ct:1.36ct & 1ct:1.36ct
PM-T1037 1ct:1.41ct & 1ct:1.41ct
PM-T1038
1ct:1ct & 1ct:1.36ct
PM-T1039
1ct:2ct & 1ct:1.08ct
PM-T1043
1ct:2ct & 1ct:1.14ct
PM-T1044
1ct:2ct & 1ct:1.36ct
PM-T1045
1ct:2ct & 1ct:2ct
PM-T1055
1ct:2ct & 1ct:2ct
PM-T1060(1) 1:1.26tp & 1:1.26tp
PRIMARY
LL
µH Max.)
(µ
1.20 & 1.20
1.20 & 1.20
1.60 & 1.60
1.20 & 1.20
1.50 & 1.20
1.20 & 1.20
1.20 & 1.20
1.20 & 1.20
1.20 & 1.20
1.20 & 1.20
1.20 & 1.20
1.20 & 1.20
1.20 & 1.20
1.50 & 1.50
1.00
1.00
1.20
1.00
1.00
1.00
1.00
1.00
1.00
1.00
1.00
1.00
1.00
0.90
PRIMARY
PINS
PRIMARY/SEC
DCR
(Ohms Max.)
PRI-SEC
Cw/w
(pf Max.)
50
50
50
50
50
50
50
50
50
50
50
50
50
50
0.80 / 0.80
0.80 / 1.00
0.80 / 0.90
0.80 / 0.90
0.80 / 1.00
0.80 / 1.00
0.80 / 1.00
0.80 / 1.00
0.80 / 1.00
0.80 / 1.00
0.80 / 1.00
0.80 / 1.00
0.80 / 1.00
0.80 / 1.00
Package
/
Schematic
1-3 & 6-8
1-3 & 6-8
16-14 & 6-8
1-3 & 6-8
16-14 & 6-8
1-3 & 6-8
16-14 & 11-9
1-3 & 6-8
16-14 & 6-8
16-14 & 6-8
16-14 & 6-8
16-14 & 6-8
16-14 & 11-9
1-3 & 6-8
A
A
A
A
A
A
A
A
A
A
A
A
A
B
(1) Dual Ratio Transformers, tp = tapped as follows PM-T1060: CORE A = PINS 16-14 : PINS 1-3 = 1:1.26 ; PINS 15-14 : PINS 1-3 = 1.1.00
CORE B = PINS 11- 9 : PINS 6-8 = 1:1.26 ; PINS 10- 9 : PINS 6-8 = 1.1.00
16
PCB LAYOUT
.520 (13.21)
7x.100 (2.54)
16
16x.050 (1.27)
13
12
11
10
9
MECHANICAL
PIN#1
DOT
1
3
4
5
6
7
.600
(15.24)
8
.950
(24.13)
MAX
.700 (17.78)
8
2
.530
(13.46)
MAX
.390
(9.91)
MAX
9
.020
(0.51)
TYP
SCHEMATICS
A
.050
(1.27)
TYP
.100
(2.54)
TYP
DUAL CORE
B
S EC O N D A R Y
13
12
2
3
4
5
11
10
9
6
7
8
16
15
14
13
12
3
4
5
S EC O N D A R Y
11
CORE A
1 :1 .2 6 t p
1
2
P R IM A R Y
TR A N C O R E
CORE B
Specifications subject to change without notice.
9
1:
1 :1 .2 6 t p
1:
1
10
1 .2 6
14
LIN E S ID E
1 .0 0
15
1 .2 6
16
.010
(0.25)
TYP
.050 (1.27)
FLAT
.030 (0.76)
.720
(18.29)
MAX
.020 (.51)
.010 (.25)
1 .0 0
1
14
P PM-T10XX
M YYWW
.760 (19.30)
16x.120 (3.05)
15
C H IP S ID E
6
7
8
P R IM A R Y
RC V C O RE
pmt10xx 6/98
20381 BARENTS SEA CIRCLE, LAKE FOREST, CA 92630 • TEL: (949) 452-0511 • FAX: (949) 452-0512 • http://www.premiermag.com
24
T1/E1/ISDN-PRI
3KV - REINFORCED
THRU-HOLE TRANSFORMERS
Ê Reinforced Insulation Per EN41003/EN60950
Ë 3000Vrms Minimum Isolation Voltage
Ì For T1/CEPT/ISDN-PRI Line Interfaces
Í Matched to Leading Transceiver Chips
Î Industry Standard UL94-V0 Package
Ï Single Core Configurations
SINGLE CORE
NORMAL TEMP RANGE
ELECTRICAL SPECIFICATIONS AT 25OC - OPERATING TEMPERATURE RANGE 0OC TO +70OC
PART
NUMBER
PM-IS30
PM-IS31
PM-IS32
PM-IS33
PM-IS34
PM-IS35 (2)
PM-IS36 (1)
PM-IS37 (2)
PM-IS38
PM-IS39 (1)
TURNS
RATIO
(Pri:Sec ± 5%)
PRIMARY
OCL
(mH Min.)
1.27CT:1
1CT:1
1:1.36CT
1CT:2CT
1:1
1: 1.14
1:1.58tp/2
1:1.36
1:1.14CT
1:1/1.26tp
0.80
0.80
1.20
1.20
1.20
0.60
1.50
0.60
1.50
1.50
PRIMARY
LL
µH Max.)
(µ
PRI-SEC
Cw/w
(pf Max.)
0.70
0.60
0.60
0.55
0.50
1.0
0.70
1.0
1.00
0.60
15
15
35
20
20
40
20
40
30
35
PRIMARY
SECONDARY
DCR
DCR
(Ohms Max.) (Ohms Max.)
0.50
0.50
0.50
0.50
0.50
1.20
0.70
1.20
0.70
0.70
0.35
0.45
0.60
0.90
0.50
1.20
1.20
1.20
0.90
1.10
Schematics
on Page 2
Primary
Pins
C
C
D
A
B
E
D
E
D
D
1-5
1-5
10-6
1-5
1-5
10-6
10-6
10-6
10-6
10-6
SINGLE CORE
EXTENDED TEMP RANGE
ELECTRICAL SPECIFICATIONSAT 25OC - OPERATING TEMPERATURE RANGE -40OC TO +85OC
PART
NUMBER
TURNS
RATIO
(Pri:Sec ± 5%)
PRIMARY
OCL
(mH Min.)
PM-IS351 (2)
PM-IS361 (1)
PM-IS391 (1)
1: 1.14
1:1.58tp/2
1:1/1.26tp
0.60
1.80
1.80
PRIMARY
LL
µH Max.)
(µ
PRI-SEC
Cw/w
(pf Max.)
1.0
0.90
0.80
40
35
50
PRIMARY
SECONDARY
DCR
DCR
(Ohms Max.) (Ohms Max.)
1.20
1.00
1.00
1.20
1.40
1.30
Schematics
on Page 2
E
D
D
Primary
Pins
10-6
10-6
10-6
(1) Dual Ratio Transformers, tp = Tapped as Follows
PINS 10-6 : PINS 3-5 = 1:1.58 ; PINS 10-6 : PINS1-5 = 1:2
PINS 10-6 : PINS 3-5 = 1:1
; PINS 10-6 : PINS1-5 = 1:1.26
(2) Pins 1 & 3 Are Electrically Connected Together Inside The Case, Trim/Remove Pin# 2,4,7,8,9
pmis3xxx 9/99
Specifications subject to change without notice.
20381 BARENTS SEA CIRCLE, LAKE FOREST, CA 92630 • TEL: (949) 452-0511 • FAX: (949) 452-0512 • http://www.premiermag.com
25
T1/E1/ISDN-PRI
3KV - REINFORCED
THRU-HOLE TRANSFORMERS
SCHEMATICS
MECHANICAL
SINGLE CORE PACKAGE
SCHEMATIC "A"
SCHEMATIC "B"
SECONDARY
SECONDARY
10
8
6
10
10
9
8
7
6
6
P PM-IS3X
M YYWW
1
3
5
1
5
PRIMARY
PRIMARY
SCHEMATIC "C"
SCHEMATIC "D"
SECONDARY
PRIMARY
10
6
10
1
2
3
4
5
.5 5 8
(1 4 .1 7 )
M AX
.4 0 0
(1 0 .1 6 )
M AX
.0 2 0
(.5 1 )
TY P
6
.120
(3.05)
MIN
.0 2 5 D IA .
(.6 4 )
1
2
4
5
PRIMARY
1
3
.200
(5.08)
.400
(10.16)
TYP
5
SECONDARY
.5 5 8
(1 4 .1 7 )
M AX
.4 0 0
(1 0 .1 6 )
UNUSED PINS ARE OMITTED
SCHEMATIC "E"
PRIMARY
10
1
6
3
5
SECONDARY
pmis3xxx 9/99
Specifications subject to change without notice.
20381 BARENTS SEA CIRCLE, LAKE FOREST, CA 92630 • TEL: (949) 452-0511 • FAX: (949) 452-0512 • http://www.premiermag.com
26
T1/E1
DUAL CORE SMD
ISOLATION TRANSFORMERS
Ê Transmit & Receive in a Single SMD Package
Ë 2000Vrms Minimum Isolation Voltage
Ì Industry Standard SMD Package
Í Extended Temperature Range Versions
ELECTRICAL SPECIFICATIONS AT 25OC - OPERATING TEMPERATURE RANGE 0OC TO +70OC
PART
NUMBER
PM-IS20
PM-IS21
PM-IS22
PM-IS23
PM-IS24
PM-IS25
PM-IS26
PM-IS27
PM-IS63
TURNS RATIO
(PRI:SEC ± 3%)
T1
T2
1:1.38ct
1ct:2ct
1:2ct
1:1.15ct
1:2ct
1:2ct
1:2ct
1:1.15ct
1ct:2ct
1:1:1
1:1
1:1.15ct
1:2ct
1:1.36ct
1:1.36
1:2ct
1ct:2ct
1:1.36ct
PRIMARY
OCL
(mH Min.)
1.20
1.20
1.20
1.20
1.20
1.20
1.20
1.20
1.20
PRI - SEC
LL
µH Max.)
(µ
0.40
0.40
0.40
0.40
0.40
0.40
0.40
0.40
0.60
PRI - SEC
Cw/w
(pf Max.)
35
30
30
30
35
35
35
30
30
DCR
(PRI/SEC Ω Max)
T1
T2
0.7/1.0
0.7/1.2
0.7/1.2
0.7/0.8
0.7/1.2
0.7/1.2
0.7/1.2
0.7/0.8
0.7/1.2
Schematic
.7/.7/.7
0.7/0.7
0.7/0.8
0.7/1.2
0.7/0.9
0.7/0.9
0.7/1.2
0.7/1.2
0.7/0.9
D
B
A
A
A
C
A
E
I
EXTENDED TEMP RANGE
ELECTRICAL SPECIFICATIONS AT 25OC - OPERATING TEMPERATURE RANGE -40OC TO +85OC
PART
NUMBER
TSD-967(2)
TSD-982(2)
PM-IS28
PM-IS29
PM-IS60
PM-IS61
PM-IS62
PM-IS64
PM-IS65
PM-IS66
PM-IS67
PM-IS68
PM-IS69
PM-IS70
PM-IS71
PM-IS72
PM-IS73
PM-IS74
PM-IS75
PM-IS76
PM-IS77
PM-IS78
PM-IS79
TURNS RATIO
(PRI:SEC ± 3%)
T1
T2
1:1.27 Tp1
1ct:2ct
1ct:2ct
1ct:2ct
1:1.15ct
1ct:1.15ct
1ct:1ct
1:1.27 Tp1
1ct:2ct
1ct:1.5ct
1ct:2.3ct
1ct:2ct
1:2ct
1ct:2.42ct
1:1.14ct
1:1.15ct
1ct:2ct
1ct:1ct
1ct:3ct
1ct:1ct
1ct:2ct
1:1ct
1ct:2ct
1ct:2ct
1ct:2ct
1ct:2ct
1ct:1ct
1ct:2ct
1ct:1.15ct
1ct:1ct
1ct:1ct
1ct:1ct
1ct:2ct
1ct:1ct
1ct:2ct
1:1.36ct
1ct:2.42ct
1: 2ct
1ct:2ct
1:1.36ct
1ct:2.4ct
1ct:1ct
1ct:2ct
1:1
1:1ct
1ct:1ct
PRIMARY
OCL
(mH Min.)
PRI - SEC
LL
µH Max.)
(µ
PRI - SEC
Cw/w
(pf Max.)
1.50/2.0
1.50
1.50
1.50
1.50
1.50
1.50
1.50/2.0
1.50
1.50
1.50
1.50
1.50
1.20
1.50
1.50
1.50
1.00
1.00
1.20
1.40
1.2
2.50
0.80/0.60
0.40
0.60
0.60
0.80
0.80
0.60
0.80/0.60
0.60
0.60
0.60
0.60
0.40
0.60
0.50
0.80
0.60
0.80
1.0
0.60
0.50
0.70
0.60
50/45
35
45
45
45
45
45
50/45
45
45
45
45
45
25
40
40
40
30
40
30
30
22.0
45
DCR
(PRI/SEC Ω Max)
T1
T2
0.9/1.1
0.7/1.4
1.0/2.0
1.0/2.0
0.9/1.0
1.0/1.0
1.0/1.0
0.9/1.1
1.0/2.0
1.0/2.0
1.0/2.0
1.0/2.0
1.0/2.0
0.7/1.2
0.7/0.9
0.9/1.0
1.0/2.0
.85/.85
1.0/2.0
1.0/1.00
0.7/1.2
0.8/0.8
0.7/1.4
1.0/2.0
0.7/1.4
1.0/2.0
1.0/1.0
1.0/2.0
1.0/1.0
1.0/1.0
1.0/1.0
1.0/1.0
1.0/2.0
1.0/1.0
1.0/2.0
1.0/1.4
0.7/1.2
0.7/1.2
1.0/2.0
1.0/1.4
.85/1.5
1.0/1.0
1.0/2.0
0.7/0.7
0.8/0.8
0.7/1.4
Schematic
E
F
F
G
H
G
G
E
F
F
G
J
A
J
A
E
I
G
G
F
B
k
G
Tp1: T1 RATIO'S ARE, PINS 16-14 : PINS 1-2 = 1: 0.027 ; PINS 16-14 : PINS 2-3 = 1:1.00 ; PINS 16-14:PINS 1-3 = 1:1.027
(2): 1500Vrms HI-POT
pmis2_7x 10/01
Specifications subject to change without notice.
20381 BARENTS SEA CIRCLE, LAKE FOREST, CA 92630 • TEL: (949) 452-0511 • FAX: (949) 452-0512 • http://www.premiermag.com
27
T1/CEPT
DUAL CORE SMD
ISOLATION TRANSFORMERS
SCHEMATICS
4
5
16
3
PRI
2
12
SEC
1
13
15
14
13
12
7
10
10
PRI
SEC
11
T2
6
11
9
8
9
5
15
4
SEC
3
12
16
2
13
PRI
1
14
14
13
12
5
15
4
12
6
10
7
8
9
8
SEC
SEC
11
11
7
9
T2
PRI
6
10
PRI
11
10
9
8
SEC
7
9
PRIMARY
6
10
PRI
11
8
T2
16
3
13
SEC
2
14
PRI
1
15
5
16
4
12
7
SEC
6
9
8
10
PRI
SEC
7
11
6
T2
14
8
SEC
7
9
PRI
6
10
8
9
11
PRI
SEC
7
SEC
6
10
3
13
PRI
2
14
SEC
1
15
SEC
5
T2
16
PRI
4
5
3
4
PRI
2
3
T1
2
T1
1
T1
13
T1
14
T1
15
K
12
J
SEC
I
16
H
1
G
T2
15
5
11
8
SEC
7
9
PRIMARY
6
10
8
PRIMARY
7
SEC
11
6
T2
16
PRI
12
T2
PRIMARY
4
SEC
3
13
5
12
5
9
8
10
7
PRIMARY
SEC
11
6
T2
SEC
2
14
4
1
15
3
13
PRIMARY
2
14
4
12
5
T2
SEC
1
15
3
SEC
16
2
13
PRI
1
14
4
15
PRIMARY
3
16
SEC
2
T2
5
T1
4
T1
3
T1
2
T1
1
T1
12
T1
13
F
14
E
15
D
16
C
16
B
1
A
PCB LAYOUT
MECHANICAL
16 15 14 13 12 11 10 9
RECOMMENDED PCB LAYOUT
P PM-ISXX
M YYWW
.420 (10.67)
16x.075 (1.91)
.270 (6.86)
7x.050 (1.27)
PIN#1
WHITE DOT
1
1
2
3
4
5
6
7
16x.025 (.64)
8
.475
(12.10)
MAX
.280
(7.11)
MAX
.350 (8.89)
.210
(5.33)
MAX
.050
.019 (1.27)
(0.48) TYP
TYP
16
.022 (.55)
.010 (.25)
8
.020 (0.51) MIN
9
.010
(0.25)
TYP
.370 (9.40)
pmis2_7x 10/01
Specifications subject to change without notice.
20381 BARENTS SEA CIRCLE, LAKE FOREST, CA 92630 • TEL: (949) 452-0511 • FAX: (949) 452-0512 • http://www.premiermag.com
28
T1/E1/ISDN-PRI
DUAL CORE SMD
ISOLATION TRANSFORMERS
Ê Transmit & Receive in a Single SMD Package
Ë 1500Vrms Minimum Isolation Voltage
Ì Industry Standard SMD Package
Í Extended Temperature Range Versions
NORMAL TEMP RANGE
ELECTRICAL SPECIFICATIONS AT 25OC - OPERATING TEMPERATURE RANGE 0OC TO +70OC
PART
NUMBER
PM-IS80
PM-IS81
PM-IS82
PM-IS83
PM-IS84
TURNS RATIO
(PRI:SEC ± 3%)
T1
T2
PRIMARY
OCL
(mH Min.)
1ct:2ct
1ct:2ct
1.20
1ct:2ct
1:1.36ct 1.20
1:2ct
1ct:1.14ct 1.20
1:1.15ct 1ct:2ct
1.50/1.20
1ct:2ct
1:1.08ct 1.20
PRI-SEC
LL
µH Max.)
(µ
0.60/0.60
0.60/0.80
0.50/0.80
0.80/0.60
0.60/0.60
PRI-SEC
Cw/w
(pf Max.)
35/35
35/35
40/35
35/40
35/30
DCR
(PRI/SEC Ω Max)
T1
T2
0.7/1.2
0.7/1.2
0.7/1.2
0.7/0.9
0.7/1.1
Schematic
0.7/1.2
0.7/0.9
0.7/0.9
0.7/1.2
0.7/0.9
C
B
A
F
B
EXTENDED TEMP RANGE
ELECTRICAL SPECIFICATIONSAT 25OC - OPERATING TEMPERATURE RANGE -40OC TO +85OC
PART
NUMBER
PM-IS85
PM-IS86
PM-IS87
PM-IS88
PM-IS89
PM-IS90
PM-IS91
PM-IS92
PM-IS93
PM-IS94
PM-IS95
PM-IS96
TURNS RATIO
(PRI:SEC ± 3%)
T1
T2
1ct:2ct
1ct:2ct
1:1.15ct
1:2ct
1ct:1ct
1ct:1.15ct
1ct:1ct
1ct:1.15ct
1ct:1.36ct
1ct:1.41ct
1ct:2.30ct
1Tp(1):2ct
1ct:2ct
1:1.36ct
1ct:2ct
2:1
1ct:1ct
1ct:1.15ct
1ct:2ct
1ct:1ct
1ct:1.36ct
1ct:1.41ct
1ct:2ct
1ct:2ct
PRIMARY
OCL
(mH Min.)
1.20
1.60
1.60
1.60
1.20
1.20
1.20
1.60
1.20
1.20
1.20
1.20
PRI-SEC
LL
µH Max.)
(µ
0.80/0.80
1.00/0.80
0.80/0.80
1.20/1.20
0.80/0.80
0.80/0.80
0.80/0.80
0.80/0.80
0.80/0.80
0.80/0.80
0.80/0.80
1.0/1.0
PRI-SEC
Cw/w
(pf Max.)
45/45
60/50
60/50
50/40
45/45
50/50
50/50
60/60
50/50
50/50
60/50
60/60
DCR
(PRI/SEC Ω Max)
T1
T2
1.0/1.7
1.2/2.0
1.0/1.0
1.1/1.1
1.0/1.0
1.1/1.4
1.0/1.0
1.2/1.4
1.2/1.4
0.9/1.2
1.1/2.1
1.1/2.2
Schematic
1.0/1.7
1.7/1.7
1.2/2.0
1.1/0.7
1.0/1.0
1.1/1.4
1.0/1.8
1.2/1.2
1.2/1.4
0.9/1.2
1.0/1.7
1.1/2.2
C
B
F
G
D
D
D
C
D
E
C
C
(1) Tp: T1 RATIO'S ARE, PINS 12-10 : PINS 1-2 = 1:1.00 ; PINS 11-10:PINS 1-3 = 1:2.53ct ; PINS 12-11:PINS 1-3 = 1:9.52ct
pmis8_9x 09/00
Specifications subject to change without notice.
20381 BARENTS SEA CIRCLE, LAKE FOREST, CA 92630 • TEL: (949) 452-0511 • FAX: (949) 452-0512 • http://www.premiermag.com
29
T1/E1/ISDN-PRI
DUAL CORE SMD
ISOLATION TRANSFORMERS
MECHANICAL
12
11
10
9
8
PCB LAYOUT
7
RECOMMENDED P.C.B. LAYOUT
P PM-IS8X
M YYWW
PIN#1
DOT
1
2
3
4
5
.600
(15.24)
.400
(10.16)
16x.120 (3.05)
.47
(11.9)
6
.675
(17.15)
MAX
.39
(9.9)
1
.050
(1.27)
TYP
.500 (12.70)
.100
(2.54)
TYP
6
7
.010
(0.25)
TYP
.050 (1.27)
FLAT
.030 (0.76)
.600
(15.24)
MAX
.020 (.51)
.010 (.25)
12
16x.050 (1.27)
.340
(8.64)
MAX
.030
(0.76)
TYP
6x.100 (2.54)
SCHEMATICS
12
3
PRI
2
10
SEC
1
11
11
10
6
9
5
7
T2
PRI
SEC
4
8
8
7
6
9
6
SEC
5
7
PRIMARY
4
8
SEC
PRIMARY
5
9
4
T2
12
PRI
SEC
3
3
2
T2
2
T1
1
T1
10
T1
11
C
PRIMARY
SEC
B
12
1
A
12
11
10
3
SEC
2
10
PRIMARY
1
11
7
6
PRI
8
5
7
9
4
8
6
SEC
9
5
7
T2
PRIMARY
4
8
6
SEC
9
5
7
PRI
4
8
SEC
9
PRI
SEC
6
4
5
T2
12
3
PRIMARY
2
10
SEC
1
11
3
T2
12
SEC
2
T2
PRI
T1
3
T1
2
T1
1
T1
10
G
11
F
SEC
PRI
E
12
1
D
pmis8_9x 09/00
Specifications subject to change without notice.
20381 BARENTS SEA CIRCLE, LAKE FOREST, CA 92630 • TEL: (949) 452-0511 • FAX: (949) 452-0512 • http://www.premiermag.com
30
T1/E1
QUAD PORT SMD
ISOLATION TRANSFORMERS
Ê Transmit & Receive in a QUAD SMD Package
Ë 1500Vrms Minimum Isolation Voltage
Ì Industry Standard SMD Package
Í Extended Temperature Range Versions
NORMAL TEMP RANGE
ELECTRICAL SPECIFICATIONS AT 25OC - OPERATING TEMPERATURE RANGE 0OC TO +70OC
PM-8100
TURNS RATIO
(PRI:SEC ± 3%)
TX
RX
1.36CT:1 1:2CT
1.2
0.8
35
TX
1-3,6-8,11-13,16-18
PM-8101
1CT:1.41
1.41:1CT
1.2
0.8
35
1-3,6-8,11-13,16-,18
4-5,9-10,14-15,19-20
PM-8102
2CT:1
1:2CT
1.2
1.0
40
1-3,6-8,11-13,16-,18
4-5,9-10,14-15,19-20
C
PM-8103
1:2
2CT:1
1.2
1.0
35
1-2,9-10,11-12,19-20
3-5,6-8,13-15,16-18
D
PM-8104
1:1.36
1:1
1.2
0.8
35
1-2,6-7,11-12,16-17
38-37,33-32,28-27,23-22
F
PM-8105
1:2
1:1
1.2
0.8
35
1-2,6-7,11-12,16-17
38-37,33-32,28-27,23-22
F
PM-8106
1:1.15
1:1
1.2
0.8
35
1-2,6-7,11-12,16-17
38-37,33-32,28-27,23-22
F
PM-8107
1:2.40
1:1
1.2
0.5
35
1-2,8-9,11-12,18-19
38-37,35-34,28-27,25-24
F
PM-8108
1:2CT
1CT:2
1.2
0.6
35
4-5,9-10,14-15,19-20
1-3,6-8,11-13,16-18
C
PM-8109
1:2
1:2
1.2
0.6
35
1-3,6-8,11-13,16-18
4-5,9-10,14-15,19-20
E
PM-8110
1:1.15
1:1.15
1.2
0.6
35
1-3,6-8,11-13,16-18
4-5,9-10,14-15,19-20
E
PM-8111
1:.79
1:2
1.2
0.6
35
1-2,6-7,11-12,16-17
21-22,26-27,31-32,36-37
B
PM-8112
1:1.15
1:2CT
1.2
0.6
35
1-2,6-7,11-12,16-17
21-23,26-28,31-33,36-38
A
PM-8113
1CT:1.41
1CT:1.41
1.2
0.6
35
1-3,6-8,11-13,16-18
21-23,26-28,31-33,36-38
C
PM-8114
1:2CT
1:1CT
1.2
0.6
35
1-2,6-7,11-12,16-17
21-22,26-27,31-32,36-37
B
PM-8115
1:1.36CT
1:2CT
1.2
0.6
35
24-25,29-30,34-35,39-40 4-5,9-10,14-15,19-20
C
PM-8116
1:2
1:2CT
1.2
0.6
35
1-2,9-10,11-12,19-20
23-25,26-28,33-35,36-38
D
PM-8117
1:2CT
1:2CT
1.2
0.6
35
4-5,9-10,14-15,19-20
24-25,29-30,34-35,39-40
C
PM-8118
1:1.14
1:1.14CT
1.2
0.6
35
1-2,6-7,11-12,16-17
21-23,26-28,31-33,36-38
A
PM-8119
1:1.36
1:1.36CT
1.2
0.6
20
1-2,6-7,11-12,16-17
21-23,26-28,31-33,36-38
A
PART
NUMBER
PRI OCL
TX&RX
(mH TYP.)
PRI - SEC PRI - SEC
Cw/w
TX&RX LL
µH Max.) (pf Max.)
(µ
PRIMARY
PINS
Schematic
RX
4-5,9-10,14-15,19-20
C
C
EXTENDED TEMP RANGE
ELECTRICAL SPECIFICATIONS AT 25OC - OPERATING TEMPERATURE RANGE -40OC TO +85OC
PM-8200
TURNS RATIO
(PRI:SEC ± 3%)
TX
RX
1.36CT:1 1:2CT
1.5
1.0
35
TX
1-3,6-8,11-13,16-18
PM-8201
1CT:1.41
1.41:1CT
1.5
1.0
35
1-3,6-8,11-13,16-,18
4-5,9-10,14-15,19-20
PM-8202
2CT:1
1:2CT
1.5
1.2
40
1-3,6-8,11-13,16-,18
4-5,9-10,14-15,19-20
C
PM-8203
1:2
2CT:1
1.5
1.2
35
1-2,9-10,11-12,19-20
3-5,6-8,13-15,16-18
D
PM-8204
1:1.36
1:1
1.5
1.0
35
1-2,6-7,11-12,16-17
38-37,33-32,28-27,23-22
F
PM-8205
1:2
1:1
1.5
1.0
35
1-2,6-7,11-12,16-17
38-37,33-32,28-27,23-22
F
PM-8206
1:1.15
1:1
1.5
1.0
35
1-2,6-7,11-12,16-17
38-37,33-32,28-27,23-22
F
PM-8207
1:2.40
1:1
1.5
1.0
35
1-2,8-9,11-12,18-19
38-37,35-34,28-27,25-24
F
PM-8208
1:2CT
1CT:2
1.5
0.8
35
4-5,9-10,14-15,19-20
1-3,6-8,11-13,16-18
C
PM-8209
1:2
1:2
1.5
0.8
35
1-3,6-8,11-13,16-18
4-5,9-10,14-15,19-20
E
PM-8210
1:1.15
1:1.15
1.5
0.8
35
1-3,6-8,11-13,16-18
4-5,9-10,14-15,19-20
E
PART
NUMBER
PRI OCL
TX&RX
(mH TYP.)
PRI - SEC PRI - SEC
Cw/w
TX&RX LL
µH Max.) (pf Max.)
(µ
PRIMARY
PINS
Schematic
RX
4-5,9-10,14-15,19-20
C
C
pm-81_82 07/00
Specifications subject to change without notice.
20381 BARENTS SEA CIRCLE, LAKE FOREST, CA 92630 • TEL: (949) 452-0511 • FAX: (949) 452-0512 • http://www.premiermag.com
31
T1/E1
QUAD PORT SMD
ISOLATION TRANSFORMERS
EXTENDED TEMP RANGE
ELECTRICAL SPECIFICATIONS AT 25OC - OPERATING TEMPERATURE RANGE -40OC TO +85OC
TURNS RATIO
(PRI:SEC ± 3%)
TX
RX
PART
NUMBER
PRI OCL
TX&RX
(mH TYP.)
PRIMARY
PINS
PRI - SEC PRI - SEC
Cw/w
TX&RX LL
µH Max.) (pf Max.)
(µ
TX
Schematic
RX
PM-8211
1:.79
1:2
1.5
0.8
35
1-2,6-7,11-12,16-17
21-22,26-27,31-32,36-37
B
PM-8212
1:1.15
1:2CT
1.5
0.8
35
1-2,6-7,11-12,16-17
21-23,26-28,31-33,36-38
A
PM-8213
1CT:1.41 1CT:1.41
1.5
0.8
35
1-3,6-8,11-13,16-18
21-23,26-28,31-33,36-38
C
PM-8214
1:2CT
1:1CT
1.5
0.8
35
1-2,6-7,11-12,16-17
21-22,26-27,31-32,36-37
B
PM-8215
1:1.36CT 1:2CT
1.5
0.8
35
24-25,29-30,34-35,39-40 4-5,9-10,14-15,19-20
C
PM-8216
1:2
1:2CT
1.5
0.8
35
1-2,9-10,11-12,19-20
23-25,26-28,33-35,36-38
D
PM-8217
1:2CT
1:2CT
1.5
0.8
35
4-5,9-10,14-15,19-20
24-25,29-30,34-35,39-40
C
PM-8218
1:1.14
1:1.14CT
1.5
0.8
35
1-2,6-7,11-12,16-17
21-23,26-28,31-33,36-38
A
PM-8219
1:1.36
1:1.36CT
1.5
0.8
20
1-2,6-7,11-12,16-17
21-23,26-28,31-33,36-38
A
PM-8220
1CT:1.0
1CT:1.0
1.2
0.8
35
1-3,6-8,11-13,16-,18
38-36,33-31,28-26,23-21
C
PM-8xxx PCB LAYOUT
PM-8xxx MECHANICAL
40
40
21
P
M
PIN #1
I.D.
21
.480
(12.19)
.090 (2.29)
40-PLACES
1
PM-8xxx
YYWW
.050 (1.27)
19-PLACES
1
.950
(24.13)
.030 (0.76)
40-PLACES
20
1.125
(28.58)
MAX
PIN#1
DOT
.480
(12.19)
.250
(6.35)
MAX
.018
(0.46)
.950
(24.13)
.050
(1.27)
TYP
.015 (.38)
.005 (.12)
.045 (1.14)
.020 (0.50) FLAT
.640 (16.26)
.590 (14.98)
.010
(0.25)
TYP
pm-81_82 07/00
Specifications subject to change without notice.
20381 BARENTS SEA CIRCLE, LAKE FOREST, CA 92630 • TEL: (949) 452-0511 • FAX: (949) 452-0512 • http://www.premiermag.com
32
T1/E1
QUAD PORT SMD
ISOLATION TRANSFORMERS
PM-8XXX SCHEMATICS
A
1
B
40
1
C
40
1
39
2
F
E
D
40
1
40
1
40
1
40
2
39
2
38
3
39
2
39
3
38
2
39
3
38
3
37
4
38
3
38
4
37
3
38
37
4
4
4
5
36
5
36
5
36
5
36
5
36
4
37
6
35
6
35
6
35
6
35
6
35
6
35
34
7
7
7
34
7
33
8
34
8
33
8
33
7
34
8
33
8
32
9
33
9
32
9
32
8
33
9
9
32
10
31
10
31
10
31
10
31
10
31
9
32
11
30
11
30
11
30
11
30
11
30
11
30
29
12
12
29
12
28
13
29
12
29
13
28
12
29
13
28
13
27
14
28
13
28
14
27
13
28
27
14
14
14
15
26
15
26
15
26
15
26
15
26
14
27
16
25
16
25
16
25
16
25
16
25
16
25
24
17
17
17
24
17
23
18
24
18
23
18
23
17
24
18
23
18
22
19
23
19
22
19
22
18
23
20
21
20
21
19
22
19
20
19
21
20
22
21
20
21
pm-81_82 07/00
Specifications subject to change without notice.
20381 BARENTS SEA CIRCLE, LAKE FOREST, CA 92630 • TEL: (949) 452-0511 • FAX: (949) 452-0512 • http://www.premiermag.com
33
T1/E1/ISDN-PRI
Quad Port SMD Transformer
with IC Side Protection
Ê
Ë
Ì
Í
IC Side Protection Circuit on Each Channel to Suppress Low Voltage Transients
Compatible with PMC-Sierra's Comet Chip (PM4354)
Industry Standard SMD Package Meets 235°C IR Reflow
1500Vrms Minimum Isolation Voltage
ELECTRICAL SPECIFICATIONS AT 25OC - OPERATING TEMPERATURE RANGE 0OC TO +70OC
PART
NUMBER
PM-8601
TURNS RATIO
(PRI:SEC ± 3%)
TX
RX
1 : 2.42
1 : 2.42
PRI OCL
TX&RX
(mH TYP.)
LEAKAGE
TX&RX
µH Max.)
(µ
Cw/w
TX&RX
(pf Max.)
0.6 & 0.6
0.6 & 0.6
35 & 35
DCR
TX&RX
(Ohm Max.)
--- & ---
Schematic
1
ELECTRICAL SPECIFICATIONS AT 25OC - OPERATING TEMPERATURE RANGE -40OC TO +85OC
LEAKAGE
TX&RX
µH Max.)
(µ
Cw/w
TX&RX
(pf Max.)
DCR
TX&RX
(Ohm Max.)
PM-8610
TURNS RATIO
(PRI:SEC ± 3%)
TX
RX
1 : 2.42
1 : 2.42
0.6 & 0.6
0.6 & 0.6
35 & 35
.70 & .40
1
PM-8611
1 : 2.42
1 : 2.42
0.6 & 0.6
0.6 & 0.6
35 & 35
.70 & 1.30
1
PM-8612
1 : 1.2
1 : 1.2
1.2 & 1.2
0.5 & 0.5
30 & 30
--- & ---
1
PART
NUMBER
PRI OCL
TX&RX
(mH TYP.)
SCHEMATICS
PM-86xx MECHANICAL
1
40
2
3
.950 (24.13)
40
.050 (1.27)
21
P
M
PM-86xx
YYWW
1
Schematic
.490
(12.45)
.090 (2.29)
40-PLACES
.030 (0.76)
40-PLACES
38
V
G
4
37
5
36
6
35
7
8
33
V
G
9
32
10
31
11
30
20
1.125
(28.58)
MAX
.480
(12.19)
12
13
.250
(6.35)
MAX
.018
(0.46)
.950
(24.13)
.050
(1.27)
TYP
.015 (.38)
.005 (.12)
.045 (1.14)
.020 (0.50) FLAT
.640 (16.26)
.590 (14.98)
.010
(0.25)
TYP
28
V
G
14
27
15
26
16
25
17
23
18
V
G
19
22
20
21
pm-86xx 05/04
Specifications subject to change without notice.
20381 BARENTS SEA CIRCLE, LAKE FOREST, CA 92630 • TEL: (949) 452-0511 • FAX: (949) 452-0512 • http://www.premiermag.com
34
T3/DS3/E3/STS-1
ISOLATION TRANSFORMERS
Ê Optimized for use with T3/DS3/E3/STS-1 Links
Ë 1500/3000Vrms Minimum Isolation Voltages
Ì Bandwidths up to 500MHz
Í Rates of 44.736 MBPS Using B3ZS Code
Î Rates of 34.368 MBPS Using HDB3 Code
Ï 6-Pin Through-Hole or SMD Packages
The characteristics of these parts will allow the pulse templates of CCITT G.703 & ATT T.A.34 to be met
NORMAL TEMP RANGE
ELECTRICAL SPECIFICATIONS AT 25OC - OPERATING TEMPERATURE RANGE 0OC TO +70OC
PART
NUMBER
TURNS
RATIO
(± 2%)
PRI INDUCTANCE PRI - SEC
µH Min.)
(µ
Cw/w
@ +25OC @ -40OC (pf Max.)
PRI - SEC
LL
µH Max.)
(µ
PACKAGE
Bandwidth
SCHEMATIC 75Ω
HI-POT
Ω System
(MHz Typ) (Vrms MIN.)
PM-T301
PM-T302
PM-T303
PM-T304
1:2CT
1:1
1:2CT
1:1
35
40
35
40
20
30
20
30
10
13
10
13
.12
.12
.12
.12
A6
A6
G6
G6
B
A
B
A
-----------------
1500
1500
1500
1500
PM-T306
PM-T307
PM-T308
PM-T309
1:1.73CT
1:1
1:2CT
1CT:1CT
50
40
19
40
-------------
12
10
10
10
.10
.10
.06
.10
L6
L6
L6
L6
B
A
B
C
.060-300
.200-340
.250-500
.200-340
1500
1500
1500
1500
PM-T310
PM-T311
PM-T312
PM-T313
PM-T314
PM-T329
PM-T330
1:1.73CT
1:1
1:2CT
1.2:1
1.2:1
1:1
1:2CT
50
40
19
40(2)
40
40
19
----------------------
15
15
15
10
10
5
10
.10
.06
.06
.10
.10
.10
.06
T7
T7
T7
L6
L6
T6
T6
C
A
C
D
A
A
D
.060-300
.200-340
.250-500
.200-340
.200-340
---------
1500
1500
1500
1500
1500
3000(1)
3000(1)
(1) 3000Vrms Reinforced insulation per BABT EN41003/EN60950
(2) Inductance test on pin 6-4 side.
EXTENDED TEMP RANGE
ELECTRICAL SPECIFICATIONS AT 25OC - OPERATING TEMPERATURE RANGE -40OC TO +85OC
PART
NUMBER
PM-T3017
PM-T3018
PM-T3019
PM-T3020
PM-T3021
PM-T3022
PM-T3023
TURNS
RATIO
(± 2%)
1:1
1:2CT
1CT:1CT
1:1
1:2CT
1:1.15
1:1.5
PRI INDUCTANCE PRI - SEC
µH Min.)
(µ
Cw/w
@ +25OC @ -40OC (pf Max.)
100
40
40
40
19
40
40
40
19
----------------
PRI - SEC
LL
µH Max.)
(µ
10
12
12
15
12
15
15
.110
.110
.110
.10
.08
.10
.10
PACKAGE
L6
L6
L6
T7
T6
T7
T7
Bandwidth
SCHEMATIC 75Ω
Ω System
HI-POT
(MHz Typ) (Vrms MIN.)
A
B
C
A
D
A
A
.200-340
.250-500
.200-340
.200-340
----.200-340
.200-340
1500
1500
1500
1500
3000(1)
1500
1500
(1) 3000Vrms Reinforced insulation per BABT EN41003/EN60950
pmt3 5/99
Specifications subject to change without notice.
20381 BARENTS SEA CIRCLE, LAKE FOREST, CA 92630 • TEL: (949) 452-0511 • FAX: (949) 452-0512 • http://www.premiermag.com
35
T3/DS3/E3/STS-1
ISOLATION TRANSFORMERS
G6 MECHANICALS
6
5
G6 SCHEMATICS
A
4
B
5
6
P PM-T3XX
M YYWW
PR IM A RY
1
1
2
PRIMARY
2
3
1
3
.300
(7.62)
MAX
4
SEC.
SE C O N D A RY
DOT
DENOTES
PIN #1
5
6
4
2
3
C
.300
(7.62)
6
5
4
1
2
3
.220
(5.58)
MAX
.019
(0.48)
TYP
.100
(2.54)
TYP
.010
(0.25)
TYP
.040 (1.02)
.015 (.38)
.008 (.20)
.420 (10.66)
.405 (10.29)
L6 MECHANICALS
6
5
L6 SCHEMATICS
A
4
B
5
6
DOT
DENOTES
PIN #1
PRIMARY
PRIMARY
1
2
1
3
.300
(7.62)
MAX
1
3
4
.390
(9.91)
PRI.
2
1
3
A6 MECHANICALS
6
5
2
A6 SCHEMATICS
B
A
6
5
4
2
5
6
4
SEC.
SECONDARY
1
3
4
P PM-T3XX
M YYWW
DOT
D EN O TES
P IN # 1
4
SEC.
PRI.
1
5
6
SEC.
.010
(0.25)
TYP
3
D
5
6
.100
(2.54)
TYP
2
C
.250
(6.35)
MAX
.019
(0.48)
TYP
2
.275
(7.00)
4
SEC.
SECONDARY
P PM-T3XX
M YYWW
5
6
4
3
.4 0 0
( 1 0 .1 6 )
M AX
.3 0 0
( 7 .6 2 )
M AX
PRIMARY
PRIMARY
.2 5 0
( 6 .3 5 )
M AX.
1
2
3
1
2
3
.1 3 0
( 3 .3 0 )
TY P
24 A W G
.0 2 0 D IA .
( 0 .5 1 )
TY P.
.2 0 0
( 5 .0 8 )
TY P
.1 0 0
( 2 .5 4 )
TY P
.3 0 0
( 7 .6 2 )
U N U S E D P IN S A R E O M I T T E D
pmt3 5/99
Specifications subject to change without notice.
20381 BARENTS SEA CIRCLE, LAKE FOREST, CA 92630 • TEL: (949) 452-0511 • FAX: (949) 452-0512 • http://www.premiermag.com
36
T3/DS3/E3/STS-1
ISOLATION TRANSFORMERS
T6 MECHANICALS
5
3
T6 SCHEMATICS
6
P PM-T3XX
M YYWW
4
A
2
1
6
5
.3 50
(8.89 )
M AX
.5 00
(12.7 0)
M AX
3
.1 30
(3.30 )
TY P
.4 00
(10.1 6)
.1 00
(2.54 )
PRI.
