Features LED DRIVER ● ● ● ● ● ● ● High Output Voltage Universal AC Input Constant Current Operation Active Power Factor Correction IP67 Design for Indoor and Outdoor Use Compact Size Digital PWM and Analogue Voltage Dimming LIGHTLINE AC/DC-Converter with 5 year Warranty Selection Guide Part Number Nominal Voltage (VAC) Rated Voltage (V) Output Voltage Range (VDC) Rated Current (mA) Efficiency typ. (%) RACD100-700A 100-277 142 100-142 700 91 RACD100-1400A 100-277 71 50-71 1400 91 100 Watt Single Output Specifications (measured at 240V AC and 25°C ambient temperature) 2/Input Voltage Range Input Frequency Range Power Factor DC Dimming PWM Dimming THD AC Current Full Load, 115VAC Full Load, 230VAC 70% Load Open = 100% Open = 100% Freq. Voltage Full Load, 115VAC Full Load, 230VAC Full Load, 277VAC 115VAC 230VAC 90-305 VAC or 127-430VDC 47-63Hz >0.98 >0.94 >0.90 DC 1-10V Duty 10% - 100% 500Hz - 3000Hz Hi=10V, Low=0V 8% max. 15% max. 17% max. 1.2A max. 0.6A max. 3.75kVAC / 1minute 1.8kVAC / 1minute 0.5kVAC / 1minute <0.75mA 50A Input/Output Isolation Input/Case Isolation Output/Case Isolation Leakage Current 230VAC Inrush Current 230VAC (Class C Circuit Breaker is recommended) Voltage Tolerance -1% to 5% Current Tolerance ±5% Start-up Time (@ Full Load) 230VAC 2s Ripple & Noise 142V Version 1000mV max. (@20MHz bandwidth) 71V Version 500mV max. Over Voltage 110 - 140% Rated Voltage Shutdown Mode Short Circuit Protection Hiccup Mode Over Temperature Protection 100°C ±10°C Operation Temperature without derating -30°C to +55°C (see graph) Operation Humidity 20%-90% RH Non-Condensing Storage Temperature -40°C to +80°C Storage Humidity 10%-95% RH Vibration 10-500Hz, 2G, 60 Min. along X, Y and Z IP Rating IP67 Safety Standards UL/cUL LED Lighting Safety UL8750 CE LVD Directive, Safety EN61347-2-13 CB Report: 1103631 001 IEC61347-2-13 continued on next page L-62 REV: 0/2015 RoHS 2011/65/EU 6/6 E340696 UL 8750 Certified EN 61347 Certified RACD100-A Derating-Graph (Ambient Temperature) Load 100% 100V 80% 230V 60% 40% 20% -30 -10 10 30 50 70 55 Ambient Temperature (°C) Refer to Application Notes www.recom-power.com RACD100-A Series LIGHTLINE AC/DC-Converter Specifications (measured at 240V AC and 25°C ambient temperature) EMC Standards EMC Compatibility EN55015 FCC, Part 15 EN61000-3-2 Class C EN61000-3-3 EN61000-4-2, 3, 4, 5, 6, 11 EN61547 177*57*37mm 750g 70 x 10³ hours max. 200 x 10³ hours min. Harmonic Current EMC Immunity Dimension Weight Design Lifetime MTBF using MIL-HDBK-217F (25°C) Note: All LED Drivers may not be used without a load. They must be switched on the primary side only. Noncompliance may damage the LED or reduce its lifetime. Derating Curves Load 100% 80% 80% 60% 60% 40% 40% 20% 20% 90 100 130 180 220 240 DC Voltage Dimming Curve Efficiency (%) Ta=25°C 100% 305 Input Voltage (VAC)60Hz 10 20 30 40 50 60 70 80 90 PWM Dimming Curve Iout (%) Iout (%) 100% 100% 10% 10% 100 0 1 Dimming (%) Vdim (V) 0 10% 10 Note: Resistor dimming is only possible with a digital potentiometer (current sink), like the RECOM REPOT Ddim (%) 100% Pule: Hi = 10V, Low = 0V Frequency: 500 - 3KHz Maximum Number of LED drivers per circuit breakers Condition 230VAC, 1Ohm 90° phase angle 277VAC, 1Ohm 90° phase angle Circuit Breaker Current Typ 10A 16A 20A 25A C 7 12 14 18 B 6 10 12 14 C 13 22 24 31 B 7 11 14 17 C 15 25 29 36 RACD100-A 115VAC, 1Ohm 90° phase angle Circuit Breaker Package Style and Pinning 10.5 5.3 15.0 6.7 300±20 AC/L (Brown) AC/N (Blue) Earth (Green/Yellow) 177.0 Tc 57.0 42.0 300±20 30.6 18AWG x 2C +V(Red) -V(Black) +Dim (Blue) -Dim (White) 188 37.0 The product information and specifications are subject to change without prior notice. RECOM products are not authorized for use in safety-critical applications (such as life support) without RECOM’s explicit written consent. A safety-critical application is defined as an application where a failure of a RECOM product may reasonably be expected to endanger or cause loss of life, inflict bodily harm or damage property. The buyer shall indemnify and hold harmless RECOM, its affiliated companies and its representatives against any damage claims in connection with the unauthorized use of RECOM products in such safety-critical applications. www.recom-power.com REV: 0/2015 L-63