2015-4장-02 2015.1.20 03:44 PM 페이지135 태산아이인쇄그룹(국) 2261-2488 2400DPI 175LPI MINIATURE ALUMINUM ELECTROLYTIC CAPACITORS LQ Low Imp., High Ripple Current Series Low Impedance Miniaturized Solvent Proof ・For LED Lighting ・High reliability withstanding 10000 hours load life at 105° C (6000 ~ 9000 hours for smaller case sizes as specified below) ・Complied to the RoHS directive, Halogen-Free Item Characteristics Operating temperature range Leakage current max. -40 ~ +105° C I = 0.01CV or 3μ A whichever is greater (after 2 minutes) Capacitance tolerance ±20% at 120Hz, 20° C Capacitance > 1000μF : tanδincreases by 0.02 for each 1000μF from below value. Dissipation factor max. (at 120Hz, 20° C) WV tanδ 6.3 0.22 Low temperature characteristics (Impedance ratio at 120Hz) 10 0.19 16 0.16 25 0.14 35 0.12 50 0.10 63 0.09 80 0.08 100 0.08 2 3 Z-25° C / Z+20° C Z-40° C / Z+20° C After an application of DC bias voltage plus the rated AC ripple current for 10000 hours at 105° C. The measurement shall meet the following limits. The DC voltage plus the peak AC voltage combined must not exceed the rated voltage. Rated voltage (Vdc) Capacitance change tanδ Leakage current Load life ØD Ø5 ~ Ø6.3 Ø8×11.5L Ø8×15L ~ 20L Ø10×12.5L Ø10×16L ~ 25L Ø12.5 ~ 6.3 ~ 10 16 ~ 100 Within ±30% of initial value Within ±25% of initial value Less than 200% of specified value Less than specified value Life time (hrs) 10~50Vdc 7000 9000 10000 9000 6.3Vdc 6000 8000 9000 63~100Vdc 6000 8000 9000 10000 After 1000 hours no load test, leakage current, capacitance and tanδare same as load life value. The measurement shall be performed at 20° C by the KS C IEC 60384 - 4 Shelf life (at 105° C) Ød±0.05 Tinned copper-ply wire ØD+0.5 max. Insulating sleeve ØD ＋ 15 min. 6.3 8 10 12.5 16 18 2.0 2.5 3.5 5.0 5.0 7.5 7.5 Ød 0.5 0.5 0.6 0.6 0.6 0.8 0.8 P±0.5 － L+βmax. 5 P β 4 min. 1.5 2.0 Safety vent (Ø6.3 up) ● FREQUENCY COEFFICIENT OF PERMISSIBLE RIPPLE CURRENT Frequency μF 120Hz 1kHz 10kHz 50kHz 100kHz≦ 0.42 0.70 0.90 0.95 1.00 47 ~ 270 0.50 0.73 0.92 0.96 1.00 330 ~ 680 0.55 0.77 0.94 0.97 1.00 820 ~ 1800 0.60 0.80 0.96 0.98 1.00 0.70 0.85 0.98 0.99 1.00 ~ 33 2200 ~ 135 MINIATURE TYPES Unit : mm ● DRAWING 2015-4장-02 2015.1.20 03:44 PM 페이지136 태산아이인쇄그룹(국) 2261-2488 2400DPI 175LPI MINIATURE ALUMINUM ELECTROLYTIC CAPACITORS LQ series ● DIMENSIONS & MAXIMUM PERMISSIBLE RIPPLE CURRENT WV 6.3 Item ØD×L (mm) μF 47 68 100 120 150 180 220 270 330 390 470 560 680 820 1000 1200 1500 1800 IMP. (Ω)max. 20° C 100kHz 10 Ripple current (mA rms) 105° C 100kHz 5 ×11 5 ×11 6.3 ×11 0.400 0.170 0.075 0.059 0.053 945 1250 1500 8×20 0.041 1500 0.036 1760 10×16 (mm) IMP. (Ω)max. 20° C 100kHz 0.400 Ripple current (mA rms) 105° C 100kHz 450 5 ×11 0.170 700 8 ×11.5 8 ×15 10 ×12.5 10 ×16 10 ×16 0.110 0.059 0.053 0.041 0.036 1200 1600 1700 1960 2000 8 ×11.5 8 ×15 10 ×12.5 8 ×20 10 ×16 0.075 0.059 0.053 0.041 0.036 1200 1600 1700 1960 2000 10×20 0.027 2500 10×20 0.027 10×25 0.023 2500 10×25 0.023 2900 0.024 2600 2900 1960 10 ×20 0.024 2600 10×25 0.023 2250 12.5×25 0.018 3200 12.5 ×20 0.024 2480 12.5 ×25 12.5 ×30 16 ×20 12.5 ×34.5 0.018 0.017 0.020 0.015 3200 