SEC.
1
.2 50
(6.35 )
M AX
.3 40
(8.64 )
D
6
5
PRI.
SEC.
4
3
4
2
1
2
.0 20
D IA
(0.51 )
UN USE D P IN S A RE O M ITTED
T7 MECHANICALS
6
5
T7 SCHEMATICS
4
C
A
P PM-T3XX
M YYWW
6
5
4
6
PRI.
DOT
DENOTES
PIN #1
1
2
SEC.
SEC.
.285
(7.0)
1
2
4
PRI.
3
.300
(7.62)
MAX
5
3
1
2
3
.245
(6.23)
MAX
.010
(0.25)
TYP
.019
(0.48)
TYP
.100
(2.54)
TYP
.300
(7.62)
MAX
pmt3 5/99
Specifications subject to change without notice.
20381 BARENTS SEA CIRCLE, LAKE FOREST, CA 92630 • TEL: (949) 452-0511 • FAX: (949) 452-0512 • http://www.premiermag.com
37
10 Base-T DUAL
INTERFACE MODULES
TRANSFORMERS & FILTERS
Ê Designed for IEEE 802.3 10 Base-T
Ë Compact Standard DIL or SIP Packages
Ì Performs Impedance Match + Filtering + Isolation
Í 2000Vrms Minimum Isolation Voltage
Î Low Insertion Loss
Ï Designed For Use With Most 10 Base T Chips
ELECTRICAL SPECIFICATIONS AT 25OC - OPERATING TEMPERATURE RANGE 0OC TO +70OC
DIL (DUAL IN-LINE) THRU-HOLE
PART
NUMBER
Insertion Loss
1 to 10MHz
(dB Max)
Tran.
Rcv
PM-BT01
PM-BT02
PM-BT031
PM-BT041,2
PM-BT051
PM-BT061
PM-BT071
1.0
4.6
1.0
4.5
1.0
1.0
1.0
Return Loss
1 to 10MHz
(dB Min.)
Crosstalk
to 10MHz
(dB Min.)
Group Delay
Change
(ns Max.)
5-10MHz
15
15
15
15
15
15
15
30
30
30
35
35
30
30
4.0
4.0
4.0
2.0
2.0
4.0
4.0
1.0
4.2
1.0
1.0
1.0
1.0
1.0
20MHz
T
R
Attenuation
(dB Min)
25MHz
30MHz
T
R
T
R
7
7
7
7
7
7
7
19
19
19
18
18
19
19
6
6
6
5
5
6
6
14
14
14
11
11
14
14
32
32
32
30
30
32
32
Cut Pri to Sec
Isolation Schematic
Off
MHz (Vrms Min)
TYP
40MHz
T
R
20
20
20
16
16
20
20
35
35
35
33
33
35
35
31
31
31
26
26
31
31
17
17
17
17
17
17
17
2000
2000
2000
2000
2000
2000
2000
A
B
C
D
E
F
G
SIP (SINGLE IN-LINE) THRU-HOLE
PART
NUMBER
Insertion Loss
to 10MHz
(dB Max)
PM-BT434(1)
Crosstalk
Return Loss
(dB Min.)
.1 to 10MHz
MHz
(dB Min.)
100 Ω 98+13 Ω 5-10 10-50
-1.0
-18
-15
-45 -40
Group Delay
Change
5-10MHz
(ns Max.)
4.0
Common mode
rejection (dB Min)
MHz
5-10
50 100
Attenuation
(dB Min @ MHz)
30
50-100
T
R
T or R
-37 -15
-40
-35
-60 -45
Pri to Sec
Isolation
(Vrms Min)
Schematic
2000
F1
1 = INCLUDES COMMON MODE FILTER
2 = INCLUDES RESISTOR MATCHING NETWORK
PM-BT01 SCHEMATICS
SCHEMATIC "A"
SCHEMATIC
"A"
Transmit
Seven Pole Butterworth
XM IT
100Ω
1:1
1
15
3
100 OHMS
16
100Ω
16
1:1
7
12
11
10
9
1
2
RCV
FILTER
3
4
5
6
7
8
11
10
8
13
XMIT
FILTER
Receive
Five Pole Butterworth
6
14
14
2
RC V
100Ω
15
100 OHMS
100 OHMS
100Ω
100 OHMS
9
pmbt 6/98
Specifications subject to change without notice.
20381 BARENTS SEA CIRCLE, LAKE FOREST, CA 92630 • TEL: (949) 452-0511 • FAX: (949) 452-0512 • http://www.premiermag.com
38
10 Base-T DUAL
INTERFACE MODULES
TRANSFORMERS & FILTERS
Ê Available in Enhanced or Standard Design Version
Ë 235°C Peak Infrared Reflow Temperature Rating
Ì Extended Temperature Version *
Í Low Profile Surface Mount Package
ELECTRICAL SPECIFICATIONS AT 25OC - OPERATING TEMPERATURE RANGE 0OC TO +70OC
PART
NUMBER
Insertion Loss
1 to 10MHz
(dB Max)
PM-BT91
PM-BT92
PM-BT93
PM-BT94
PM-BT95
PM-BT96
PM-BT97
PM-BT98
PM-BT99
-6.0
-1.0
-6.5
-1.0
-5.5
-6.0
-5.0
-5.0
-1.0
Return Loss
1 to 10MHz
(dB Min.)
100Ω 98 ±13Ω
-18
-18
-18
-18
-18
-18
-18
-18
-18
Crosstalk
Common Mode Rejection
Pri to Sec
Attenuation (XMIT)
to 10MHz
(dB Min)
Isolation Schematic
(dB Min)
(dB Min.)
(Vrms Min)
5-10Mhz 30MHz 40MHz 100MHz 5MHz 10MHz 50MHz 100MHz 200MHz
-15
-15
-15
-15
-15
-15
-15
-15
-15
-35
-35
-35
-30
-30
-35
-25
-25
-35
-35
-30
-35
-30
-30
-30
-30
-30
-30
-35
-35
-35
-27
-30
-27
-35
-35
-27
-35
-35
-35
-27
-35
-27
-40
-40
-27
-60
-60
-42
-40
-35
-40
-35
-35
-40
-60
-60
-37
-30
-30
-35
-30
-30
-35
-55
-55
-33
-50
-55
-45
-55
-55
-45
-50
-50
-45
-45
-50
-30
-50
-50
-45
-45
-45
-40
1500
1500
1500
1500
1500
1500
1500
1500
1500
H
J
H
K
L
L
L
L
K
RESISTOR VALUE (Ω)
PART
NUMBER
IC
Manufacturer
PM-BT91
PM-BT92
PM-BT93
PM-BT95
PM-BT96
PM-BT97
PM-BT98
AMD
Various
National
National
AMD
LSI
Motorola
R2
R1
61.9
N/A
274
348
61.9
390
39
R3
422
N/A
66.5
53.6
422
63.4
N/A
R4
61.9
N/A
66.5
53.6
61.9
390
39
R5
422
N/A
274
348
422
63.4
N/A
R6
1210
N/A
806
806
1210
N/A
N/A
49.9
N/A
49.9
49.9
49.9
49.9
49.9
R7
49.9
N/A
49.9
49.9
49.9
49.9
49.9
* Note: For Extended Temperature version (-40°°C to +85°°C)
Add "E" at the end of part # example: PM-BTxxxE
PM-BT9XX PHYSICALS
16
15
14
1
2
12
11
10
3
4
5
6
7
16
8
9
7 x .100 (2.54)
8
.390
(9.90)
MAX
.240
(6.10)
MAX
.700
(17.78)
1
16 x .040 (1.02)
1.000
(25.40)
MAX
.026
(0.66)
TYP
.340 (6.64)
16 x .100 (2.54)
9
PM-BT9xx
YYWW
P
M
PIN #1
I.D.
13
PCB LAYOUT
.100
(2.54)
TYP
SUGGESTED PAD LAYOUT
.008R
(0.20)
.045 (1.14)
FLAT
.030 (0.76)
.530 (12.95)
.500 (12.44)
.015 (.38)
.005 (.12)
.010
(0.25)
TYP
pmbt 6/98
Specifications subject to change without notice.
20381 BARENTS SEA CIRCLE, LAKE FOREST, CA 92630 • TEL: (949) 452-0511 • FAX: (949) 452-0512 • http://www.premiermag.com
39
10 Base-T DUAL
INTERFACE MODULES
TRANSFORMERS & FILTERS
PM-BT01 MECHANICAL
.800
(20.32)
MAX
.400
(10.16)
MAX
P PM-BT01
M
YYWW
.300
(7.62)
MAX
.120
(3.05)
MIN
PIN#1 I.D.
WHITE DOT
.020
(0.51)
TYP
PM-BT02 PHYSICALS
RC V
100Ω
.300
(7.62)
SCHEMATIC "B"
100 OHMS
1:1
100 OHMS
16
100Ω
2
16
14
3
.100
(2.54)
TYP
SCHEMATIC
"B"
Receive
Five Pole Butterworth
1
.300
(7.62)
TYP
15
15
14
13
12
11
RCV
FILTER
10
9
XMIT
FILTER
Transmit
Seven Pole Butterworth
6
XM IT
400Ω
1
2:1
100Ω
7
8
2
3
4
5
6
7
8
11
100 OHMS
400 OHMS
9
10
.800
(20.32)
MAX
.400
(10.16)
MAX
P PM-BT02
M
.300
(7.62)
MAX
YYWW
.120
(3.05)
MIN
PIN#1 I.D.
WHITE DOT
.020
(0.51)
TYP
.300
(7.62)
TYP
.100
(2.54)
TYP
.300
(7.62)
pmbt 6/98
Specifications subject to change without notice.
20381 BARENTS SEA CIRCLE, LAKE FOREST, CA 92630 • TEL: (949) 452-0511 • FAX: (949) 452-0512 • http://www.premiermag.com
40
10 Base-T DUAL
INTERFACE MODULES
TRANSFORMERS & FILTERS
PM-BT03 PHYSICALS
SCHEMATIC "C"
SCHEMATIC
"C"
TYPICAL COMMON MODE CHOKE:
Inductance: 18 to 36 µHy
Leakage Inductance: <0.3 µHy Max.
Inter-Winding Capacitance: <25 pF Max.
CMRR 10-100MHz >20db
Transmit
Seven Pole Butterworth
XMIT
100Ω
16
1:1
1
15
3
100 OHMS
100Ω
14
2
16
Receive
Five Pole Butterworth
RCV
100Ω
13
12
8
1
100Ω
9
2
3
4
5
6
7
8
100 OHMS
PM-BT03 WITHOUT STANDOFFS
P PM-BT03
M
YYWW
P PM-BT03S
M
YYWW
.810
(20.57)
MAX
.400
(10.16)
MAX
PIN#1 I.D.
WHITE DOT
.810
(20.57)
MAX
.400
(10.16)
MAX
.300
(7.62)
MAX
.300
(7.62)
MAX
.015
(.38)
TYP
.120
(3.05)
MIN
.120
(3.05)
MIN
.300
(7.62)
TYP
10
RCV
FILTER
100 OHMS
9
PM-BT03S WITH STANDOFFS
.020
(0.51)
TYP
11
XMIT
FILTER
10
7
PIN#1 I.D.
WHITE DOT
14
11
1:1
6
15
100 OHMS
.100
(2.54)
TYP
.020
(0.51)
TYP
.300
(7.62)
.300
(7.62)
TYP
.100
(2.54)
TYP
.300
(7.62)
pmbt 6/98
Specifications subject to change without notice.
20381 BARENTS SEA CIRCLE, LAKE FOREST, CA 92630 • TEL: (949) 452-0511 • FAX: (949) 452-0512 • http://www.premiermag.com
41
10 Base-T DUAL
INTERFACE MODULES
TRANSFORMERS & FILTERS
PM-BT04/05 PHYSICALS
SCHEMATIC "D" & "E"
SCHEMATIC
"D" & "E"
COMMON MODE
REJECTION:
Transmit: 30dB min from 1 to 100MHz
Receive: 30dB min from 1 to 100MHz
RETURN LOSS:
Transmit: 15dB min from 5 to 10MHz
Receive: 15dB min from 5 to 10MHz
SCHEMATIC DIAGRAM
"D" = PM-BT04
Transmit
7-Pole Butterworth
2
4
Transmit
7-Pole Butterworth
61.9
16
422
61.9
49.9
15
49.9
422
14
5
12
6
11
7
10
8
9
P
M
Receive
5-Pole Butterworth
1
16
3
14
5
12 RC V
6
11
100Ω
RCV
X M IT
3
Receive
5-Pole Butterworth
1.2K
1
SCHEMATIC DIAGRAM
"E" = PM-BT05
XM IT
100Ω
100Ω
100Ω
7
8
9
PM-BT0X
YYWW
PIN#1 I.D.
WHITE DOT
1.000
(25.40)
MAX.
.400
(10.16)
MAX.
.350
(8.89)
MAX
.125
(3.30)
TYP
.020
(0.51)
TYP
.100
(2.54)
TYP
.020
(0.51)
TYP
.300
(7.62)
pmbt 6/98
Specifications subject to change without notice.
20381 BARENTS SEA CIRCLE, LAKE FOREST, CA 92630 • TEL: (949) 452-0511 • FAX: (949) 452-0512 • http://www.premiermag.com
42
10 Base-T DUAL
INTERFACE MODULES
TRANSFORMERS & FILTERS
PM-BT434 PHYSICALS
SCHEMATIC "F1"
SCHEMATIC
"F1"
SCHEMATIC DIAGRAM
1
LOW PASS
FILTER
9
XM IT
100Ω
100Ω
2
C HIP SIDE
10
LOW PASS
FILTER
UTP SIDE
5
3
LOW PASS
FILTER
7
RECV
100Ω
100Ω
4
8
LOW PASS
FILTER
P PM-BT434
M
YYWW
PIN#1
WHITE DOT
1.080
(27.43)
MAX
.350
(8.89)
MAX
.472
(11.98)
MAX
.100
(2.54)
.020
(0.51)
.010
(.25)
.200
(5.08)
.900
(22.86)
.020
(.51)
.125
(3.17)
pmbt 6/98
Specifications subject to change without notice.
20381 BARENTS SEA CIRCLE, LAKE FOREST, CA 92630 • TEL: (949) 452-0511 • FAX: (949) 452-0512 • http://www.premiermag.com
43
10 Base-T DUAL
INTERFACE MODULES
TRANSFORMERS & FILTERS
PM-BT06 PHYSICALS
TYPICAL COMMON MODE CHOKE:
Inductance: 18 to 36 µHy
Leakage Inductance: <0.3 µHy Max.
Inter-Winding Capacitance: <25 pF Max.
CMRR 10-100MHz >20db
100 OHMS
Transmit
Seven Pole Butterworth
1
100Ω
16
1:1
16
14
3
1
13
12
11
10
9
RCV
FILTER
1:1
2
3
4
5
6
100 OHMS
11
7
8
14
15
Receive
Five Pole Butterworth
100Ω
15
100 OHMS
XMIT
FILTER
XM IT
100Ω
2
6
SCHEMATIC "F"
SCHEMATIC
"F"
9
7
8
100 OHMS
RC V
100Ω
10
P
M
PIN#1 I.D.
WHITE DOT
PM-BT06
YYWW
.810
(20.57)
MAX
.400
(10.16)
MAX
.300
(7.62)
MAX
.120
(3.05)
MIN
.020
(0.51)
TYP
.300
(7.62)
TYP
.100
(2.54)
TYP
.300
(7.62)
pmbt 6/98
Specifications subject to change without notice.
20381 BARENTS SEA CIRCLE, LAKE FOREST, CA 92630 • TEL: (949) 452-0511 • FAX: (949) 452-0512 • http://www.premiermag.com
44
10 Base-T DUAL
INTERFACE MODULES
TRANSFORMERS & FILTERS
PM-BT07 PHYSICALS
TYPICAL COMMON MODE CHOKE:
Inductance: 18 to 36 µHy
Leakage Inductance: <0.3 µHy Max.
Inter-Winding Capacitance: <25 pF Max.
CMRR 10-100MHz >20db
SCHEMATIC "G"
SCHEMATIC
"G"
100 OHMS
1
Transmit
Seven Pole Butterworth
XM IT
100Ω
15
3
4
5
6
7
8
RCV
FILTER
100Ω
15
16
14
2
3
XMIT
FILTER
16
1:1
1
2
100 OHMS
14
13
12
100 OHMS
11
10
9
100 OHMS
Receive
Five Pole Butterworth
RC V
100Ω
1:1
6
11
10
8
100Ω
9
7
PIN#1 I.D.
WHITE DOT
P
M
PM-BT07
YYWW
.810
(20.57)
MAX
.400
(10.16)
MAX
.300
(7.62)
MAX
.120
(3.05)
MIN
.020
(0.51)
TYP
.300
(7.62)
TYP
.100
(2.54)
TYP
.300
(7.62)
pmbt 6/98
Specifications subject to change without notice.
20381 BARENTS SEA CIRCLE, LAKE FOREST, CA 92630 • TEL: (949) 452-0511 • FAX: (949) 452-0512 • http://www.premiermag.com
45
10 Base-T DUAL
INTERFACE MODULES
TRANSFORMERS & FILTERS
PM-BT9xx SCHEMATIC " H "
1
2
C H IP
S ID E
3
4
R1
1 :1
R2
R3
8
R5
R4
1 :1
16
C H IP
15
S ID E
14
C H IP
S ID E
R7
10
1 :1
8
4
6
5
7
1 :1
16
11
12
10
1 :1
1
TX
U T P S ID E
100Ω
RX
U T P S ID E
100Ω
9
14
C H IP
S ID E
U T P S ID E
1 0 0Ω
11
1
PM-BT9xx SCHEMATIC " K "
RX
9
R6
12
C H IP
S ID E
U T P S ID E
1 0 0Ω
7
5
PM-BT9xx SCHEMATIC " J "
TX
6
8
TX
U T P S ID E
10 0Ω
RX
U T P S ID E
10 0Ω
6
3
5
C H IP
S ID E
1 :1
16
9
14
11
12
* Turn Ratio for transmit: PM-BT94 is 1:1, PM-BT99 is 1:1.414
PM-BT9xx SCHEMATIC " L "
1
C H IP
S ID E
2
3
4
R1
1 :1
R2
R3
TX
U TP S ID E
1 0 0Ω
RX
U TP S ID E
1 0 0Ω
6
R4
N o te
5
16
C H IP
15
S ID E
14
8
R5
1 :1
R6
R7
9
11
12
* Note: Common Mode Choke on Transmit Channel for PM-BT95, PM-BT96, PM-BT97
pmbt 6/98
Specifications subject to change without notice.
20381 BARENTS SEA CIRCLE, LAKE FOREST, CA 92630 • TEL: (949) 452-0511 • FAX: (949) 452-0512 • http://www.premiermag.com
46
Ê
Ë
Ì
Í
º
»
10/100 Base-TX QUAD PORT
ISOLATION TRANSFORMERS
WITH FILTERS
Designed for 10/100MB/s Transmission Over UTP-5 Cable, IEEE 802.3u & ANSI X3.236-1995
Maintains > 350uHY Primary OCL with an 8mA Bias Over the Full Temp Range of 0OC to +70OC
Supports All Leading Fast Ethernet Chip Sets That Require a 1:1 Transmit & Receive Turns Ratio
Provides the Cable Interface, Isolation & Common Mode Filtering Required by the PMD Sublayer
Low Profile Surface Mount Transfer Molded Package Meets UL94-V0
All Units Meet 1500Vrms Isolation
NORMAL TEMP RANGE
ELECTRICAL SPECIFICATIONS AT 25OC - OPERATING TEMPERATURE RANGE 0OC TO +70OC
PART
NUMBER
PM-8036
PM-8044
PM-8053
PM-8060
PM-8062
PM-8071
PM-8072
INSERTION
LOSS
1
(dB Typ)
0.1 to 100MHz MHz
-0.5
-0.5
-0.5
-0.5
-0.5
-0.5
-1.0 *
-65
-65
-65
-65
-65
-65
-55
Cross Talk
(dB Typ)
30
60
100
MHz MHz MHz
-55
-55
-50
-50
-55
-50
-45
-45
-45
-40
-40
-45
-40
-40
-35
-35
-30
-30
-35
-30
-25
2-30
MHz
-22
-22
-22
-22
-22
-22
-18
Return Loss
(dB Typ)
40
50
60-80
MHz MHz MHz
Diff to Com Mode Com to Com Mode
Rejection (dB Typ) Rejection (dB Typ)
1-60
60-200
0.1 to 60 MHz
MHz
MHz
Transmit Receive
-18
-18
-18
-18
-18
-18
-14.4
-40
-40
-40
-40
-40
-40
-37
-15
-15
-15
-15
-15
-15
-13.1
-12
-12
-12
-12
-12
-12
-12
-30
-30
-30
-30
-30
-30
-25
-30
-30
-30
-30
-30
-30
-----
-30
-30
-30
-30
-30
-30
-----
* Maximum
EXTENDED TEMP RANGE
ELECTRICAL SPECIFICATIONS AT 25OC - OPERATING TEMPERATURE RANGE -40OC TO +85OC
PART
NUMBER
PM-8080
PM-8081
PM-8082
PM-8083
PM-8084
PM-8085
PM-8086
INSERTION
LOSS
(dB Typ)
1
0.1 to 100MHz MHz
-0.5
-0.5
-0.5
-0.5
-0.5
-0.5
-1.0 *
-65
-65
-65
-65
-65
-65
-55
Cross Talk
(dB Typ)
30
60
100
MHz MHz MHz
-55
-55
-50
-50
-55
-50
-45
-45
-45
-40
-40
-45
-40
-40
-35
-35
-30
-30
-35
-30
-25
2-30
MHz
-22
-22
-22
-22
-22
-22
-18
Return Loss
(dB Typ)
40
50
60-80
MHz MHz MHz
Diff to Com Mode Com to Com Mode
Rejection (dB Typ) Rejection (dB Typ)
1-60
60-200
0.1 to 60 MHz
MHz
MHz
Transmit Receive
-18
-18
-18
-18
-18
-18
-14.4
-40
-40
-40
-40
-40
-40
-37
-15
-15
-15
-15
-15
-15
-13.1
-12
-12
-12
-12
-12
-12
-12
-30
-30
-30
-30
-30
-30
-25
-30
-30
-30
-30
-30
-30
-----
-30
-30
-30
-30
-30
-30
-----
* Maximum
pm-80xx 04/99
Specifications subject to change without notice.
20381 BARENTS SEA CIRCLE, LAKE FOREST, CA 92630 • TEL: (949) 452-0511 • FAX: (949) 452-0512 • http://www.premiermag.com
47
10/100 Base-TX QUAD PORT
ISOLATION TRANSFORMERS
WITH FILTERS
PM-8036 & PM-8080
TD1+ 1
PM-8044 & PM-8081
1:1
3
RD1+ 4
1:1
38 TX1-
RD1-
2
37 RX1+
TD1+
3
39 RX138 TX1+
1:1
37 TXct1
TDct1 4
5
TD2+ 6
1:1
TDct2 7
TD2-
RD2+ 9
35 TX2+
RD2+ 6
1:1
RD2-
7
32 RX2+
TD2+
8
35 RX2+
31 RX230 TX3+
1:1
TD2- 10
31 TX2-
RD3+ 11
TD3- 13
28 TX3-
RD3- 12
27 RX3+
TD3+ 13
1:1
RD3- 15
1:1
30 RX3+
29 RX328 TX3+
1:1
27 TXct3
26 RX3-
TD3- 15
26 TX3-
25 TX4+
RD4+ 16
24 TXct4
TD4- 18
23 TX4-
RD4- 17
22 RX4+
TD4+ 18
RD4- 20
1:1
TDct3 14
TDct4 17
1:1
33 TX2+
1:1
32 TXct2
29 TXct3
RD3+ 14
34 RX2-
TDct2 9
TDct3 12
RD4+ 19
1:1
21 RX4-
MEDIA SIDE
RD2- 10
TD4+ 16
36 TX1-
5
33 TX2-
MEDIA SIDE
CHIP SIDE
TD1-
34 TXct2
8
TD3+ 11
36 RX1-
CHIP SIDE
RD1-
40 RX1+
39 TXct1
TDct1 2
TD1-
RD1+ 1
40 TX1+
1:1
1:1
25 RX4+
24 RX4-
1:1
23 TX4+
TDct4 19
22 TXct4
TD4- 20
21 TX4-
pm-80xx 04/99
Specifications subject to change without notice.
20381 BARENTS SEA CIRCLE, LAKE FOREST, CA 92630 • TEL: (949) 452-0511 • FAX: (949) 452-0512 • http://www.premiermag.com
48
10/100 Base-TX QUAD PORT
ISOLATION TRANSFORMERS
WITH FILTERS
PM-8053 & PM-8082
RD1+ 1
PM-8060 & PM-8083
1:1
RD1+ 1
40 TX1+
1:1
40 RX1-
39 TXct1
RD1-
2
TD1+ 3
1:1
38 TX1-
RD1-
37 RX1+
TDct1 3
4
37 TX1-
36 RX1-
TD1-
5
36 TX1+
TD2-
6
1:1
35 TX2-
TD2-
6
34 TXct2
TD2+
7
TD2+
8
33 TX2+
TDct2 8
RD2-
9
1:1
32 RX2-
RD2-
31 RX2+
RD3+ 11
1:1
30 TX3+
29 TXct3
RD3- 12
TD3+ 13
1:1
RD2+ 10
RD3- 12
27 RX3+
TDct3 13
1:1
30 RX329 RX3+
28 TXct3
1:1
TD3+ 14
27 TX326 TX3+
26 RX3-
TD3- 15
25 TX4-
TD4- 16
TDct4 17
24 TXct4
TD4+ 17
TD4+ 18
23 TX4+
TDct4 18
22 RX4-
RD4- 19
1:1
33 TXct2
31 TX2+
RD3+ 11
TD4- 16
RD4- 19
1:1
32 TX2-
TD3- 15
1:1
34 RX2+
9
28 TX3-
TDct3 14
35 RX2-
1:1
MEDIA SIDE
RD2+ 10
MEDIA SIDE
CHIP SIDE
TDct2 7
CHIP SIDE
5
38 TXct1
1:1
TD1+
TDct1 4
TD1-
39 RX1+
2
25 RX4-
1:1
24 RX4+
1:1
23 TXct4
22 TX4-
RD4+ 20
RD4+ 20
21 RX4+
21 TX4+
pm-80xx 04/99
Specifications subject to change without notice.
20381 BARENTS SEA CIRCLE, LAKE FOREST, CA 92630 • TEL: (949) 452-0511 • FAX: (949) 452-0512 • http://www.premiermag.com
49
10/100 Base-TX QUAD PORT
ISOLATION TRANSFORMERS
WITH FILTERS
PM-8062 & PM-8084
RD1+ 1
1
40 RX1+
RD1-
39 RX1-
RD1+ 2
38 TXct1
TDct1 3
TD1+ 4
37 TX1+
TD1-
4
37 TX1+
5
36 TX1-
TD1+ 5
36 TX1-
6
35 TX2-
6
TD2+ 7
34 TX2+
TDct2 8
33 TXct2
RD2+ 7
32 RX2-
TDct2 8
2
TDct1 3
TD1TD2-
RD2-
1:1
1:1
9
1:1
RD3+ 11
1:1
30 RX3+
40 RX1+
39 RX138 TXct1
1:1
1:1
35 TX2-
TD2-
33 TXct2
32 RX2-
1:1
9
31 RX2+
TD2+ 10
RD3- 11
1:1
30 RX3+
MEDIA SIDE
31 RX2+
1:1
34 TX2+
MEDIA SIDE
RD2+ 10
RD2-
CHIP SIDE
RD1-
CHIP SIDE
PM-8071 & PM-8085
RD3- 12
29 RX3-
RD3+ 12
29 RX3-
TDct3 13
28 TXct3
TDct3 13
28 TXct3
TD3+ 14
27 TX3+
TD3- 14
27 TX3+
TD3- 15
26 TX3-
TD3+ 15
26 TX3-
TD4- 16
25 TX4-
RD4- 16
TD4+ 17
24 TX4+
TDct4 18
23 TXct4
RD4+ 17
22 RX4-
TDct2 18
RD4- 19
1:1
1:1
1:1
1:1
25 TX424 TX4+
23 TXct4
1:1
22 RX4-
TD2- 19
RD4+ 20
21 RX4+
TD2+ 20
21 RX4+
pm-80xx 04/99
Specifications subject to change without notice.
20381 BARENTS SEA CIRCLE, LAKE FOREST, CA 92630 • TEL: (949) 452-0511 • FAX: (949) 452-0512 • http://www.premiermag.com
50
10/100 Base-TX QUAD PORT
ISOLATION TRANSFORMERS
WITH FILTERS
PM-80xx MECHANICAL
PM-8072 & PM-8086
RECOMMENDED PCB LAYOUT
.480
(12.19)
21
RD4+ 4
39 TX438 CMGND
37 RX4+
RD4- 5
36 RX4-
RD3- 6
35 RX3-
RD3+ 7
TDct3 8
CHIP SIDE
TD3+ 10
31 TX3+
TD2+ 11
30 TX2+
TD2- 12
TDct2 13
RD2+ 14
MEDIA SIDE
TD3- 9
34 RX3+
33 CMGND
32 TX3-
.030 (0.76)
40-PLACES
26 RX2-
RD1- 16
25 RX1-
RD1+ 17
TDct1 18
TD1- 19
24 RX1+
23 CMGND
22 TX1-
TD1+ 20
21 TX1+
.640 (16.26)
.590 (14.98)
.480
(12.19)
1
40
.050 (1.27)
19-PLACES
.045 (1.14)
FLAT
.020 (0.50)
.250
(6.35)
MAX
29 TX228 CMGND
27 RX2+
RD2- 15
.010
(0.25)
TYP
.950
(24.13)
21
.015 (.38)
.005 (.12)
20
.050
(1.27)
TYP
PM-80xx
YYWW
TD4- 2
TDct4 3
40 TX4+
1.125
(28.58)
MAX
P
M
TD4+ 1
.090 (2.29)
40-PLACES
.950
(24.13)
.018
(0.46)
1
40
PIN #1
I.D.
PIN#1
DOT
pm-80xx 04/99
Specifications subject to change without notice.
20381 BARENTS SEA CIRCLE, LAKE FOREST, CA 92630 • TEL: (949) 452-0511 • FAX: (949) 452-0512 • http://www.premiermag.com
51
SMALL OUTLINE
10/100BASE-T ISOLATION
TRANSFORMERS
FEATURES
Ê Designed for 10/100BASE-T Applications
Ë Compliant With IEEE 802.3 Standard
Ì 1500 - 3000V IEC950 Isolation Voltages
Í Versions Available with or without CMC
Î Fast Rise Times
GENERAL SPECIFICATIONS:
Insertion Loss, 1 to 10MHz .................. -0.5dB Typ
Return Loss, 1 to 10MHz ...................... -20dB Typ
CMRR, 1 to 10MHz ............................... -50dB Typ
Differential to CMRR, 1 to 10MHz ...... -60dB Typ
Cross Talk, 1 to 10MHz ......................... -45dB Min
NORMAL TEMP RANGE
ELECTRICAL SPECIFICATIONS AT 25OC - OPERATING TEMPERATURE RANGE 0OC TO 70OC
PART
NUMBER
PM-1001
PM-1002
PM-1003
PM-1004
PM-1005
PM-1006
PM-1007
PM-1008
PM-1011
PM-1013
PM-1015
TURNS RATIO
(PRI:SEC ± 5%)
RCV
XMIT
1ct:1ct
1:1
1ct:1ct
1ct:1ct
1ct:1ct
1ct:1ct
1ct:2ct
1ct:1ct
1ct:1ct
1ct:1ct
1ct:1ct
1ct:1ct
1:1.41
1ct:1ct
1ct:1.41ct
1ct:1.41ct
1ct:1ct
1ct:1ct
1ct:2ct
1ct:2.50ct
1ct:1.ct
1ct:2ct
PRIMARY
OCL
µH Min.)
(µ
150
150
200
150
150
150
150
112
150
150
140
PRI / SEC
LL
µH Max.)
(µ
0.17
0.30
0.40
0.40
0.30
0.40
0.40
0.30
0.30
0.30
0.40
PRI-SEC
Cw/w
(pf Max.)
PRI
DCR
Ω Max.)
(Ω
20
20
20
20
20
20
20
8/12
20
20
15
0.30
0.40
0.40
0.40
0.40
0.80
0.80
0.80
0.40
0.40
0.30
Hi-Pot
(Vrms)
2000
2000
2000
2000
2000
2000
2000
1500
2000
1500
2000
CMC
NO
NO
NO
YES
NO
YES
YES
YES
YES
YES
YES
Package/
Schematic
G1/C
G1/B
G1/C
G1/D
G1/C
G1/D
G1/D
G1/E
G1/D
G1/H
G1/D
EXTENDED TEMP RANGE
ELECTRICAL SPECIFICATIONS AT 25OC - OPERATING TEMPERATURE RANGE -40OC TO +85OC
PART
NUMBER
PM-1009
PM-1010
PM-1012
PM-1014
PM-10202
PM-30081
PM-30091
TURNS RATIO
(PRI:SEC ± 5%)
RCV
XMIT
1ct:1ct
1ct:1ct
1ct:2ct
1ct:1ct
1:1
1ct:1ct
1ct:1ct
1ct:2.50ct
1ct:1.41ct
1ct:1ct
1ct:1.41ct
1:1
1ct:2ct
1ct:1ct
PRIMARY
OCL
µH Min.)
(µ
180
180
note 3
150
200
150
150
PRI / SEC
LL
µH Max.)
(µ
0.40
0.40
0.30
0.40
0.30
0.60
0.50
PRI-SEC
Cw/w
(pf Max.)
20
15
20
30
25
18
20
PRI
DCR
Ω Max.)
(Ω
0.40
0.40
1.0
0.50
.030
0.40/0.90
0.90
Hi-Pot
(Vrms)
2000
2000
1500
2000
2000
3KV IEC
3KV IEC
CMC
NO
YES
YES
NO
YES
YES
YES
Package/
Schematic
G1/C
G1/D
G1/E
G1/C
A8/G
H1/E
H1/D
NOTES:
1) 3KV ISOLATION VERSIONS ARE BUILT TO UL1950, CSA950 & IEC950 REINFORCED INSULATION REQUIREMENTS
2) PM-1020 IS A QUAD DESIGN WITH COMMON MODE CHOKES.
3) OCL 1-3 = 50 µH Min., 9-11 = 200 µH Min.
pm-10_30 09/01
Specifications subject to change without notice.
20381 BARENTS SEA CIRCLE, LAKE FOREST, CA 92630 • TEL: (949) 452-0511 • FAX: (949) 452-0512 • http://www.premiermag.com
52
SMALL OUTLINE
10/100BASE-T ISOLATION
TRANSFORMERS
SCHEMATICS
G1 PACKAGE
SCHEMATIC DIAGRAM "B"
15
16
14
13
12
11
SECONDARY
PRIMARY
PRIMARY
1
2
3
4
5
6
15
13
12
11
PRI.
1
3
4
5
6
RCV
11
10
9
16
7
8
1
PRI.
3
4
5
XMIT
9
16
7
8
1
15
14
13
12
11
2
3
4
5
6
PRI.
XMIT
14
13
12
11
2
3
4
5
6
10
9
16
7
8
1
PRI.
RCV
15
XMIT
5
6
13
12
11
3
4
5
6
9
7
8
XMIT
SUGGESTED PCB LAYOUT
.270 (6.86)
16
7x.050 (1.27)
16x.025 (.64)
7
10
G1 PACKAGE
P PM-10XX
M YYWW
4
14
RCV
1
3
8
PRI.
2
16x.075 (1.91)
2
7
XMIT
PRI.
16 15 14 13 12 11 10 9
1
9
SCHEMATIC DIAGRAM "H"
DIMENSIONS & PCB LAYOUT
PIN#1
WHITE DOT
10
PRI.
RCV
SCHEMATIC DIAGRAM "F"
10
15
PRI.
6
RCV
PRI.
2
12
SCHEMATIC DIAGRAM "D"
SEC.
2
XMIT
14
13
PRI.
1
8
SCHEMATIC DIAGRAM "E"
16
14
SEC.
7
RCV
15
16
9
10
SECONDARY
SCHEMATIC DIAGRAM "C"
8
.475
(12.10)
MAX
.280
(7.11)
MAX
8
9
.210
(5.33)
MAX
.050
.019 (1.27)
(0.48) TYP
TYP
.022 (.55)
.010 (.25)
.020 (0.51) MIN
.010
(0.25)
TYP
.370 (9.40)
pm-10_30 09/01
Specifications subject to change without notice.
20381 BARENTS SEA CIRCLE, LAKE FOREST, CA 92630 • TEL: (949) 452-0511 • FAX: (949) 452-0512 • http://www.premiermag.com
53
SMALL OUTLINE
10/100BASE-T ISOLATION
TRANSFORMERS
SCHEMATICS
H1 PACKAGE
SCHEMATIC DIAGRAM "B"
15
16
14
13
11
12
SECONDARY
PRIMARY
PRIMARY
1
2
3
4
5
6
14
13
11
12
PRI.
1
3
4
5
6
RCV
11
10
9
16
7
8
1
PRI.
3
4
5
XMIT
9
16
7
8
1
15
14
13
12
11
2
3
4
5
6
PRI.
XMIT
14
13
12
11
2
3
4
5
6
10
9
7
8
XMIT
SCHEMATIC DIAGRAM "H"
10
9
16
7
8
1
PRI.
RCV
PRI.
RCV
SCHEMATIC DIAGRAM "F"
10
15
PRI.
6
RCV
PRI.
2
12
SCHEMATIC DIAGRAM "D"
SEC.
2
XMIT
15
13
PRI.
1
8
SCHEMATIC DIAGRAM "E"
16
14
SEC.
7
RCV
15
16
9
10
SECONDARY
SCHEMATIC DIAGRAM "C"
15
14
13
12
11
3
4
5
6
10
PRI.
XMIT
PRI.
2
7
RCV
DIMENSIONS & PCB LAYOUT
9
8
XMIT
H1 PACKAGE
SUGGESTED PCB LAYOUT
.760 (19.30)
16
15
14
13
12
11
10
9
.520 (13.21)
16x.120 (3.05)
7x.100 (2.54)
1
P
M
PIN#1
DOT
1
2
16x.050 (1.27)
PM-3xxx
YYWW
3
4
5
6
16
.700 (17.78)
7
.580
(14.73)
8
8
9
.950
(24.13)
MAX
.390
(9.91)
MAX
.020
(0.51)
TYP
.050
(1.27)
TYP
.100
(2.54)
TYP
.050 (1.27)
FLAT
.030 (0.76)
.720
(18.29)
MAX
.020 (.51)
.010 (.25)
.010
(0.25)
TYP
pm-10_30 09/01
Specifications subject to change without notice.
20381 BARENTS SEA CIRCLE, LAKE FOREST, CA 92630 • TEL: (949) 452-0511 • FAX: (949) 452-0512 • http://www.premiermag.com
54
SMALL OUTLINE
10/100BASE-T ISOLATION
TRANSFORMERS
SCHEMATIC
A8 PACKAGE
SCHEMATIC DIAGRAM "G"
16
15
14
PRI.
1
13
PRI.
2
3
RCV
11
12
10
PRI.
4
PRI.
5
XMIT
9
6
7
RCV
8
XMIT
DIMENSIONS & PCB LAYOUT
A8 PACKAGE
16
9
P
M
PIN#1
DOT
PM-1020
YYWW
1
8
.800
(20.32)
MAX
.385
(9.78)
MAX
.250
(6.35)
MAX
1
8
.100
(2.54)
.700
(17.78)
.120
(3.05)
MIN
.020 DIA
(0.51)
.300
(7.62)
pm-10_30 09/01
Specifications subject to change without notice.
20381 BARENTS SEA CIRCLE, LAKE FOREST, CA 92630 • TEL: (949) 452-0511 • FAX: (949) 452-0512 • http://www.premiermag.com
55
10/100 Base-TX SINGLE PORT
MAGNETIC MODULES
Ê Meets All IEEE 802.3 and ANSI X3.263 Standard Including 350 uH OCL With 8 mADC Bias
Ë Compact Footprint for Use in the Most Space Restrictive Applications
ELECTRICAL SPECIFICATIONS AT 25OC - OPERATING TEMPERATURE RANGE 0OC TO +70OC
PM-6101
PM-6102
PM-6103
PM-6104
PM-6105
PM-6106
PM-6107
TX
RX
1:1
1:1
2:1
1:1
1.41:1
1.25:1
1:1.41
1:1
1:1
1:1
2:1
1:1
1:1
1:1
Diff. to Com Mode
Return Loss
INSERTION
LOSS
(dB TYP)
(dB Max)
30
60
80
100KHz to
MHz MHz MHz
100MHz
Turn Ratio
PART
NUMBER
1.1
1.1
1.1
1.1
1.1
1.1
1.1
-20
-20
-20
-20
-20
-20
-18
-14
-14
-14
-14
-14
-14
-12
Crosstalk
Rejection (dB Min)
-11.5
-11.5
-11.5
-11.5
-11.5
-11.5
-11.5
30
50
MHz
MHz
MHz
-42
-42
-42
-42
-42
-42
-42
-37
-37
-37
-37
-37
-37
-37
-33
-33
-33
-33
-33
-33
-30
(dB Min)
100
30
MHz
-45
-45
-45
-45
-45
-45
-45
60
100
MHz
MHz
-40
-40
-40
-40
-40
-40
-40
SCHEMATIC "A"
Schematic HI-POT
(Vrms)
-35
-35
-35
-35
-35
-35
-35
A
B
B
B
B
B
B
1500
1500
1500
1500
1500
1500
1500
SCHEMATIC "B"
TRANSMIT
TRANSMIT
1
16
1
16
2
15
2
15
3
14
3
14
RECEIVE
RECEIVE
6
11
6
11
7
10
7
10
8
9
8
9
PCB LAYOUT
MECHANICAL
16
15
14
13
12
11
10
9
.420 (10.67)
P
M
PIN #1
I.D.
1
2
3
16x.075 (1.91)
PM-61xx
YYWW
4
5
6
7
7x.050 (1.27)
1
8
.350 (8.89)
0.285
(7.24)
MAX
0.235
(5.97)
0.350
(8.89)
16
16x.025 (.64)
0.500
(12.70)
MAX
.019
(0.48)
TYP
.270 (6.86)
0.050
(1.27)
TYP
.015
(0.38)
8
0.035
(0.89)
0.37 (9.40)
9
0.020
(0.05)
TYP
pm-61xx 11/00
Specifications subject to change without notice.
20381 BARENTS SEA CIRCLE, LAKE FOREST, CA 92630 • TEL: (949) 452-0511 • FAX: (949) 452-0512 • http://www.premiermag.com
56
10/100 PC CARD LAN
MAGNETICS SOLUTION
Ê
Ë
Ì
Í
Half Port and Single Port Designs for Maximum Layout Flexibility
Low Profile Package for PC Card and Cardbus Application
Compatible with TDK, QSI, and ICS Transceivers
Hi-pot: 1500Vrms
ELECTRICAL SPECIFICATIONS AT 25OC - OPERATING TEMPERATURE RANGE 0OC TO +70OC
PART
NUMBER
PM-6201
PM-6202
PM-6203
PM-6204
PM-6205
PM-6206
PM-6207
PM-6208
PM-6209
PM-6211
PM-6213
PM-6215
PM-6217
PM-6218
PM-6219
PM-6220
PM-6221
PM-6222
PM-6223
PM-6225
PM-6227
PM-6260
PM-6262
PM-6264
PM-6266
PM-6278
PM-6281
PM-6283
PM-6284
PM-6290
Turn Ratio
TX
RX
1:1:1ct
2ct:1ct
1ct:1ct
1ct:1ct
1.41ct:1ct 1ct:1ct
1.41ct:1ct 1ct:1ct
1.41ct:1ct 1ct:1ct
1.41ct:1ct 1ct:1ct
1ct:1ct
1ct:1ct
1ct:1ct
1ct:1ct
1ct:1ct
1ct:1ct
1ct:1ct
1.25ct:1ct
1ct:1ct
1ct:1ct
1.25ct:1ct 1ct:1ct
1.25ct:1ct 1ct:1ct
1ct:1ct
1ct:1ct
1ct:1ct
1ct:1ct
1ct:1ct
1ct:1ct
1ct:1ct
1ct:1ct
1ct:1ct
1ct:1ct
1ct:1ct
1ct:1ct
1ct:1ct
1ct:1ct
1.41ct:1ct 1ct:1ct
1ct:1.41ct 1ct:1ct
1ct:1ct
1ct:1ct
1ct:1ct
1ct:1ct
1ct:1ct
1ct:1ct
1ct:1ct
1ct:1ct
1ct:1ct
1ct:1ct
1ct:1ct
1ct:1ct
1ct:1ct
1ct:1ct
Return Loss
Ind
Insertion
Differential to CMR
(uH Min) Loss
(dB Min)
(dB Min)
100K (dB Max)
60
80
30
50
80
8mADC 100K to 30
100MHz MHz MHz MHz MHz MHz MHz
350
350
350
350
350
350
350
350
350
350
350
350
350
350
350
350
350
350
350
350
350
350
350
350
350
200
170
170
350
150
-1.0
-1.0
-1.0
-1.1
-2.0
-2.0
-1.3
-1.3
-1.0
-1.1
-1.1
-1.3
-1.1
-1.1
-1.0
-1.0
-1.0
-1.5
-1.0
-1.0
-1.0
-1.0
-1.1
-1.0
-1.0
-0.9
-0.9
-0.9
-1.1
-2.0
-20
-18
-18
-18
-18
-18
-18
-18
-20
-17
-17
-16
-17
-17
-18
-18
-18
-18
-18
-18
-18
-17
-18
-18
-18
-16
-16
-16
-18
-18
-17
-15
-12
-13
-12
-12
-13
-13
-17
-12
-12
-12
-12
-12
-12
-12
-12
-11
-13
-13
-13
-12
-13
-12
-12
-12
-12
-12
-16
-14
-10
-12
-10
-11
-10
-10
-11
-11
-10
-10
-10
-11
-10
-10
-11
-11
-10
-10
-11
-11
-11
-10
-11
-11
-11
-11
-11
-11
-10
-12
-38
-30
-30
-30
-30
-30
-40
-40
-38
-30
-30
-15
-30
-30
-30
-30
-45
-40
-45
-45
-45
-30
-30
-30
-30
-40
-40
-40
-30
-30
-38
-30
-30
-30
-30
-30
-35
-35
-38
-30
-30
-18
-30
-30
-30
-30
-35
-40
-35
-35
-35
-30
-30
-30
-30
-40
-40
-40
-30
-30
-10
-30
-30
-30
-20
-20
-30
-30
-10
-30
-30
-20
-20
-20
-20
-20
-10
-40
-30
-30
-30
-20
-30
-30
-30
-40
-40
-40
-30
-30
Crosstalk
Package/
Schematic
(dB Min)
30
62
MHz
MHz
-38
-40
-40
-40
-40
-40
-40
-40
-38
-------40
-40
-40
-40
-40
-35
-40
-40
-40
-40
-40
-40
-40
-40
-38
-38
-38
-38
-50
-38
-40
-40
-40
-40
-40
-40
-40
-38
-------40
-35
-35
-40
-40
-35
-35
-40
-40
-40
-35
-40
-40
-40
-38
-38
-38
-38
-45
100
MHz
-35
-30
-35
-35
-35
-35
-35
-35
-35
-------35
-30
-30
-35
-35
-35
-35
-35
-35
-35
-30
-30
-35
-35
-38
-38
-38
-38
-40
1/E
3/F
1/G
2/F
1/A
2/A
1/A
2/A
1/B
3/C
3/C
4/D
4/D
2/B
4/D
2/B
1/H
5/I
1/J
1/K
1/L
4/D
4/M
4/D
4/T
3/N
3/P
3/R
3/D
6/S
pm-6xxx 11/00
Specifications subject to change without notice.
20381 BARENTS SEA CIRCLE, LAKE FOREST, CA 92630 • TEL: (949) 452-0511 • FAX: (949) 452-0512 • http://www.premiermag.com
57
10/100 PC CARD LAN
MAGNETICS SOLUTION
PACKAGE "1"
PACKAGE "2"
.900
(22.86)
MAX
16
.455
(11.56)
14
8
P PM-62XX
M YYWW
1
.020
(.51)
.100
(2.54)
.685
(17.4)
.10
(2.54)
Typ
7
8
P PM-62XX
M YYWW
.530
(13.46)
.520
(13.21)
7
1
.018
(.46)
.035 (0.89) TYP
.600
(15.24)
.095
(2.41)
MAX
.050
(1.27)
.080
(2.03)
.007 (.18) TYP
PACKAGE "3"
PACKAGE "4"
.560
(14.22)
.500
(12.70)
MAX
16
16
1
.050
(1.27)
9
9
P PM-62XX
M YYWW
.018
(.457)
8
.078
(1.98)
MAX
.380
(9.65)
.280
(7.11)
.035 (0.89) TYP
.350
(8.89)
P PM-62XX
M YYWW
.007 (.18) TYP
.018
(.457)
1
8
.050
(1.27)
.670
(17.01)
.560
(14.22)
.098
(2.5)
MAX
.035 (0.89) TYP
.350
(8.89)
.007 (.18) TYP
PACKAGE "5"
PACKAGE "6"
.465
(11.81)
1.000
(25.4)
MAX
16
9
16
P PM-62XX
M YYWW
.020
(.5.8)
.100
(2.54)
.605
(15.37)
1
P PM-62XX
M YYWW
8
.24
(6.10)
MAX
.500
(12.7)
.390
(9.906)
.035 (0.89) TYP
.700
(17.78)
9
.020
(.51)
.050
(1.27)
.010 (.254) TYP
.085
8 (2.159)
MAX
1
.450
(11.43)
.340
(8.63)
.035 (0.89) TYP
.350
(8.89)
.004-010 (.10-.25)
pm-6xxx 11/00
Specifications subject to change without notice.
20381 BARENTS SEA CIRCLE, LAKE FOREST, CA 92630 • TEL: (949) 452-0511 • FAX: (949) 452-0512 • http://www.premiermag.com
58
10/100 PC CARD LAN
MAGNETICS SOLUTION
SCHEMATIC "A"
SCHEMATIC "B"
CT 3
13 RX
RD 2
RD 1
CT 1
14 RX
12 C T
12 RX
RD 3
14 C T
TD 5
10 TX
RD 2
13 RX
TD 6
9 TX
CT 5
CT 7
TD 7
9 TX
TD 6
8 TX
10 C T
8 CT
SCHEMATIC "C"
SCHEMATIC "D"
CT 3
16 RX
RD 1
16
9
15
10
1
8
14 C T
6
RD 2
15 RX
TD 7
10 TX
CT 6
TD 8
9 TX
11 C T
SCHEMATIC "E"
1
SCHEMATIC "F"
14
1
2
3
4
5
3
13
2
12
13
12
5
9
6
6
7
14
9
10
8
7
10
8
pm-6xxx 11/00
Specifications subject to change without notice.
20381 BARENTS SEA CIRCLE, LAKE FOREST, CA 92630 • TEL: (949) 452-0511 • FAX: (949) 452-0512 • http://www.premiermag.com
59
10/100 PC CARD LAN
MAGNETICS SOLUTION
SCHEMATIC "G"
SCHEMATIC "H"
14 RX
RD 1
CT 2
12 RX
RD 3
13 C T
TD 5
13
9
12
10
14
8
3
10 TX
1
CT 6
7
5
8 TX
TD 7
2
6
9 CT
SCHEMATIC "I"
SCHEMATIC "J"
TD 16
10 TX
CT 14
12 CT
TD 15
11 TX
3
5
2
6
1
7
8
14
CT 3
RD 1
7 RX
10
5 CT
9
6 RX
RD 2
13
12
SCHEMATIC "K"
SCHEMATIC "L"
12
8
3
13
10
1
14
9
14
13
2
12
7
5
10
5
6
9
6
7
8
3
1
2
pm-6xxx 11/00
Specifications subject to change without notice.
20381 BARENTS SEA CIRCLE, LAKE FOREST, CA 92630 • TEL: (949) 452-0511 • FAX: (949) 452-0512 • http://www.premiermag.com
60
10/100 PC CARD LAN
MAGNETICS SOLUTION
SCHEMATIC "M"
1
SCHEMATIC "N"
16
7
3
2
6
15
8
14
16
10
1
14
11
8
9
11
6
7
10
15
9
2
3
SCHEMATIC "P"
SCHEMATIC "R"
TD 15
13 CT
RD 1
10 TX
CT 2
CT 14
RD 3
TD 16
11 TX
TD 6
RD 2
7 RX
CT 7
5 CT
TD 8
6 RX
16 TX
14 TX
15 C T
SCHEMATIC "S"
SCHEMATIC "T"
CT 3
3
1
9 RX
10 C T
CT 3
RD 1
11 RX
RD 1
16
14 C T
14
2
15
7
10
6
11
8
9
16 RX
RD 2
15 RX
TD 7
10 TX
CT 6
TD 8
9 TX
11 C T
pm-6xxx 11/00
Specifications subject to change without notice.
20381 BARENTS SEA CIRCLE, LAKE FOREST, CA 92630 • TEL: (949) 452-0511 • FAX: (949) 452-0512 • http://www.premiermag.com
61
1000 Base-T MODULES
ISOLATION TRANSFORMERS
WITH FILTERS
Ê
Ë
Ì
Í
Designed for Long Haul Gigabit Ethernet 100/1000 Base-T
Provides the Cable Interface, Isolation & Common Mode Filtering
Meet IEEE 802.3ab Standard for 1000 Base-T
Supports 4 Pairs of Category 5 UTP Cable
ELECTRICAL SPECIFICATIONS AT 25OC - OPERATING TEMPERATURE RANGE 0OC TO +70OC
INSERTION
LOSS
(dB Max)
1 to 100MHz
PART
NUMBER
PM-9001
PM-9002
-1.0
-1.0
Return Loss
Differential to Common
(dB Typ)
Mode Rejection (dB Min)
1-30
40
50
MHz
MHz
MHz
-18
-18
60-80
MHz
-14.4 -13.1 -12
-14.4 -13.1 -12
100
30
MHz
MHz
-10
-10
-43
-43
Crosstalk
(dB Min)
50
100
30
MHz
MHz
MHz
-37
-37
-33
-33
60
-45
-45
-40
-40
MHz
-35
-35
1500
1500
PCB LAYOUT
PM-900X MECHANICAL
24
MHz
HI-POT
100 (Vrms Min)
13
.050 (1.27)
P PM-900X
M YYWW
PIN #1
I.D.
1
24
.480
(12.19)
12
.705
(17.91)
MAX
PIN#1
DOT
.480
(12.19)
.250
(6.35)
MAX
.018
(0.46)
.550
(13.97)
.050
(1.27)
TYP
.015 (.38)
.005 (.12)
.090 (2.29)
40-PLACES
1
1
.045 (1.14)
.020 (0.50) FLAT
.640 (16.26)
.590 (14.98)
.030 (0.76)
.550
(13.97)
.010
(0.25)
TYP
PM-9001 SCHEMATIC
TCT1
1
TD1+
2
TD1-
PM-9002 SCHEMATIC
24 TCT1
TCT1
1
23 MX1+
TD1+
2
3
22 MX1-
TD1-
3
22 MX1-
TCT2
4
21 TCT2
TCT2
4
21 TCT2
TD2+
5
20 MX2+
TD2+
5
TD2-
6
19 MX2-
TD2-
6
19 MX2-
TCT3
7
18 TCT3
TCT3
7
18 TCT3
TD3+
8
17 MX3+
TD3+
8
TD3-
9
16 MX3-
TD3-
9
TCT4 10
15 TCT4
TCT4 10
14 MX4+
TD4+ 11
13 MX4-
TD4- 12
TD4+ 11
TD4- 12
1:1
1:1
1:1
1:1
24 TCT1
1:1
1:1
1:1
23 MX1+
20 MX2+
17 MX3+
16 MX315 TCT4
1:1
14 MX4+
13 MX4pm-9xxx 02/02
Specifications subject to change without notice.
20381 BARENTS SEA CIRCLE, LAKE FOREST, CA 92630 • TEL: (949) 452-0511 • FAX: (949) 452-0512 • http://www.premiermag.com
62
1000 Base-T MODULES
ISOLATION TRANSFORMERS
WITH FILTERS
Ê
Ë
Ì
Í
Designed for Long Haul Gigabit Ethernet 100/1000 Base-T
Provides the Cable Interface, Isolation & Common Mode Filtering
Meet IEEE 802.3ab Standard for 1000 Base-T
Supports 2 Pairs of Category 5 UTP Cable
ELECTRICAL SPECIFICATIONS AT 25OC - OPERATING TEMPERATURE RANGE 0OC TO +70OC
INSERTION
LOSS
(dB Max)
1 to 100MHz
PART
NUMBER
PM-9111
PM-9112
-1.0
-1.0
1-30
MHz
-18
-18
Return Loss
Differential to Common
(dB Typ)
Mode Rejection (dB Min)
40
50
MHz
MHz
60-80
MHz
-14.4 -13.1 -12
-14.4 -13.1 -12
100
30
MHz
-10
-10
50
MHz
-37
-37
(dB Min)
30
100
MHz
-43
-43
Crosstalk
MHz
-33
-33
1
TD1+ 2
MHz
MHz
MHz
-40
-40
-35
-35
15 MX1+
TD1-
3
14 MX1-
TCT2
6
11 TCT2
TD2+ 7
TD2-
1:1
.505
(12.83)
MAX
16
PIN #1
I.D.
.018
(.457)
10 MX2+
9
P PM-9111
M YYWW
1
.050
(1.27)
9 MX2-
8
8
TD1+ 2
.350
(8.89)
14 MX1-
TCT2 6
11 TCT2
TD2+ 7
TD2-
1:1
8
.280
(7.11)
.007 (.18) TYP
.505
(12.83)
MAX
16
15 MX1+
3
TD1-
.380
(9.65)
PM-9112 MECHANICAL
16 TCT1
1:1
.098
(2.5)
MAX
.035 (0.89) TYP
PM-9112 SCHEMATIC
TCT1 1
1500
1500
PM-9111 MECHANICAL
16 TCT1
1:1
HI-POT
100 (Vrms Min)
-45
-45
PM-9111 SCHEMATIC
TCT1
60
PIN #1
I.D.
.018
(.457)
10 MX2+
.050
(1.27)
9 MX2-
Specifications subject to change without notice.
9
P PM-9112
M YYWW
1
8
.098
(2.5)
MAX
.450
(11.43)
.346
(8.80)
.035 (0.89) TYP
.350
(8.89)
.007 (.18) TYP
pm-9xxx 02/02
20381 BARENTS SEA CIRCLE, LAKE FOREST, CA 92630 • TEL: (949) 452-0511 • FAX: (949) 452-0512 • http://www.premiermag.com
63
GENERAL PURPOSE
COUPLING
TRANSFORMERS
Ê Wide Selection of Standard Types
Ë Industry Standard Package
Ì Low Leakage Ind. and Winding Capacitance
Í Average Power Rating 500 mW (40OC Rise)
Î Dissipation Rating 150 mW
Ï Fast Rise Times
Ð 2000Vrms Minimum Isolation Voltage
Ñ Insulation Resistance 10,000MΩ Minimum
Ò Peak Pulse Voltage 100V
Ó Custom Designs Available
ELECTRICAL SPECIFICATIONS AT 25OC - OPERATING TEMPERATURE RANGE -40OC TO +85OC
PART
NUMBER
TURNS
RATIO
(± 5%)
PRIMARY
OCL
µH MIN)
(µ
PRIMARY
RISE
PRI-SEC PRI / SEC
PRI
SEC
TER
Sch.
ET CONSTANT TIME
Cw/w
LL
DCR
DCR
DCR
µsec Min.) (ns Max.) (pf Max.) (µ
µH Max.) (Ω
(V-µ
Ω Max.) (Ω
Ω Max.) (Ω
Ω Max.)
PM-NW01
PM-NW02
PM-NW03
PM-NW04
PM-NW05
PM-NW06
PM-NW07
PM-NW08
PM-NW09
1:1:1
1:1:1
1:1:1
1:1:1
1:1:1
1:1:1
1:1:1
1:1:1
1:1:1
5,000
2,000
1,000
500
200
100
50
20
10
25.0
16.0
11.0
8.5
6.5
6.0
5.5
4.0
3.5
11.0
8.5
8.0
5.5
4.5
5.5
5.0
4.4
4.2
60.0
37.0
30.0
32.0
18.0
15.0
10.0
9.0
8.0
1.3
.80
.70
.60
.50
.40
.30
.30
.30
3.9
2.5
2.0
1.5
1.0
0.8
0.7
0.6
0.5
3.9
2.5
2.0
1.5
1.0
0.8
0.7
0.6
0.5
3.9
2.5
2.0
1.5
1.0
0.8
0.7
0.6
0.5
A
A
A
A
A
A
A
A
A
PM-NW10
PM-NW11
PM-NW12
PM-NW13
PM-NW14
2:1:1
2:1:1
2:1:1
2:1:1
2:1:1
5,000
2,000
500
200
20
25.0
16.0
8.5
6.5
4.0
11.0
8.5
5.5
4.5
4.4
35.0
20.0
12.0
9.0
8.0
4.0
2.0
1.5
1.0
0.8
3.9
2.5
1.5
1.0
0.6
2.0
1.5
0.8
0.6
0.5
2.0
1.5
0.8
0.6
0.5
A
A
A
A
A
PM-NW15
PM-NW16
PM-NW17
PM-NW18
PM-NW19
PM-NW20
1ct:1ct
1ct:1ct
1ct:1ct
1ct:1ct
1ct:1ct
1ct:1ct
2,000
1,000
500
200
100
50
16.0
11.0
8.5
6.5
6.0
5.5
8.5
8.0
5.5
4.5
5.5
5.0
37.0
30.0
32.0
18.0
15.0
10.0
.80
.70
.60
.50
.40
.30
2.5
2.0
1.5
1.0
0.8
0.7
2.5
2.0
1.5
1.0
0.8
0.7
-------------------
G
G
G
G
G
G
PM-NW21
PM-NW22
PM-NW23
PM-NW24
PM-NW25
2ct:1
2ct:1
2ct:1
2ct:1
2ct:1
5,000
2,000
500
200
20
25.0
16.0
8.5
6.5
4.0
11.0
8.5
5.5
4.5
4.4
35.0
20.0
12.0
9.0
8.0
4.0
2.0
1.5
1.0
0.8
3.9
2.5
1.5
1.0
0.6
2.0
1.5
0.8
0.6
0.5
2.0
1.5
0.8
0.6
0.5
A
A
A
A
A
PM-NW26
1.25:1
1,200
11.0
10.0
35.0
0.8
0.8
0.7
----
B
pmnw 10/97
Specifications subject to change without notice.
20381 BARENTS SEA CIRCLE, LAKE FOREST, CA 92630 • TEL: (949) 452-0511 • FAX: (949) 452-0512 • http://www.premiermag.com
64
GENERAL PURPOSE
COUPLING
TRANSFORMERS
"T6" SCHEMATICS
SINGLE CORE
SCHEMATIC DIAGRAMS
SCHEMATIC "A"
TE R.
5
1
6
5
SEC.
SCHEMATIC "G"
6
4
3
2
PRIMARY
1
2
PRI.
3
Schematic "B"
Pin #3 & 6 Removed
5
6
4
.080
(2.03)
TYP
.400
(10.16)
2
.350
(8.89)
MAX
.080
(2.03)
TYP
.250
(6.35)
MAX
.340
(8.64)
.30
(7.62)
TYP
6
.500
(12.70)
MAX
.350
(8.89)
MAX
.500
(12.70)
MAX
.340
(8.64)
P PM-NWXX
M YYWW
1
2
1
2
SINGLE CORE
Schematic "A" & "G"
P PM-NWXX
M YYWW
4
PRI.
1
"T6" MECHANICALS
5
6
5
SEC.
SEC .
3
SCHEMATIC "B"
.020
DIA
(0.51)
.400
(10.16)
.100
(2.54)
.30
(7.62)
TYP
.250
(6.35)
MAX
.020
DIA
(0.51)
.200
(5.08)
pmnw 10/97
Specifications subject to change without notice.
20381 BARENTS SEA CIRCLE, LAKE FOREST, CA 92630 • TEL: (949) 452-0511 • FAX: (949) 452-0512 • http://www.premiermag.com
65
SIGNAL LINE FILTERS
COMMON MODE CHOKES
Ê Ideal for LAN & Telecom Applications
Ë Filters Common Mode Noise
Ì Provides EMI Suppression
Í Frequency Ranges 100KHz to 500 MHz
º 500Vrms Isolation Minimum
» Thru-Hole & SMD Packages
ELECTRICAL SPECIFICATIONS AT 25OC - OPERATING TEMPERATURE RANGE 0OC TO 70OC
THRU-HOLE CHOKES
# of CORES
PRIMARY
x
INDUCTANCE
# of LINES (OCL µH min)
TURNS
RATIO
(± 5%)
PART
NUMBER
PM-SF01
1:1:1:1
PM-SF02
1:1:1:1
PM-SF03
1:1:1:1
PM-SF04
1:1:1:1:1:1
PM-SF05
1:1:1:1:1:1
PM-SF06
1:1:1:1
PM-SF07
1:1:1:1
PM-SF08
1:1:1:1
PM-SF09
1:1:1:1
PM-FS10
1:1
SURFACE MOUNT CHOKES
PART
NUMBER
PM-SF30
PM-SF31
PM-SF32
PM-SF33
PM-SF34
PM-SF35
1x4
1x4
1x4
1x6
1x6
2x4
2x4
2x4
1x4
1x2
TURNS
RATIO(S)
(± 5%)
4.0
8.0
24.0
4.0
24.0
4.0
8.0
24.0
36.0
6.3
# of CORES
PRIMARY
x
INDUCTANCE
# of LINES (OCL µH min)
1:1 x 2
1:1 x 3
1:1 x 4
1:1:1:1
1:1:1:1
1:1 x 2
2x2
3x2
4x2
1x4
1x4
2x2
37.0
21.0
36.0
36.0
24.0
100
LEAKAGE
INDUCTANCE
µH max.)
(µ
PRI-SEC
Cw/w
(pf max.)
PRIMARY
DCR
(OHMS max.)
PACKAGE
&
SCHEMATIC
.20
.20
.20
.20
.20
.20
.20
.20
.30
4.0
6.0
10.0
15.0
6.0
15.0
6.0
10.0
15.0
25.0
180.0
.17
.25
.30
.18
.35
.17
.25
.30
.35
.65
1-A
1-A
1-A
2-A
2-A
3-C
3-C
3-C
1-A
7-A
LEAKAGE
INDUCTANCE
µH max.)
(µ
PRI-SEC
Cw/w
(pf max.)
PRIMARY
DCR
(OHMS max.)
SCHEMATIC
&
PACKAGE
15.0
15.0
15.0
25.0
15.0
35.0
.30
.35
.35
.25
.30
.60
5-A
5-B
5-C
5-D
4-A
4-B
LEAKAGE
INDUCTANCE
µH max.)
(µ
PRI-SEC
Cw/w
(pf max.)
PRIMARY
DCR
(OHMS max.)
SCHEMATIC
&
PACKAGE
N/A
N/A
N/A
N/A
.200
.110
.20
.20
.20
.30
.20
.30
SELF LEAD SURFACE MOUNT CHOKES
PART
NUMBER
PM-SF50
PM-SF51
TURNS
RATIO(S)
(± 5%)
# of CORES
PRIMARY
x
INDUCTANCE
# of LINES (OCL µH min)
1:1
1:1
1
1
877
663
SCHEMATIC "A"
PACKAGE "1"
P IN # 1
DOT
6-A
6-A
.4 00
(1 0 .16 )
M AX
.5 00
(1 2 .70 )
M AX
.0 20
(.5 1 )
TYP
8
7
6
5
1
2
3
4
.2 80
(6 .3 5)
M AX
.1 20
(3 .0 5)
M IN
.1 00
(2 .5 4)
.0 20
D IA
(.5 1 )
.3 00
(7 .6 2)
.3 00
(7 .6 2)
pm-sfxx 09/00
Specifications subject to change without notice.
20381 BARENTS SEA CIRCLE, LAKE FOREST, CA 92630 • TEL: (949) 452-0511 • FAX: (949) 452-0512 • http://www.premiermag.com
66
SIGNAL LINE FILTERS
COMMON MODE CHOKES
PACKAGE "2"
SCHEMATIC "A"
.675
(17.14)
MAX
PIN#1
DOT
.400
(12.70)
MAX
12
11
10
9
8
7
1
2
3
4
5
6
.250
(6.35)
MAX
.120
(3.05)
MIN
.020 DIA
(0.51)
.100
(2.54)
.500
(12.70)
.300
(7.62)
PACKAGE "3"
SCHEMATIC "A"
1.000
(25.40)
MAX
PIN#1
DOT
.400
(12.70)
MAX
16
15
14
13
12
11
10
9
.020 DIA
(0.51)
1
2
3
4
5
6
7
8
.250
(6.35)
MAX
.120
(3.05)
MIN
.100
(2.54)
.700
(17.78)
PACKAGE "4"
PACKAGE "4"
8
7
6
.300
(7.62)
RECOMMENDED PCB LAYOUT
.640 (16.23)
5
SCHEMATIC "A"
8
7
6
5
1
2
3
4
.400 (10.16)
8x.120 (3.05)
3x.100 (2.54)
1
P PM-SFXX
M YYWW
8
8x.050 (1.27)
.300 (7.62)
4
PIN#1
1
DOT
2
3
5
.475
(12.07)
4
.475
(12.07)
MAX
SCHEMATIC "B"
.400
(10.16)
8
7
6
5
1
2
3
4
.340
(8.64)
MAX
.030
(0.76)
TYP
.100
(2.54)
TYP
.050
(1.27)
TYP
.020 (.51)
.010 (.25)
.010
(0.25)
TYP
.050 (1.27)
FLAT
.030 (0.76)
.600
(15.24)
MAX
pmsf 09/00
Specifications subject to change without notice.
20381 BARENTS SEA CIRCLE, LAKE FOREST, CA 92630 • TEL: (949) 452-0511 • FAX: (949) 452-0512 • http://www.premiermag.com
67
SIGNAL LINE FILTERS
COMMON MODE CHOKES
RECOMMENDED PCB LAYOUT
PACKAGE "5"
.420 (10.67)
16 15 14 13 12 11 10 9
16x.075 (1.91)
7x.050 (1.27)
P PM-SFxx
M YYWW
PIN#1 1 2
WHITE DOT
3
4
5
6
7
SCHEMATIC "B"
SCHEMATIC "A"
.270 (6.86)
1
SCHEMATIC
16
16
15
14
13
12
11
10
9
16
15
14
13
12
11
10
9
1
2
3
4
5
6
7
8
1
2
3
4
5
6
7
8
16x.025 (.64)
.350 (8.89)
8
8
9
.475
(12.10)
MAX
SCHEMATIC "D"
SCHEMATIC "C"
.280
(7.11)
MAX
16
15
14
13
12
11
10
9
16
15
14
13
12
11
10
9
1
2
3
4
5
6
7
8
1
2
3
4
5
6
7
8
.210
(5.33)
MAX
.050
.019 (1.27)
(0.48) TYP
TYP
.022 (.55)
.004 (.10)
.010
(0.25)
TYP
.020 (0.51) MIN
.370 (9.40)
PACKAGE "6"
1
P
M
.5 0 0
(1 2 .7 0 )
M A X
SCHEMATIC "A"
PM-SFXX
YYWW
2
3
1
3
2
4
4
.5 0 0
(1 2 .7 0 )
M A X
.2 1 5
(5 .4 6 )
M A X
.3 3 0
(8 .3 8 )
0.510
(12.95)
MAX
SCHEMATIC "A"
0.400
(10.16)
.4 00
(1 0 .16 )
.0 32
(.8 1 )
10
8
.5 58
(1 4 .17 )
MAX
.4 00
(1 0 .16 )
8x # 24AW G
9
7
P PM-SFXXX
M YYWW
4
6
SCHEMATIC "E"
.4 00
(1 0 .16 )
MAX
.5 58
(1 4 .17 )
MAX
2
10
0.300
(7.62)
PACKAGE "8"
3
5
6
0.410
(10.41)
MAX
0.130
(3.30)
1
1
5
1
P
M
PM-SFXX
YYWW
10
PACKAGE "7"
Specifications subject to change without notice.
.2 00
(5 .0 8)
M IN
.2 00
(5 .0 8)
.1 00
(2 .5 4)
1
2
3
4
7
8
9
10
pmsfxx 09/00
20381 BARENTS SEA CIRCLE, LAKE FOREST, CA 92630 • TEL: (949) 452-0511 • FAX: (949) 452-0512 • http://www.premiermag.com
68
SIGNAL LINE FILTERS
COMMON MODE CHOKES
Ê Ideal for LAN & Telecom Applications
Ë Filters Common Mode Noise
Ì Reduces Radiated EMI Emissions
Í Common Mode Attenuation from
100 KHz to 1 GHz
ELECTRICAL SPECIFICATIONS AT 25OC - OPERATING TEMPERATURE RANGE 0OC TO 70OC
SURFACE MOUNT CHOKES
PART
NUMBER
PM-SF100
PM-SF101
PM-SF102
PM-SF103
PM-SF104
PM-SF105
PM-SF106
PM-SF107
PM-SF108
PM-SF109
PM-SF110
PM-SF111
PM-SF112
PM-SF113
No. of
Lines
PRIMARY
INDUCTANCE
(OCL µH min)
2
3
4
4
4
4
4
4
6
6
8
8
2
4
40
85
22.5
36
37
85
100
4700 ± 30%
21
85
36
85
47
47
Common Mode Attenuation in Hz
(dB TYP)
100K
7
9
7
7
8
8
14
40
6
8
8
8
11
3
1M
23
24
20
23
21
22
33
51
19
22
24
24
27
19
10M
35
31
30
35
28
28
44
38
28
29
36
30
40
32
30M
39
30
37
38
28
28
48
30
34
30
39
29
44
36
50M
37
29
38
38
28
27
49
25
35
30
35
27
42
35
100M 300M 500M 1G
32
27
34
26
27
25
44
20
36
29
29
24
36
29
21
21
24
29
25
20
34
14
34
24
18
16
26
12
16
16
13
24
22
15
29
13
29
19
11
11
17
6
------20
-1
------
DCR
(Ω max.)
PACKAGE
&
SCHEMATIC
0.20
0.20
0.22
0.50
0.30
0.20
0.60
1.20
0.35
0.20
0.35
0.20
0.40
0.38
A&1
A&2
B&3
B&3
C&4
B&3
B&5
D&6
C&7
C&7
C&8
C&9
E&1
F&3
pm-sfxxx 10/02
Specifications subject to change without notice.
20381 BARENTS SEA CIRCLE, LAKE FOREST, CA 92630 • TEL: (949) 452-0511 • FAX: (949) 452-0512 • http://www.premiermag.com
69
SIGNAL LINE FILTERS
COMMON MODE CHOKES
PACKAGE "A"
6
5
PACKAGE "B"
4
8
P
M
PM-SFXXX
YYWW
2
6
5
P IN # 1
DOT
3
.300
(7.62)
MAX
1
2
.275
(7.00)
3
1
0.300 (7.62)
0 .4 7
(1 1 .9 )
4
0 .4 7 5
(1 2 .0 6 )
M AX
0 .3 9
(9 .9 )
0 .3 4 0
(8 .6 4 )
M AX
.010
(0.25)
TYP
.390
(9.91)
.100
(2.54)
TYP
0 .0 1 8
(0 .4 5 )
TYP
0 .6 0 0
(1 5 .2 4 )
M AX
0 .1 0 0
(2 .5 4 )
TYP
PACKAGE "C"
PACKAGE "D"
.420 (10.67)
16x.075 (1.91)
16
15
14
13
12
11
10
.270 (6.86)
10
7x.050 (1.27)
9
1
P PM-SFXXX
M YYWW
2
3
5
4
.350 (8.89)
6
7
8
8
9
1
2
0.285
(7.24)
MAX
0.500
(12.70)
MAX
8
7
6
3
4
0.050
(1.27)
TYP
0.350
(8.89)
.015
(0.38)
5
0.030
(0.76)
0.375 (9.53)
0.350 (8.89)
0.020
(0.05)
TYP
0.0 30
(0 .7 6 )
TY P
0.6 00
(1 5 .2 4 )
5
0.5 30
(1 3 .4 6 )
PACKAGE "F"
0.400
(10.16)
MAX
8
PIN #1
I.D.
DOT
DENOTES
PIN #1
.275
(7.00)
.018
(.457)
.250
(6.35)
TYP
.100
(2.54)
TYP
0.060
(1.52)
TYP
Specifications subject to change without notice.
0.550
(13.97)
TYP
0.100
(0.254)
.010
(0.25)
TYP
5
P PM-SFXXX
M YYWW
3
0.310
(7.87)
MAX
0.020
(0.51)
TYP
0.7 20
(1 8 .2 8 )
M AX
0.1 00
(2 .5 4 )
TY P
4
2
10
0.3 90
(9 .9 1 )
M AX
P PM-SFXXX
M YYWW
1
0.100
x8
(2.54)
0.400
(10.16)
0.5 50
(1 3 .9 7 )
M AX
PACKAGE "E"
6
1
0.050 x 8
(1.27)
0.215
(5.46)
MAX
.019
(0.48)
TYP
0.760
(19.30)
0.520
(13.20)
0.240 x 8
(6.09)
P PM-SFXXX
M YYWW
P IN # 1
DOT
1
9
16
16x.025 (.64)
PIN #1
I.D.
3x 0.100 (2.54)
8
8x 0.050 (1.27)
.250
(6.35)
MAX
.019
(0.48)
TYP
0.640
(16.25)
0.400
(10.16)
8x 0.24 (6.09)
P PM-SFXXX
M YYWW
DOT
DENOTES
PIN #1
1
7
4
1
.098
(2.5)
MAX
0.472
(11.98)
TYP
0.400
(10.16)
.025 (0.63)
0.300
(7.62)
.012 (.30) TYP
pm-sfxxx 10/02
20381 BARENTS SEA CIRCLE, LAKE FOREST, CA 92630 • TEL: (949) 452-0511 • FAX: (949) 452-0512 • http://www.premiermag.com
70
SIGNAL LINE FILTERS
COMMON MODE CHOKES
SCHEMATIC
#1
#2
#3
#4
6
4
6
5
4
8
7
6
5
16
15
14
13
12
11
10
9
1
3
1
2
3
1
2
3
4
1
2
3
4
5
6
7
8
#5
#6
#7
8
7
6
5
10
9
8
7
6
16
15
14
13
12
11
10
9
1
2
3
4
1
2
3
4
5
1
2
3
4
5
6
7
8
#9
#8
16
15
14
13
12
11
10
9
16
15
14
13
12
11
10
9
1
2
3
4
5
6
7
8
1
2
3
4
5
6
7
8
pm-sfxxx10/02
Specifications subject to change without notice.
20381 BARENTS SEA CIRCLE, LAKE FOREST, CA 92630 • TEL: (949) 452-0511 • FAX: (949) 452-0512 • http://www.premiermag.com
71
FCC PART68 VOICE/DATA COUPLING
TRANSFORMERS
FEATURES:
Ê Designed to Meet FCC Part 68
Ë Designed for V.29, V.32, V.32 Bis & V.Fast Apps.
Ì Low Profile Thru-Hole Packages
¹ 1250, 1500 & 3000Vrms Isolation Voltages Available
GENERAL SPECIFICATIONS:
Turns Ratio (Pri:Sec) .................... 1:1 + 2%
Longitudinal Balance:
60 to 1000 Hz ...................... 60 dB Min.
1000 to 4000 Hz ...................... 40 dB Min.
MC26/27 200 to 4000Hz ............ 60 dB Typ.
ELECTRICAL SPECIFICATIONS AT 25OC - OPERATING TEMPERATURE RANGE 0OC TO 70OC
PM-MC01
PM-MC04
PM-MC02
PM-MC03
PM-MC05(1 )
PM-MC21
PM-MC26(2)
PM-MC27(2)
NOTE:
Pri = 600 Ω Ins. Loss
DCR
Ω +10%) with Load @ 1KHz
(Ω
Ω)
(dB Max.)
of (Ω
Pri
Sec
Primary
Package/ DC Current
Schematic (mA Max)
PART
NUMBER
1/A
1/A
1/A
1/A
1/A
2/B
3/C
4/D
100
100
0
0
0
0
0
0
108
108
108
150
164
67
68
68
120
120
120
150
168
85
85
85
470
470
374
301
301
487
475
475
2.5
2.5
2.5
3.0
3.2
1.50
1.25
1.25
Harm Dist
@ 300Hz
(% Typ.)
Ret Loss Frequency Response
(+dB)
@ 1800Hz
HI-POT
(dB Min.) 300-600Hz 600-3500 Vrms
0.5
0.5
0.5
0.5
0.5
0.5
0.5
0.5
13.0
13.0
25.0
25.0
20.0
15.0
26.0
26.0
2.5
2.5
0.25
0.25
0.25
0.50
0.25
0.25
1.0
1.0
0.25
0.25
0.25
0.50
0.25
0.25
1500
3000
1500
1500
1875
1500
1250
1250
(1) DESIGNED TO MEET SUPPLEMENTARY INSULATION REQUIREMENTS FOR A PRIMARY CIRCUIT AS DEFINED BY IEC-950, EN60950, UL1950/CSA950
(2) PRIMARY INDUCTANCE = 700mH MINIMUM
PACKAGE " 1 "
RECOMMENDED PCB LAYOUT
TOP VIEW
1.6 DIA
(0.062)
2
4
1
.448
(11.4)
14.0
(.550)
.025 (0.64)
SQUARE
2
P PM-MCXX
M YYWW
3
3
4
SCHEMATIC " A "
.473 (12.0)
MAX
TOP VIEW
.945
(24.0)
MAX
4
1
SEC
PRI
NOTCH
1.03
(26.0)
MAX
3
2
1
.157 (4.0)
TYP
SCHEMATIC " B "
PACKAGE " 2 "
PIN #1 DO T
6.00
(.236)
2
3
4
P PM-MC21
M YYWW
1
6.0
(.24)
6.30
(.248)
M AX
8
2
0.70
(.028)
2.0
(.079)
TYP
5
CO RE
TAPED -or- CLAM PED
SEC
PRI
7
6
8
3
5
RECOMMENDED PCB LAYOUT
12.0
(.473)
M AX
11.0 (.433)
8x0.6 (.024)
1
4.5
(.18)
8
3x2.0 (.079)
8x0.8 (.031)
9.2
(.362)
11.0
(.433)
4
12.0 (.472)
12.4 (.488)
5
pmmc 06/04
Specifications subject to change without notice.
20381 BARENTS SEA CIRCLE, LAKE FOREST, CA 92630 • TEL: (949) 452-0511 • FAX: (949) 452-0512 • http://www.premiermag.com
72
FCC PART68 VOICE/DATA COUPLING
TRANSFORMERS
SCHEMATIC " C "
PACKAGE " 3 "
4
5
6
3
2
PRI (CT)
PIN #1
DOT
1
.410
(10.41)
MAX
3
4
2
5
1
6
SEC (CT)
P PM-MC26
M YYWW
.360
(9.14)
MAX
CORE
CLAMP
.400
(10.16)
MAX
.118
(3.00)
TYP
.024
SQ.
.098
(2.49)
3
2
.197
(5.00)
1
.197
(5.00)
4
5
6
SCHEMATIC " D "
PACKAGE " 4 "
5
4
P PM-MC27
M YYWW
PIN
#1
(Dot)
1
2
6
2
5
3
4
3
.335
(8.51)
MAX
.394
(10.01)
MAX
CORE
TAPED
RECOMMENDED PCB LAYOUT
.075
(1.91)
.375
(9.53)
MAX
.010
(0.25)
.050
(1.27)
.024
(0.6)
1
SEC (CT)
PRI (CT)
6
.100
(2.54)
.375
(9.53)
.100
(2.54)
.492 (12.5)
.508 (12.9)
pmmc 06/04
Specifications subject to change without notice.
20381 BARENTS SEA CIRCLE, LAKE FOREST, CA 92630 • TEL: (949) 452-0511 • FAX: (949) 452-0512 • http://www.premiermag.com
73
FCC PART68 VOICE/DATA COUPLING
TRANSFORMERS
FEATURES:
Ê Designed to Meet FCC Part 68
Ë Developed for PCMCIA Type II Card
Ì For 56.6kbps Technologies
¹ Designed for V.29, V.32, V.32, V.90 Bis & V.Fast Apps.
GENERAL SPECIFICATIONS:
Turns Ratio (Pri:Sec) ....................... 1:1 + 2%
Longitudinal Balance:
MC10
200 to 1000 Hz ............. 40 dB Min.
1000 to 4000 Hz ............. 60 dB Min.
MC60
200 to 1000 Hz ............. 60 dB Min.
1000 to 4000 Hz ............. 40 dB Min.