3660 3300 4120 12.5×25 0.018 2900 3810 3450 3660 3300 4120 3810 0.016 0.017 0.018 0.016 0.021 0.017 16×25 12.5×30 12.5 ×30 16 ×25 16 ×25 16 ×25 12.5 ×34.5 16 ×20 16 ×25 0.015 0.020 0.016 3570 3250 3630 4700 WV 50 Item ØD×L (mm) μF 63 Ripple IMP. (Ω)max. current (mA rms) 20° C 105° C 100kHz 100kHz ØD×L (mm) 5 ×11 5 ×11 0.480 47 0.380 400 56 6.3 ×11 0.220 500 0.710 82 6.3×11 0.280 8 ×11.5 0.180 ØD×L (mm) 5 ×11 1.200 220 6.3 ×11 0.460 370 420 8×11.5 0.290 620 8 ×15 0.200 780 10×12.5 0.170 780 720 8 ×20 0.160 1040 10×16 0.110 1040 10 ×20 12.5 ×16 10 ×25 12.5 ×20 0.084 0.110 0.069 0.062 1430 1430 1620 1750 100 8×11.5 0.120 950 8×15 0.130 990 120 8 ×15 0.082 1230 10 ×12.5 0.110 990 150 10×12.5 0.073 8×20 0.096 1200 180 220 8 ×20 10 ×16 0.058 0.050 1280 1580 1650 10 ×16 0.076 1200 10×20 0.070 1570 12.5×25 0.047 2210 10×25 0.060 1990 12.5 ×30 16 ×20 0.042 0.048 2400 1950 270 0.036 2060 390 10 ×25 0.030 2240 12.5 ×20 0.041 1990 12.5 ×34.5 0.036 2600 470 12.5 ×20 0.030 2300 12.5 ×25 0.031 2460 12.5 ×40 16 ×25 18 ×20 0.032 0.038 0.045 2860 2430 2270 12.5 ×30 16 ×20 0.028 0.032 2760 2380 560 680 820 1000 1200 2200 Ripple current (mA rms) 105° C 100kHz 5 ×11 5 ×11 0.400 0.400 450 450 6.3 ×11 0.170 700 (mm) 12.5×25 0.024 2800 12.5×34.5 0.024 3040 12.5 ×30 16 ×20 12.5 ×34.5 16 ×25 0.022 0.025 0.020 0.021 3370 3070 3810 3510 16×25 0.025 2890 16×31.5 0.023 2950 18×40 0.02 8 ×11.5 8 ×15 10 ×12.5 8 ×20 10 ×16 0.075 0.059 0.053 0.041 0.036 1200 1600 1700 1960 2000 10 ×20 10 ×25 0.027 0.023 2500 2900 12.5×20 0.024 2600 12.5×25 0.018 3200 12.5 ×30 16 ×20 12.5 ×34.5 0.017 0.020 0.015 3660 3330 4120 16×25 0.016 3810 100 Ripple IMP. (Ω)max. current (mA rms) 20° C 105° C 100kHz 100kHz 240 68 10×20 IMP. (Ω)max. 20° C 100kHz ØD×L 80 Ripple IMP. (Ω)max. current (mA rms) 20° C 105° C 100kHz 100kHz 310 6.3×11 330 35 3200 IMP. (Ω)max. 20° C 100kHz Ripple current (mA rms) 105° C 100kHz 5 ×11 0.400 450 6.3 ×11 0.170 700 8 ×11.5 8 ×15 10 ×12.5 8 ×20 10 ×16 10 ×16 10 ×20 10 ×25 12.5 ×20 12.5 ×20 12.5 ×25 12.5 ×30 16 ×20 12.5 ×34.5 16 ×25 0.075 0.059 0.053 0.041 0.038 0.038 0.028 0.024 0.025 0.025 0.019 0.018 0.021 0.016 0.017 1200 1600 1700 1960 2000 2100 2500 2900 2600 2800 3200 3660 3330 4120 3810 ØD×L (mm) 450 0.027 3900 136 ØD×L 12.5×20 3300 8.2 12 18 27 33 0.400 540 8 ×11.5 8 ×15 10 ×12.5 10 ×20 6800 Ripple current (mA rms) 105° C 100kHz 25 345 2200 8200 (mm) IMP. (Ω)max. 20° C 100kHz 5 ×11 2700 5600 ØD×L 16 16×31.5 0.032 2640 16 ×35.5 18 ×25 16 ×40 18 ×31.5 0.029 0.036 0.027 0.030 2860 2500 3510 2860 18×35.5 0.027 3510 18 ×40 0.026 3860 IMP. (Ω)max. 20° C 100kHz Ripple current (mA rms) 105° C 100kHz 5 ×11 1.200 220 6.3 ×11 0.460 370 8 ×11.5 8 ×15 10 ×12.5 10 ×12.5 8 ×20 10 ×16 10 ×16 10 ×20 12.5 ×16 10 ×25 0.450 0.350 0.250 0.250 0.250 0.105 0.105 0.080 0.105 0.066 620 780 780 780 1040 1040 1140 1430 1430 1620 12.5×20 0.650 1750 12.5 ×25 12.5 ×30 16 ×20 0.045 0.040 0.046 2210 2400 1950 ØD×L (mm) 12.5×34.5 0.034 2600 12.5 ×40 16 ×25 18 ×20 16 ×31.5 0.030 0.036 0.045 0.030 2860 2430 2270 2640 18×25 0.034 2500 16 ×35.5 18 ×31.5 16 ×40 18 ×35.5 0.028 0.029 0.026 0.026 2860 2860 3510 3510 18×40 0.025 3860