ELECTRICAL SPECIFICATIONS AT 25OC - OPERATING TEMPERATURE RANGE 0OC TO 70OC
PART
NUMBER
Pri = 600 Ω Ins. Loss Harm Dist
Primary
DCR
Package/ DC Current (Ω
Ω +10%) with Load
@ 1KHz @ 600Hz
Schematic (mA Max) Pri
Ω)
of (Ω
Sec
(dB Max.) (db MAX)
PM-MC10
PM-MC60
5/E
6/F
0
0
155 145
108 120
297
374
3.5
2+ .25
-82
-82
Ret Loss Frequency Response
@ 1800Hz
(+dB)
HI-POT
(dB Min.)
200Hz - 4000Hz
Vrms
14.0
15.0
0.20
0.25
SCHEMATIC " E "
PACKAGE " 5 "
16.31
(.642)
MAX
6
1
5.05
(.200)
3
4
8.51
(.335)
MAX
1650
1500
PM-MCXX
YYWW
PRI
SEC
4
3
1
20.88
(.822)
4.4
(.174)
MAX
6
1.2
(.047)
2.4
(.095)
SCHEMATIC " F "
PACKAGE " 6 "
19.8
(.78)
MAX
11.9
(.47)
MAX
1
3
1
3
5
4
PRI
SEC
3
30.7
(1.21)
MAX
4
1
20.32
(.800)
MAX
P PM-MC60
M YYWW
6
PART IS 100% REVERSIBLE
I.E. IT CAN BE INSERTED INTO THE
PCB EITHER WAY
6
6
5.08
(.200)
5
4
pmmc 06/04
Specifications subject to change without notice.
20381 BARENTS SEA CIRCLE, LAKE FOREST, CA 92630 • TEL: (949) 452-0511 • FAX: (949) 452-0512 • http://www.premiermag.com
74
WIDEBAND RF
PULSE COUPLING
TRANSFORMERS
Ê Designed for use in 50 Ω WideBand R.F. and Fast Rise Time Applications
Ë Impedance Levels from 12.5 to 800 Ohms
Í Frequency Range 10 KHz to 500 MHz
Ì Low Insertion Loss, 500Vrms Isolation
Î 6-Pin DIP & Gull Wing Packages
ELECTRICAL SPECIFICATIONS AT 25OC - OPERATING TEMPERATURE RANGE -40OC TO +85OC
TURNS
RATIO
(± 5%)
PRIMARY
Inductance
µH Min.)
(µ
PM-WT01
PM-WT02
PM-WT03
PM-WT04
PM-WT05
PM-WT06
1:1
1:2
1:4
1:1ct
1:2ct
1:4ct
80
40
20
80
40
20
2.50
2.00
1.25
2.50
2.00
1.25
2.20
3.00
6.00
3.00
3.00
6.00
12
15
10
15
15
10
0.15
0.14
0.10
0.18
0.14
0.10
0.20
0.20
0.20
0.20
0.20
0.20
0.20
0.30
0.60
0.20
0.30
0.60
0.05
0.10
0.20
0.05
0.10
0.20
110
110
60
90
110
60
B
B
B
E
E
E
PM-WT07
PM-WT08
1ct:1ct
1ct:2ct
80
40
2.50
2.00
3.00
3.00
15
15
0.18
0.14
0.20
0.20
0.20
0.30
0.05
0.10
90
110
C
C
PM-WT09
PM-WT10
1:1:1
1ct:1ct
40
800
2.00
4.00
2.00
6.00
12
20
0.10
0.30
0.20
0.26
0.20
0.26
0.10
0.005
150
100
A
C
PART
NUMBER
ET
Rise PRI-SEC PRI / SEC
PRI
SEC
-3dB Bandwidth
Schµsec Time
Cw/w
LL
DCR
DCR
MHz
V-µ
(Min.) ns Max (pf Max.) (µ
µH Max.) (Ω
Ω Max.) (Ω
Ω Max.) Low
High matic
VARIATIONS AVAILABLE. FOR INTERMEDIATE VALUES AND/
OR CUSTOM DESIGNS PLEASE CONSULT THE FACTORY.
THRU-HOLE OR SURFACE MOUNT:
Table Part Numbers are THRU-HOLE
Change the "T" to "G" for SURFACE MOUNT.
Example:
PM-WT01 = THRU-HOLE
PM-WG01 = SURFACE MOUNT
MECHANICAL
.310
(7.87)
MAX
THRU-HOLE PACKAGE
PM-WTXX
.280
SURFACE MOUNT PACKAGE
PM-WGXX
.310
.280
(7.11)
MAX
(7.87)
MAX
.210
(5.33)
MAX
.020
(0.51)
TYP
.210
(5.33)
MAX
.008R
(0.20)
.120 .020 (.51)
(3.05) .010 (.25)
MIN
.050
(1.27)
TYP
(7.11)
MAX
.010
(0.25)
.300
(7.62)
.100
(2.54)
TYP
.050
(1.27)
TYP
.100
(2.54)
TYP
.020
(0.51)
TYP
.340
(8.64)
.008R
(0.20)
.030 (0.76)
FLAT
.020 (0.51)
.425 (10.80)
.390 (9.90)
.020 (.51)
.010 (.25)
.010
(0.25)
TYP
SCHEMATICS
SCHEMATIC "A"
5
4
3
4
2
5
2
3
4
3
6
1
5
2
4
3
SEC.
2
1
SCHEMATIC "E"
PRIMARY
5
6
SECONDARY
1
SCHEMATIC "D"
PRI.
6
SEC.
PRIMARY
1
PRI.
3
SECONDARY
6
PRIMARY
2
TERTIARY
SCHEMATIC "C"
SECONDARY
1
SCHEMATIC "B"
6
5
4
pm-wt&wg 08/99
Specifications subject to change without notice.
20381 BARENTS SEA CIRCLE, LAKE FOREST, CA 92630 • TEL: (949) 452-0511 • FAX: (949) 452-0512 • http://www.premiermag.com
75
FIBRE CHANNEL
COUPLING TRANSFORMERS
Ê Optimized for Copper Media Applications of Fast Ethernet & FDDI
Ë For use in 150 Ω or 75 Ω Systems to ANSI X3T9.5
Ì Frequency Range 2 MHz to 450 MHz
Í 2000Vrms Isolation (Hi-Pot)
ELECTRICAL SPECIFICATIONS AT 25OC - OPERATING TEMPERATURE RANGE -40OC TO +85OC
PM-WT75
PM-WT76
PM-WT150
PM-WT20
PM-WT30
Baud
Rate
(MHz)
CABLE
MEDIA
TYPE
PART
NUMBER
75Ω/150Ω
75Ω/150Ω
150Ω STP
75Ω Coax
150Ω STP
266+
266+
266
133
133
PRIMARY*
Inductance
µH Typ.)
(µ
7.0
7.0
15.0
30.0
60.0
PRI-SEC PRI / SEC PRI/SEC
Rise
-3dB Bandwidth
Cw/w
LL
DCR
Time
MHz
µH Max.) (Ω
(pf Max.) (µ
Ω Max.) (ns Max.) Low Max. High Typ.
TURNS
RATIO
(± 5%)
1:1
1ct:1ct
1:1
1:1
1:1
2.5
2.5
2.5
4.0
5.5
0.08
0.08
0.08
0.10
0.10
0.15
0.15
0.15
0.20
0.20
0.50
0.50
0.80
1.50
2.00
2.5
2.5
2.0
0.5
0.5
410
350
410
250
200
APPLICATION NOTE:
The PM-WT75 & PM-WT150 versions have been optimized for use with 8B/10B code and NRZ modulation as
used in HOTLinkTM for communication. One of the main advantages of 8B/10B code is the elimination of
baseline wander concerns (DC bias). Methods of encoding that are not DC balanced, such as FDDI 4B/5B
require a compromise in the magnetics design as more turns (higher inductances) are necessary to combat
the DC imbalance. Thus the major design consideration for 8B/10B code was to provide sufficient high end
bandwidth to allow passage of at least the 3rd hamonic. In a system operating at a 266 MHz baud rate this 3rd
harmonic is at 399MHz. The PM-WT75 should be used for both 75Ω & 150Ω applications using 8B/10B coding
@ > 266MHz Baud Rates.
HOTLinkTM is a Trade Mark of CYPRESS SEMICONDUCTOR Inc.
CY7B923 HOTLinkTM Transmitter & CY7B933 HOTLinkTM Receiver.
SCHEMATIC
MECHANICAL
PM-WT75,150,20,30
"G1" PACKAGE
16
16 15 14 13 12 11 10 9
P PM-WTXX
M YYWW
14
13
12
11
9
10
15
16
14
13
12
11
SECONDARY
SECONDARY
SEC.
SEC.
PRIMARY
PRIMARY
PRI.
PRI.
2
3
4
5
6
7
1
8
2
3
4
5
10
9
7
8
6
FIGURE 3: RECOMMENDED PCB LAYOUT
1
2
3
4
5
6
7
8
7x.050 (1.27)
.460
(11.68)
MAX
.280
(7.11)
MAX
.210
(5.33)
MAX
.050
.019 (1.27)
(0.48) TYP
TYP
.010 (.25)
.004 (.10)
16
9
1
8
.270 (6.86)
PIN#1
WHITE DOT
1
15
PM-WT76
.020 (0.51) MIN
.370 (9.40)
Specifications subject to change without notice.
.010
(0.25)
TYP
16x.075 (1.91)
16x.025 (.64)
pm-wt&wg 08/99
20381 BARENTS SEA CIRCLE, LAKE FOREST, CA 92630 • TEL: (949) 452-0511 • FAX: (949) 452-0512 • http://www.premiermag.com
76
PM-CIXX
CURRENT SENSE
INDUCTORS
Ê Designed for Switch Mode Power Supply Applications
Ë Frequency Range from 10KHz to 200KHz
Ì Fully Encapsulated Construction
Í Tapped and Untapped Versions
Î 2500Vrms Minimum Isolation Voltage
Ï Center Hole for Primary Lead
ELECTRICAL SPECIFICATIONS AT 25OC - OPERATING TEMPERATURE RANGE -40OC TO +80OC
CONTROL VALUES
PART
NUMBER
REFERENCE VALUES
CALC. VALUES
INDUCTANCE
DCR
TURNS
LS
RS
IPK
RT
KV
DROOP
NS + 1%
(mH Min.)
(Ohms Max.) (Amps) (Ohms) (Volt/Amp)
(%)
PM-CI01
PM-CI02*
50
100
PM-CI03
PM-CI04
PM-CI05
PM-CI06
PM-CI07
PM-CI08
200
300
50ct
100ct
200ct
300ct
FLUX
FACTOR
KB
LOSS
FACTOR
KL
SCHEMATIC
5.0
20.0
0.70
1.40
35
50
15
50
0.30
0.50
2.4
2.0
273.97x103 3.31x10-9
68.49x103 3.33x10-9
A
A
80.0
180.0
5.0
20.0
80.0
180.0
4.50
9.00
0.70
1.40
4.50
9.00
50
75
35
50
50
75
200
300
15
50
200
300
1.00
1.00
0.30
0.50
1.00
1.00
2.0
1.4
2.4
2.0
2.0
1.4
17.12x103
7.61x103
273.97x103
68.49x103
17.12x103
7.61x103
A
A
B
B
B
B
3.35x10-9
3.37x10-9
3.31x10-9
3.33x10-9
3.35x10-9
3.37x10-9
NOTE: * PM-CI02* TRIM THE PIN LENGTH = 0.12" - 0.15" PER CUSTOMER PO ONLY.
REFER TO CALCULATION EXAMPLE FOR PM-CIXX SERIES ON PAGE 2 OF THIS DATA SHEET.
1) REFERENCE VALUES ARE FOR UNIPOLAR OPERATION @ 50KHz, 40% DUTY CYCLE (Dmax = .40).
2) THE MAXIMUM USABLE PEAK SENSE CURRENT (I pk) IS DEPENDENT ON CORE SATURATION FACTORS AND SHOULD BE
EVALUATED FOR THE ACTUAL OPERATING CONDITIONS. SEE APPLICATION DATA AND EXAMPLE ON PAGE 78.
3) THE MAXIMUM RECOMMENDED OPERATING FLUX DENSITY (BOP) @ AN OPERATING TEMPERATURE OF 105OC IS 2000 GAUSS.
4) THE TERM. RESISTOR (Rt) CAN BE VARIED TO ADJUST THE OPERATING FLUX DENSITY (BOP), DROOP, AND SCALE FACTOR (KV).
5) THE SCALE FACTOR (KV) IS PROPORTIONAL TO THE TERMINATING RESISTOR (RT) AND IS EQUAL TO 1VOLT/AMP WHEN RT = NS
6) SECONDARY INDUCTANCE IS MEASURED AT 20KHz, 1.0VRMS.
MECHANICAL
SCHEMATIC
SCHEMATIC "A"
1
.410
(10.4)
MAX
.35
(8.8)
3
SCHEMATIC "B"
.838
(21.3)
MAX
P
M
PM-CIXX
YYWW
1
1
2
.180 DIA.
(4.57) MIN
2
3
∅
.040
(1.02)
LEAD 2 PRESENT
ON CENTER TAPPED
VERSION ONLY
ARROW INDICATES
CURRENT FLOW
PIN#1 IN PHASE
.500
(12.70)
.030
(.762)
.250
(6.35)
3
.19
(4.8)
3
pmci 4/97
Specifications subject to change without notice.
20381 BARENTS SEA CIRCLE, LAKE FOREST, CA 92630 • TEL: (949) 452-0511 • FAX: (949) 452-0512 • http://www.premiermag.com
77
PM-CIXX
CURRENT SENSE
INDUCTORS
APPLICATION EXAMPLE
APPLICATION EXAMPLE
GIVEN:
Part# = PM-CI02
Peak Current (IPK) = 30.0 Amps
Terminating Resistor (RT) = 100 Ohms
Operating Frequency (f) = 100KHz
Duty Cycle (Dmax) = .40 (40% on time)
CALCULATE THE SCALE FACTOR
From the Table the Secondary Turns are:
NS = 100
THEN:
KV = RT / NS
= 100 / 100
= 1 volt/amp
CALCULATE OPERATING FLUX DENSISTY
From the Table the FLUX FACTOR is:
KB = 68.49 x 103
Flux Utilization Constant (KF) is:
1.0 For Unipolar Operation
2.0 For Bipolar Operation
THEN:
BOP = KB x IPK x RT x (Dmax / KF x f)
= 68.49x103 x 30 x 100 x (.4 / 1 x 100x103)
= 822 gauss (OK less than 2000 gauss)
ESTIMATE ERROR DUE TO LOSSES
From the Table the Secondary DCR is:
RS = 1.40 Ohms Maximum
From the Table the approximate Loss Factor is:
KL = 3.33 x 10-9
Note: The loss factor (KL) is valid approximation
from10KHz to 200KHz
Secondary Copper Losses are:
P_lossS = (IPK / NS )2 x RS
= (30/100)2 x 1.40
CALCULATE PULSE DROOP
= 0.126 Watt
From the Table the Secondary Inductance is:
LS = 20mHy Minimum
Core losses are:
P_lossC = KL2 x f1.621 x BOP2.569
Note: The actual droop is dependent on the actual LS
in the circuits enviorment.
= (3.33x10-9)2 x (100x103)1.621 x 8222.569
Droop Exponent (D) = RT x Dmax / (LS x f)
= 100 x .4 / (20x10-3 x 100x103)
= 0.020
= 0.0435 Watt
Output Power is:
P_outS
= (30/100)2 x 100
THEN:
%_Droop = (1-e-D) x 100
= 1.98 %
OK less than 10%
(Depending on the application
Droop to 20% may be acceptable)
= (IPK / NS )2 x RT
= 9.00 Watt
THEN:
%_Error
= [(P_lossS + P_lossC ) / P_out] x 100
= [(.126 + .0435) / 9] x 100
= 1.88 %
Specifications subject to change without notice.
pmci 4/97
20381 BARENTS SEA CIRCLE, LAKE FOREST, CA 92630 • TEL: (949) 452-0511 • FAX: (949) 452-0512 • http://www.premiermag.com
78
PM-CSXX
CURRENT SENSE
TRANSFORMERS
Ê Designed for Switch Mode Power Supply Applications
Ë Frequency Range from 10KHz to 200KHz
Ì Fully Encapsulated Construction
Í Tapped and Untapped Versions
Î 2500Vrms Minimum Isolation Voltage
Ï Primary Lead Included
ELECTRICAL SPECIFICATIONS AT 25OC - OPERATING TEMPERATURE RANGE -40OC TO +80OC
CONTROL VALUES
PART
NUMBER
REFERENCE VALUES
INDUCTANCE
DCR
TURNS
LS
RS
IPK
RT
KV
DROOP
NS + 1%
(mH Min.)
(Ohms Max.) (Amps) (Ohms) (Volt/Amp)
(%)
CALC. VALUES
FLUX
FACTOR
KB
LOSS
FACTOR
KL
SCHEMATIC
PM-CS01
PM-CS02
PM-CS03
PM-CS04
50
100
200
300
5.0
20.0
80.0
180.0
0.70
1.40
4.50
11.00
35
50
50
75
15
50
200
300
0.30
0.50
1.00
1.00
2.4
2.0
2.0
1.4
273.97x103
68.49x103
17.12x103
7.61x103
3.31x10-9
3.33x10-9
3.35x10-9
3.37x10-9
A
A
A
A
PM-CS05
PM-CS06
PM-CS07
PM-CS08
50ct
100ct
200ct
300ct
5.0
20.0
80.0
180.0
0.50
1.00
2.00
3.00
35
50
50
75
15
50
200
300
0.30
0.50
1.00
1.00
2.4
2.0
2.0
1.4
273.97x103
68.49x103
17.12x103
7.61x103
3.31x10-9
3.33x10-9
3.35x10-9
3.37x10-9
B
B
B
B
REFER TO CALCULATION EXAMPLE FOR PM-CSXX SERIES ON PAGE 2 OF THIS DATA SHEET.
1) REFERENCE VALUES ARE FOR UNIPOLAR OPERATION @ 50KHz, 40% DUTY CYCLE (Dmax = .40).
2) THE MAXIMUM USABLE PEAK SENSE CURRENT (Ipk) IS DEPENDENT ON CORE SATURATION FACTORS AND SHOULD BE
EVALUATED FOR THE ACTUAL OPERATING CONDITIONS. SEE APPLICATION DATA AND EXAMPLE ON PAGE 80.
3) THE MAXIMUM RECOMMENDED OPERATING FLUX DENSITY (BOP) @ AN OPERATING TEMPERATURE OF 105OC IS 2000 GAUSS.
4) THE TERM. RESISTOR (Rt) CAN BE VARIED TO ADJUST THE OPERATING FLUX DENSITY (BOP), DROOP, AND SCALE FACTOR (KV).
5) THE SCALE FACTOR (KV) IS PROPORTIONAL TO THE TERMINATING RESISTOR (RT) AND IS EQUAL TO 1VOLT/AMP WHEN RT = NS
6) SECONDARY INDUCTANCE IS MEASURED AT 20KHz, 1.0VRMS.
MECHANICAL
SCHEMATIC
SCHEMATIC "A"
WHITE DOT
DENOTES PIN #1
1
1
3
1 TURN
PRIMARY
2
4
P PM-CSXX
M YYWW
2
3
4
5
.900
(22.86)
MAX.
5
.700
(17.78)
MAX.
UNUSED PINS MAY BE OMITTED
SCHEMATIC "B"
.700
(17.78)
MAX.
WHITE DOT
DENOTES PIN #1
1
3
1 TURN
PRIMARY
2
4
5
PINS 1 & 2
.052
∅ (1.3)
2
5
.700
(17.78)
TYP.
Specifications subject to change without notice.
.150
(3.81)
MIN.
PINS 3 - 5
.032
∅ (0.8)
.250
(6.35)
TYP.
.250
(6.35)
TYP.
pmcs 5/99
20381 BARENTS SEA CIRCLE, LAKE FOREST, CA 92630 • TEL: (949) 452-0511 • FAX: (949) 452-0512 • http://www.premiermag.com
79
SWITCH MODE DC/DC
POWER CONVERSION
TRANSFORMERS
Ê Designed for use with Leading Controller Chips
Ë Provides DC/DC Conversion & Isolation
Ì Design Engineering Support Available
Í Multiple Configurations
GENERAL APPLICATION INFORMATION
Premier Magnetics' Switch Mode Output transformers have been designed for use with the most popular current-mode
switching regulators such as Linear Technologies LT1X7X & National Semiconductors LM25XX series of High Efficiency
Switching Regulators. These output transformers have been optimized to provide maximum power throughput in the
smallest packages currently available. This combination of components finds wide use in Distributed Power Systems
where a main dc voltage bus is converted for use on or near the circuits being served.
These types of switching regulators provide a very simple solution to power conversion designs. The inductor or
transformer used are critical to the overall performance of the converter and typically define the overall efficiency,
output power and physical size.
The following tables of transformers were designed for use in the Flyback Buck-Boost circuit configuration. This
conversion topology allows the output voltage to be regulated higher or lower than the input voltage. It can also
provide isolated or non-isolated multiple outputs. Typical efficiency of this topology is 75%.
Below is a typical application circuit utilizing Linear Technologies LT1X7X switching regulator in the flyback buck-boost
configuration. The use of Premiers VTP-01XXX or VTK-01XXX optional output filter choke will drastically reduce output
ripple and noise. The component values listed are intended for reference purposes only. The Output Filter(s), Damper
Network & Foldback Current Limiting Network are optional depending on the specific application.
General Component Values:
R3 = 1.0K 1/8W
D1 = MBRXXX, Schottky Rectifier
C3 = 2.2uF Film
D2 = MBRXXX, Schottky Rectifier
R4 = 1.5K 1W Snubber
D3 = MBRXXX, Schottky Rectifier
C4 = .47uF Film
C1 = Electrolytic
R5 = 2.0K 1W
C7 = Electrolytic
C5 = 0.1uF Ceramic
R6 = 1% Metal Film as needed.
L1 = 10uHy @ Rated DC amps (VTP-XXXX)
C6 = 1000uF Electrolytic
L2 = 10uHy @ Rated DC amps (VTP-XXXX)
C8 = 1000uF Electrolytic
Np:Ns2
R1 = 1% Metal Film, For 5Vdc = 3.0K, For 9Vdc = 9.09K
R1 = [Vout-Vref/Vref] * R2, where Vref = 1.244 for LT1X7X series
R2 = 1% Metal Film, For 5Vdc = 1.0K, For 9Vdc = 1.5K
C2 = Input Bypass Capacitor 100uF Electrolytic
SCHEMATIC
OUTPUT FILTER
D3
+Vout2
L2
C7
+
C8
+
Isolated Output
-Vout2
FLYBACK Buck-Boost CONVERTER USING LT1X7X
RC Snubber
Damper
+Vin
T1
R4
D2
GND
Vc
Np:Ns1
FB
C3
+
R1
Vsw
R3
C6
R6
Foldback
Current Limiting
* *
E1 E2
+
1N914
+
Linear Technology
LT-1X70 = 5A
LT-1X71 = 2.5A
LT-1X72 = 1.25A
LT-107X = 40KHz
LT-117X = 100KHz
C1
C5
Frequency
Compensation
Vin
+Vout1
L1
C4
R5
C2
OUTPUT FILTER
D1
R2
pmsm 6/97
Specifications subject to change without notice.
20381 BARENTS SEA CIRCLE, LAKE FOREST, CA 92630 • TEL: (949) 452-0511 • FAX: (949) 452-0512 • http://www.premiermag.com
80
SWITCH MODE DC/DC
POWER CONVERSION
TRANSFORMERS
GENERAL ELECTRICAL SPECIFICATIONS AT 25OC - OPERATING TEMPERATURE RANGE 0OC TO +70OC
To receive complete specifications & application information, request the respective part number data sheet.
PART
NUMBER
Designed For
Use With
APPLICATION
PRIMARY HI-POT
Vin
Vout
Io_max OCL µHY
Vdc
(Vdc)
(Vdc)
(mA)
Typ.
Min.
PM-SM02
PM-SM03
PM-SM04
PM-SM05
PM-SM07
PM-SM09
LT1071
LT1071
LT1071
LT1071
LT1070
LT1070
12.0
12.0
24.0
24.0
12.0
12.0
TSD-546
Output #2
LT1072
12.0
------
TSD-578
LT1072
Output #2
Output #3 = Tap off #2
PCB
Mount
Method
1000
1000
2000
2000
2000
4000
140
110
200
200
50
135
550
550
550
550
550
250
20
35
40
40
40
50
Feed Back Output
THRU
Feed Back Output
THRU
Feed Back Output
THRU
Feed Back Output
THRU
Feed Back Output
THRU
Feed Back Output
THRU
5.0
9.0
220
160
250
-----
550
550
15
-----
Feed Back Output
Isolated Output
THRU
24.0
-----------
5.0
5.0
6.0
100
200
32
1000
---------
500
500
-----
15
---------
Isolated Output #1
Isolated Output #2
Tap Output off #2
THRU
TSD-648
LT1171
Outputs #2 & #3: +15.0
5.0
------
5.0
+15.0
60
+100
48
-----
750
750
15
-----
Isolated Output, Opto F.B.
Isolated + Linear Reg.
SMD
TSD-649
18-50
15.0
700
80
N/A
15
Positive Buck
SMD
TSD-652
MAX783
Output #2 = Auxiliary
5.5-30
------
3.3
15.0
3100
220
10
-----
500
500
10
-----
Positive Buck
Auxiliary Output
SMD
TSD-723
12.0
15.0
2000
210
550
30
Isolated Output
THRU
LT1076HV
LT1070
5.0
9.0
5.0
5.0
5.0
5.0
Temp
Rise oC
General Notes
Typ.
TSD-725
LT1172
13V TAP Output
15V TAP Output
12.0
-----------
5.0
13.0
15.0
500
150
60
100
---------
550
---------
15
---------
Feed Back Output
Tap Output
Tap Output
SMD
TSD-726
LT1172
Output #2, 13V TAP
Output #3, 15V TAP
12.0
-----------
5.0
13.0
15.0
100
40
200
100
---------
100
---------
15
---------
Feed Back Output
Tap Output
Tap Output
SMD
9-33
5.0
200
1000
1000
10
Isolated Output
THRU
18-30
------
5.0
+15.0
250
+25
1000
-----
500
500
10
-----
Isolated Output
Isolated Output
SMD
TSD-727
LT1172
TSD-730
LT1172
Output #2 & #3: +15V
(TSD-933 = THRU VERSION)
TSD-643 40KHz
Full Wave C.T.
Full Brige
Dual Full Brige
DISCRETE SELF OSCILLATING PUSH-PULL CONVERTERS, DUAL SECONDARIES
12.0
-----------
24
48
+ 24
420
210
+ 210
2300
3750
3750
3750
25
Isolated Output
Isolated Output
Isolated Output
THRU
TSD-644 40KHz
Full Wave C.T.
Full Brige
Dual Full Brige
12.0
-----------
100
200
+100
50
25
+ 25
2300
3750
3750
3750
25
Isolated Output
Isolated Output
Isolated Output
THRU
TSD-645 40KHz
Full Wave C.T.
Full Brige
Dual Full Brige
52.0
-----------
100
200
+100
100
50
+ 50
6800
3750
3750
3750
25
Isolated Output
Isolated Output
Isolated Output
THRU
TSD-742 1.0KHz DC to AC
1.5-3.5 85rms
500
10
Isolated rms Output
SMD
TSD-750
Output #2
10-30
------
10
-----
Isolated Output
Isolated Output
SMD
LT1172
24.0
24.0
8 rms
50
50
31mH
610
-----
500
500
pmsm 6/97
Specifications subject to change without notice.
20381 BARENTS SEA CIRCLE, LAKE FOREST, CA 92630 • TEL: (949) 452-0511 • FAX: (949) 452-0512 • http://www.premiermag.com
81
SWITCH MODE DC/DC
POWER CONVERSION
TRANSFORMERS
GENERAL ELECTRICAL SPECIFICATIONS AT 25OC - OPERATING TEMPERATURE RANGE 0OC TO +70OC
To receive complete specifications & application information, request the respective part number data sheet.
PART
NUMBER
Designed For
Use With
PRIMARY HI-POT Temp
APPLICATION
Vin
Vout
Io_max OCL µHY
Vdc
Rise oC
Typ.
Typ.
General Notes
(Vdc)
(Vdc)
(mA)
Min.
PCB
Mount
Method
TSD-769
LT1071
Output #2
Output #3 = Auxiliary
9-32
-----------
32.0
20.0
8.0
100
100
20
410
---------
500
500
500
25
---------
Isolated Output
Isolated Output
Isolated Output
THRU
TSD-826
LT1171
Output #2
Outputs #3 & #4: +48V
7-16
-----------
5.0
-5.0
+ 48.0
500
20
+50
55
---------
500
500
500
25
---------
Feed back Output
Second Output
Isolated Outputs +48V
SMD
TSD-834
Output #2
130-260
------
+5.0
-5.0
+1000
-10
324
-----
1500
------
15
-----
Isolated Output, Opto F.B.
Isolated Output
THRU
TSD-839
LT1171
Output #2 & #3: +20Vdc
Output #4 & #5: +30Vdc
12.0
-----------
+9.0
+20.0
+30.0
+250
+80
+10
150
---------
300
-----------
15
---------
Isolated Output, Opto F.B.
Isolated Output
Isolated Output
SMD
TSD-841
Output #2
5-30V
------
-180.0
+60.0
-50
+50
45
-----
500
------
20
-----
Isolated Output, Opto F.B.
Isolated Output
THRU
TSD-849
UC2843
3.3V TAP Output
Output #2
100-280
-----------
+5.0
+3.3
-5.5
+450
+200
-100
292
---------
1500
-----------
15
---------
Isolated Output, Opto F.B.
Tap Output
Isolated Output
SMD
TSD-850
UC2843
Output #2
-24V TAP Output off #2
100-280
-----------
-48.0
-65.0
-24.0
-40
-75
-150
200
---------
1500
-----------
15
---------
Isolated Output, Opto F.B.
Isolated Output
Tap Output
SMD
TSD-851
UC2843
-28V TAP Output
120-260
------
-48.0
-28.0
-20
-200
324
-----
1500
-----
15
-----
Isolated Output, Opto F.B.
Tap Output
THRU
TSD-852
Output #2
UC2843
130-260 +12.0
------160.0
+100
-200
324
-----
1500
------
15
-----
Isolated Output, Opto F.B.
Isolated Output
THRU
TSD-878
Output #2
LT1170
24.0
------
5.0
12.0
1250
1250
68
-----
1500
------
30
-----
Isolated Output, Opto F.B.
Isolated Output
THRU
TSD-879
LT1170
24.0
+12.0
+250
150
1500
15
Isolated Output, Opto F.B.
SMD
TSD-887
LT1170
15-21
175.0
120
63.0
1000
20
Direct Feedback
THRU
TSD-906
Output #2
LM2588T
WITH REG'S
24.0
------
5.0
15.0
2500
1000
160
-----
1000
------
15
-----
Isolated Output, Opto F.B.
Iso. Linear Reg Output
THRU
TSD-913
LT1171
10-30
5.0
1200
100.0
1500
10
Isolated Output, Opto F.B.
THRU
TSD-933
LT1172
Output #2 & #3
18-30
------
5.0
+15.0
250
+25
1000
-----
500
500
10
-----
Isolated Output
Isolated Output
THRU
TSD-980
Output #2
LT1082
12-40
------
12.0
12.0
125
125
1300
-----
1500
1500
10
-----
Isolated Output
Isolated Output
THRU
TSD-989
LT1172
Output #2 & #3
8-40
------
5.0
+10.0
200
+50
100
-----
----500
10
-----
Direct Feedback Output
Isolated Output
SMD
TSD-1040
Output #1
Output #2
LT1172
8-40
-----------
5.0
12.0
20.0
200
80
80
110
---------
----250
250
10
---------
Direct Feedback Output
Isolated Output #1
Isolated Output #2
SMD
TSD-1145
LM2585-5.0 6-18
600
64.0
250
15
Direct Feedback
SMD
UC2843
LT1070
5.0
pmsm 6/97
Specifications subject to change without notice.
20381 BARENTS SEA CIRCLE, LAKE FOREST, CA 92630 • TEL: (949) 452-0511 • FAX: (949) 452-0512 • http://www.premiermag.com
82
8-PIN SMD
PUSH-PULL
TRANSFORMERS
Ê Designed to Support Maxim's MAX253
Ë 1500Vrms Minimum Isolation Voltage
Ì Designed For >125KHz, 50% Duty Cycle
Push-Pull Operation @ 1.0 Watt Output
Í Low profile 8-Pin SMD Package
Î Industry Standard Package
Ï Multiple Configurations
ELECTRICAL SPECIFICATIONS AT 25OC - OPERATING TEMPERATURE RANGE -25OC TO +80OC
PART
NUMBER
PM-SM15
PM-SM16
PM-SM17
PM-SM18
TURNS
RATIO
(Pri:Sec ± 5%)
PRIMARY
OCL
µH Min.)
(µ
1CT : 1.00
1CT : 1.38CT
1CT : 2.00CT
1CT : 0.667
150
150
150
150
Primary
Pins
1-4
1-4
1-4
1-4
PRI/SEC
HI-POT
(Vrms) GENERAL CHARACTERISTICS
TYPICAL
APPLICATION
+5V to +10V
+5V to +5V
+3.3V to +5V
+5V to +5V
1500
1500
1500
1500
Volt Doubler Driving a Regulator
Full Wave Center Tap
Full Wave Center Tap
Full Wave Bridge
MECHANICALS
TYPICAL APPLICATIONS
0.1uF
REGULATED
OUTPUT
5V @ 200mA
78L05
7
0.33uF
6
0.33uF
5
8
8
D2
MBR0520L
4
MAXIM
MAX253
3x2.0 (.079)
8x1.0 (.040)
1
3
8
D1
PM-SM15
1CT : 1
2
Vcc
10.1 (.398)
1
6
1
8x1.0 (.040)
VOLTAGE DOUBLER
+5V
RECOMMENDED P.C.B. LAYOUT
ISO
GND
MBR0520L
4
FULL WAVE CENTER TAP
+5V
5
0.1uF
7
6
5
8
MBR0520L
0.33uF
MBR0520L
FULL WAVE CENTER TAP
+3.3V
0.1uF
6
1
7
6
5
8
6
8
7
6
5
8
4
D2
3
MAXIM
MAX253
11.6 (.457)
12.0 (.472)
2
D1
PM-SM18
1CT : 0.667
1
1
Vcc
10.1
(.398)
ISO
GND
FULL WAVE BRIDGE
+5V
0.1uF
UNREGULATED
OUTPUT
5V @ 100mA
0.33uF
MBR0520L
8.10
(.319)
ISO
GND
8
D2
4
6.30
(.248)
MAX
3
MAXIM
MAX253
MBR0520L
2
CORE CLAMP
D1
PM-SM17
1CT : 2.0CT
1
Vcc
UNREGULATED
OUTPUT
5V @ 200mA
8
5
2.0
(.079)
TYP
D2
10.7
(.421)
MAX
4
4
6
0.70
(.028)
3
3
7
2
6.00
(.236)
2
1
MAXIM
MAX253
8
P PM-SMXX
M YYWW
1
D1
1
Vcc
PIN#1 I.D.
DOT
PM-SM16
1CT : 1.38CT
6
UNREGULATED
OUTPUT
5V @ 200mA
0.33uF
ISO
GND
pmsm15 7/97
Specifications subject to change without notice.
20381 BARENTS SEA CIRCLE, LAKE FOREST, CA 92630 • TEL: (949) 452-0511 • FAX: (949) 452-0512 • http://www.premiermag.com
83
LOW COST
TOROIDAL
POWER INDUCTORS
FEATURES
NOTES: Temp Rise T1 & T2 are Calculated.
Ê Powdered Iron Toroidal Construction
Ë Optimized For Use as High Frequency DC Chokes
Ì Temp Rise Data: Ripple Currents < 10% @ 100KHz
Í Low Cost Self Lead Construction
1) Ln = Nominal Ind. @ 0.0Adc
L1 = Nominal Ind. @ I1 Adc, T1 Temp Rise
L2 = Nominal Ind. @ I2 Adc, T2 Temp Rise
2) I1 Represents a 1-20% Drop in Ln
I2 Represents a 20-40% Drop in Ln
ELECTRICAL SPECIFICATIONS AT 25OC - OPERATING TEMPERATURE RANGE -25OC TO +80OC
Ln
(µ
µH)
DCR
(Ohm)
L1 @ I1
(µ
µH) (dc A)
T2
T1
L2 @ I2
(OC) (µ
(dc A) (OC)
µH)
VTP-00301
VTP-01001
VTP-02001
VTP-05001
VTP-10001
VTP-12001
VTP-25001
3
10
20
50
100
120
250
0.020
0.032
0.035
0.061
0.106
0.075
0.168
3
10
20
46
91
115
229
1
1
1
1
1
1
1
10
12
7
6
9
5
7
2.8
9
17
40
75
102
188
2
2
2
2
2
2
2
30
46
27
23
34
14
27
A
.32
.33
.46
.60
.60
.95
.93
C
.15
.24
.25
.32
.46
.53
.46
VT/B
.13
.22
.23
.30
.43
.45
.44
HT/B PIN OD
.30
.016
.31
.013
.43
.018
.57
.020
.57
.018
.90
.025
.90
.020
VTP-01002
VTP-02002
VTP-05002
VTP-07002
VTP-10002
VTP-25002
10
20
50
70
100
250
0.016
0.024
0.031
0.039
0.043
0.068
10
18
48
61
89
222
2
2
2
2
2
2
12
11
5
11
6
6
8
14
41
48
72
178
4
4
4
4
4
4
48
43
20
43
24
24
.47
.61
.95
.82
.95
1.24
.26
.27
.49
.36
.63
.71
.24
.24
.45
.31
.59
.67
.44
.58
.91
.82
.91
1.20
.022
.025
.032
.025
.032
.032
VTP-01005
VTP-02005
VTP-05005
VTP-10005
VTP-15005
VTP-20005
VTP-30005
10
20
50
100
150
200
300
0.006
0.008
0.013
0.023
0.029
0.033
0.038
10
18
47
83
122
155
241
5
5
5
5
5
5
5
6
7
7
11
9
10
14
8
14
36
61
90
109
175
10
10
10
10
10
10
10
22
27
27
44
34
39
36
1.00 .53
1.00 .67
1.29 .75
1.54 .59
1.85 .75
1.85 .75
2.18 1.00
.47
.61
.69
.53
.69
.69
.84
.93
.93
1.22
1.48
1.79
1.79
2.10
.051
.051
.051
.051
.051
.051
.051
VTP-02007
VTP-05007
VTP-10007
VTP-15007
VTP-20007
20
50
100
150
200
0.005
0.009
0.015
0.025
0.030
16
42
78
145
177
7
7
7
7
7
9
8
9
7
8
12
31
55
110
131
14
14
14
14
14
33
30
34
26
29
1.02 .70
.62
1.58 .63
.55
1.88 .78
.70
2.35 1.25 1.18
2.35 1.25 1.18
.95
1.50
1.80
2.28
2.28
.064
.064
.064
.064
.064
VTP-03408
34
0.008
26
8
16
22
12
30
1.25 0.62 0.55
1.23
.055
VTP-00510
VTP-01510
VTP-05010
VTP-25010
TSD-904
VTP-07012
VTP-01020
VTP-01025
5
15
50
250
1.4
70
11
12
10
10
10
10
11
12
20
25
12
40
12
32
25
15
30
27
4
11
32
125
1.0
54
7.5
8.7
16
14
16
14
15
16
25
30
25
50
31
50
40
23
42
33
1.03 .70
1.33 .80
1.87 .78
2.19 1.10
0.75 0.40
2.21 .98
1.45 .85
2.25 .95
.95
1.24
1.80
2.10
n/a
2.12
1.26
1.85
.064
.064
.064
.055
.051
.018
.080
.100
PART
NUMBER
0.005
5
0.004
12
0.010
40
0.027 152
0.0017 1.2
0.009
60
0.0025
8.5
0.0023
9.4
REF. DIMENSIONS IN INCHES
.65
.71
.70
.85
.27
.88
.73
.75
vtp 5/98
Specifications subject to change without notice.
20381 BARENTS SEA CIRCLE, LAKE FOREST, CA 92630 • TEL: (949) 452-0511 • FAX: (949) 452-0512 • http://www.premiermag.com
84
LOW COST
TOROIDAL
POWER INDUCTORS
VTP-XXXX MECHANICAL
HTP-XXXX MECHANICAL
SCHEMATIC
VTP-XXXXX OUTLINE
VERTICAL MOUNT
HTP-XXXXX OUTLINE
HORIZONTAL MOUNT
HORIZONTAL OR VERTICAL MOUNT:
Table Part Numbers are Vertical Mount.
Change the "V" to "H" for Horizontal Mount.
Example:
VTP-05001 = Vertical Mount 50uH, 1.0Adc
HTP-05001 = Horizontal Mount 50uH, 1.0Adc
EPOXY
HOLDS WIRE
EPOXY
HOLDS WIRE
A
C
A
P VTP-XXXXX
M
STRIPPED & TINNED
.01 TO .12 ABOVE
SEATING PLANE
C
B
P HTP-XXXXX
M
STRIPPED & TINNED
.01 TO .12 ABOVE
SEATING PLANE
0.5 TYP
0.5
TYP
B
SCHEMATIC
APPLICATION
D2
MUR610CT
VTP/HTP-XXXX
XXuH @ X.XA
Vout DC
C2
+
1000uF
35V
SECONDARY
R4
20.0K 1%
+
C3
R5
220uF
10.0K 1% 25V
RTN
FOR INTERMEDIATE VALUES OR CUSTOM DESIGNS CONSULT THE FACTORY.
vtp 5/98
Specifications subject to change without notice.
20381 BARENTS SEA CIRCLE, LAKE FOREST, CA 92630 • TEL: (949) 452-0511 • FAX: (949) 452-0512 • http://www.premiermag.com
85
SENDUST
TOROIDAL
POWER INDUCTORS
FEATURES
NOTES: Temp Rise T1 & T2 are Calculated
1) Ln = Nominal Ind. @ 0.0Adc
L1 = Nominal Ind. @ I1 Adc, T1 Temp Rise
L2 = Nominal Ind. @ I2 Adc, T2 Temp Rise
2) I1 Represents a 1-20% Drop in Ln
I2 Represents a 20-40% Drop in Ln
Ê Sendust Powdered Iron Toroidal Construction
Ë Optimized For Use as High Frequency DC Chokes
Ì Temp Rise Data: Ripple Currents < 10% @ 100KHz
Í Low Cost Self Lead Construction
Ï Lower AC Losses Than Powdered Iron
ELECTRICAL SPECIFICATIONS AT 25OC - OPERATING TEMPERATURE RANGE -25OC TO +80OC
Ln
µH)
(µ
DCR
(Ohm)
L1 @ I1
µH) (dc A)
(µ
T2
T1
L2 @ I2
(OC) (µ
(dc A) (OC)
µH)
A
VTK-01001
VTK-02001
VTK-05001
VTK-10001
VTK-15001
VTK-25001
10
20
50
100
150
250
0.024
0.030
0.054
0.102
0.091
0.171
10
18
42
82
127
210
1
1
1
1
1
1
12
9
10
12
6
9
8
13
31
57
96
154
2
2
2
2
2
2
47
36
39
46
24
33
VTK-01002
VTK-02002
VTK-05002
VTK-10002
VTK-15002
VTK-25002
10
20
50
100
150
250
0.008
0.012
0.032
0.043
0.053
0.053
9
17
37
79
117
205
2
2
2
2
2
2
6
5
17
9
8
5
7
12
22
53
80
150
4
4
4
4
4
4
VTK-01005
VTK-02005
VTK-05005
VTK-10005
VTK-15005
VTK-20005
VTK-30005
10
20
50
100
150
200
312
0.005
0.006
0.010
0.021
0.026
0.030
0.037
9
16
36
80
124
154
258
5
5
5
5
5
5
5
6
6
9
8
8
9
11
7
12
20
57
90
108
194
VTK-02007
VTK-05007
VTK-10007
VTK-15007
VTK-20007
20
50
100
150
200
0.004
0.010
0.013
0.020
0.025
18
41
78
128
168
7
7
7
7
7
5
8
8
7
8
VTK-05010
VTK-25010
50
250
0.006
0.027
40
167
10
10
VTK-07012
70
0.009
60
VTK-01025
12
0.0023
PART
NUMBER
9.4
REF. DIMENSIONS IN INCHES
C
VT/B
.31
.38
.48
.59
.76
.92
.16
.18
.21
.25
.32
.32
.14
.16
.19
.23
.30
.30
.29
.36
.46
.57
.74
.90
.014
.016
.016
.016
.020
.018
23
20
66
33
30
21
.51
.63
.60
.95
1.06
1.24
.24
.28
.26
.34
.40
.56
.21
.25
.24
.31
.36
.52
.48
.59
.58
.92
1.03
1.20
.025
.032
.0225
.0285
.0285
.032
10
10
10
10
10
10
10
22
22
36
33
30
35
32
1.00
.39
1.11
.45
1.11
.45
1.67
.57
1.85
.75
1.85
.75
2.18 1.00
.33
.39
.39
.51
.69
.69
.84
.94
1.05
1.05
1.61
1.79
1.79
2.10
.051
.051
.051
.051
.050
.051
.051
13
29
54
96
120
14
14
14
14
14
19
29
30
28
32
1.32
1.70
1.88
2.18
2.18
.63
.60
.78
.95
.95
.56
.53
.70
.86
.86
1.24
1.63
1.80
2.10
2.10
.064
.064
.064
.064
.064
7
26
33
122
16
16
18
50
1.91
.81
2.19 1.10
.72
.85
1.82
2.10
.064
.057
12
14
55
16
20
2.21
.98
.88
2.12
.080
25
26
30
32
2.25
.95
.75
1.85
.100
8.7
HT/B PIN OD
VTK 9/2000
Specifications subject to change without notice.
20381 BARENTS SEA CIRCLE, LAKE FOREST, CA 92630 • TEL: (949) 452-0511 • FAX: (949) 452-0512 • http://www.premiermag.com
86
SENDUST
TOROIDAL
POWER INDUCTORS
FEATURES
NOTES: Temp Rise T1 & T2 are Calculated
Ê Sendust Powdered Iron Toroidal Construction
Ë Optimized For Use as High Frequency DC Chokes
Ì Temp Rise Data: Ripple Currents < 10% @ 100KHz
Í Low Cost Self Lead Construction
Ï Lower AC Losses Than Powdered Iron
1) Ln = Nominal Ind. @ 0.0Adc
L1 = Nominal Ind. @ I1 Adc, T1 Temp Rise
L2 = Nominal Ind. @ I2 Adc, T2 Temp Rise
2) I1 Represents a 1-20% Drop in Ln
I2 Represents a 20-40% Drop in Ln
ELECTRICAL SPECIFICATIONS AT 25OC - OPERATING TEMPERATURE RANGE -25OC TO +80OC
PART
NUMBER
VTK-00001
VTK-00002
VTK-00003
VTK-00004
VTK-00005
VTK-00006
VTK-00007
VTK-00008
VTK-00009
Rate DCR
L1 @ I1 T1
IDC (Ohm) (µ
µH) (dc A) (OC)
Ln
µH)
(µ
10
25
50
75
100
150
200
250
330
7.37
5.20
3.95
3.50
3.15
2.35
1.98
1.85
1.70
0.010
0.020
0.035
0.045
0.055
0.100
0.140
0.160
0.190
9.0
22.5
45.0
67.5
90.0
135.0
180.0
225.0
297.0
1.7
1.00
0.70
0.60
0.50
0.40
0.35
0.30
0.27
15
15
15
15
15
15
15
15
15
T2
L2 @ I2
O
(dc
A)
(
C) A
µH)
(µ
REF. DIMENSIONS IN INCHES
C
VT/B
8.0
20.0
40.0
60.0
80.0
120.0
160.0
200
264
.16
.18
.21
.25
.32
.32
.24
.28
.26
.14
.16
.19
.23
.30
.30
.21
.25
.24
3.3
1.9
1.3
1.1
0.95
0.75
0.65
0.60
0.50
40
40
40
40
40
35
35
35
35
.31
.38
.48
.59
.76
.92
.51
.63
.60
VTK-XXXX MECHANICAL
HT/B PIN OD
.29
.36
.46
.57
.74
.90
.48
.59
.58
.036
.032
.028
.025
.025
.020
.018
.018
.018
HTK-XXXX MECHANICAL
VTK-XXXXX OUTLINE
VERTICAL MOUNT
HTK-XXXXX OUTLINE
HORIZONTAL MOUNT
SCHEMATIC
HORIZONTAL OR VERTICAL MOUNT:
Table Part Numbers are Vertical Mount.
Change the "V" to "H" for Horizontal Mount.
Example:
VTK-05001 = Vertical Mount 50uH, 1.0Adc
HTK-05001 = Horizontal Mount 50uH, 1.0Adc
EPOXY
HOLDS WIRE
EPOXY
HOLDS WIRE
A
A
C
P VTK-XXXXX
M
STRIPPED & TINNED
.01 TO .12 ABOVE
SEATING PLANE
C
B
STRIPPED & TINNED
.01 TO .12 ABOVE
SEATING PLANE
APPLICATION
0.5 TYP
D2
MUR610CT
P HTK-XXXXX
M
0.5
TYP
B
VTK/HTK-XXXX
XXuH @ X.XA
Vout DC
FOR INTERMEDIATE VALUES OR
CUSTOM DESIGNS CONSULT THE
FACTORY.
R4
20.0K 1%
C2
+
1000uF
35V
+
C3
R5
220uF
10.0K 1% 25V
SECONDARY
RTN
VTK 9/2000
Specifications subject to change without notice.
20381 BARENTS SEA CIRCLE, LAKE FOREST, CA 92630 • TEL: (949) 452-0511 • FAX: (949) 452-0512 • http://www.premiermag.com
87
OFF-LINE
SWITCH MODE
TRANSFORMERS
Indicated Parts are UL1950 & CSA-950 Recognized Under UL File# E162344
Ê Designed for use with Power Integrations IC's
Ë Designed to meet UL1950/IEC950 Safety Standards
Ì Design Engineering Support Available
Í Multiple Configurations
GENERAL APPLICATION INFORMATION
Premier Magnetics' Off-Line Switch Mode Transformers have been designed for use with Power Integrations,
Inc. TOPXXX series of three to six terminal off-line PWM switching regulators in the Flyback Buck-Boost circuit
configuration. This conversion topology can provide isolated multiple outputs with efficiencies upto 95%.
Premiers' Switching Transformers have been optimized to provide maximum power throughput.
The TOPXXX series from Power Integrations, Inc. are self contained 100KHz & 132KHz voltage controlled PWM
switching regulators. This series contains all necessary functions for an off-line switched mode control DC
power source. These switching regulators provide a very simple solution to off-line designs. The inductors and
transformer used with the PWR-TOPXXX are critical to the performance of the circuit. They define the overall
efficiency, output power and overall physical size.
Below is a universal input high precision 18V @ 0.300 Amps, 30V @0.750 Amps, & -30V @0.050Amps (30watt)
application circuit utilizing Power Integrations PWR-TOP244Y switching regulator in the flyback buck-boost
configuration. The component values listed are intended for reference purposes only. The soft start
capacitor Css is optional depending on the specific application. Simpler topology is possible depending on
the line/load regulation required.
SCHEMATIC
A LUM INUM ELECTROLYTIC FILTER C APAC ITOR RATINGS:
+30V OUTPUT: C 12 >63V, Ripp le Rated > 900m A @ 100KHz @ M a x. Op . Te mp .
PAN ASON IC: ECA 1JFG471
-30V OUTPUT: C10 >63V, Ripp le Rated > 95mA @ 100KHz @ M ax. Op. Tem p.
PAN ASON IC: ECA 1JFG100
+18V OUTPUT: C 2 >35V, Ripp le Rated > 410m A @ 100KHz @ M a x. Op . Te mp .
PAN ASON IC: ECA IVFG470
PREM IER M AGN ETICS PART NUM BERS:
(REQUEST DATA S HEETS BY PART#)
L1 = PM C U-0330 33mHy EM I/RFI CM C
T1 = POL-30208 M A IN SW ITCHING TRAN SFORM ER
L2 = VTP-01001 10uHy, 1.0Amp IN DUCTOR
BR1
DF04M
400V, 1.0A
EM I FILTER
F1
3.1A
250v
LINE
1
~
2
+
C1
63 u F
400V
C6
0.1uF
4
NEUT
HOT RAIL
+90 to 375Vdc
3
~
D5
M UR620
+
85-265Vac
50/60Hz
L1
PMCU-0330
33mHY
10
-
C6 = 0.1uF 250Vac
X2-Saftey Cap
1
VR1
P6KE200A
PROPERLY SIZED
HEAT SINK
8
SOURCE
1/2 OF U3
D2
1N 4148
4
D3
M UR420
4
R1
6.2
C2
47uF
35V
5
E
6
C7 & C8 = 250Vac
Y-SAFTEY CAPACITORS
EMI FILTER
C7
2.2nF
R3
11.0K 1%
1/2 OF U3
A
+
R4
1.0K 1%
C
2
S EC # 1
T1
POL-30208
C11
10uF
63V
-30Vdc
@ 50mA
L2
VTP-01001
10uH @ 1.0A
1
KELVIN CONNECT
CONTROL
+
L3
VTP-01001
10uH @ 1.0A
7
C4
0.1uF
3
C5
47uF
+
D4 M UR620
BIAS
+
DRAIN
C 10
10uF
63V
2
C
+/- 30V RTN
S EC # 2
PRI
D1
M UR160
(BY V26C)
U1
POWER INT.
PWR-TOP244 YAI
+30Vdc
@ 750m A
C13
100uF
63V
9
CLAMP
NETWORK
U3 N EC
PS2501-1
L4
VTP-01001 +
10uH @ 1.0A
C 12
+
470uF
63V
+18Vdc
@ 300m A
C3
47uF
35V
+
18V RTN
R2
470
S OFT
S TART
Css +
4.7uF
U2
1
C TL431
R
A
C8
2.2nF
R5
39
1/4W
C9
0.1uF
8
6
HIGH VOLTA GE RETURN
pol 10/99
Specifications subject to change without notice.
20381 BARENTS SEA CIRCLE, LAKE FOREST, CA 92630 • TEL: (949) 452-0511 • FAX: (949) 452-0512 • http://www.premiermag.com
88
OFF-LINE
SWITCH MODE
TRANSFORMERS
GENERAL ELECTRICAL SPECIFICATIONS AT 25OC - OPERATING TEMPERATURE RANGE 0OC TO +70OC
Units are Designed for a Universal AC Input of 85 to 265Vac, 47/440 Hz, Unless Otherwise designated
1 = Unit Designed for Voltage Doubler input -or- PFC Corrected Front End
2 = Unit Designed for AC Input of 85 to135Vac, 47/440Hz
3 = Minimum Parts Count Design (lowest cost). Designed for Relatively Constant Load Power
Applications Where Load Regulation of 5.0 % & Line Regulation of 3.0 % is Acceptable
4 = Faraday Shield Between Primary + Bias & Secondaries. Connected to Bias - Pin
PART
NUMBER
TSD-1684
TSD-1715
TSD-1848
TSD-1813
TSD-1687
POL-050063
TSD-816
TSD-1185
POL-050103
POL-05012
TSD-1812
POL-05020
POL-05030
TSD-1486
TSD-1952
TSD-778
TSD-1853
TSD-1962
TSD-1829
TSD-937
TSD-1201
TSD-1160
TSD-1695
TSD-1390
TSD-877
TSD-1017
TSD-1135
TSD-13054
TSD-1110
TSD-1941
TSD-1866
TSD-1869
TSD-893
TSD-876
TSD-8151
TSD-1961
TSD-1820
APPLICATION DATA
Recommended
Output Currents
Power Intgr. Output Voltages
Vout Vdc
Io_cont Amps
Controller
TOP 232
TOP 242
TOP 242
TOP 233
TOP 243
TOP 210
TOP 210
TOP 221
TOP 200
TOP 200
TOP 242
TOP 223
TOP 202
TOP 200
TOP 202
TOP 201
TOP 246
TOP 242
TOP 234
TOP 204
TOP 225
TOP 225
TOP 248
TOP 226
TOP 204
TOP 209
TOP 209
TOP 209
TOP 224
TOP 247
TOP 247
TOP 248
TOP 201
TOP 210
TOP 201
TOP 248
TOP 234
2.5/3.3/12
3.3
3.3/5
3.3/5/5
5.0
5.0
5.0
5.0
5.0
5.0
5.0
5.0
5.0
5.0
5x2
5.0 x 2
5.0 x 4
5.0/7.5/7.5
5/7/17.6/17.6/50
5/+8/-8
5/+9/-9
5/+12/-12
5/5/12/12
5/12
5x2 & 15
5/15
5/15
5/15
5/+15/-15
5/7.75/21/21/51
5/15/30
5/33
5/30/+12/-12
5/12
5/15
5/15/24
5/18
0.5/0.6/0.16
0.6
1.5/0.7
1.5/1.5/0.3
2.5
0.60
0.60
0.70
1.00
1.20
1.60
2.00
3.00
1.00
1.2/1.2
1.20/0.80
.150-7.0
0.4/0.25/0.25
1.2/.9/.3/.3/.16
3.0/+1.0
6/+1.3/-0.13
6/+1.0/-0.10
3/2/2/2
5.0/3.0
2.5/0.10
0.02/0.10
0.05/0.12
0.05/0.12
2.2/+0.3
1.4/1/.35/.35/.19
.75/.10/2.5
3.0/3.0
1.0/.05/.25/.25
0.10/0.20
1.0/1.0
1/1/4
2/0.5
Con
Watt
5.2
2.0
8.5
14.0
12.5
3.0
3.0
3.5
5.0
6.0
8.0
10.0
15.0
5.0
12.0
6.4
140.0
5.8
31.0
30.0
43.0
43.0
49.0
61.0
16.0
1.7
2.1
2.1
20.0
39.2
80.5
115.0
14.0
3.0
20.0
116.0
19.0
Recommended
Output Filter
Input Filter
Inductor (L2)
CMC (L1)
VTP-01001
VTP-01001
VTP-01001
VTP-01001
VTP-01002
VTP-01001
VTP-01001
VTP-00301
VTP-01001
VTP-01001
VTP01001
VTP-01002
VTP-01002
VTP-01001
VTP-01001
VTP-01001
VTP-01005
VTP-01001
VTP-01002
VTP-01002
VTP-01005
VTP-01005
VTP-01001
VTP-01005
VTP-01002
N/A
N/A
N/A
VTP-01002
VTP-01002
VTP-01002
VTP-01002
VTP-01001
Bead
VTP-01001
VTP-01002
VTP-01001
PMCU-0330
PMCU-0220
PMCU-0330
PMCU-0330
PMCU-0330
PMCU-0220
PMCU-0220
PMCU-0220
PMCU-0220
PMCU-0330
PMCU-0220
PMCU-0330
PMCU-0330
PMCU-0220
PMCU-0220
PMCU-0330
PMCE-0330
PMCU-0220
PMCU-0330
PMCE-0330
PMCU-0330
PMCU-0330
PMCE-0330
PMCE-0330
PMCU-0330
PMCU-0220
PMCU-0220
PMCU-0220
PMCU-0330
PMCU-0330
PMCE-0330
PMCU-0330
PMCU-0330
PMCU-0220
PMCU-0330
PMCE-0330
PMCU-0330
Package
Schematic
EE16
EE16
EE16
EEL19
E22/19
E16-Horz
E16-Horz
E16-Vert
E16-Horz
E16-Horz
EE16
E16-Vert
E22/19/6
EE16/EI16
EPC19
E22,10pin
ER35
EE16
EE30
E28/11
EI33/29
EI33/29
EE33
EI33/29
E28/11
E16-Vert
E22/19/6
E22/19/6
EEL19
EI30
EE33
EFD25
E30
E19-Horz
E22/19/6
EERL35
E20/10/6
pol 10/99
Specifications subject to change without notice.
20381 BARENTS SEA CIRCLE, LAKE FOREST, CA 92630 • TEL: (949) 452-0511 • FAX: (949) 452-0512 • http://www.premiermag.com
89
OFF-LINE
SWITCH MODE
TRANSFORMERS
GENERAL ELECTRICAL SPECIFICATIONS AT 25OC - OPERATING TEMPERATURE RANGE 0OC TO +70OC
Units are Designed for a Universal AC Input of 85 to 265Vac, 47/440 Hz, Unless Otherwise designated
1 = Unit Designed for Voltage Doubler input -or- PFC Corrected Front End
2 = Unit Designed for AC Input of 85 to135Vac, 47/440Hz
3 = Minimum Parts Count Design (lowest cost). Designed for Relatively Constant Load Power
Applications Where Load Regulation of 5.0 % & Line Regulation of 3.0 % is Acceptable
4 = Faraday Shield Between Primary + Bias & Secondaries. Connected to Bias - Pin
PART
NUMBER
TSD-1694
TSD-1753
TSD-858
TSD-1696
TSD-779
TSD-988
TSD-983
TSD-1422
TSD-979
TSD-10463
TSD-1370
TSD-11441
TSD-940
TSD-860
TSD-1347
POL-07050
POL-07003
TSD-10934
POL-07020
TSD-1024
TSD-1751
TSD-1759
TSD-1195
TSD-1740
TSD-7941
TSD-1691
TSD-1489
TSD-880
POL-97505
TSD-8132
POL-97506
TSD-8253
TSD-9353
TSD-9903
POL-12012
POL-12017
POL-15020
APPLICATION DATA
Recommended
Output Currents
Power Intgr. Output Voltages
Vout Vdc
Io_cont Amps
Controller
TOP 234
TOP 243
TOP 210
TOP 248
TOP 202
TOP 214
TOP 202
TOP 223Y
TOP 210
TOP 221
TOP 222
TOP 223
TOP 210
TOP 224
TOP 224
TOP 226
TOP 209P
TOP 209P
TOP 202
TOP 223P
TOP 249
TOP 243
TOP224
TOP 248
TOP 202
TOP 243
TOP 221Y
TOP 204
TOP 221
TOP 200
TOP 221
TOP 221P
TOP 200
TOP 222P
TOP 202
TOP 224P
TOP 226
5/20/20
5/24
5/24
5/24/48
5/33
5/28
5/33
5/-65
5.5/10
6/25
6/24
6/ -38/ -60
6.5
6.9/2x15
6.9/24/-15
7.0
7.5
7.5
7.5
7.5/15
7.5/15
7.5/24/24
8/16/16
8/13/18/18
8.5
8.6
9.0
9/24
9.75
9.75
9.75
12.0
12.0
12.0
12.0
12.0
12.0
1.3/.260/.260
0.50/0.150
0.30/0.08
0.8/0.15/0.02
1.0/0.50
1.0/0.50
1.0/0.50
1.0/0.1
0.80/0.05
0.30/0.09
0.55/0.10
1.2/0.30/.050
0.80
0.30/0.60
0.3/0.6/0.2
5.00
0.26
0.26
2.00
1.0/0.25
1.0/8
.27/.20/.04
2.0/0.25/0.25
1.5/3x1.25
4.00
1.8
0.40
3.0/0.60
0.50
0.50
0.60
0.30
0.50
0.67
1.20
1.70
2.50
Con
Watt
17.0
6.1
3.4
8.6
21.5
21.0
21.5
11.5
5.0
3.9
5.0
20.0
5.2
20.0
20.0
35.0
2.0
2.0
15.0
11.3
128.0
7.8
30.0
73.3
34.0
15.5
3.6
50.0
4.9
4.9
5.8
3.6
5.0
8.0
15.0
20.4
30.0
Recommended
Output Filter
Input Filter
Inductor (L2)
CMC (L1)
VTP-01001
VTP-01001
VTP-01001
VTP-01001
VTP-01001
VTP-01001
VTP-01001
VTP-01001
VTP-01001
VTP-00301
VTP-01001
VTP-01001
VTP-01001
VTP-01001
VTP-01001
VTP-01005
VTP-01002
VTP-01002
VTP-01002
VTP-01002
VTP-02007
VTP-01001
VTP-01001
VTP-01001
VTP-01005
VTP-01002
VTP-0100
VTP-01002
VTP-01001
Bead
Bead
VTP-01001
VTP-01001
VTP-01001
VTP-01001
VTP-01002
VTP-01002
PMCU-0330
PMCU-0220
PMCU-0220
PMCU-0330
PMCU-0100
PMCU-0100
PMCU-0100
PMCU-0330
PMCU-0220
PMCU-0220
PMCU-0220
PMCE-0330
PMCU-0220
PMCU-0330
PMCU-0330
PMCE-0330
PMCU-0330
PMCU-0330
PMCU-0330
PMCU-0330
PMCE-0330
PMCU-0220
PMCE-0330
PMCE-0330
PMCU-2220
PMCU-0330
PMCU-0220
PMCE-0330
PMCU-0330
PMCU-0220
PMCU-0220
PMCU-0220
PMCU-0220
PMCU-0220
PMCU-0330
PMCU-0220
PMCU-0330
Package
Schematic
EEL19
EE19
E19-Horz
EI28
E22/19/6
EEL22
E22/19/6
EFD30
E16-Horz
E22/19/6
E2425
E2425
E16-Horz
E28/11
E28/11
E28/11
E16-Vert
E16-Vert
E22/19/6
E22/19/6
EER35
EE16
E30
EER35
E28/11
E22/19
EE16/EI16
E30
E16-Vert
E19-Horz
E19-Horz
E16-Horz
E19-Horz
E19-Horz
E22/19/6
E25-Vert
E28/11
pol 10/99
Specifications subject to change without notice.
20381 BARENTS SEA CIRCLE, LAKE FOREST, CA 92630 • TEL: (949) 452-0511 • FAX: (949) 452-0512 • http://www.premiermag.com
90
OFF-LINE
SWITCH MODE
TRANSFORMERS
GENERAL ELECTRICAL SPECIFICATIONS AT 25OC - OPERATING TEMPERATURE RANGE 0OC TO +70OC
Units are Designed for a Universal AC Input of 85 to 265Vac, 47/440 Hz, Unless Otherwise designated
1 = Unit Designed for Voltage Doubler input -or- PFC Corrected Front End
2 = Unit Designed for AC Input of 85 to135Vac, 47/440Hz
3 = Minimum Parts Count Design (lowest cost). Designed for Relatively Constant Load Power
Applications Where Load Regulation of 5.0 % & Line Regulation of 3.0 % is Acceptable
4 = Faraday Shield Between Primary + Bias & Secondaries. Connected to Bias - Pin
PART
NUMBER
POL-15033
TSD-7622
TSD-1834
TSD-7772
TSD-1405
POL-12208
POL-12216
TSD-1943
TSD-1551
TSD-1654
TSD-1469
POL-150332
TSD-9463
TSD-1010
TSD-10033
TSD-13303
TSD-1811
TSD-7373
POL-15020
POL-15033
TSD-812
POL-150731
POL-152043
TSD-1683
TSD-860
TSD-1432
TSD-1385
TSD-8731
TSD-1035
TSD-1197
TSD-10553
TSD-1439
TSD-9683
POL-30208
TSD-1668
TSD-1752
POL-22007
TSD-9244
Recommended
APPLICATION DATA
Power Intgr.
Output Voltages
Output Currents
Controller
Vout Vdc
Io_cont Amps
TOP 226
TOP 103
TOP 247
TOP 104
TOP 224P
TOP 223
TOP 224
TOP 248
TOP 222Y
TOP 223Y
TOP 222Y
TOP 104
TOP 210
TOP 210
TOP 210
TOP 210
TOP 243
TOP 223
TOP 226
TOP 226
TOP 204
TOP 204
TOP 200
TOP 221
TOP 202
TOP 224Y
TOP 204
TOP 210
TOP 221
TOP 227
TOP 210
TOP 221Y
TOP 202
TOP 244
TOP 232
TOP 232
TOP 202
TOP 202
12.0
12.0
12
12.0
12.0
12x2
12x2
12x2
12/5/3.3/-12
12/12
13/6/3.3/-13
13.8
14.0
14.0
15.0
15.0
15.0
15.0
15.0
15.0
15.0
15.0
15x2
15.0/15.0
+15/6.9
15/-15/6.9
15/15/5
17.0
17.0
17/21/17
15V to 18V
18.0
18x2
18/+30/-30
18.0
19.0
22.0
22.0
3.00
3.40
3.75
5.00
1.70
0.50/0.30
0.80/0.80
2.5/2.5
0.1/0.2/1.5/0.1
0.30/0.50
0.1/0.2/1.5/0.1
4.00
0.20
0.43
0.20
0.20
1.0
1.00
2.00
3.33
3.33
7.33
0.20/0.20
0.20/0.18
+0.60/0.30
0.8/0.8/0.3
0.2/0.2/1.0
0.10
0.20
2.0/0.25/0.25
.300 to .350
0.2
0.40/0.40
0.30/0.75/0.5
0.40
0.45
0.70
0.70
Con
Watt
36.0
41.0
45.0
60.0
20.4
9.6
21.5
62.5
8.4
9.6
8.8
56.0
3.0
4.5
3.0
3.0
15.0
15.0
30.0
50.0
50.0
110.0
6.0
6.3
20.0
26.1
11.0
1.7
3.5
90.0
5.5
3.6
14.4
30.0
7.2
8.6
15.4
15.4
Recommended
Output Filter
Input Filter
Inductor (L2)
CMC (L1)
VTP-01002
VTP-01002
VTP-01005
VTP-01005
VTP-01002
VTP-01001
VTP-01001
VTP-01002
VTP-01001
VTP-01001
VTP-01001
VTP-01002
VTP-01001
VTP-01001
VTP-01001
VTP-01001
VTP-01001
VTP-01001
VTP-01002
VTP-01002
VTP-01002
VTP-02007
VTP-01001
VTP-01001
VTP-01001
VTP-01001
VTP-01002
Bead
Bead
VTP-01002
VTP-01001
VTP-01001
VTP-01001
VTP-01001
VTP-01001
VTP-01001
VTP-01001
VTP-01001
PMCE-0330
PMCE-0330
PMCE-0330
PMCE-0330
PMCU-0220
PMCU-0330
PMCU-0330
PMCE-0330
PMCU-0330
PMCU-0330
PMCU-0330
PMCE-0330
PMCU-0330
PMCU-0330
PMCU-0330
PMCU-0330
PMCU-0220
PMCU-0330
PMCU-0330
PMCE-0330
PMCE-0330
PMCE-3330
PMCU-0220
PMCU-0220
PMCU-0330
PMCU-0330
PMCU-0330
N/A
N/A
PMCE-0330
PMCU-0220
PMCU-0220
PMCU-0330
PMCU-0330
PMCU-0220
PMCU-0220
PMCU-0330
PMCU-0330
Package
Schematic
E30
E28/11
EI19
E30
E25.4
E22/19/
EI25-Vert
E30
EE22/19/6
EE19/EI19
EE22/19/6
E30
E16-Horz
EFD20
E16-Horz
E16-Vert
EE16
E22/19/6
E28/11
E30
EER28L
EER28L
E19-Horz
EE22
E28/11
EER28L
E28/11
EP10-SMD
EP10-SMD
EI33/29
EEL16
EE16/EI16
E22/19/6
EE28/11
EEL16
EEL19
E22/19/6
E22/19/6
pol 10/99
Specifications subject to change without notice.
20381 BARENTS SEA CIRCLE, LAKE FOREST, CA 92630 • TEL: (949) 452-0511 • FAX: (949) 452-0512 • http://www.premiermag.com
91
OFF-LINE
SWITCH MODE
TRANSFORMERS
GENERAL ELECTRICAL SPECIFICATIONS AT 25OC - OPERATING TEMPERATURE RANGE 0OC TO +70OC
Units are Designed for a Universal AC Input of 85 to 265Vac, 47/440 Hz, Unless Otherwise designated
1 = Unit Designed for Voltage Doubler input -or- PFC Corrected Front End
2 = Unit Designed for AC Input of 85 to135Vac, 47/440Hz
3 = Minimum Parts Count Design (lowest cost). Designed for Relatively Constant Load Power
Applications Where Load Regulation of 5.0 % & Line Regulation of 3.0 % is Acceptable
4 = Faraday Shield Between Primary + Bias & Secondaries. Connected to Bias - Pin
PART
NUMBER
POL-24013
POL-24020
TSD-1936
TSD-1693
TSD-790
TSD-1801
TSD-1791
POL-24013
TSD-10434
TSD-975
POL-24020
POL-24208
POL-24219
TSD-1667
TSD-1395
TSD-1406
TSD-1476
TSD-1647
TSD-1468
POL-28022
TSD-1717
POL-300301
TSD-10561
POL-30030
TSD-1737
POL-40020
POL-45012
TSD-1421
TSD-1739
TSD-1854
TSD-1686
TSD-1809
TSD-1552
TSD-9745
TSD-1851
Recommended
APPLICATION DATA
Power Intgr.
Output Voltages
Output Currents
Controller
Vout Vdc
Io_cont Amps
TOP 204
TOP 226
TOP 243
TOP 246
TOP 200
TOP 243
TOP 234
TOP 226
TOP 204
TO P214
TOP 226
TOP 226
TOP 227
TOP 242
TOP 224Y
TOP 223P
TOP 202YAI
TOP 222
TOP 222
TOP 204
TOP 249
TOP 227Y
TOP 227Y
TOP 227Y
TOP 247
TOP 227Y
TOP 204
TOP 222Y
TOP 246
TOP 250
TOP 246
TOP 245
TOP 227
TOP104
TOP 249
22.0
22.0
24.0
24.0
24.0
24.0
24.0
24.0
24.0
24.0
24.0
24.0x2
24.0x2
24.0/5.0
24.0/5.0
24.0/5.0
24.0/5.0
24.0/7.5
-24.0/-60.0
28.0
28.0
28.0
29/9.5
30.0
30.0
40.0
45.0
48.0
48.0
48
72.0
72.0
85/-85/48/24
-118
360
1.50
2.00
0.50
3.5
0.15
0.20
1.25
1.30
1.30
1.30
2.00
0.80x2
1.875x2
0.150/0.400
1.0/3.0
0.15/0.8
0.5/1.0
0.2/0.265
0.3/0.13
2.20
7.5
4.00
3.50/0.25
3.00
4.0
2.00
1.20
0.25
2.0
4.16
0.8
0.5
0.175/0.175/1.3/1.3
-0.13
.180
Con
Watt
33.0
44.0
12..
8.4
3.6
4.8
30.0
31.2
31.2
31.2
48.0
38.4
90.0
5.6
39.0
7.6
17.0
6.8
15.0
61.6
210.0
112.0
104.0
90.0
120.0
80.0
54.0
12.0
96.0
200.0
58.0
36.0
123.4
15.3
65.0
Recommended
Output Filter
Input Filter
Inductor (L2)
CMC (L1)
VTP-01002
VTP-01002
VTP-01001
VTP-01005
VTP-01001
VTP-01001
VTP-01001
VTP-01002
VTP-01002
VTP-01001
VTP-01002
VTP-01001
VTP-01001
VTP-01001
VTP-01002
VTP-01001
VTP-01001
VTP-01001
VTP-01001
VTP-01002
VTP-02007
VTP-01005
VTP-01003
VTP-01002
VTP-01005
VTP-01002
VTP-01002
VTP-01001
VTP-01002
VTP-01005
VTP-01001
VTP-01001
VTP-01002
VTP-01002
VTP-01001
PMCU-0330
PMCE-0330
PMCU-0220
PMCU-0330
PMCU-0220
PMCU-0220
PMCU-0330
PMCU-0330
PMCU-0330
PMCU-0330
PMCE-0330
PMCU-0330
PMCE-0330
PMCU-0220
PMCE-0330
PMCU-5330
PMCU-0100
PMCU-0100
PMCU-0330
PMCE-0330
PMCE-0330
PMCE-0160
PMCE-0330
PMCE-0160
PMCE-0330
PMCE-0160
PMCE-0330
PMCE-0330
PMCE-0330
PMCE-0330
PMCE-0330
PMCU-0330
PMCE-0330
N/A
PMCE-0330
Package
Schematic
E28/11
E30
EE16
EI30
E22/19/6
EE16
EF25
E28/11
E28/11
EPC25
E30
E25-Vert
EI33/29
EI19
EE30
EE22/19/6
EI22/19/6
EE16/EI16
EE19/EI19
E30
ETD39
EI33/29
EI40
EI33/29
E42
EI33/29
E28/11
EF25
EI33
E42/21
E28
EI25
EI33/29/1
EFD25
EI40
pol 10/99
Specifications subject to change without notice.
20381 BARENTS SEA CIRCLE, LAKE FOREST, CA 92630 • TEL: (949) 452-0511 • FAX: (949) 452-0512 • http://www.premiermag.com
92
OFF-LINE
SWITCH MODE
TRANSFORMERS
MECHANICALS
E16-Vert
E16-Horz
8
7
6
10
9
8
7
6
5
5
P POL-XXXX
M YYWW
PIN #1
WHITE DOT
WHITE DOT
DENOES PIN#1
1
2
3
1
3.0
(.118)
3
2
4
16.2
(.638)
MAX
17.6
(.693)
MAX
14.5
(.571)
MAX
1.3
(.051)
3
18.2
(.716)
MAX
15.5
(.610)
MAX
P POL-XXXX
M YYWW
3.5
(.137)
MIN
2
4
16.8
(.661)
MAX
CORE
TAPED
1
6.0
(.236)
TYP
3.8
(.150)
4.5
(.177)
TYP
∅ 0.6
(.024)
3.5
(.138)
4
1
12.5
(.492)
10.5
(.413)
2
3
4
11.0
(.433)
8
7
6
0.6 DIA.
(.024)
12.5
(.492)
5
10
9
8
2.7
(.106)
7
6
5
13.5
(.531)
E19-Horz
8
7
6
E22/19/6
5
8
7
6
5
P POL-XXXX
M YYWW
WHITE DOT
DENOES PIN#1
1
2
3
PIN #1
WHITE DOT
4
20.0
(.788)
MAX
CORE
TAPED
1
2
16.4
(.646)
MAX
P POL-XXXX
M YYWW
3
4
23.00
(.906)
MAX
CORE
TAPED
18.00
(.709)
MAX
21.00
(.827)
MAX
18.8
(.740)
MAX
6.5
(.256)
1
1
2
3
4
1.3 6.0
(.051) (.236)
5.08
6-PLACES
(.200)
∅ 0.8
(.032)
5.00
(.197)
12.7
(.500)
2
3
0.8 DIA.
(.032)
4
4.0
(.157)
MIN
12.50
(.492)
BOTTOM HALF OF
CORE IS CUFF WRAPPED
WITH MYLAR TO GUARANTEE
5mm PIN-CORE-PIN CREEPAGE
pol 10/99
Specifications subject to change without notice.
20381 BARENTS SEA CIRCLE, LAKE FOREST, CA 92630 • TEL: (949) 452-0511 • FAX: (949) 452-0512 • http://www.premiermag.com
93
OFF-LINE
SWITCH MODE
TRANSFORMERS
MECHANICALS
EPC 19
19.7
(.776)
MAX
E-25
20.6
(.811)
MAX
CORE
TAPED
8
1
3.75
(.148)
4-PLCS
5
1
2
PIN #1
WHITE DOT
4.5
(.177)
1
3
3
4
18.3
(.720)
MAX
0.49 (.019)SQ.
11-PLCS
5
4
2
26.0
(1.024)
MAX
16.25
(.640)
15.0
(.591)
5
6
P POL-XXXX
M YYWW
12.00
(.472)
MAX
2.5
(.098)
7
21.16
(.833)
MAX
16.25
(.640)
1
2
3
0.8 DIA.
(.030)
4
4.0
(.158)
TYP
5.0
(.197)
2.50
(.098)
5-PLCS
11
10
9
C
L
8
7
12.5
(.492)
15.0
(.591)
6
12.5
(.492)
EPC25
5.00
(.197)
4-PLCS
20.0
(.787)
1
2
3
4
5
0.8 DIA.
11-PLCS
25.75
(1.014)
MAX
P POL-XXXX
M YYWW
20.0
(.787)
3.75
(.148)
5-PLCS
11
10
9
C
L
8
7
6
17.00
(.670)
MAX
4.85
(.191)
1
26.0
(1.024)
MAX
CORE
TAPED
5
3.0
(.118)
4.5
(.177)
20.0
(.787)
18.75
(.738)
pol 10/99
Specifications subject to change without notice.
20381 BARENTS SEA CIRCLE, LAKE FOREST, CA 92630 • TEL: (949) 452-0511 • FAX: (949) 452-0512 • http://www.premiermag.com
94
OFF-LINE
SWITCH MODE
TRANSFORMERS
MECHANICALS
E28/11
10
9
8
7
E30
12
6
1
2
3
4
10
9
8
7
P POL-XXXX
M YYWW
P POL-XXXX
M YYWW
PIN #1
WHITE DOT
11
PIN #1
WHITE DOT
5
28.5
(1.122)
MAX
1
2
3
4
5
6
31.50
(1.240)
MAX
25.5
(1.004)
MAX
CORE
TAPED
29.00
(1.142)
MAX
24.2
(.953)
MAX
1
2
3
4
0.8 DIA.
(.032)
5
17.5
(.689)
4.0
(.157)
MIN
5.0
(.197)
1
2
3
4
5.00
(.197)
20.0
(.787)
5
10
9
8
2
3
4
11
10
9
8
7
P TSD-XXXX
M YYWW
PIN #1
WHITE DOT
1
5
1
6
34.30
(1.350)
MAX
CORE
TAPED
2
3
4
5
6
41.00
(1.615)
MAX
29.00
(1.142)
MAX
CORE
TAPED
2
3
5.00
(.197)
4
25.00
(.984)
5
0.8 DIA.
(.032)
6
4.0
(.157)
MIN
31.00
(1.220)
MAX
36.10
(1.421)
MAX
32.00
(1.260)
MAX
1
20.0
(.787)
7
P POL-XXXX
M YYWW
PIN #1
WHITE DOT
4.0
(.157)
MIN
EI40
12
11
0.8 DIA.
(.032)
6
25.00
(.984)
EI33/29
12
26.50
(1.043)
MAX
22.5
(.886)
1
2
3
5.00
(.197)
4
25.00
(.984)
5
0.8 DIA.
(.032)
6
4.0
(.157)
MIN
22.5
(.886)
pol 10/99
Specifications subject to change without notice.
20381 BARENTS SEA CIRCLE, LAKE FOREST, CA 92630 • TEL: (949) 452-0511 • FAX: (949) 452-0512 • http://www.premiermag.com
95
OFF-LINE
SWITCH MODE
TRANSFORMERS
Indicated Parts are UL1950 & CSA-950 Recognized Under UL File# E162344
UL 1950 & CSA 950-95, C-UL US Recognized Parts
UL & CSA Recognized Components in UL File E162344 (S), Product Designation XNWX2
REF
#
1
2
3
4
5
6
7
8
9
10
11
12
13
14
15
16
17
18
19
20
21
22
23
24
25
26
27
28
29
30
31
32
33
34
35
36
37
PART
NUMBER
TSD-737
TSD-762
TSD-777
TSD-778
TSD-779
TSD-790
TSD-794
TSD-812
TSD-813
TSD-816
TSD-825
TSD-858
TSD-860
TSD-876
TSD-877
TSD-880
TSD-893
TSD-924
TSD-935
TSD-937
TSD-940
TSD-946
TSD-968
TSD-974
TSD-975
TSD-979
TSD-983
TSD-988
TSD-990
TSD-1003
TSD-1017
TSD-1024
TSD-1043
TSD-1046
TSD-1055
TSD-1056
TSD-1093
Package
Schematic
E22/19/6
E28/11
E30
E22/19/6
E22/19/6
E22/19/6
E28/11
EER28L
E19 HORIZ
E-16 HORIZ
E-16 HORIZ
E19 HORIZ
E28/11
E19 HORIZ
E28/11
E30
E30
E22/19/6
E19 HORIZ
E28/11
E-16 HORIZ
E-16 HORIZ
E22/19/6
EFD25
EPC25
E-16 HORIZ
E22/19/6
EEL22
E19 HORIZ
E-16 HORIZ
E-16 VERT
E22/19/6
E28/11
E22/19/6
EEL16
EI40
E-16 VERT
REF
#
38
39
40
41
42
43
44
45
46
47
48
49
50
51
52
53
54
55
56
57
58
59
60
61
62
PART
NUMBER
Package
Schematic
TSD-1110
POL-05006
POL-05010
POL-05012
POL-05020
POL-05030
POL-07003
POL-07020
POL-07050
POL-12012
POL-12017
POL-12208
POL-12216
POL-15020
POL-15033
POL-15073
POL-15204
POL-22007
POL-24013
POL-24020
POL-28022
POL-30030
POL-40020
POL-45012
POL-97506
EEL19
E-16 HORIZ
E-16 HORIZ
E-16 HORIZ
E-16 VERT
E22/19/6
E-16 VERT
E22/19/6
E28/11
E22/19/6
EI25 VERT
E22/19/6
EI25 VERT
E28/11
E30
EER28L
E19 HORIZ
E22/19/6
E28/11
E28/11
E30
EI33/29
EI33/29
E28/11
E19 HORIZ
REF
#
PART
NUMBER
Package
Schematic
pol 10/99
Specifications subject to change without notice.
20381 BARENTS SEA CIRCLE, LAKE FOREST, CA 92630 • TEL: (949) 452-0511 • FAX: (949) 452-0512 • http://www.premiermag.com
96
OFF-LINE SWITCH MODE
TINY SWITCH TRANSFORMERS
Indicated Parts are UL1950, IEC950, CSA-950 Recognized Under UL File# E162344
Ê Designed for Use with Power Integrations IC's, Tiny Switch Family
Ë Output Voltage Range from 3.5 to 27 Vdc
Ì 3000 Vrm Isolation (Hi-Pot). Meets UL1950, IEC950 Safety Standard
Í Units are Designed for a Universal AC Input of 85 to 265Vac, 47/440 Hz, Unless otherwise Designated
GENERAL ELECTRICAL SPECIFICATIONS AT 25OC - OPERATING TEMPERATURE RANGE 0OC TO +70OC
PART
NUMBER
Recommended
Power Intgr.
Controller
PNY-05015
TNY-255
PNY-05015
TNY-256
Output
Voltages
(Vdc)
3.5
3.8
4.0
4.4
4.9
5.2
5.8
6.1
6.5
6.8
7.5
8.4
9.0
9.8
11.2
3.6
3.9
4.2
4.6
5.0
5.4
5.9
6.2
6.8
7.0
7.6
8.4
9.0
9.8
11.2
Output
Currents
(Amp)
1.8
1.7
1.6
1.5
1.4
1.3
1.2
1.2
1.1
1.1
1.0
1.0
0.9
0.8
0.5
1.7
1.8
1.3
1.45
1.57
1.3
1.14
1.20
1.1
1.13
1.06
1.04
0.9
0.81
0.5
VR1
Voltages
Ref(V)
3.0
3.3
3.6
3.9
4.3
4.7
5.1
5.6
6.0
6.2
6.8
7.5
8.2.
9.1
10.0
3.0
3.3
3.6
3.9
4.3
4.7
5.1
5.6
6.0
6.2
6.8
7.5
8.2.
9.1
10.0
Part
Number
Manufacturer
Made
1N5225B
1N5226B
1N5227B
1N5228B
1N5229B
1N5230B
1N5231B
1N5232B
1N5233B
1N5234B
1N5235B
1N5236B
1N5237B
1N5239B
1N5240B
1N5225B
1N5226B
1N5227B
1N5228B
1N5229B
1N5230B
1N5231B
1N5232B
1N5233B
1N5234B
1N5235B
1N5236B
1N5237B
1N5239B
1N5240B
Motorola
Motorola
Motorola
Motorola
Motorola
Motorola
Motorola
Motorola
Motorola
Motorola
Motorola
Motorola
Motorola
Motorola
Motorola
Motorola
Motorola
Motorola
Motorola
Motorola
Motorola
Motorola
Motorola
Motorola
Motorola
Motorola
Motorola
Motorola
Motorola
Motorola
pny 12/01
Specifications subject to change without notice.
20381 BARENTS SEA CIRCLE, LAKE FOREST, CA 92630 • TEL: (949) 452-0511 • FAX: (949) 452-0512 • http://www.premiermag.com
97
OFF-LINE SWITCH MODE
TINY SWITCH TRANSFORMERS
PART
NUMBER
Recommended
Power Intgr.
Controller
PNY-07006
TNY-254
PNY-07006
TNY-256
PNY-24004
TNY-255
Output
Voltages
(Vdc)
3.1
3.5
4.2
5.8
6.2
6.6
6.9
7.5
8.3
8.9
9.7
11.0
12.0
12.5
13.1
14.1
16.0
16.7
3.08
3.50
4.60
5.60
6.12
6.58
7.04
7.35
8.34
8.98
9.62
10.90
11.88
12.57
13.26
14.10
15.70
16.93
26.9
22.7
21.1
18.4
17.6
16.0
13.7
12.6
12.0
9.9
7.5
Output
Currents
(Amp)
0.7
0.7
0.7
0.6
0.6
0.6
0.5
0.5
0.5
0.4
0.4
0.3
0.3
0.3
0.3
0.3
0.2
0.2
1.43
1.12
0.91
0.80
0.76
0.65
0.63
0.60
0.59
0.50
0.48
0.45
0.40
0.38
0.37
0.32
0.30
0.26
0.30
0.42
0.46
0.50
0.53
0.55
0.64
0.70
0.72
0.77
0.92
VR1
Voltages
Ref (V)
3.9
4.3
4.7
5.1
5.6
6.0
6.2
6.8
7.5
8.2
8.7
10.0
11.0
12.0
13.0
14.0
15.0
16.0
3.9
4.3
4.7
5.1
5.6
6.0
6.2
6.8
7.5
8.2
8.7
10.0
11.0
12.0
13.0
14.0
15.0
16.0
24
20
19
17
16
15
13
12
11
9.1
6.8
Part
Number
1N5228B
1N5229B
1N5230B
1N5231B
1N5232B
1N5233B
1N5234B
1N5235B
1N5236B
1N5237B
1N5238B
1N5240B
1N5241B
1N5242B
1N5243B
1N5244B
1N5245B
1N5246B
1N5228B
1N5229B
1N5230B
1N5231B
1N5232B
1N5233B
1N5234B
1N5235B
1N5236B
1N5237B
1N5238B
1N5240B
1N5241B
1N5242B
1N5243B
1N5244B
1N5245B
1N5246B
1N5252B
1N5250B
1N5249B
1N5247B
1N5246B
1N5245B
1N5243B
1N5242B
1N5241B
1N5239B
1N5235B
Manufacturer
Made
Motorola
Motorola
Motorola
Motorola
Motorola
Motorola
Motorola
Motorola
Motorola
Motorola
Motorola
Motorola
Motorola
Motorola
Motorola
Motorola
Motorola
Motorola
Motorola
Motorola
Motorola
Motorola
Motorola
Motorola
Motorola
Motorola
Motorola
Motorola
Motorola
Motorola
Motorola
Motorola
Motorola
Motorola
Motorola
Motorola
Motorola
Motorola
Motorola
Motorola
Motorola
Motorola
Motorola
Motorola
Motorola
Motorola
Motorola
pny 12/01
Specifications subject to change without notice.
20381 BARENTS SEA CIRCLE, LAKE FOREST, CA 92630 • TEL: (949) 452-0511 • FAX: (949) 452-0512 • http://www.premiermag.com
98
OFF-LINE SWITCH MODE
TINY SWITCH TRANSFORMERS
PART
NUMBER
Output
Voltages
(Vdc)
27.3
22.2
20.7
18.4
17.6
16.5
13.5
12.7
12.1
9.9
7.7
12/12/5
12/12
5/15
24
5
Recommended
Power Intgr.
Controller
PNY-24004
TNY-256
PNY-12206
PNY-12238
PNY-15000
PNY-24002
TSD-1460
TNY-256
TNY-267
TNY-266
TNY-266
TNY-254
Output
Currents
(Amp)
0.30
0.40
0.44
0.49
0.52
0.55
0.64
0.71
0.72
0.82
0.94
.06/.06/.60
.380/.380
.050/.500
.400
.500
VR1
Voltages
Ref (V)
24
20
19.1
17
16
15
13
12
11
9.1
6.8
Part
Number
Manufacturer
Made
1N5252B
1N5250B
1N5249B
1N5247B
1N5246B
1N5245B
1N5243B
1N5242B
1N5241B
1N5239B
1N5235B
Motorola
Motorola
Motorola
Motorola
Motorola
Motorola
Motorola
Motorola
Motorola
Motorola
Motorola
DIMENSIONS mm (IN)
SCHEMATIC
18.2
(.716)
MAX
PIN #1
WHITE DOT
16.5
(.650)
MAX
18
(.709)
MAX
6.0
(.236)
TYP
4.5
(.177)
TYP
3.5
(.138)
1
10
2
9
12.5
(.492)
10.5
(.413)
3
8
7
2.7
(.106)
0.6 DIA.
(.024)
4
6
5
13.5
(.531)
pny 12/01
Specifications subject to change without notice.
20381 BARENTS SEA CIRCLE, LAKE FOREST, CA 92630 • TEL: (949) 452-0511 • FAX: (949) 452-0512 • http://www.premiermag.com
99
PMCE-XXXX EMI/RFI
COMMON MODE
LINE FILTERS
MEDIUM & HI POWER
Ê Rated Voltage: 250Vac, 45/400Hz
Ë < 50OC Temp Rise & Rated Current (1)
Ì Operating Temp -40 to +80 OC
Í Low Profile Construction
Î 3750Vrms Isolation
Ï Insulation Resistance @ 500Vdc >100MΩ
ELECTRICAL SPECIFICATIONS AT 25OC - OPERATING TEMPERATURE RANGE -40OC TO +80OC
PART
NUMBER
RATED
RMS Current
Amps rms
Load VA
@ RMS Line
115V
230V
INDUCTANCE
DCR
@ 1KHz
EACH WINDING
(mH Min.)
(Ohms Max.)
PACKAGE
PMCE-0470
PMCE-0330
PMCE-0160
PMCE-0100
PMCE-0056
PMCE-0033
PMCE-0015
0.75
1.00
1.50
1.75
2.25
2.75
3.50
86.25
115.00
172.50
201.25
258.75
316.25
402.50
172.50
230.00
345.00
402.50
517.50
632.50
805.00
47.0
33.0
16.0
10.0
5.6
3.3
1.5
0.720
0.550
0.250
0.170
0.080
0.055
0.032
E25.4
E25.4
E25.4
E25.4
E25.4
E25.4
E25.4
PMCE-3470
PMCE-3330
PMCE-3220
PMCE-3100
PMCE-3056
PMCE-3033
PMCE-3015
1.75
2.00
2.50
3.50
4.50
5.50
7.00
201.25
230.00
316.25
402.50
517.50
632.50
805.00
402.5
460.00
632.50
805.00
1035.0
1265.0
1610.0
47.0
33.0
22.0
10.0
5.6
3.3
1.5
0.520
0.375
0.250
0.150
0.090
0.050
0.030
E35
E35
E35
E35
E35
E35
E35
Notes:
(1) Temperature Rise is specified at maximum continuous current. Lower currents
will result in reduced temperature rise. Design point is < 50OC rise at rated current.
SCHEMATIC
APPLICATION
DOT ON BOBBIN
DENOTES PIN #1
TYPICAL APPLICATION CIRCUIT
F1
LINE
115/230Vac
50/60Hz
NEUT
1
PMCU-XXXX
2
1
Cy
Cx
Cx
3
4
Cy
L1A
FG
L1B
4
2
Cx = 0.1uF (Line-to-Line)
Cy = 2200pF (Line-to-FG)
3
pmce 10/98
Specifications subject to change without notice.
20381 BARENTS SEA CIRCLE, LAKE FOREST, CA 92630 • TEL: (949) 452-0511 • FAX: (949) 452-0512 • http://www.premiermag.com
100
PMCE-XXXX EMI/RFI
COMMON MODE
LINE FILTERS
PMCE-3XXX E35
PMCE-0XXX E25.4
PART IS REVERSIBLE.
IT CAN BE INSERTED INTO PCB EITHER WAY.
PART IS REVERSIBLE.
IT CAN BE INSERTED INTO PCB EITHER WAY.
DOT ON BOBBIN
DENOTES PIN #1
DOT ON BOBBIN
DENOTES PIN #1
1
4
1
L1B
L1A
2
4
2
3
4
PIN #1
DOT
1
3
3
P PMCE-3XXX
YYWW
M
3
P PMCE-0XXX
YYWW
M
4
L1B
L1A
PIN #1
DOT
2
.750
(19.05)
MAX
1
2
1.200
(30.48)
MAX
1.015
(25.78)
MAX
.790
(20.07)
MAX
1.060
(27.00)
MAX
.18
(4.5)
1.450
(36.83)
MAX
.031
DIA
(0.8)
.539
(13.70)
.16
(4.0)
.579
(14.70)
4
.768
(19.50)
.031
DIA
(0.8)
3
.866
(22.00)
1
2
pmce 10/98
Specifications subject to change without notice.
20381 BARENTS SEA CIRCLE, LAKE FOREST, CA 92630 • TEL: (949) 452-0511 • FAX: (949) 452-0512 • http://www.premiermag.com
101
PMCU-XXXX EMI/RFI
COMMON MODE
LINE FILTERS
LOW PROFILE-HORZ
Ê Rated Voltage: 250Vac, 45/400Hz
Ë < 30OC Temp Rise & Rated Current (1)
Ì Operating Temp -40 to +80 OC
Í Low Profile Horizontal Construction
Î 3750Vrms Isolation
Ï Insulation Resistance @ 500Vdc >100MΩ
ELECTRICAL SPECIFICATIONS AT 25OC - OPERATING TEMPERATURE RANGE -40OC TO +80OC
RATED
RMS Current
mA rms
PART
NUMBER
PMCU-4470
PMCU-4330
PMCU-4220
PMCU-4100
PMCU-4056
PMCU-4033
PMCU-4015
PMCU-4009
PMCU-4005
PMCU-4002
PMCU-4001
150
200
250
350
450
600
800
1000
1500
2000
3000
Load VA
@ RMS Line
115V
17.25
23.00
28.75
40.25
51.75
69.00
92.00
115.00
172.50
230.00
345.00
INDUCTANCE
DCR
@ 1KHz
EACH WINDING
(mH Min.)
(Ohms Max.)
230V
34.50
46.00
57.50
80.50
103.50
138.00
184.00
230.00
345.00
460.00
690.00
47.0
33.0
22.0
10.0
5.6
3.3
1.5
0.9
0.5
0.2
0.1
PACKAGE
6.90
5.50
3.70
1.40
0.75
0.50
0.30
0.16
0.12
0.06
0.03
U9.8
U9.8
U9.8
U9.8
U9.8
U9.8
U9.8
U9.8
U9.8
U9.8
U9.8
Notes:
(1) Temperature Rise is specified at maximum continuous current. Lower currents
will result in reduced temperature rise. Design point is < 30OC rise at rated current.
SCHEMATIC
MECHANICAL
15.5
(.610)
MAX
16.0
(.629)
MAX
10.8
(.425)
PART IS REVERSIBLE.
IT CAN BE INSERTED INTO PCB EITHER WAY.
DOT ON BOBBIN
DENOTES PIN #1
12.6
(.495)
1
CORE
CLAMP
12.5
(.492)
MAX
∅ 0.6
(.024)
1
4
2
8.0
(.315)
2
1
3
2
4
1
P PMCU-4XXX
M
4
3
TYPICAL APPLICATION CIRCUIT
TOP VIEW
8.0
(.315)
L1B
L1A
5.0
(.197)
TYP
7.0
(.276)
4
PMCU-XXXX
F1
LINE
115/230Vac
50/60Hz
NEUT
2
1
Cy
Cx
Cx
3
Cy
FG
4
Cx = 0.1uF (Line-to-Line)
Cy = 2200pF (Line-to-FG)
3
pmcu 12/98
Specifications subject to change without notice.
20381 BARENTS SEA CIRCLE, LAKE FOREST, CA 92630 • TEL: (949) 452-0511 • FAX: (949) 452-0512 • http://www.premiermag.com
102
PMCU-XXXX EMI/RFI
COMMON MODE
LINE FILTERS
LOW PROFILE-VERT
Ê Rated Voltage: 250Vac, 45/400Hz
Ë < 30OC Temp Rise & Rated Current (1)
Ì Operating Temp -40 to +80 OC
Í Low Profile Vertical Construction
Î 3750Vrms Isolation
Ï Insulation Resistance @ 500Vdc >100MΩ
ELECTRICAL SPECIFICATIONS AT 25OC - OPERATING TEMPERATURE RANGE -40OC TO +80OC
PART
NUMBER
Load VA
@ RMS Line
RATED
RMS Current
mA rms
PMCU-5470
PMCU-5330
PMCU-5220
PMCU-5100
PMCU-5056
PMCU-5033
PMCU-5015
PMCU-5009
PMCU-5005
PMCU-5002
PMCU-5001
150
200
250
350
450
600
800
1000
1500
2000
3000
115V
17.25
23.00
28.75
40.25
51.75
69.00
92.00
115.00
172.50
230.00
345.00
230V
INDUCTANCE
DCR
@ 1KHz
EACH WINDING
(mH Min.)
(Ohms Max.)
34.50
46.00
57.50
80.50
103.50
138.00
184.00
230.00
345.00
460.00
690.00
47.0
33.0
22.0
10.0
5.6
3.3
1.5
0.9
0.5
0.2
0.1
6.90
4.95
3.70
1.40
0.75
0.50
0.30
0.16
0.12
0.06
0.03
PACKAGE
Notes:
(1) Temperature Rise is specified at maximum continuous current. Lower currents
will result in reduced temperature rise. Design point is < 30OC rise at rated current.
U9.8
U9.8
U9.8
U9.8
U9.8
U9.8
U9.8
U9.8
U9.8
U9.8
U9.8
SCHEMATIC
MECHANICAL
PART IS REVERSIBLE.
IT CAN BE INSERTED INTO PCB EITHER WAY.
16.0
(.630)
MAX
11.2
(.441)
MAX
DOT ON BOBBIN
DENOTES PIN #1
CORE
CLAMP
1
16.3
(.642)
MAX
∅ 0.6
(.024)
1
4
2
1
3
TYPICAL APPLICATION CIRCUIT
2
TOP VIEW
3
8.0
(.315)
2
PM PMCU-5XXX
4
1
PMCU-XXXX
F1
LINE
115/230Vac
50/60Hz
NEUT
4
L1B
L1A
4.0
(.157)
TYP
7.0
(.276)
4
2
1
Cy
Cx
Cx
3
Cy
FG
4
Cx = 0.1uF (Line-to-Line)
Cy = 2200pF (Line-to-FG)
3
pmcu 12/98
Specifications subject to change without notice.
20381 BARENTS SEA CIRCLE, LAKE FOREST, CA 92630 • TEL: (949) 452-0511 • FAX: (949) 452-0512 • http://www.premiermag.com
103
PMCU-XXXX EMI/RFI
COMMON MODE
LINE FILTERS
MEDIUM POWER
Ê Rated Voltage: 250Vac, 45/400Hz
Ë < 50OC Temp Rise & Rated Current (1)
Ì Operating Temp -40 to +80 OC
Í Low Profile Construction
Î 3750Vrms Isolation
Ï Insulation Resistance @ 500Vdc >100MΩ
ELECTRICAL SPECIFICATIONS AT 25OC - OPERATING TEMPERATURE RANGE -40OC TO +80OC
PART
NUMBER
RATED
RMS Current
Amps rms
Load VA
@ RMS Line
115V
230V
INDUCTANCE
DCR
@ 1KHz
EACH WINDING
(mH Min.)
(Ohms Max.)
PACKAGE
PMCU-0470
PMCU-0330
PMCU-0220
PMCU-0100
PMCU-0056
PMCU-0033
PMCU-0015
0.35
0.40
0.50
0.65
1.00
1.20
1.80
40.25
46.00
57.50
74.75
115.00
138.00
207.00
80.50
92.00
115.00
149.50
230.00
276.00
414.00
47.0
33.0
22.0
10.0
5.6
3.3
1.5
2.40
2.00
1.20
0.75
0.40
0.25
0.11
U10.5
U10.5
U10.5
U10.5
U10.5
U10.5
U10.5
PMCU-2470
PMCU-2330
PMCU-2220
PMCU-2100
PMCU-2056
PMCU-2033
PMCU-2015
0.50
0.60
0.75
1.00
1.40
2.00
2.70
57.50
69.00
86.25
115.00
161.00
230.00
287.50
115.00
138.00
172.50
230.00
322.00
460.00
575.00
47.0
33.0
22.0
10.0
5.6
3.3
1.5
1.35
1.00
0.60
0.34
0.15
0.10
0.04
U16
U16
U16
U16
U16
U16
U16
Notes:
(1) Temperature Rise is specified at maximum continuous current. Lower currents
will result in reduced temperature rise. Design point is < 50OC rise at rated current.
SCHEMATIC
APPLICATION
DOT ON BOBBIN
DENOTES PIN #1
TYPICAL APPLICATION CIRCUIT
F1
LINE
115/230Vac
50/60Hz
NEUT
1
PMCU-XXXX
2
1
Cy
Cx
Cx
3
4
Cy
L1A
FG
L1B
4
2
Cx = 0.1uF (Line-to-Line)
Cy = 2200pF (Line-to-FG)
Specifications subject to change without notice.
3
pmcu 12/98
20381 BARENTS SEA CIRCLE, LAKE FOREST, CA 92630 • TEL: (949) 452-0511 • FAX: (949) 452-0512 • http://www.premiermag.com
104
PMCU-XXXX EMI/RFI
COMMON MODE
LINE FILTERS
PMCU-2XXX U16
PMCU-0XXX U10.5
PART IS REVERSIBLE.
IT CAN BE INSERTED INTO PCB EITHER WAY.
PART IS REVERSIBLE.
IT CAN BE INSERTED INTO PCB EITHER WAY.
DOT ON BOBBIN
DENOTES PIN #1
DOT ON BOBBIN
DENOTES PIN #1
1
4
1
L1B
L1A
2
4
2
3
4
PIN#1
DOT
1
3
3
16.5
(.650)
MAX
PIN#1
DOT
2
P PMCU-2XXX
YYWW
M
3
P PMCU-0XXX
YYWW
M
4
L1B
L1A
1
2
19.0
(.748)
MAX
18.4
(.725)
MAX
22.0
(.866)
MAX
27.2
(1.070)
MAX
21.7
(.854)
MAX
∅ 0.7
(.028)
4.2
(.165)
TYP
10.0
(.394)
1
4.2
(.165)
TYP
∅ 0.7
(.028)
13.0
(.512)
10.3
(.394)
2
1
17.2
(.677)
2
13.0
(.512)
4
13.0
(.512)
13.0
(.512)
3
4
Specifications subject to change without notice.
3
pmcu 12/98
20381 BARENTS SEA CIRCLE, LAKE FOREST, CA 92630 • TEL: (949) 452-0511 • FAX: (949) 452-0512 • http://www.premiermag.com
105
OPEN COMMON MODE EMI
SUPRESSION INDUCTORS
Ê For High Frequency Power Supply Applications
Ë Balanced Windings
Ì Vertical Mount
Í Custom Values Available
Î 1250 Vrms Minimum Isolation Voltage
Ï Industry Standard Package
NORMAL TEMP RANGE
ELECTRICAL SPECIFICATIONS AT 25OC - OPERATING TEMPERATURE RANGE 0OC TO +70OC
PART
NUMBER
RATED
RMS Current
Amps
Load VA
@ RMS Line
117V
220V
INDUCTANCE
@ 1KHz
(mH Min.)
LL
@ 130KHz
µH Max.)
(µ
DCR
EACH WINDING
(Ohms Max.)
PM-OM01
PM-OM02
PM-OM03
1.8
3.5
6.0
210
400
700
420
800
1400
10.0
3.0
1.0
130
35
12
0.240
0.060
0.020
A
A
A
PM-OM04
PM-OM05
PM-OM06
PM-OM07
2.6
3.2
5.2
7.5
300
375
600
875
600
750
1200
1750
16.0
8.0
4.0
2.0
180
90
45
25
0.320
0.120
0.040
0.020
B
B
B
B
PACKAGE "B"
PACKAGE "A"
2
4
2
L1B
L1A
1
4
L1B
L1A
3
1.200
(30.48)
MAX
1
POLYESTER
TAPE
3
1.370
(35.00)
MAX
.650
(16.51)
MAX
1.200
(30.48)
MAX
.850
(21.59)
MAX
P PM-OMXX
M YYWW
.050 DIA
(1.27)
PIN #3
.800
(20.32)
POLYESTER
TAPE
1.500
(38.10)
MAX
P PM-OMXX
M YYWW
PIN #1
PACKAGE
.200
(5.08)
PIN #1
.900
(22.86)
.400
(10.16)
.050 DIA
(1.27)
PIN #3
.200
(5.08)
.600
(15.24)
PM-OMXX 8/01
Specifications subject to change without notice.
20381 BARENTS SEA CIRCLE, LAKE FOREST, CA 92630 • TEL: (949) 452-0511 • FAX: (949) 452-0512 • http://www.premiermag.com
106
VERSA-PAC
TRANSFORMERS & INDUCTORS
Ê Surface Mount with 1:1:1:1:1:1
Ë Low Radiated Noise
Ì Frequency Range Over 1MHz
Í 500 VAC Isolation Winding to Winding
Î Can Be Used As Transformer or Inductor
ELECTRICAL SPECIFICATIONS AT 25OC
PART
NUMBER
OCL
(µ
µH ±20%.)
Leak Ind
µH
(TYP)
Isat
A
(TYP)
I rms
A
(TYP)
DCR
Ω
(MAX)
Volt-µ
µsec
µVs
(TYP)
E peak
µJ
(TYP)
Thermal
Resistance
(TYP)
PM-V011400
89.6±30%
0.10
0.06
0.85
0.145
21.8
0.11
60.5
PM-V010190
12.2±20%
0.10
0.43
.085
0.145
21.8
0.77
60.5
PM-V010102
6.5±20%
0.10
0.80
0.85
0.145
21.8
1.45
60.5
PM-V010076
4.9±20%
0.10
1.06
0.85
0.145
21.8
1.90
60.5
PM-V010059
3.8±20%
0.10
1.37
0.85
0.145
21.8
2.40
60.5
PM-V021400
201.6±30%
0.21
0.04
0.55
0.345
33.0
0.11
60.5
PM-V020190
27.4±20%
0.21
0.29
0.55
0.345
33.0
0.77
60.5
PM-V020102
6.5±20%
0.21
0.52
0.55
0.345
33.0
1.45
60.5
PM-V020076
10.9±20%
0.21
0.70
0.55
0.345
33.0
1.90
60.5
PM-V020059
8.5±20%
0.21
0.90
0.55
0.345
33.0
2.40
60.5
PM-V031600
078.4±3%
0.08
0.10
1.25
0.090
34.0
0.30
44.0
PM-V030216
10.6±20%
0.08
0.76
1.26
0.090
34.0
2.10
44.0
PM-V030116
5.7±20%
0.80
1.40
1.25
0.090
34.0
4.00
44.0
PM-V030083
4.1±20%
0.08
1.95
1.25
0.090
34.0
5.50
44.0
PM-V030066
3.2±20%
0.08
2.50
1.25
0.090
34.0
7.00
44.0
PM-V041600
160±30%
0.16
0.07
0.95
0.160
48.0
0.30
44.0
PM-V040216
21.6±20%
0.16
0.55
0.95
0.160
48.0
2.10
44.0
PM-V040116
11.6±20%
0.16
0.99
0.95
0.160
48.0
4.00
44.0
PM-V040083
8.3±20%
0.16
1.40
0.95
0.160
48.0
5.50
44.0
PM-V040066
6.6±20%
0.16
1.75
0.95
0.160
48.0
7.00
44.0
PM-V050780
63.2±30%
0.06
0.10
1.48
0.060
27.8
0.24
43.4
PM-V030138
11.2±20%
0.06
0.60
1.48
0.060
27.8
1.36
43.4
PM-V050084
6.8±20%
0.06
0.97
1.48
0.060
27.8
2.23
43.4
PM-V050055
4.5±20%
0.06
1.46
1.48
0.060
27.8
3.40
43.4
PM-V050047
3.8±20%
0.06
1.72
1.48
0.060
27.8
4.00
43.4
PM-V060780
132±20%
0.12
0.07
0.97
0.14
40.0
0.24
43.4
PM-V060138
23.3±20%
0.12
0.40
0.97
0.14
40.0
1.36
43.4
PM-V060084
14.2±20%
0.12
0.67
0.97
0.14
40.0
2.23
43.4
PM-V060055
9.3±20%
0.12
1.00
0.97
0.14
40.0
3.40
43.4
PM-V060047
7.9±20%
0.12
1.20
0.97
0.14
40.0
4.00
43.4
PM-V070860
69.7±20%
0.08
0.15
1.70
0.06
45.0
0.57
39.0
PM-V070140
11.3±20%
0.08
0.95
1.70
0.06
45.0
3.50
39.0
PM-V070075
6.1±20%
0.08
1.75
1.70
0.06
45.0
6.50
39.0
PM-V070060
4.9±20%
0.08
2.18
1.70
0.06
45.0
8.20
39.0
PM-V070047
3.8±20%
0.08
2.80
1.70
0.06
45.0
10.5
39.0
pm-vxxxxx
Specifications subject to change without notice.
20381 BARENTS SEA CIRCLE, LAKE FOREST, CA 92630 • TEL: (949) 452-0511 • FAX: (949) 452-0512 • http://www.premiermag.com
107
VERSA-PAC
INDUCTORS & TRANSFORMERS
Ê Surface Mount With 1:1:1:1:1:1
Ë Low Radiated Noise
Ì Frequency Range Over 1MHz
Í 500 VAC Isolation Winding to Winding
Î Can Be Used As Transformer or Inductor
ELECTRICAL SPECIFICATIONS AT 25OC
PART
NUMBER
OCL
(µ
µH ±20%.)
Leak Ind
µH
(TYP)
Isat
A
(TYP)
I rms
A
(TYP)
DCR
Ω
(MAX)
Volt-µ
µsec
µVs
(TYP)
E peak
µJ
(TYP)
Thermal
Resistance
(TYP)
PM-V080860
145±30%
0.16
0.11
1.40
0.08
64.5
0.57
39.0
PM-V080140
23.7±20%
0.16
0.65
1.40
0.08
64.5
3.50
39.4
PM-V080075
12.7±20%
0.16
1.21
1.40
0.08
64.5
6.50
39.4
PM-V080060
10.1±20%
0.16
1.52
1.40
0.08
64.5
8.20
39.0
PM-V080047
7.94±20%
0.16
1.94
1.40
0.08
64.5
10.5
39.0
PM-V091200
76.8±30%
0.10
0.20
2.0
0.05
65.5
1.10
30.0
PM-V090155
9.90±20%
0.10
1.60
2.0
0.05
65.5
8.80
30.0
PM-V090083
5.30±20%
0.10
2.95
2.0
0.05
65.5
16.1
30.0
PM-V090067
4.30±20%
0.10
3.60
2.0
0.05
65.5
19.8
30.0
PM-V090053
3.40±20%
0.10
4.60
2.0
0.05
65.5
25.1
30.0
PM-V101200
173±30%
0.24
0.14
1.70
0.07
98.0
1.10
30.0
PM-V100155
22.3±20%
0.24
1.05
1.70
0.07
98.0
8.80
30.0
PM-V100083
12.0±20%
0.24
1.95
1.70
0.07
98.0
16.1
30.0
PM-V100067
9.65±20%
0.24
2.40
1.70
0.07
98.0
19.8
30.0
PM-V100053
7.63±20%
0.24
3.10
1.70
0.07
98.0
25.1
30.0
PM-V01 & PM-V02 MECHANICAL
10x0.6 (.024)
PIN #1 DOT
12
2
11
3
4
5
PM-VXXXXXX
D/C
0.51
(12.95)
MAX
1
11.0 (.433)
1
10
4x2.0 (.079)
10x0.8 (.031)
10
9
5
8
6
7
6
4
10
1
5
7
11
2
6
8
12
CORE CLAMP
.248
(6.30)
MAX
0.362
(9.20)
REF
0.51 (13.0)
MAX
9
3
RATIO 1:1:1:1:1:1
pm-vxxxxx
Specifications subject to change without notice.
20381 BARENTS SEA CIRCLE, LAKE FOREST, CA 92630 • TEL: (949) 452-0511 • FAX: (949) 452-0512 • http://www.premiermag.com
108
VERSA-PAC
INDUCTORS & TRANSFORMERS
PM-V03 & PM-V04 MECHANICAL
1
12
2
12
PM-VXXXXXX
D/C
0.64
(16.3)
MAX
5.1 (13.0)
12x0.69 (1.75)
PIN#1 DOT
3
4
9
8
6
7
1
10
6
7
.100 (2.5)
0.56
(14.25)
TYP
10
5
12x0.1 (2.5)
CORE CLAMP
.335
(8.50)
MAX
0.473
(12.0)
REF
0.66 (16.8)
MAX
4
10
1
5
7
11
2
6
8
12
3
9
RATIO 1:1:1:1:1:1
PM-V05 & PM-V06 MECHANICAL
12
11
10
9
8
.900
(22.86)
7
.110
(2.80)
.680
(17.27)
1
12
6
7
.098
(2.50)
.050
(1.27)
PM-VXXXXXX
D/C
PIN #1
DOT
1
2
3
4
5
6
.630
(16.00)
MAX
.630
(16.00)
MAX
.327
(8.30)
MAX
.016
(0.40)
.0196
(0.50)
.098
(2.50)
.67
(17.0)
.015
(0.39)
1
4
12
2
9
5
11
3
8
6
.720
(18.30)
.866
(22.00)
MAX
10
7
RATIO 1:1:1:1:1:1
pm-vxxxxx
Specifications subject to change without notice.
20381 BARENTS SEA CIRCLE, LAKE FOREST, CA 92630 • TEL: (949) 452-0511 • FAX: (949) 452-0512 • http://www.premiermag.com
109
VERSA-PAC
INDUCTORS & TRANSFORMERS
PM-V07 & PM-V08 MECHANICAL
12
11
10
9
8
1.00
(25.4)
7
.123
(3.12)
.754
(19.14)
1
12
6
7
.098
(2.50)
.068
(1.75)
PM-VXXXXXX
D/C
PIN#1
DOT
1
2
3
4
5
6
7.08
(18.0)
REF
7.08
(18.0)
REF
.394
(10.0)
MAX
.016
(0.40)
.027
(0.70)
REF
.015
(0.39)
.098
(2.50)
.720
(18.30)
7.08
(18.0)
MAX
.97
(24.6)
MAX
1
4
12
2
9
5
11
3
8
6
10
7
RATIO 1:1:1:1:1:1
PM-V09 & PM-V10 MECHANICAL
12
11
10
9
8
.120
(3.05)
.940
(23.87)
7
1
12
6
7
.118
(3.00)
.085
(2.16)
PM-VXXXXXX
D/C
PIN#1
DOT
1
2
3
4
5
6
.827
(21.0)
MAX
.827
(21.0)
MAX
.430
(11.0)
MAX
.016
(0.40)
.027
(0.70)
.118
(3.00)
.787
(20.0)
.015
(0.39)
.968
(24.6)
1
4
12
2
9
5
11
3
8
6
10
1.128
(28.65)
7
RATIO 1:1:1:1:1:1
pm-vxxxxx
Specifications subject to change without notice.
20381 BARENTS SEA CIRCLE, LAKE FOREST, CA 92630 • TEL: (949) 452-0511 • FAX: (949) 452-0512 • http://www.premiermag.com
110
GATE DRIVE
& BASE DRIVE
TRANSFORMERS
Ê Designs for Single or Double Ended Controllers
Ë High Isolation Voltages
Ì Designs From 20KHz to >300KHz
Í Very Low Leakage Inductance
Î Industry Standard Packages
Ï Multiple Configurations
ELECTRICAL SPECIFICATIONS AT 25OC - OPERATING TEMPERATURE RANGE -25OC TO +80OC
PART
NUMBER
PMGD-02
PMGD-03
PMGD-04
PMGD-05
PMGD-06
PMGD-07
PMGD-08
PMGD-09
PMGD-10
TURNS
RATIO
(Pri:Sec ± 5%)
PRIMARY
OCL
µH Typ.)
(µ
1:1:1
1:1
1:1:1
1 : 0.67
1:1
1:2:2
1 : 1.25 : 1.25
1:2:2
1:2:2
530
800
24500
6200
6200
2350
575
2350
8350
LEAKAGE PRI/SEC
IND
HI-POT
µH Max.)
V
(µ
1.5
2.0
20.0
15.0
15.0
2.0
1.0
2.0
25.0
1500dc
1500dc
1000dc
1000dc
2000ac
1500ac
3000ac
3000ac
2500ac
PACKAGE
EP13
EP7
EP10
EP10
EP10
EP13
EP13
EP13
EP13
TYPICAL APPLICATION NOTE
150KHz Double Ended Drive
100KHz Single Ended Drive
20KHz Double Ended Drive
25KHz Single Ended Drive
100KHz Double Ended Drive
40KHz Dual Single Ended Drive
180KHz Dual Single Ended Drive
40KHz Dual Single Ended Drive
20KHz Dual Single Ended Drive
TYPICAL APPLICATIONS
TYPICAL SINGLE ENDED APPLICATION CIRCUIT
G
C
S
C25
T1
PMGD-05
B
R30
D5
1
8
E
C
D7
B
VO2
11
R14
C
B
1
Q3
Q1
D
E
C
G
B
S
D6
PMGD-XX
OUT B
Q1
E
>>
D10
DOUBLE ENDED
PWM OUTPUT
PRIMARY
R15
C20
E
3
1.5:1
OUT A
Q1
4
5
PWM DRIVER
(ML4824)
Q1
SEC #1
R17
+Vdc
D
SEC #2
Q2
PRIMARY
+382VDC HOT RAIL >>
TYPICAL DOUBLE ENDED APPLICATION CIRCUIT
pmgd 04/03
Specifications subject to change without notice.
20381 BARENTS SEA CIRCLE, LAKE FOREST, CA 92630 • TEL: (949) 452-0511 • FAX: (949) 452-0512 • http://www.premiermag.com
111
GATE DRIVE
& BASE DRIVE
TRANSFORMERS
Ê Designs for Gate/Base/Flyback/Push-Pull
Ë High Isolation Voltages
Ì Operating Frequency from 50KHz and Higher
Í SMD Industry Standard Packages
Î Operation Temp -40C to +85C
Ï Multiple Configurations
ELECTRICAL SPECIFICATIONS AT 25OC - OPERATING TEMPERATURE RANGE -40 OC TO +85OC
PMGD-50
PMGD-51
PMGD-52
PMGD-53
PMGD-54
PMGD-55
PMGD-56
PMGD-57
TURNS
RATIO
(Pri:Sec ± 5%)
PRIMARY
OCL
µH)
(µ
LEAKAGE
IND
µH tpy.)
(µ
1CT : 1CT
1CT : 2CT
1CT : 2.5CT
1CT : 3CT
1 : 1CT
1 : 2CT
1 : 12.04
1 : 3.0
800 MIN
390 MIN
390 MIN
2000 MIN
2000 MIN
17.2 ± 20%
3.7 ± 20%
9.88 ± 20%
3.00
1.50
1.50
1.20
1.20
1.00
0.275
0.500
PRI
DCR
(Ω MAX.)
SEC
DCR
PRI/SEC
HI-POT
VDC
3.50
4.50
6.00
25.00
2.75
3.00
12.25
3.25
1250
1250
1250
1250
1250
1250
550
1250
(Ω MAX.)
3.50
2.25
2.25
3.00
2.75
1.25
0.90
1.00
EP5G MECHANICAL
#1
4
PIN
#1
(Dot)
1
2
PRIMARY
P PMGD-XX
M YYWW
#2
6
1
5
2
4
3
3
.240
(6.10)
MAX
.250
(6.35)
MAX
.010
(0.25)
1
.024
(0.6)
#3
1
6
6
PRIMARY
5
EP5G/1
EP5G/1
EP5G/1
EP5G/1
EP5G/2
EP5G/2
EP5G/3
EP5G/4
EP5G SCHEMATICS
SECONDARY
6
PACKAGE/
SCHEMATIC
2
4
1
SECONDARY
PART
NUMBER
3
#4
6
.334 (8.5)
MAX
PRIMARY
.059
(1.5)
SECONDARY
SECONDARY
PRIMARY
.22
(5.6)
.043
(1.1)
.073
(1.85)
3
4
3
4
pmgd 04/03
Specifications subject to change without notice.
20381 BARENTS SEA CIRCLE, LAKE FOREST, CA 92630 • TEL: (949) 452-0511 • FAX: (949) 452-0512 • http://www.premiermag.com
112
GATE DRIVE
& BASE DRIVE
TRANSFORMERS
EP13 MECHANICALS
EP10 MECHANICALS
PIN #1
WHITE DOT
.536
(13.61)
MAX
P PMGD-XX
M YYWW
3
2
1
6
7
8
9
10
8
4
3
2
1
CORE
TAPED
EP7 MECHANICALS
.440
(11.18)
MAX
P PMGD-XX
M YYWW
5
6
3
2
1
.024
(.61)
.024
(.61)
.295
(7.49)
.098
(2.49)
4
3
2
1
5
6
7
8
.335
(8.51)
M AX
CO RES
TAP ED
P PMGD-XX
M XXXX
.400
(10.16)
M AX
.118
(3.00)
TYP
.024
SQ .
.098
(2.49)
2
.475
(12.07)
MAX
PIN # 1
W HITE D O T
.394
(10.01)
M AX
3
CORE
TAPE
.120
(3.81)
MIN
.024
(.61)
4
PIN #1
WHITE DOT
.480
(12.19)
MAX
.394
(10.00)
4
7
.530
(13.46)
MAX
.100
(2.54)
5
6
.550
(13.97)
MAX
.130
(3.3)
MIN
.024
(.61)
5
.197
(5.00)
1
.197
(5.00)
4
5
6
pmgd 04/03
Specifications subject to change without notice.
20381 BARENTS SEA CIRCLE, LAKE FOREST, CA 92630 • TEL: (949) 452-0511 • FAX: (949) 452-0512 • http://www.premiermag.com
113
SPLIT BOBBIN
HIGH ISOLATION
POWER TRANSFORMERS
Parts are UL & CSA Recognized Under UL File
Ê 115V Single -or- 115/230V Dual Primaries, 50/60Hz
Ë Low Capacitive Coupling Minimizes Line Noise
Ì Dual Secondaries May Be Series -or- Parallel Connected
Í 1.1VA To 36VA
Î 2500Vrms Isolation (Hi-Pot)
Ï Split Bobbin Construction
ELECTRICAL SPECIFICATIONS AT 25OC - OPERATING TEMPERATURE RANGE -25OC TO +80OC
PART NUMBER
SINGLE
115V
PSB-101
PSB-102
PSB-106
PSB-1012
PSB-1020
PSB-1036
PSB-121
PSB-122
PSB-126
PSB-1212
PSB-1220
PSB-1236
PSB-161
PSB-162
PSB-166
PSB-1612
PSB-1620
PSB-1636
PSB-201
PSB-202
PSB-206
PSB-2012
PSB-2020
PSB-2036
PSB-241
PSB-242
PSB-246
PSB-2412
PSB-2420
PSB-2436
DUAL
115/230V
PSB-101D
PSB-102D
PSB-106D
PSB-1012D
PSB-1020D
PSB-1036D
PSB-121D
PSB-122D
PSB-126D
PSB-1212D
PSB-1220D
PSB-1236D
PSB-161D
PSB-162D
PSB-166D
PSB-1612D
PSB-1620D
PSB-1636D
PSB-201D
PSB-202D
PSB-206D
PSB-2012D
PSB-2020D
PSB-2036D
PSB-241D
PSB-242D
PSB-246D
PSB-2412D
PSB-2420D
PSB-2436D
SIZE
(VA)
1.1
2.4
6
12
20
36
1.1
2.4
6
12
20
36
1.1
2.4
6
12
20
36
1.1
2.4
6
12
20
36
1.1
2.4
6
12
20
36
PART NUMBER
SECONDARY RMS RATINGS
SERIES
10V C.T. @ 110mA
10V C.T. @ 250mA
10V C.T. @ 600mA
10V C.T. @ 1200mA
10V C.T. @ 2000mA
10V C.T. @ 3600mA
12V C.T. @ 90mA
12V C.T. @ 200mA
12V C.T. @ 500mA
12V C.T. @ 1000mA
12V C.T. @ 1600mA
12V C.T. @ 2850mA
16V C.T. @ 70mA
16V C.T. @ 150mA
16V C.T. @ 400mA
16V C.T. @ 800mA
16V C.T. @ 1250mA
16V C.T. @ 2250mA
20V C.T. @ 55mA
20V C.T. @ 120mA
20V C.T. @ 300mA
20V C.T. @ 600mA
20V C.T. @ 1000mA
20V C.T. @ 1800mA
24V C.T. @ 45mA
24V C.T. @ 100mA
24V C.T. @ 250mA
24V C.T. @ 500mA
24V C.T. @ 800mA
24V C.T. @ 1500mA
PARALLEL
5V @ 220mA
5V @ 500mA
5V @ 1200mA
5V @ 2400mA
5V @ 4000mA
5V @ 7200mA
6V @ 180mA
6V @ 400mA
6V @ 1000mA
6V @ 2000mA
6V @ 3200mA
6V @ 5700mA
8V @ 140mA
8V @ 300mA
8V @ 800mA
8V @ 1600mA
8V @ 2500mA
8V @ 4500mA
10V @ 110mA
10V @ 240mA
10V @ 600mA
10V @ 1200mA
10V @ 2000mA
10V @ 3600mA
12V @ 90mA
12V @ 200mA
12V @ 500mA
12V @ 1000mA
12V @ 1600mA
12V @ 3000mA
SINGLE
115V
PSB-281
PSB-282
PSB-286
PSB-2812
PSB-2820
PSB-2836
PSB-361
PSB-362
PSB-366
PSB-3612
PSB-3620
PSB-3636
PSB-481
PSB-482
PSB-486
PSB-4812
PSB-4820
PSB-4836
PSB-561
PSB-562
PSB-566
PSB-5612
PSB-5620
PSB-5636
PSB-1201
PSB-1202
PSB-1206
PSB-12012
PSB-12020
PSB-12036
DUAL
115/230V
PSB-281D
PSB-282D
PSB-286D
PSB-2812D
PSB-2820D
PSB-2836D
PSB-361D
PSB-362D
PSB-366D
PSB-3612D
PSB-3620D
PSB-3636D
PSB-481D
PSB-482D
PSB-486D
PSB-4812D
PSB-4820D
PSB-4836D
PSB-561D
PSB-562D
PSB-566D
PSB-5612D
PSB-5620D
PSB-5636D
PSB-1201D
PSB-1202D
PSB-1206D
PSB-12012D
PSB-12020D
PSB-12036D
SIZE
(VA)
1.1
2.4
6
12
20
36
1.1
2.4
6
12
20
36
1.1
2.4
6
12
20
36
1.1
2.4
6
12
20
36
1.1
2.4
6
12
20
36
SECONDARY RMS RATINGS
SERIES
28V C.T. @ 40mA
28V C.T. @ 85mA
28V C.T. @ 200mA
28V C.T. @ 420mA
28V C.T. @ 700mA
28V C.T. @ 1300mA
36V C.T. @ 30mA
36V C.T. @ 65mA
36V C.T. @ 170mA
36V C.T. @ 350mA
36V C.T. @ 550mA
36V C.T. @ 1000mA
48V C.T. @ 23mA
48V C.T. @ 50mA
48V C.T. @ 125mA
48V C.T. @ 250mA
48V C.T. @ 400mA
48V C.T. @ 750mA
56V C.T. @ 20mA
56V C.T. @ 45mA
56V C.T. @ 110mA
56V C.T. @ 220mA
56V C.T. @ 350mA
56V C.T. @ 650mA
120V C.T. @ 10mA
120V C.T. @ 20mA
120V C.T. @ 50mA
120V C.T. @ 100mA
120V C.T. @ 160mA
120V C.T. @ 300mA
PARALLEL
14V @ 80mA
14V @ 170mA
14V @ 400mA
14V @ 840mA
14V @ 1400mA
14V @ 2600mA
18V @ 60mA
18V @ 130mA
18V @ 340mA
18V @ 700mA
18V @ 1100mA
18V @ 2000mA
24V @ 46mA
24V @ 100mA
24V @ 250mA
24V @ 500mA
24V @ 800mA
24V @ 1500mA
28V @ 40mA
28V @ 90mA
28V @ 220mA
28V @ 440mA
28V @ 700mA
28V @ 1300mA
60V @ 20mA
60V @ 40mA
60V @ 100mA
60V @ 200mA
60V @ 320mA
60V @ 600mA
psb 4/97
Specifications subject to change without notice.
20381 BARENTS SEA CIRCLE, LAKE FOREST, CA 92630 • TEL: (949) 452-0511 • FAX: (949) 452-0512 • http://www.premiermag.com
114
SPLIT BOBBIN
HIGH ISOLATION
POWER TRANSFORMERS
PSB-XXX MECHANICAL
W
L
P PSB-XXXX
M YYWW
1
2
3
H
4
.23
TYP
.041
A
1
B
2
A
3
SIZE
(VA)
L
1.1
2.4
6
12
20
36
1-3/8
1-3/8
1-5/8
1-7/8
2-1/4
2-5/8
6
7
C
CLEARANCE HOLES
FOR OPTIONAL (4-40 x 1-3/8)
NYLON MOUNTING SCREW
4
ML
5
.018
NOTE: PINS 2 & 3
OMITTED ON SINGLE
PRIMARY (6-PIN) VERSION
8
DIMENSIONS IN INCHES
W
H
ML
A
B
1-1/8
1-1/8
1-5/16
1-9/16
1-7/8
2-3/16
0-15/16
1-3/16
1-5/16
1-7/16
1-7/16
1-9/16
N/A
N/A
1-1/16
1-1/4
1-1/2
N/A
.250
.250
.250
.300
.300
.400
.250
.250
.350
.400
.400
.400
C
1.200
1.200
1.280
1.410
1.600
1.850
FOR INTERMEDIATE VALUES AND/ OR CUSTOM DESIGNS CONSULT THE FACTORY.
SCHEMATIC
APPLICATION
8-PIN
DUAL PRIMARY
1
PRI #1
115V
50/60Hz
6-PIN
SINGLE PRIMARY
5
SEC #1
2
6
3
7
PRI #2
115V
50/60Hz
4
5
1
PRI
115V
50/60Hz
SEC #2
8
INDICATES POLARITY
4
PSB-SERIES 6-SIZES: 1.1 TO 36VA
SEC #1
SINGLE PRIMARY: 6-PIN, 115V - 50/60Hz
6
DUAL PRIMARIES: 8-PIN PACKAGE
Series for 230V - 50/60Hz
Parallel for 115V - 50/60Hz
7
SEC #2
8
INDICATES POLARITY
psb 4/97
Specifications subject to change without notice.
20381 BARENTS SEA CIRCLE, LAKE FOREST, CA 92630 • TEL: (949) 452-0511 • FAX: (949) 452-0512 • http://www.premiermag.com
115
Parts are UL & CSA Recognized Under UL File
SHROUDED SPLIT BOBBIN
HIGH ISOLATION
POWER TRANSFORMERS
Ê 115/230V, 50/60Hz Dual Primaries
Ë Low Capacitive Coupling Minimizes Line Noise
Ì Dual Secondaries May Be Series -or- Parallel Connected
Í PVD-SERIES 6-SIZES: 2.5 TO 56VA
Î 4000Vrms Isolation (Hi-Pot)
Ï Shrouded Split Bobbin Construction
ELECTRICAL SPECIFICATIONS AT 25OC - OPERATING TEMPERATURE RANGE -25OC TO +80OC
P/N
SIZE
DUAL
(VA)
115/230V
PVD-102
2.5
PVD-105
5
PVD-1010 10
PVD-1020 20
PVD-1030 30
PVD-1056 56
10V C.T. @ .25A
10V C.T. @ .50A
10V C.T. @ 1.00A
10V C.T. @ 2.00A
10V C.T. @ 3.00A
10V C.T. @ 5.60A
5V @ .50A
5V @ 1.00A
5V @ 2.00A
5V @ 4.00A
5V @ 6.00A
5V @ 11.20A
P/N
SIZE
DUAL
(VA)
115/230V
PVD-242
2.5
PVD-245
5
PVD-2410 10
PVD-2420 20
PVD-2430 30
PVD-2456 56
SECONDARY RMS RATINGS
SERIES
PARALLEL
SECONDARY RMS RATINGS
SERIES
PARALLEL
24V C.T. @ .10A
24V C.T. @ .21A
24V C.T. @ .42A
24V C.T. @ .83A
24V C.T. @ 1.25A
24V C.T. @ 2.33A
12V @ .20A
12V @ .42A
12V @ .84A
12V @ 1.66A
12V @ 2.50A
12V @ 4.66A
PVD-122
PVD-125
PVD-1210
PVD-1220
PVD-1230
PVD-1256
2.5
5
10
20
30
56
12.6V C.T. @ .20A
12.6V C.T. @ .40A
12.6V C.T. @ .80A
12.6V C.T. @ 1.60A
12.6V C.T. @ 2.40A
12.6V C.T. @ 4.40A
6.3V @ .40A
6.3V @ .80A
6.3V @ 1.60A
6.3V @ 3.20A
6.3V @ 4.80A
6.3V @ 8.80A
PVD-282
PVD-285
PVD-2810
PVD-2820
PVD-2830
PVD-2856
2.5
5
10
20
30
56
28V C.T. @ .09A
28V C.T. @ .18A
28V C.T. @ .36A
28V C.T. @ .72A
28V C.T. @ 1.06A
28V C.T. @ 2.00A
14V @ .18A
14V @ .36A
14V @ .72A
14V @ 1.44A
14V @ 2.12A
14V @ 4.00A
PVD-162
PVD-165
PVD-1610
PVD-1620
PVD-1630
PVD-1656
2.5
5
10
20
30
56
16V C.T. @ .15A
16V C.T. @ .31A
16V C.T. @ .62A
16V C.T. @ 1.25A
16V C.T. @ 1.90A
16V C.T. @ 3.50A
8V @ .30A
8V @ .62A
8V @ 1.25A
8V @ 2.50A
8V @ 3.80A
8V @ 7.00A
PVD-362
PVD-365
PVD-3610
PVD-3620
PVD-3630
PVD-3656
2.5
5
10
20
30
56
36V C.T. @ .07A
36V C.T. @ .14A
36V C.T. @ .28A
36V C.T. @ .56A
36V C.T. @ .82A
36V C.T. @ 1.56A
18V @ .14A
18V @ .28A
18V @ .56A
18V @ 1.12A
18V @ 1.64A
18V @ 3.12A
PVD-202
PVD-205
PVD-2010
PVD-2020
PVD-2030
PVD-2056
2.5
5
10
20
30
56
20V C.T. @ .12A
20V C.T. @ .25A
20V C.T. @ .50A
20V C.T. @ 1.00A
20V C.T. @ 1.50A
20V C.T. @ 2.80A
10V @ .24A
10V @ .50A
10V @ 1.00A
10V @ 2.00A
10V @ 3.00A
10V @ 5.60A
SCHEMATIC
APPLICATION
DUAL PRIMARIES:
Series for 230V - 50/60Hz
Parallel for 115V - 50/60Hz
WHITE DOT ON BOBBIN
DENOTES PIN#1
7
1
PRI #1
115V
50/60Hz
3
9
4
10
PRI #2
115V
50/60Hz
HI-POT:
4000Vac Primary To Secondary
4000Vac Windings to Core
130OC Insulation System
SEC #1A
Note: Primary and Secondary windings
are designed to be used as one primary
& one secondary winding. That is, they
must each be used simultaneously either
parallel or series connected.
SEC #1B
6
12
INDICATES POLARITY
pvd 4/97
Specifications subject to change without notice.
20381 BARENTS SEA CIRCLE, LAKE FOREST, CA 92630 • TEL: (949) 452-0511 • FAX: (949) 452-0512 • http://www.premiermag.com
116
SHROUDED SPLIT BOBBIN
HIGH ISOLATION
POWER TRANSFORMERS
PVD-XXX MECHANICAL
L
WHITE DOT
PIN#1 I.D.
W
P PVD-XXXX
M YYWW
F
(SQ.)
1
A
3
B
4
H
6
12
.187
(4.75)
C
MIN
DxE = 4 EA THROUGH HOLES
FOR OPTIONAL (#6) MOUNTING SCREW
30 & 56 VA SIZES ONLY
6
A
E
1
3
4
6
ML -OR- D
7
SIZE
(VA)
L
W
2.5
5
10
20
30
56
1-5/8
1-5/8
1-7/8
2-1/4
2-5/8
3.000
1-5/16
1-5/16
1-9/16
1-7/8
2-3/16
2.500
9
10
ML = 2EA THROUGH HOLE
FOR OPTIONAL (#4) MOUNTING SCREW
2.5, 5, 10, 20 VA SIZES ONLY
12
NOMINAL DIMENSIONS IN INCHES
H
A
B
C
ML
D1
1.125
1.375
1.375
1.625
1.575
1.820
.200
.200
.200
.400
.550
.600
.250
.400
.400
.400
.275
.300
1.000
1.000
1.128
1.436
1.650
1.866
1-1/16
1-1/16
1-1/4
1-1/2
-----------
--------------------1-3/4
2.000
E1
F
--------------------2-3/16
2-1/2
.025
.025
.036
.036
.045
.045
NOTES:
1) 4-HOLE CORNER PATTERN
APPLIES TO 30 & 56VA SIZES ONLY
2) WHITE DOT ON TOP OF PART
DENOTES PIN#1
FOR INTERMEDIATE VALUES OR CUSTOM DESIGNS PLEASE CONSULT THE FACTORY.
pvd 4/97
Specifications subject to change without notice.
20381 BARENTS SEA CIRCLE, LAKE FOREST, CA 92630 • TEL: (949) 452-0511 • FAX: (949) 452-0512 • http://www.premiermag.com
117
LOW PROFILE DUAL
BOBBIN HIGH ISOLATION
POWER TRANSFORMERS
Ê Low Height, Ideal for P.C.B. Applications
Ë Dual Secondaries May Be Series -or- Parallel Connected
Ì Construction Minimizes Radiated Magnetic Fields
Í 115/230V, 50/60Hz Dual Primaries
Î Split Bobbin Construction
Ï 1500Vrms Isolation (Hi-Pot)
ELECTRICAL SPECIFICATIONS AT 25OC - OPERATING TEMPERATURE RANGE -25OC TO +80OC
115/230V
PART
NUMBER
PLP-102
PLP-106
PLP-1012
PLP-122
PLP-126
PLP-1212
PLP-162
PLP-166
PLP-1612
PLP-202
PLP-206
PLP-2012
PLP-242
PLP-246
PLP-2412
PLP-302
PLP-306
PLP-3012
PLP-342
PLP-346
PLP-3412
PLP-402
PLP-406
PLP-4012
PLP-562
PLP-566
PLP-5612
PLP-882
PLP-886
PLP-8812
SIZE
(VA)
2.5
6.0
12.0
2.5
6.0
12.0
2.5
6.0
12.0
2.5
6.0
12.0
2.5
6.0
12.0
2.5
6.0
12.0
2.5
6.0
12.0
2.5
6.0
12.0
2.5
6.0
12.0
2.5
6.0
12.0
115/230V SIZE
PART
(VA)
NUMBER
PLP-1024 24.0
PLP-1048 48.0
SECONDARY RMS RATINGS
SERIES
PARALLEL
10V C.T. @ 250mA
10V C.T. @ 600mA
10V C.T. @ 1200mA
12.6V C.T. @ 200mA
12.6V C.T. @ 450mA
12.6V C.T. @ 900mA
16V C.T. @ 150mA
16V C.T. @ 350mA
16V C.T. @ 700mA
20V C.T. @ 125mA
20V C.T. @ 300mA
20V C.T. @ 600mA
24V C.T. @ 100mA
24V C.T. @ 250mA
24V C.T. @ 500mA
30V C.T. @ 85mA
30V C.T. @ 200mA
30V C.T. @ 400mA
34V C.T. @ 75mA
34V C.T. @ 170mA
34V C.T. @ 340mA
40V C.T. @ 60mA
40V C.T. @ 150mA
40V C.T. @ 300mA
56V C.T. @ 45mA
56V C.T. @ 100mA
56V C.T. @ 200mA
88V C.T. @ 28mA
88V C.T. @ 65mA
88V C.T. @ 130mA
5V @ 500mA
5V @ 1.2A
5V @ 2.4A
6.3V @ 400mA
6.3V @ 900mA
6.3V @ 1.8A
8V @ 300mA
8V @ 700mA
8V @ 1.4A
10V @ 250mA
10V @ 600mA
10V @ 1.2A
12V @ 200mA
12V @ 500mA
12V @ 1.0A
15V @ 170mA
15V @ 400mA
15V @ 800mA
17V @ 150mA
17V @ 340mA
17V @ 680mA
20V @ 120mA
20V @ 300mA
20V @ 600mA
28V @ 90mA
28V @ 200mA
28V @ 400mA
44V @ 56mA
44V @ 130mA
44V @ 260mA
SECONDARY RMS RATINGS
SERIES
PARALLEL
10V C.T. @ 2.40A
10V C.T. @ 4.80A
5V @ 4.80A
5V @ 9.60A
PLP-1224
PLP-1248
24.0 12.6V C.T. @ 1.90A
48.0 12.6V C.T. @ 3.80A
6.3V @ 3.80A
6.3V @ 7.60A
PLP-1624
PLP-1648
24.0
48.0
16V C.T. @ 1.50A
16V C.T. @ 3.00A
8V @ 3.00A
8V @ 6.00A
PLP-2024
PLP-2048
24.0
48.0
20V C.T. @ 1.20A
20V C.T. @ 2.40A
10V @ 2.40A
10V @ 4.80A
PLP-2424
PLP-2448
24.0
48.0
24V C.T. @ 1.00A
24V C.T. @ 2.00A
12V @ 2.00A
12V @ 4.00A
PLP-3024
PLP-3048
24.0
48.0
30V C.T. @ 0.80A
30V C.T. @ 1.60A
15V @ 1.60A
15V @ 3.20A
PLP-3424
PLP-3448
24.0
48.0
34V C.T. @ 0.70A
34V C.T. @ 1.40A
17V @ 1.40A
17V @ 2.80A
PLP-4024
PLP-4048
24.0
48.0
40V C.T. @ 0.60A
40V C.T. @ 1.20A
20V @ 1.20A
20V @ 2.40A
PLP-5624
PLP-5648
24.0
48.0
56V C.T. @ 0.425A
56V C.T. @ 0.850A
28V @ 0.850A
28V @ 1.70A
PLP-8824
PLP-8848
24.0
48.0
88V C.T. @ 0.270A
88V C.T. @ 0.545A
44V @ 0.540A
44V @ 1.09A
SCHEMATIC
1
PRIMARY #1
115V 50/60Hz
APPLICATION
5
SEC #1
2
6
4
8
PRIMARY #2
115V 50/60Hz
3
SEC #2
7
INDICATES POLARITY
PLP-SERIES 5-SIZES:
2.5VA - 0.650" HIGH
6.0VA - 0.850" HIGH
12.0VA - 1.065" HIGH
24.0VA - 1.250" HIGH
48.0VA - 1.375" HIGH
SECONDARIES:
Connected series or parallel
PRIMARIES:
Series for 230V - 50/60Hz
Parallel for 115V - 50/60Hz
SPLIT BOBBIN:
Provides high isolation and low
capacitive couping which minimizes
line noise.
REGULATION:
2.5VA - 30%
6.0VA - 30%
12.0VA - 20%
24.0VA - 15%
48.0VA - 15%
Note: Primary and Secondary windings
are designed to be used as one primary
& one secondary winding. That is, they
must each be used simultaneously either
parallel or series connected.
plp 4/97
Specifications subject to change without notice.
20381 BARENTS SEA CIRCLE, LAKE FOREST, CA 92630 • TEL: (949) 452-0511 • FAX: (949) 452-0512 • http://www.premiermag.com
118
LOW PROFILE DUAL
BOBBIN HIGH ISOLATION
POWER TRANSFORMERS
PLP-XXX MECHANICAL
2.5 TO 12VA SIZES
W
PRIMARY #1
115V 50/60Hz
H
B
5
1
B
.25
TYP
B
.041x.020
SEC #1
2
6
4
8
PRIMARY #2
115V 50/60Hz
SEC #2
7
3
3
4
2
1
INDICATES POLARITY
A
7
8
6
L
SIZE
(VA)
2.5
6.0
12.0
5
A
1.600
1.600
2.000
DIMENSIONS IN INCHES
B
L
W
0.375
0.375
0.500
1.87
1.87
2.50
1.56
1.56
2.00
PLP-XXX MECHANICAL
5
1
PRIMARY #1
115V 50/60Hz
H
.25
TYP
B
SEC #1
2
6
4
8
PRIMARY #2
115V 50/60Hz
.041 SQ.
.600
0.650
0.850
1.065
24 & 48VA SIZES
W
.600
H
SEC #2
7
3
INDICATES POLARITY
3
4
2
1
A
7
8
6
5
L
SIZE
(VA)
24.0
48.0
A
1.900
2.180
DIMENSIONS IN INCHES
B
L
W
0.530
0.660
2.87
3.12
2.25
2.50
H
1.250
1.375
plp 4/97
Specifications subject to change without notice.
20381 BARENTS SEA CIRCLE, LAKE FOREST, CA 92630 • TEL: (949) 452-0511 • FAX: (949) 452-0512 • http://www.premiermag.com
119
TOROIDAL
POWER TRANSFORMERS
Ê
Ë
Ì
Í
Meets UL, CSA, VDE Requirements.
All Units meet 4000Vrms Hi-pot .
Available with either 115V, 50-400 Hz or 115/230V Input.
Mounting Hardware Accessory Option Available Upon Request
(Metal Washer, Silicone Rubber Pads, Plastic Washers, Screws/Nuts)
DIMENSIONS
P PT-xxxxx
M YYWW
Power
(VA)
18
36
60
100
155
200
325
440
585
690
Dimensions
(D x H)
Weight
(lbs)
2.4" x 1.4"
2.8" x 1.6"
3.2" x 1.7"
3.9" x 1.6"
4.4" x 1.6"
4.4" x 1.9"
4.4" x 2.6"
5.3" x 2.3"
5.3" x 2.8"
5.3" x 3.2"
0.7
1.1
1.5
2.8
3.7
4.2
6.2
7.5
9.0
10.3
pt-xxxxx 03/04
Specifications subject to change without notice.
20381 BARENTS SEA CIRCLE, LAKE FOREST, CA 92630 • TEL: (949) 452-0511 • FAX: (949) 452-0512 • http://www.premiermag.com
120
TOROIDAL
POWER TRANSFORMERS
ELECTRICAL SPECIFICATIONS AT 25OC
PART
NUMBER
PT-18012
PT-18018
PT-18024
PT-18030
PT-18036
PT-18044
PT-36012
PT-36018
PT-36024
PT-36030
PT-36036
PT-36044
PT-60012
PT-60018
PT-60024
PT-60030
PT-60036
PT-60044
PT-60048
PT-100018
PT-100024
PT-100030
PT-100036
PT-100044
PT-100048
PT-100056
PT-100060
PT-155024
PT-155032
PT-155036
PT-155044
PT-155048
PT-155056
PT-155060
PT-200024
PT-200030
PT-200036
PT-200044
PT-200048
PT-200056
PT-200060
18
18
18
18
18
18
36
36
36
36
36
36
60
60
60
60
60
60
60
100
100
100
100
100
100
100
100
155
155
155
155
155
155
155
200
200
200
200
200
200
200
12 @ 1.5
18 @ 1.0
24 @ 0.8
30 @ 0.6
36 @ 0.5
44 @ 0.4
12 @ 2.9
18 @ 1.9
24 @ 1.5
30 @ 1.2
36 @ 1.0
44 @ 0.8
12 @ 5.0
18 @ 3.3
24 @ 2.5
30 @ 2.0
36 @1.7
44 @ 1.4
48 @ 1.3
18 @ 5.6
24 @ 4.2
30 @ 3.3
36 @ 2.8
44 @2.3
48 @ 2.1
56 @ 1.8
60 @ 1.7
24 @ 6.5
30 @ 5.2
36 @ 4.3
44 @ 3.5
48 @ 3.2
56 @ 2.8
60 @ 2.6
24 @ 8.3
30 @ 6.7
36 @ 5.5
44 @ 4.5
48 @ 4.2
56 @ 3.6
60 @ 3.3
PART
NUMBER
DC Output
Power AC Output
Series
(VA)
V@I
Series
V@I
13.2 @ 1.0
21.0 @ 0.6
28.4 @ 0.5
36.0 @ 0.4
43.4 @ 0.3
53.4 @ 0.3
13.4 @ 1.9
20.8 @ 1.2
28.6 @ 0.9
36.4 @ 0.7
44.0 @ 0.6
54.2 @ 0.5
13.6 @ 3.2
21.4 @ 2.1
29.0 @ 1.6
36.8 @ 1.3
44.6 @ 1.1
55 @ 0.9
60.2 @ 0.8
21.4 @ 3.2
29.4 @ 2.4
37.4 @ 1.9
45.0 @ 1.7
55.2 @ 1.4
60.8 @ 1.2
71.2 @ 1.1
76.6 @ 1.0
30.0 @ 3.5
37.6 @ 3.3
46.0 @ 2.3
56.2 @ 1.9
61.2 @ 1.7
72.0 @ 1.6
77.2 @ 1.4
29.6 @ 4.5
37.6 @ 3.7
45.8 @ 3.0
56.5 @ 2.5
61.4 @ 2.3
72.4 @ 1.9
77.2 @ 1.8
Parallel
V@I
5.6 @
9.5 @
13.2 @
17.0 @
20.7 @
25.7 @
5.7 @
9.4 @
13.3 @
17.2 @
21.0 @
26.1 @
5.8 @
9.7 @
13.5 @
17.4 @
21.3 @
26.5 @
29.1 @
9.7 @
13.7 @
17.7 @
21.5 @
26.6 @
29.4 @
34.6 @
37.3 @
14.0 @
17.8 @
22.0 @
27.1 @
29.6 @
35.0 @
37.6 @
13.8 @
17.8 @
21.9 @
27.3 @
29.7 @
35.2 @
37.6 @
PT-325030
PT-325036
PT-325048
PT-325060
PT-325076
PT-440036
PT-440048
PT-440060
PT-440076
PT-585048
PT-585060
PT-585076
PT-690048
PT-690060
PT-690066
PT-690076
2.0
1.3
1.0
0.8
0.6
0.5
3.7
2.5
1.9
1.5
1.2
1.0
5.9
3.9
30
2.4
2.0
1.7
1.5
6.4
4.8
3.8
3.3
2.7
2.4
2.1
1.9
7.0
6.1
4.5
3.7
3.4
3.1
2.8
9.0
7.3
6.0
4.9
4.6
3.8
3.5
Power AC Output
Series
(VA)
V@I
325
325
325
325
325
440
440
440
440
585
585
585
690
690
690
690
30 @
36 @
48 @
60 @
76 @
36 @
48 @
60 @
76 @
48 @
60 @
76 @
48 @
60 @
66 @
76 @
10.8
9.0
6.8
5.4
4.3
12.2
9.2
7.3
5.8
12.2
9.7
7.7
14.4
11.5
11.5
9.1
DC Output
Series
V@I
38.2 @ 5.7
46.0 @ 4.6
62.0 @ 3.6
78.0 @ 2.9
99.6 @ 2.2
46.0 @ 6.1
62.2 @ 4.6
78.6 @ 3.7
100 @ 3.0
62.6 @ 6.0
78.6 @ 5.0
100 @ 3.8
63.0 @ 7.0
79.0 @ 5.5
87.4 @ 5.1
100.8@ 4.3
Parallel
V@I
18.1 @
22.0 @
30.0 @
38.0 @
48.8 @
22.0 @
30.1 @
38.3 @
49.0 @
30.3 @
38.3 @
49.2 @
30.5 @
38.5 @
42.7 @
49.4 @
11.4
9.2
7.1
5.8
4.5
12.3
9.2
7.3
5.8
11.8
9.8
7.7
14.0
11.0
10.2
8.6
pt-xxxxx 03/04
Specifications subject to change without notice.
20381 BARENTS SEA CIRCLE, LAKE FOREST, CA 92630 • TEL: (949) 452-0511 • FAX: (949) 452-0512 • http://www.premiermag.com
121
1.00 WATT MINI-SIP
DC/DC CONVERTERS
1000 Vdc Isolation
FEATURES
Ê
Ë
Ì
Í
INPUT SPECIFICATIONS
1 Watt Output
Up to 80% Efficiency
Momentary Short Circuit Protection
Miniature SIP Package
l Voltage ................................... Per Table Vdc
l Voltage Range ...................................... ±10%
l Input Filter ................................................ Cap
GENERAL SPECIFICATIONS
l
l
l
l
OUTPUT SPECIFICATIONS
Efficiency ........................................... 75% Typ.
Switching Frequency .................100KHz Typ.
Isolation Voltage .....................1000Vdc min.
Operating Temperature ..... -25OC to +80OC
l
l
l
l
Voltage ........................................... Per Table
Voltage Accuracy .................................. ±5%
Ripple & Noise 20MHz BW .............. 1% p-p
Load Regulation ................................... ±10%
ELECTRICAL SPECIFICATIONS AT 25OC - OPERATING TEMPERATURE RANGE -25OC TO 80OC
INPUT
VOLTAGE
(Vdc)
PART
NUMBER
S3AS050520
S3AD050510
S3AS051208
S3AD051204
S3AS051507
S3AD051503
S3AS120520
S3AD120510
S3AS121208
S3AD121204
OUTPUT
VOLTAGE
(Vdc)
5
5
5
5
5
5
12
12
12
12
5
+5
12
+ 12
15
+ 15
5
+5
12
+ 12
OUTPUT
CURRENT
(mA max.)
INPUT
VOLTAGE
(Vdc)
PART
NUMBER
200
+ 100
84
+ 42
66
+ 33
200
+ 100
84
+ 42
S3AS121507
S3AD121503
S3AS151507
S3AD151503
S3AS240520
S3AD240510
S3AS241208
S3AD241204
S3AS241507
S3AD241503
OUTPUT
VOLTAGE
(Vdc)
12
12
15
15
24
24
24
24
24
24
15
+ 15
15
+ 15
5
+5
12
+ 12
15
+ 15
.280
(7.11)
MAX
.770
(19.56)
MAX
DC/DC CONVERTER
P S3AXXXXXXX
M
YYWW
.015
(0.38)
1
.400
(10.16)
MAX
6
.020
(.508)
.100
(2.54)
.120
(3.05)
MIN
6
2
4
5
Specifications subject to change without notice.
2
-IN
PIN
NUMBER
1
2
3
4
5
6
6
1
+IN
4
5
6
-OUT COM +OUT
.080
(2.0)
.010
(.25)
.500
(12.70)
1
66
+ 33
66
+ 33
200
+ 100
84
+ 42
66
+ 33
SCHEMATIC
"S3A" PACKAGE
WHITE DOT
DENOTES
PIN #1
OUTPUT
CURRENT
(mA max.)
DUAL
OUTPUT
+INPUT
-INPUT
OMITTED
-Vout
0 Vout
+Vout
SINGLE
OUTPUT
+INPUT
-INPUT
OMITTED
N.C.
-Vout
+Vout
s3_1watt 10/97
20381 BARENTS SEA CIRCLE, LAKE FOREST, CA 92630 • TEL: (949) 452-0511 • FAX: (949) 452-0512 • http://www.premiermag.com
122
1.00 WATT MINI-SIP
DC/DC CONVERTERS
3K Vdc Isolation
FEATURES
Ê
Ë
Ì
Í
INPUT SPECIFICATIONS
1 Watt Output
Up to 80% Efficiency
Momentary Short Circuit Protection
Miniature SIP Package
l Voltage .................................. Per Table Vdc
l Voltage Range ...................................... ±10%
l Input Filter ................................................ Cap
GENERAL SPECIFICATIONS
l
l
l
l
OUTPUT SPECIFICATIONS
Efficiency ........................................... 70% Typ.
Switching Frequency ..................90 KHz Typ.
Isolation Voltage .....................3000Vdc min.
Operating Temperature ...... -25OC to +80OC
l
l
l
l
Voltage ........................................... Per Table
Voltage Accuracy .................................. ±5%
Ripple & Noise 20MHz BW .............. 1% p-p
Load Regulation ................................... ±10%
ELECTRICAL SPECIFICATIONS AT 25OC - OPERATING TEMPERATURE RANGE -25OC TO 80OC
INPUT
VOLTAGE
(Vdc)
PART
NUMBER
S3BS050520
S3BD050510
S3BS051208
S3BD051204
S3BS051507
S3BD051503
S3BS120520
S3BD120510
S3BS121208
OUTPUT
VOLTAGE
(Vdc)
5
5
5
5
5
5
12
12
12
OUTPUT
CURRENT
(mA max.)
5
+5
12
+ 12
15
+ 15
5
+5
12
INPUT
VOLTAGE
(Vdc)
PART
NUMBER
200
+ 100
84
+ 42
66
+ 33
200
+ 100
84
S3BD121204
S3BS121507
S3BD121503
S3BS240520
S3BD240510
S3BS241208
S3BD241204
S3BS241507
S3BD241503
12
12
12
24
24
24
24
24
24
.240
(6.10)
MAX
.770
(19.56)
MAX
P S3BXXXXXXX
M
YYWW
.015
(0.38)
7
.020
(.508)
.100
(2.54)
.600
(15.24)
2
+ 42
66
+ 33
200
+ 100
84
+ 42
66
+ 33
5
6
DC/DC CONVERTER
.400
(10.16)
MAX
1
1
+ 12
15
+ 15
5
+5
12
+ 12
15
+ 15
OUTPUT
CURRENT
(mA max.)
SCHEMATIC
"S3B" PACKAGE
WHITE DOT
DENOTES
PIN #1
OUTPUT
VOLTAGE
(Vdc)
.120
(3.05)
MIN
7
.035 +.015
(.89 + 0.05)
.010
(.25)
7
1
2
5
+IN
-IN
-OUT
PIN
NUMBER
1
2
3
4
5
6
7
DUAL
OUTPUT
+INPUT
-INPUT
OMITTED
OMITTED
-Vout
COMMON
+Vout
6
7
COM +OUT
SINGLE
OUTPUT
+INPUT
-INPUT
OMITTED
OMITTED
-Vout
N.C.
+Vout
s3_1watt 10/97
Specifications subject to change without notice.
20381 BARENTS SEA CIRCLE, LAKE FOREST, CA 92630 • TEL: (949) 452-0511 • FAX: (949) 452-0512 • http://www.premiermag.com
123
2.00 WATT MINI-SIP
DC/DC CONVERTERS
500Vdc Isolation
FEATURES
Ê
Ë
Ì
Í
INPUT SPECIFICATIONS
2 Watt Output
Up to 80% Efficiency
Momentary Short Circuit Protection
6-Pin SIP Package
l Voltage ................................... Per Table Vdc
l Voltage Range ...................................... ±10%
l Input Filter ................................................ Cap
OUTPUT SPECIFICATIONS
GENERAL SPECIFICATIONS
l
l
l
l
l
l
l
l
l
Efficiency ........................................... 70% Typ.
Switching Frequency ................. 50KHz min.
Isolation Voltage ..................... 500Vdc min.
Operating Temperature ......... 0OC to +70OC
Voltage ........................................... Per Table
Voltage Accuracy .................................. ±5%
Ripple & Noise 20MHz BW ........ 150mV p-p
Line Regulation..................... 1.2%/1% of Vin
Load Regulation ................................... ±10%
ELECTRICAL SPECIFICATIONS AT 25OC - OPERATING TEMPERATURE RANGE 0OC TO 70OC
PART
NUMBER
INPUT
VOLTAGE
(Vdc)
S3AS051217
S3AD050520
S3AD051208
S3AD051506
5
5
5
5
12
+5
+ 12
+ 15
170
+200
+85
+65
S3AD120520
S3AS120540
S3AD121208
S3AD121506
12
12
12
12
+5
5
+ 12
+ 15
+200
400
+85
+65
OUTPUT
VOLTAGE
(Vdc)
OUTPUT
CURRENT
(mA max.)
INPUT
VOLTAGE
(Vdc)
PART
NUMBER
S3AD240520
S3AD241208
S3AD241506
OUTPUT
VOLTAGE
(Vdc)
24
24
24
+5
+ 12
+ 15
.280
(7.11)
MAX
.770
(19.56)
MAX
DC/DC CONVERTER
P S3AXXXXXXX
M
YYWW
.015
(0.38)
1
.400
(10.16)
MAX
6
.020
(.508)
.100
(2.54)
.120
(3.05)
MIN
6
2
4
5
Specifications subject to change without notice.
2
-IN
PIN
NUMBER
1
2
3
4
5
6
6
1
+IN
4
5
6
-OUT COM +OUT
.080
(2.0)
.010
(.25)
.500
(12.70)
1
+200
+85
+65
SCHEMATIC
"S3" PACKAGE
WHITE DOT
DENOTES
PIN #1
OUTPUT
CURRENT
(mA max.)
DUAL
OUTPUT
+INPUT
-INPUT
OMITTED
-Vout
0 Vout
+Vout
SINGLE
OUTPUT
+INPUT
-INPUT
OMITTED
N.C.
-Vout
+Vout
s3_2watt 10/97
20381 BARENTS SEA CIRCLE, LAKE FOREST, CA 92630 • TEL: (949) 452-0511 • FAX: (949) 452-0512 • http://www.premiermag.com
124
2.00 WATT MINI-SIP
DC/DC CONVERTERS
1000Vdc Isolation
FEATURES
Ê
Ë
Ì
Í
INPUT SPECIFICATIONS
2 Watt Output
Up to 80% Efficiency
Momentary Short Circuit Protection
6-Pin SIP Package
l Voltage ................................... Per Table Vdc
l Voltage Range ...................................... ±10%
l Input Filter ................................................ Cap
OUTPUT SPECIFICATIONS
GENERAL SPECIFICATIONS
l
l
l
l
l
l
l
l
l
Efficiency ........................................... 70% Typ.
Switching Frequency ................. 50KHz min.
Isolation Voltage ................... 1000Vdc min.
Operating Temperature ......... 0OC to +70OC
Voltage ........................................... Per Table
Voltage Accuracy .................................. ±5%
Ripple & Noise 20MHz BW ........ 150mV p-p
Line Regulation..................... 1.2%/1% of Vin
Load Regulation ................................... ±10%
ELECTRICAL SPECIFICATIONS AT 25OC - OPERATING TEMPERATURE RANGE 0OC TO 70OC
PART
NUMBER
INPUT
VOLTAGE
(Vdc)
OUTPUT
VOLTAGE
(Vdc)
S4AD050520
S4AS050922
S4AD051208
S4AD051506
5
5
5
5
+ 5
9
+ 12
+ 15
+ 200
220
+ 85
+ 65
S4AD120520
S4AD121208
S4AD121506
12
12
12
+ 5
+ 12
+ 15
+ 200
+ 85
+ 65
OUTPUT
CURRENT
(mA max.)
INPUT
VOLTAGE
(Vdc)
PART
NUMBER
S4AD240520
S4AD241208
S4AD241506
S4AS241512
OUTPUT
VOLTAGE
(Vdc)
24
24
24
24
+ 5
+ 12
+ 15
15 +
+ 200
+ 85
+ 65
130
SCHEMATIC
"S4" PACKAGE
.280
(7.11)
MAX
.770
(19.56)
MAX
WHITE DOT
DENOTES
PIN #1
OUTPUT
CURRENT
(mA max.)
DC/DC CONVERTER
P S4AXXXXXXX
M
YYWW
.015
(0.38)
1
.400
(10.16)
MAX
6
.020
(.508)
.100
(2.54)
.120
(3.05)
MIN
6
1
2
4
5
PIN
NUMBER
1
2
3
4
5
6
6
Specifications subject to change without notice.
2
-IN
4
5
6
-OUT COM +OUT
.080
(2.0)
.010
(.25)
.500
(12.70)
1
+IN
DUAL
OUTPUT
+INPUT
-INPUT
OMITTED
-Vout
0 Vout
+Vout
SINGLE
OUTPUT
+INPUT
-INPUT
OMITTED
N.C.
-Vout
+Vout
s4ax 10/97
20381 BARENTS SEA CIRCLE, LAKE FOREST, CA 92630 • TEL: (949) 452-0511 • FAX: (949) 452-0512 • http://www.premiermag.com
125
1.5 & 3.0 WATT 24 PIN DIL
DC/DC CONVERTERS
500Vdc Isolation
FEATURES
INPUT SPECIFICATIONS
GENERAL SPECIFICATIONS
OUTPUT SPECIFICATIONS
Ê
Ë
Ì
Í
1.5 & 3.0 Watt Output
500Vdc Isolation
Momentary Short Circuit Protection
24-Pin DIL Package
l Voltage .................................. Per Table Vdc
l Voltage Range ..................................... ±10%
l Input Filter .......................................Pi Network
l Efficiency .....................................50% to 70%
l Switching Frequency ................. 25KHz min.
l Isolation Voltage ..................... 500Vdc min.
l Operating Temperature ..... -20OC to +70OC
l Storage Temperature.......... -55 OC to +105OC
l
l
l
l
l
Voltage ........................................... Per Table
Voltage Accuracy .................................. ±3%
Ripple & Noise 20MHz BW ......... 0.5-1%Vp-p
Line & Load Regulation ................... ±0.05%
Voltage Stability(24HR) .................... ±0.05%
ELECTRICAL SPECIFICATIONS AT 25OC - OPERATING TEMPERATURE RANGE -20OC TO +70OC
3.0 WATT DC/DC CONVERTERS
DUAL & SINGLE OUTPUTS REGULATED
1.5 WATT DC/DC CONVERTERS
DUAL & SINGLE OUTPUTS REGULATED
PART
NUMBER
INPUT
OUTPUT
OUTPUT
VOLTAGE VOLTAGE CURRENT
(Vdc+10%)
(Vdc)
(mA max.)
FULL LOAD
INPUT
(mA typ.)
PART
NUMBER
INPUT
OUTPUT
OUTPUT
VOLTAGE VOLTAGE CURRENT
(Vdc+10%)
(Vdc)
(mA max.)
FULL LOAD
INPUT
(mA typ.)
B3AS050530
B3AS051212
B3AS051510
B3AD051212
B3AD051510
5.0
5.0
5.0
5.0
5.0
5
12
15
+ 12
+ 15
300
125
100
+ 60
+ 50
540
450
440
450
440
B3AS050550
B3AS051225
B3AS051520
B3AD051225
B3AD051520
5.0
5.0
5.0
5.0
5.0
5
12
15
+ 12
+ 15
500
250
200
+ 125
+ 100
540
450
440
450
440
B3AS120530
B3AS121212
B3AS121510
B3AD121212
B3AD121510
12.0
12.0
12.0
12.0
12.0
5
12
15
+ 12
+ 15
300
125
100
+ 60
+ 50
195
190
190
190
190
B3AS120550
B3AS121225
B3AS121520
B3AD121225
B3AD121520
12.0
12.0
12.0
12.0
12.0
5
12
15
+ 12
+ 15
500
250
200
+ 125
+ 100
195
190
190
190
190
B3AS240530
B3AS241212
B3AS241510
B3AD241212
B3AD241510
B3AS280530
B3AS281212
B3AS281510
B3AD281212
B3AD281510
24.0
24.0
24.0
24.0
24.0
28.0
28.0
28.0
28.0
28.0
5
12
15
+ 12
+ 15
5
12
15
+ 12
+ 15
300
125
100
+ 60
+ 50
300
125
100
+ 60
+ 50
95
90
90
90
90
95
90
90
90
90
B3AS480530
B3AS481212
B3AS481510
B3AD481212
B3AD481510
48.0
48.0
48.0
48.0
48.0
5
12
15
+ 12
+ 15
300
125
100
+ 60
+ 50
52
47
47
47
47
B3AS240550
B3AS241225
B3AS241520
B3AD241225
B3AD241520
B3AS280550
B3AS281225
B3AS281520
B3AD281225
B3AD281520
B3AS480550
B3AS481225
B3AS481520
B3AD480560
B3AD481225
B3AD481520
24.0
24.0
24.0
24.0
24.0
28.0
28.0
28.0
28.0
28.0
48.0
48.0
48.0
48.0
48.0
48.0
5
12
15
+ 12
+ 15
5
12
15
+ 12
+ 15
5
12
15
+5
+ 12
+ 15
500
250
200
+ 125
+ 100
500
250
200
+ 125
+ 100
500
250
200
+ 300
+ 125
+ 100
95
90
90
90
90
95
90
90
90
90
52
47
47
52
47
47
B3AS-AD watt 08/08/03
Specifications subject to change without notice.
20381 BARENTS SEA CIRCLE, LAKE FOREST, CA 92630 • TEL: (949) 452-0511 • FAX: (949) 452-0512 • http://www.premiermag.com
126
1.5 & 3.0 WATT 24 PIN DIL
DC/DC CONVERTERS
SCHEMATIC (DUAL)
SCHEMATIC (SINGLE)
+Vin
24
NC
23
+Vin -Vout Com
-Vout +Vout -Vin
NC
22
15
14
24
13
23
1
2
3
NC
NC
15
14
13
10
11
12
DC to DC CONVERTER
DC to DC CONVERTER
+Vin
Com +Vout -Vin
22
10
11
1
12
-Vout +Vout -Vin
2
3
+Vin -Vout Com
Com +Vout -Vin
PIN ASSIGNMENTS
B3 PACKAGE
1.250
(31.75)
MAX
.800
(20.32)
MAX
.420
(10.67)
MAX
.150
(3.81)
TYP
.020 Dia.
(0.51)
TYP.
1.100
(27.94)
TYP
.100
(2.54)
TYP
.600
(15.24)
PIN
NUMBER
1
2
3
10
11
12
13
14
15
22
23
24
SINGLE
OUTPUT
+INPUT
NC
NC
-OUTPUT
+OUTPUT
-INPUT
-INPUT
+OUTPUT
-OUTPUT
NC
NC
+INPUT
DUAL
OUTPUT
+INPUT
-OUTPUT
COMMON
COMMON
+OUTPUT
-INPUT
-INPUT
+OUTPUT
COMMON
COMMON
-OUTPUT
+INPUT
B3AS-AD watt 08/08/03
Specifications subject to change without notice.
20381 BARENTS SEA CIRCLE, LAKE FOREST, CA 92630 • TEL: (949) 452-0511 • FAX: (949) 452-0512 • http://www.premiermag.com
127
1.0 & 2.25 WATT 24 PIN DIL
DC/DC CONVERTERS
500Vdc Isolation
FEATURES
INPUT SPECIFICATIONS
GENERAL SPECIFICATIONS
OUTPUT SPECIFICATIONS
Ê
Ë
Ì
Í
1.0 & 2.25 Watt Output
Regulated & Unregulated Models
Short Circuit Protection
24-Pin DIL Package
l Voltage .................................. Per Table Vdc
l Voltage Range ..................................... ±10%
l Input Filter .......................................Pi Network
l Efficiency (unregulated)........................ 70%
l Efficiency (regulated)............................. 50%
l Switching Frequency ................. 20KHz min.
l Isolation Voltage ..................... 500Vdc min.
l Operating Temperature ........0OC to +70OC
l
l
l
l
l
Voltage .............................................. 9.0 Vdc
Voltage Accuracy .................................. ±5%
Ripple & Noise 20MHz BW ......... 100mVp-p
Load Regulation (unregulated)........... ±6%
Load Regulation (regulated)................ ±5%
ELECTRICAL SPECIFICATIONS AT 25OC - OPERATING TEMPERATURE RANGE 0OC TO +70OC
PART
NUMBER
INPUT
VOLTAGE
(Vdc)
OUTPUT
VOLTAGE
(Vdc)
OUTPUT
CURRENT
(mA max.)
REGULATED
OUTPUT
B2AU050920
B2AU050921(*)
B2AU050925
B2AU050926 (*)
B2AU120920
B2AU120925
B2AR050920
B2AR050925
B2AR120920
B2AR120925
5
5
5
5
12
12
5
5
12
12
9
9
9
9
9
9
9
9
9
9
200
200
250
250
200
250
200
250
200
250
NO
NO
NO
NO
NO
NO
YES
YES
YES
YES
INPUT CURRENT (mA typ.)
NO LOAD
FULL LOAD
100
100
100
100
40
40
120
120
50
50
575
575
625
625
200
250
720
750
320
350
NOTE: (*) B2AU050921: MAY USE B2AU050920 AND REMOVE PIN #2-9, 16-23.
B2AU050926: MAY USE B2AU050925 AND REMOVE PIN #2-9, 16-23.
SCHEMATIC
PACKAGE
1.280
(32.51)
MAX.
.585
(14.86)
MAX.
.475
(12.07)
MAX.
.008 R
(0.20)
TYP.
.180
(4.57)
TYP.
.020
(0.51)
TYP.
.050
(1.27)
TYP.
.125
(3.18)
MIN.
.100
(2.54)
TYP.
.010
(0.25)
TYP.
.600
(15.24)
.030 (.51)
.010 (.25)
.635
(16.13)
MAX.
+ V in
24
-V o u t + V o u t -V in
23
22
21
20
19
18
17
16
8
9
15
14
13
10
11
12
D C to D C C O N V E RTER
1
+ V in
2
3
5
6
7
-V o u t + V o u t -V in
B2AX 08/08/03
Specifications subject to change without notice.
20381 BARENTS SEA CIRCLE, LAKE FOREST, CA 92630 • TEL: (949) 452-0511 • FAX: (949) 452-0512 • http://www.premiermag.com
128
2.2 WATT 2:1WIDE INPUT RANGE
DC/DC POWER MODULES
INPUT SPECIFICATIONS
FEATURES
Ê
Ë
Ì
Í
º
l Voltage ............................... 5, 12, 24,48 Vdc
l Voltage Range ...4.5-9,9-18,18-36,36-72Vdc
l Input Filter ........................................... Pi Type
2.2 Watt Isolated Output
2:1 Wide Input Range
High Conversion Efficiency
Continuous Short Circuit Protection
Regulate Output
OUTPUT SPECIFICATIONS
l
l
l
l
l
Voltage ........................................... Per Table
Initial Voltage Accuracy ................ ±2% Max
Voltage Stability ......................... ±0.05% max
Ripple & Noise 20MHz BW .......... 50mV p-p
Load Regulation (10 to 100% Load)
Single Output Units:
±0.5%
Dual Output Units:
±1.0%
l Line Regulation .......................... ±0.3% Typ.
GENERAL SPECIFICATIONS
l
l
l
l
l
Efficiency ...................................... Per Table
Operating Frequency ............... 100KHz Typ.
Isolation Voltage: ................... 1000 Vdc Min.
Operating Temperature ........ -40 to +85OC
Case Material:
1000Vdc.......Non-Conductive Black Plastic
PIN ASSIGNMENTS
PACKAGE
2000VDC & 4000VDC
1000VDC
P PDCx03xxxx
YYWW
M
1.25
(31.8)
.40
(10.2)
.10
(2.5)
.20
(5.1)
1
2
3
5
9 10 11 12
.15
(3.8)
.08
(2.0)
PIN
#
SINGLE
OUTPUT
DUAL
OUTPUTS
PIN
#
SINGLE
OUTPUT
DUAL
OUTPUTS
1
2
3
5
9
10
11
12
13
14
15
16
22
23
24
+ INPUT
NC
NC
NP
NP
- OUTPUT
+ OUTPUT
- INPUT
- INPUT
+ OUTPUT
- OUTPUT
NP
NC
NC
+ INPUT
+INPUT
- OUTPUT
COMMON
NP
NP
COMMON
+ OUTPUT
- INPUT
- INPUT
+ OUTPUT
COMON
NP
COMMON
- OUTPUT
+ INPUT
1
2
3
5
9
10
11
12
13
14
15
16
22
23
24
NP
- INPUT
- INPUT
NP
NC
NC
NC
NP
NP
+ OUTPUT
NC
- OUTPUT
+ INPUT
+ INPUT
NP
NP
- INPUT
- INPUT
NP
COMMON
NC
- OUTPUT
NP
NP
+ OUTPUT
NC
COMMON
+ INPUT
+ INPUT
NP
.60
.80
(15.24) (20.3)
24 23 22
NP* - NO PIN
NC* - NO CONNECTION WITH PIN
16 15 14 13
pm-xxxx 2/00
Specifications subject to change without notice.
20381 BARENTS SEA CIRCLE, LAKE FOREST, CA 92630 • TEL: (949) 452-0511 • FAX: (949) 452-0512 • http://www.premiermag.com
129
2.2 WATT 2:1WIDE INPUT RANGE
DC/DC POWER MODULES
ELECTRICAL SPECIFICATIONS AT 25OC - OPERATING TEMPERATURE RANGE -40OC TO +80OC
PART
NUMBER
(SINGLE OUTPUT)
OUTPUT OUTPUT
INPUT
VOLTAGE VOLTAGE CURRENT
(Vdc)
(Vdc)
(mA max.)
PART
NUMBER
%EFF
(DUAL OUTPUT)
OUTPUT OUTPUT
INPUT
VOLTAGE VOLTAGE CURRENT
(Vdc)
(Vdc)
(mA max.)
%EFF
PDCS03071
PDCS03072
PDCS03073
PDCS03074
PDCS03075
5
5
5
5
5
3.3
5
9
12
15
600
440
244
183
147
70
72
74
77
78
PDCD03072
PDCD03073
PDCD03074
PDCD03075
5
5
5
5
±5
±9
±12
±15
±220
±122
±92
±74
70
72
74
78
PDCS03076
PDCS03077
PDCS03078
PDCS03079
PDCS03080
12
12
12
12
12
3.3
5
9
12
15
600
440
244
183
147
74
78
81
83
84
PDCD03077
PDCD03078
PDCD03079
PDCD03080
12
12
12
12
±5
±9
±12
±15
±220
±122
±92
±74
78
81
83
84
PDCS03081
PDCS03082
PDCS03083
PDCS03084
PDCS03085
24
24
24
24
24
3.3
5
9
12
15
600
440
244
183
147
76
79
82
84
85
PDCD03082
PDCD03083
PDCD03084
PDCD03085
24
24
24
24
±5
±9
±12
±15
±220
±122
±92
±74
79
82
84
85
PDCS03086
PDCS03087
PDCS03088
PDCS03089
PDCS03090
48
48
48
48
48
3.3
5
9
12
15
600
440
244
183
147
78
80
83
85
85
PDCD03087
PDCD03088
PDCD03089
PDCD03090
48
48
48
48
±5
±9
±12
±15
±220
±122
±92
±74
80
83
85
85
NOTE #1:
PDCx030xx_ : BLANK FOR STANDARD PART WITH ISOLATION = 1000VDC
PDCx030xxN : ADD "N" FOR PART WITH ISOLATION = 2000VDC
PDCx030xxS : ADD "S" FOR PART WITH ISOLATION = 4000VDC
pm-xxxx 2/00
Specifications subject to change without notice.
20381 BARENTS SEA CIRCLE, LAKE FOREST, CA 92630 • TEL: (949) 452-0511 • FAX: (949) 452-0512 • http://www.premiermag.com
130
3.0 WATT 2:1WIDE INPUT RANGE
DC/DC POWER MODULES
INPUT SPECIFICATIONS
FEATURES
Ê
Ë
Ì
Í
º
l Voltage ................................. 5, 12, 24,48 Vdc
l Voltage Range ...4.5-6,9-18,18-36,36-72Vdc
l Input Filter ........................................... Pi Type
3.0 Watt Isolated Output
2:1 Wide Input Range
High Conversion Efficiency
Continuous Short Circuit Protection
Regulate Output
OUTPUT SPECIFICATIONS
l
l
l
l
l
Voltage ........................................... Per Table
Initial Voltage Accuracy ................ ±2% Max
Voltage Stability ......................... ±0.05% max
Ripple & Noise .................... 100/150mV p-p
Load Regulation (10 to 100% Load)
Single Output Units:
±0.5%
Dual Output Units:
±1.0%
l Line Regulation ........................... ±0.5% typ.
l Temp Coefficient ...................... ±0.05% /OC
l Short Circuit Protection ........... Continuous
GENERAL SPECIFICATIONS
l
l
l
l
Efficiency ...................................... Per Table
Switching Frequency ............... 100KHz Min.
Isolation Voltage: ..................... 500 Vdc Min.
Operating Temperature ...... -25 OC to +71OC
Derate Linear to No Load @ 100OC Max.
l Case Material:
500Vdc.......Non-Conductive Black Plastic
1.5kVdc & 3kVdc.....Black Coated Copper
With Non-Conductive Base
PIN ASSIGNMENTS
PACKAGE
1500VDC & 3000VDC
500VDC
P PDCx03xxxx
YYWW
M
1.25
(31.8)
.40
(10.2)
.10
(2.5)
.20
(5.1)
1
2
3
9
10 11 12
.15
(3.8)
.08
(2.0)
PIN
#
SINGLE
OUTPUT
DUAL
OUTPUTS
PIN
#
SINGLE
OUTPUT
DUAL
OUTPUTS
1
2
3
9
10
11
12
13
14
15
16
22
23
24
+ INPUT
NC
NC
NP
- OUTPUT
+ OUTPUT
- INPUT
- INPUT
+ OUTPUT
- OUTPUT
NP
NC
NC
+ INPUT
+INPUT
- OUTPUT
COMMON
NP
COMMON
+ OUTPUT
- INPUT
- INPUT
+ OUTPUT
COMON
NP
COMMON
- OUTPUT
+ INPUT
1
2
3
9
10
11
12
13
14
15
16
22
23
24
NP
- INPUT
- INPUT
NC
NC
NC
NP
NP
+ OUTPUT
NC
- OUTPUT
+ INPUT
+ INPUT
NP
NP
- INPUT
- INPUT
COMMON
NC
- OUTPUT
NP
NP
+ OUTPUT
NC
COMMON
+ INPUT
+ INPUT
NP
NP* - NO PIN
NC* - NO CONNECTION WITH PIN
.60
.80
(15.24) (20.3)
24 23 22
16 15 14 13
PDCx0300x 12/00
Specifications subject to change without notice.
20381 BARENTS SEA CIRCLE, LAKE FOREST, CA 92630 • TEL: (949) 452-0511 • FAX: (949) 452-0512 • http://www.premiermag.com
131
3.0 WATT 2:1 WIDE INPUT RANGE
DC/DC POWER MODULES
ELECTRICAL SPECIFICATIONS AT 25OC - OPERATING TEMPERATURE RANGE -25OC TO +75OC
PART
NUMBER
INPUT VOLTAGE
NOMINAL
RANGE
OUTPUT
VOLTAGE
(Vdc)
OUTPUT
CURRENT
(mAdc)
PDCS03001
PDCS03002
PDCS03003
PDCS03004
5
5
5
5
4.5-6.0
4.5-6.0
4.5-6.0
4.5-6.0
3.3
5
12
15
600
600
250
200
PDCD03002
PDCD03003
PDCD03004
5
5
5
4.5-6.0
4.5-6.0
4.5-6.0
±5
±12
±15
±300
±125
±100
PDCS03005
PDCS03006
PDCS03007
PDCS03008
12
12
12
12
9-18
9-18
9-18
9-18
3.3
5
12
15
600
600
250
200
PDCD03006
PDCD03007
PDCD03008
12
12
12
9-18
9-18
9-18
±5
±12
±15
±300
±125
±100
PDCS03009
PDCS03010
PDCS03011
PDCS03012
24
24
24
24
18-36
18-36
18-36
18-36
3.3
5
12
15
600
600
250
200
PDCD03010
PDCD03011
PDCD03012
24
24
24
18-36
18-36
18-36
±5
±12
±15
±300
±125
±100
PDCS03013
PDCS03014
PDCS03015
PDCS03016
48
48
48
48
36-72
36-72
36-72
36-72
3.3
5
12
15
PDCD03014
PDCD03015
PDCD03016
48
48
48
36-72
36-72
36-72
±5
±12
±15
INPUT
CURRENT
NO LOAD
FULL LOAD
mA
mA
TYPICAL
EFFICIENCY
15
15
15
15
650
850
800
800
61 %
70 %
75 %
75 %
25
25
25
850
800
800
70 %
75 %
75 %
254
340
320
320
65 %
73 %
78 %
78 %
12
12
12
340
320
320
73 %
78 %
78 %
5
5
5
5
125
168
156
156
66 %
74 %
80 %
80 %
7.5
7.5
7.5
168
156
156
74 %
80 %
80 %
600
600
250
200
3
2
2
2
61
82
78
78
68 %
76 %
80 %
80 %
±300
±125
±100
3
3
3
82
80
80
76 %
78 %
78 %
7.5
7.5
7.5
7.5
NOTE:
PDCx030xx_ : BLANK FOR STANDARD PART WITH ISOLATION = 500VDC
PDCx030xxK : ADD "K" FOR PART WITH ISOLATION = 1500VDC
PDCx030xxQ : ADD "Q" FOR PART WITH ISOLATION = 3000VDC
PDCx0300x 12/00
Specifications subject to change without notice.
20381 BARENTS SEA CIRCLE, LAKE FOREST, CA 92630 • TEL: (949) 452-0511 • FAX: (949) 452-0512 • http://www.premiermag.com
132
3.0 WATT 2:1WIDE INPUT RANGE
DC/DC POWER MODULES
ELECTRICAL SPECIFICATIONS AT 25OC - OPERATING TEMPERATURE RANGE -25OC TO +75OC
PART
NUMBER
INPUT VOLTAGE
NOMINAL
RANGE
OUTPUT
VOLTAGE
(Vdc)
OUTPUT
CURRENT
(mAdc)
PDCS03017
PDCS03018
PDCS03019
PDCS03020
5
5
5
5
4.5-6.0
4.5-6.0
4.5-6.0
4.5-6.0
3.3
5
12
15
600
600
250
200
PDCD03018
PDCD03019
PDCD03020
5
5
5
4.5-6.0
4.5-6.0
4.5-6.0
±5
±12
±15
±300
±125
±100
INPUT
CURRENT
NO LOAD
FULL LOAD
mA
mA
TYPICAL
EFFICIENCY
15
15
15
15
600
850
800
800
70 %
70 %
75 %
75 %
25
25
25
850
800
800
70 %
75 %
75 %
NOTE:
PDCx030xx_ : BLANK FOR STANDARD PART WITH ISOLATION = 500VDC
P PDCx03xxxx
YYWW
M
500VDC
1 .2 5
(3 1 .8 )
.5 0
(1 0 .2 )
.1 5
(3 .8 )
.1 0
(2 .5 )
1
2
3
10 11
12
.0 8
(2 .0 )
.6 0
(1 5 .2 4 )
24
23
22
15 14
.8 0
(2 0 .3 )
PIN
#
SINGLE
OUTPUT
DUAL
OUTPUTS
1
2
3
+ INPUT
NC
NC
+INPUT
+INPUT
NC
10
11
12
NC
- OUTPUT
- OUTPUT
NC
COMMON
COMMON
13
14
15
NC
- OUTPUT
+ OUTPUT NC
+ OUTPUT + OUTPUT
22
23
24
NC
- INPUT
- INPUT
NC
- INPUT
- INPUT
13
NC* - NO CONNECTION WITH PIN
PDCx0300x 12/00
Specifications subject to change without notice.
20381 BARENTS SEA CIRCLE, LAKE FOREST, CA 92630 • TEL: (949) 452-0511 • FAX: (949) 452-0512 • http://www.premiermag.com
133
3.0 WATT 2:1 WIDE INPUT RANGE
DC/DC POWER MODULES
Extended Temperature
INPUT SPECIFICATIONS
FEATURES
l Voltage .................................5,12, 24, 48 Vdc
l Voltage Range.. 4.5-9,9-18,18-36, 36-72Vdc
l Input Filter ........................................... Pi Type
Ê
Ë
Ì
Í
3.0 Watt Isolated Output
2:1 Wide Input Range
Continuous Short Circuit Protection
Extended Temperature
l
l
l
l
l
Efficiency ...................................... Per Table
Operating Frequency ............... 50KHz Min.
Isolation Voltage: ..................... 500 Vdc Min.
Operating Temperature ...... -40OC to +80OC
Efficiency ..................................... Up to 80%
OUTPUT SPECIFICATIONS
GENERAL SPECIFICATIONS
l Voltage ........................................... Per Table
l Voltage Stability ......................... ±0.05% max
l Ripple & Noise Vout = 5~9V....... 100mV p-p
Vout = 12~15V.................... 1% of Vout
l Load Regulation ......................... ±0.2% typ.
l Line Regulation ........................... ±0.1% typ.
ELECTRICAL SPECIFICATIONS AT 25OC - OPERATING TEMPERATURE RANGE -40OC TO +80OC
PART
NUMBER
(SINGLE OUTPUT)
OUTPUT OUTPUT
INPUT
VOLTAGE VOLTAGE CURRENT
(Vdc)
(Vdc)
(mA max.)
PART
NUMBER
%EFF
(DUAL OUTPUT)
OUTPUT OUTPUT
INPUT
VOLTAGE VOLTAGE CURRENT
(Vdc)
(Vdc)
(mA max.)
%EFF
PDCS03051
PDCS03052
PDCS03053
PDCS03054
5
5
5
5
5
9
12
15
600
333
250
200
65
70
72
73
PDCD03051
PDCD03052
PDCD03053
PDCD03054
5
5
5
5
±5
±9
±12
±15
±300
±167
±125
±100
65
70
71
72
PDCS03056
PDCS03057
PDCS03058
PDCS03059
12
12
12
12
5
9
12
15
600
333
250
200
66
75
77
75
PDCD03056
PDCD03057
PDCD03058
PDCD03059
12
12
12
12
±5
±9
±12
±15
±300
±167
±125
±100
65
74
71
75
PDCS03061
PDCS03062
PDCS03063
PDCS03064
24
24
24
24
5
9
12
15
600
333
250
200
78
79
80
80
PDCD03061
PDCD03062
PDCD03063
PDCD03064
24
24
24
24
±5
±9
±12
±15
±300
±167
±125
±100
80
75
79
80
PDCS03066
PDCS03067
PDCS03068
PDCS03069
48
48
48
48
5
9
12
15
600
333
250
200
72
75
76
80
PDCD03066
PDCD03067
PDCD03068
PDCD03069
48
48
48
48
±5
±9
±12
±15
±300
±167
±125
±100
77
75
74
76
PIN ASSIGNMENTS
PACKAGE
1
23
2
22
3
.10
(2.5)
1.25
(31.8)
.70
(17.78)
15
10
14
11
13
12
.60
(15.24)
.80
(20.3)
.15
(3.8)
P PDCx03xxxx
M YYWW
24
.50
(12.7)
PIN
#
1
2
3
10
11
12
13
14
15
22
23
24
500 VDC
DUAL
SINGLE
OUTPUT OUTPUTS
+INPUT
NP
NP
-OUTPUT
+OUTPUT
- INPUT
- INPUT
+OUTPUT
-OUTPUT
NP
NP
+INPUT
+INPUT
- OUTPUT
COMMON
COMMON
+OUTPUT
- INPUT
- INPUT
+OUTPUT
COMMON
COMMON
-OUTPUT
+INPUT
*NP-NO PIN
*NC-NO CONNECTION WITH PIN
Specifications subject to change without notice.
PDCx0305x 12/00
20381 BARENTS SEA CIRCLE, LAKE FOREST, CA 92630 • TEL: (949) 452-0511 • FAX: (949) 452-0512 • http://www.premiermag.com
134
3.0 WATT 2:1 WIDE INPUT RANGE
DC/DC POWER MODULES
With Remote On/Off Option
FEATURES
Ê
Ë
Ì
Í
º
INPUT SPECIFICATIONS
3.0 Watt Isolated Output
2:1 Wide Input Range
High Conversion Efficiency
Continuous Short Circuit Protection
Remote ON/OFF Option
l Voltage ....................................12, 24, 48 Vdc
l Voltage Range .........9-18, 18-36 & 36-72Vdc
l Input Filter ........................................... Pi Type
OUTPUT SPECIFICATIONS
GENERAL SPECIFICATIONS
l
l
l
l
l
Voltage ........................................... Per Table
Initial Voltage Accuracy ................ ±2% Max
Voltage Stability ......................... ±0.05% max
Ripple & Noise .................... 100/150mV p-p
Load Regulation (10 to 100% Load)
Single Output Units:
±0.5%
Dual Output Units:
±1.0%
l Line Regulation ........................... ±0.5% typ.
l Temp Coefficient ...................... ±0.05% /OC
l Short Circuit Protection ........... Continuous
l
l
l
l
Efficiency ...................................... Per Table
Switching Frequency ............... 100KHz Min.
Isolation Voltage: ..................... 500 Vdc Min.
Operating Temperature ..... -25OC to +75OC
Derate Linear to no load @ 100OC max.
l Case Material:
500Vdc.......Non-Conductive Black Plastic
1.5kVdc & 3kVdc.....Black Coated Copper
With Non-Conductive Base
l EMI/RFI........................Conductive EMI Meets
EN55022 Class B
PIN ASSIGNMENTS
PACKAGE
REMOTE ON/OFF CONTROL
Logic
Ec-On
Ec-Off
Shutdown Idle Current
Input Resistance
Control Common
P PDCx03xxxx
YYWW
M
CMOS or Open Collector TTL
>+5.5VDC or Open Circuit
<1.8VDC
10mA
100 Ohm
Referenced to Input Minus
1500VDC & 3000VDC
500VDC
1.25
(31.8)
.50
(12.7)
.10
(2.5)
.20
(5.1)
1 2 3
5
9 10 11 12
.15
(3.8)
.08
(2.0)
.60
.80
(15.24) (20.3)
24 23 22
16 15 14 13
PIN
#
SINGLE
OUTPUT
DUAL
OUTPUTS
PIN
#
SINGLE
OUTPUT
DUAL
OUTPUTS
1
2
3
5
9
10
11
12
13
14
15
16
22
23
24
+ INPUT
NC
NC
NP
NP
- OUTPUT
+ OUTPUT
- INPUT
- INPUT
+ OUTPUT
- OUTPUT
NP
NC
NC
+ INPUT
+INPUT
- OUTPUT
COMMON
NP
NP
COMMON
+ OUTPUT
- INPUT
- INPUT
+ OUTPUT
COMON
NP
COMMON
- OUTPUT
+ INPUT
1
2
3
5
9
10
11
12
13
14
15
16
22
23
24
NP
- INPUT
- INPUT
NP
NC
NC
NC
NP
NP
+ OUTPUT
NC
- OUTPUT
+ INPUT
+ INPUT
NP
NP
- INPUT
- INPUT
R.ON/OFF
COMMON
NC
- OUTPUT
NP
NP
+ OUTPUT
NC
COMMON
+ INPUT
+ INPUT
NP
PDCx0302x 12/00
Specifications subject to change without notice.
20381 BARENTS SEA CIRCLE, LAKE FOREST, CA 92630 • TEL: (949) 452-0511 • FAX: (949) 452-0512 • http://www.premiermag.com
135
3.0 WATT 2:1 WIDE INPUT RANGE
DC/DC POWER MODULES
With Remote On/Off Option
ELECTRICAL SPECIFICATIONS AT 25OC - OPERATING TEMPERATURE RANGE -25OC TO +75OC
PART
NUMBER
(NOTE #1)
INPUT VOLTAGE OUTPUT
Previous
VOLTAGE
Premier Magnetic
NOMINAL RANGE
(Vdc)
Part # (NOTE #2)
OUTPUT
CURRENT
(mAdc)
INPUT
CURRENT
NO LOAD
FULL LOAD
mA
mA
TYPICAL
EFFICIENCY
PDCS03021
PDCS03022
PDCS03023
PDCS03024
B5AS1203NX
B5AS1205NX
B5AS1212NX
B5AS1215NX
12
12
12
12
9-18
9-18
9-18
9-18
3.3
5
12
15
600
600
250
200
7.5
7.5
7.5
7.5
226
340
320
330
73 %
73 %
78 %
76 %
PDCD03022
PDCD03023
PDCD03024
B5AD1205NX
B5AD1212NX
B5AD1215NX
12
12
12
9-18
9-18
9-18
±5
±12
±15
±300
±125
±100
12
12
12
340
330
330
73 %
76 %
75 %
PDCS03025
PDCS03026
PDCS03027
PDCS03028
B5AS2403NX
B5AS2405NX
B5AS2412NX
B5AS2415NX
24
24
24
24
18-36
18-36
18-36
18-36
3.3
5
12
15
600
600
250
200
5
5
5
5
113
168
156
156
73 %
74 %
80 %
80 %
PDCD03026
PDCD03027
PDCD03028
B5AD2405NX
B5AD2412NX
B5AD2415NX
24
24
24
18-36
18-36
18-36
±5
±12
±15
±300
±125
±100
7.5
7.5
7.5
168
156
160
74 %
80 %
80 %
PDCS03029
PDCS03030
PDCS03031
PDCS03032
B5AS4803NX
B5AS4805NX
B5AS4812NX
B5AS4815NX
48
48
48
48
36-72
36-72
36-72
36-72
3.3
5
12
15
600
600
250
200
3
2
2
2
55
82
82
82
76 %
76 %
77 %
77 %
PDCD03030
PDCD03031
PDCD03032
B5AD4805NX
B5AD4812NX
B5AD4815NX
48
48
48
36-72
36-72
36-72
±5
±12
±15
±300
±125
±100
3
3
3
82
82
82
76 %
76 %
76 %
NOTE #1:
PDCx030xx_ : BLANK FOR STANDARD PART WITH ISOLATION = 500VDC
PDCx030xxK : ADD "K" FOR PART WITH ISOLATION = 1500VDC
PDCx030xxQ : ADD "Q" FOR PART WITH ISOLATION = 3000VDC
PDCx030xxR : ADD "R" FOR PART WITH ISOLATION = 3000VDC AND REMOTE ON/OFF
NOTE #2: (FOR PREVIOUS PREMIER MAGNETICS PART #)
B5AXXXXXNX : FOR STANDARD PART WITH ISOLATION = 500VDC
B5AXXXXXNM : FOR PART WITH ISOLATION = 1500VDC
B5AXXXXXNT : FOR PART WITH ISOLATION = 3000VDC
B5AXXXXXYT : FOR PART WITH ISOLATION = 3000VDC AND REMOTE ON/OFF
PDCx0302x 12/00
Specifications subject to change without notice.
20381 BARENTS SEA CIRCLE, LAKE FOREST, CA 92630 • TEL: (949) 452-0511 • FAX: (949) 452-0512 • http://www.premiermag.com
136
3.0 WATT 4:1WIDE INPUT RANGE
DC/DC POWER MODULES
INPUT SPECIFICATIONS
FEATURES
Ê
Ë
Ì
Í
º
l Voltage ........................................ 24,48 Vdc
l Voltage Range ..................... 9-36,18-72Vdc
l Input Filter ........................................... Pi Type
3.0 Watt Isolated Output
4:1 Wide Input Range
High Conversion Efficiency
Continuous Short Circuit Protection
Regulate Output
OUTPUT SPECIFICATIONS
l
l
l
l
l
Voltage ........................................... Per Table
Initial Voltage Accuracy ................ ±2% Max
Voltage Stability ......................... ±0.05% max
Ripple & Noise .................... 100/150mV p-p
Load Regulation (10 to 100% Load)
Single Output Units:
±0.5%
Dual Output Units:
±1.0%
l Line Regulation ........................... ±0.5% typ.
l Temp Coefficient ...................... ±0.05% /OC
l Short Circuit Protection ........... Continuous
GENERAL SPECIFICATIONS
l
l
l
l
Efficiency ...................................... Per Table
Switching Frequency ............... 100KHz Min.
Isolation Voltage: ..................... 500 Vdc Min.
Operating Temperature ..... -25OC to +71OC
Derate Linear to No Load @ 100OC Max.
l Case Material:
500Vdc.......Non-Conductive Black Plastic
1.5kVdc & 3kVdc.....Black Coated Copper
With Non-Conductive Base
PIN ASSIGNMENTS
PACKAGE
1.25
(31.8)
.40
(10.2)
.10
(2.5)
.20
(5.1)
1
2
3
5
9
1500VDC & 3000VDC
500VDC
P PDCx03xxxx
YYWW
M
10 11 12
.15
(3.8)
.08
(2.0)
PIN
#
SINGLE
OUTPUT
DUAL
OUTPUTS
PIN
#
SINGLE
OUTPUT
DUAL
OUTPUTS
1
2
3
5
9
10
11
12
13
14
15
16
22
23
24
+ INPUT
NC
NC
NP
NP
- OUTPUT
+ OUTPUT
- INPUT
- INPUT
+ OUTPUT
- OUTPUT
NP
NC
NC
+ INPUT
+INPUT
- OUTPUT
COMMON
NP
NP
COMMON
+ OUTPUT
- INPUT
- INPUT
+ OUTPUT
COMON
NP
COMMON
- OUTPUT
+ INPUT
1
2
3
5
9
10
11
12
13
14
15
16
22
23
24
NP
- INPUT
- INPUT
NP
NC
NC
NC
NP
NP
+ OUTPUT
NC
- OUTPUT
+ INPUT
+ INPUT
NP
NP
- INPUT
- INPUT
NP
COMMON
NC
- OUTPUT
NP
NP
+ OUTPUT
NC
COMMON
+ INPUT
+ INPUT
NP
NP* - NO PIN
NC* - NO CONNECTION WITH PIN
.60
.80
(15.24) (20.3)
24 23 22
16 15 14 13
PDCx0304x 12/00
Specifications subject to change without notice.
20381 BARENTS SEA CIRCLE, LAKE FOREST, CA 92630 • TEL: (949) 452-0511 • FAX: (949) 452-0512 • http://www.premiermag.com
137
3.0 WATT 4:1WIDE INPUT RANGE
DC/DC POWER MODULES
ELECTRICAL SPECIFICATIONS AT 25OC - OPERATING TEMPERATURE RANGE -25OC TO +75OC
PART
NUMBER
INPUT VOLTAGE
NOMINAL
RANGE
OUTPUT
VOLTAGE
(Vdc)
OUTPUT
CURRENT
(mAdc)
INPUT
CURRENT
NO LOAD
FULL LOAD
mA
mA
TYPICAL
EFFICIENCY
PDCS03041
PDCS03042
PDCS03043
PDCS03044
24
24
24
24
9-36
9-36
9-36
9-36
3.3
5
12
15
600
600
250
200
15
15
15
15
117
174
165
165
70 %
72 %
76 %
76 %
PDCD03042
PDCD03043
PDCD03044
24
24
24
9-36
9-36
9-36
±5
±12
±15
±300
±125
±100
25
25
25
179
174
174
70 %
72 %
72 %
PDCS03045
PDCS03046
PDCS03047
PDCS03048
48
48
48
48
18-72
18-72
18-72
18-72
3.3
5
12
15
600
600
250
200
58
87
78
78
70 %
72 %
80 %
80 %
PDCD03046
PDCD03047
PDCD03048
48
48
48
18-72
18-72
18-72
±5
±12
±15
±300
±125
±100
88
87
87
71 %
72 %
72 %
7.5
7.5
7.5
7.5
12
12
12
NOTE:
PDCx030xx_ : BLANK FOR STANDARD PART WITH ISOLATION = 500VDC
PDCx030xxK : ADD "K" FOR PART WITH ISOLATION = 1500VDC
PDCx030xxQ : ADD "Q" FOR PART WITH ISOLATION = 3000VDC
PDCx0304x 12/00
Specifications subject to change without notice.
20381 BARENTS SEA CIRCLE, LAKE FOREST, CA 92630 • TEL: (949) 452-0511 • FAX: (949) 452-0512 • http://www.premiermag.com
138
DC/DC POWER MODULES
1-4 AMP ADJUSTABLE
FEATURES
l Efficiency Up to 96% (ISR)
l ON/OFF Control (ground off)
l Adjustable Output Voltage
l Wide Input Range
l Overload Protection (125% full load typical)
l Continuous Short Circuit Protection
l Non-Isolation (No Hi Pot)
PART
NUMBER
INPUT VOLTAGE
RANGE
(Vdc)
OUTPUT VOLTAGE
(Vdc)
OUTPUT VOLTAGE
ADJUST RANGE
(Vdc)
OUTPUT
CURRENT
(Adc)
EFFICIENCY
INPUT VOLTAGE
Min
12V
Max
PDCS5212 *
PDCS5218 *
PDCS5225 *
PDCS5233 *
PDCS5250 *
4.5 - 18
4.5 - 18
4.5 - 18
4.5 - 18
6.5 - 18
1.2
1.8
2.5
3.3
5.0
1.0
1.6
1.6
1.6
3.0
-4.0
- 5.5
- 5.5
- 5.5
- 5.5
2.0
2.0
2.0
2.0
2.0
83%
88%
91%
92%
95%
79%
85%
88%
90%
93%
75%
82%
86%
89%
92%
PDCS5312 *
PDCS5318 *
PDCS5325 *
PDCS5333 *
PDCS5350 *
4.5 - 18
4.5 - 18
4.5 - 18
4.5 - 18
6.5 - 18
1.2
1.8
2.5
3.3
5.0
1.0
1.6
1.6
1.6
3.6
- 4.0
- 5.5
- 5.5
- 5.5
- 5.5
3.0
3.0
3.0
3.0
3.0
85%
89%
92%
94%
96%
84%
88%
91%
93%
95%
82%
86%
89%
92%
94%
PDCS5412 *
PDCS5418 *
PDCS5425 *
PDCS5433 *
PDCS5450 *
4.5 - 18
4.5 - 18
4.5 - 18
4.5 - 18
6.5 - 18
1.2
1.8
2.5
3.3
5.0
1.0
1.6
1.6
1.6
3.6
- 4.0
- 5.5
- 5.5
- 5.5
- 5.5
4.0
4.0
4.0
4.0
4.0
82%
87%
91%
93%
95%
81%
86%
89%
92%
94%
79%
85%
88%
91%
93%
PDCS6133 *
PDCS6150 *
PDCS6190 *
PDCS6112 *
9
9
12
15
26
38
38
38
3.3
5.0
9.0
12.0
1.8
1.8
3.3
5.0
-
6.0
11.0
12.0
18.0
1.0
1.0
1.0
1.0
88%
92%
96%
97%
81%
86%
89%
94%
PDCS6233 *
PDCS6250 *
PDCS6290 *
PDCS6212 *
9 - 26
9 - 38
12 - 38
15 - 38
3.3
5.0
9.0
12.0
1.8
1.8
3.3
5.0
-
6.0
11.0
12.0
18.0
2.0
2.0
2.0
2.0
86%
90%
95%
96%
82%
87%
92%
94%
-
* NOTE: ADD "V" FOR VERTICAL PACKAGE, "H" FOR HORIZONTAL PACKAGE
PDCx5-6xxx 12/03
Specifications subject to change without notice.
20381 BARENTS SEA CIRCLE, LAKE FOREST, CA 92630 • TEL: (949) 452-0511 • FAX: (949) 452-0512 • http://www.premiermag.com
139
DC/DC POWER MODULES
1-4 AMP ADJUSTABLE
PIN ASSIGNMENTS
PACKAGE
P PDCSxxxxV
M YYWW
1
.10
(2.54)
1.27
(32.2)
.01 x .03
(.25 x .75)
PIN
#
1
2
3
4
5
6
7
8
9
10
11
12
12
.028
(.70)
.36
(9.1)
.59
(15.0)
.157
(4.0)
VERTICAL
.10
(2.54)
INHIBIT (10V max)
Vin
Vin
Vin
GND
GND
GND
GND
Vout
Vout
Vout
Vout Adj
P PDCSxxxxH
M YYWW
1
FUNCTION
1.27
(32.2)
.01 x .03
(.25 x .75)
12
.157
(4.0)
.59
(15.0)
.36
(9.1)
HO RIZONTAL
TYPICAL APPLICATION CIRCUIT
Pin #2,3,4
Vin
1 uF
Optional
Pin #1
Pin #9,10,11
P
M
PDCSxxxxH/V
YYWW
Pin #5,6,7,8
TTL
R1
Adjustable down
C2
Pin #1
Q1
Vout
R1
Adjustable up
GND
GND
C2: 100uF ELECTROLYTIC OR TANTALUM OUTPUT CAPACITOR
Q1: TRANSISTOR OR MOSFET (Vce OR Vds >25Vdc)
Specifications subject to change without notice.
20381 BARENTS SEA CIRCLE, LAKE FOREST, CA 92630 • TEL: (949) 452-0511 • FAX: (949) 452-0512 • http://www.premiermag.com
140

Open as PDF

Similar pages: FCC PART68 VOICE/DATA COUPLING TRANSFORMERS; GATE DRIVE & BASE DRIVE TRANSFORMERS; PMCU-0330; Common Mode Chokes; EMI/RFI Common Mode Inductors; TRANSFORMER FOR DIGITAL AUDIO DATA TRANSMISSION; DSL High Speed Data Coupling Transformers; PMI PM-DSL65; ICHAUS IC-DIEVALDI1D; MAXIM MAX3535ECWI; PMI POL; PMI TSD-1085; PMI S3AD120510; PMI PMCE-0100; PMI PM-BT06; Product Catalog - Premier Magnetics; TSD-858 - Premier Magnetics; Product Catalog - Premier Magnetics