Yageo corporation ELECTROLYTIC CAPACITORS Miniature Aluminum Electrolytic Capacitors SY [ For Low Impedance and Low ESR Suitable for Motherboard Output Termination ] 105°C Single-Ended Lead Aluminum Electrolytic Capacitors for High Frequency Applications Electrical Characteristics Operating Temperature Range : -40 ~ +105°C Rated Voltage Range : 6.3 ~ 100V Rated Capacitance Range : 6.8 ~15,000μF Capacitance Tolerance : -20 ~ +20% at 120Hz, 20°C description Features: Low ESR, high permissible ripple current at high frequency and long life than SC Recommended Applications: Used switching regulator applications in computers Especially for high frequency MULTIPLIER FOR RIPPLE CURRENT Frequency Coefficient FREQUENCY (Hz) 120 1K 10K 100K 22~180µF 0.40 0.75 0.90 1.00 220~560µF 0.50 0.85 0.94 1.00 680~1800µF 0.60 0.87 0.95 1.00 2200~3900µF 0.75 0.90 0.95 1.00 4700µF Higher 0.85 0.95 0.98 1.00 Leakage Current (Max.) (20°C): I = 0.01CV or 3μA whichever is greater. (After Rated Voltage Applied for 2 Minutes) I = Leakage Current (μA), C = Nominal Capacitance (μF), V = Rated Voltage (V) Dissipation Factor W V (V): 6.3 D.F. (%) : 22 10 19 16 16 25 14 35 12 50 10 63 9 100 8 When nominal capacitance is over 1,000uF, tan δ shall be added 0.02 to the listed value with increase of every 1000μF. W V (V) : Rated Voltage (V) 6.3 10 16 25 35 50 63 100 Impedance : Z - 25°C / Z + 20°C 4 3 2 2 2 2 2 2 Z - 40°C / Z + 20°C 8 6 4 3 3 3 3 3 Endurance Dø : 5ø~6.3ø 8ø~10øx12.5 10øx15~12ø 13ø~18ø Life : 3000hrs 4000hrs 5000hrs 6000hrs After the rated voltage has been applied at 105°C for 6000 hours. The capacitors shall meet the following requirements. (a) Capacitance Change : Within 25% of Initial Value (b) Dissipation Factor : Not Exceeding 200% of Specified Value (c) Leakage Current : Not Exceeding the Specified Value Shelf Life : After having beening placed at 105°C without voltage applied for 1000 hours, the capacitors shall meet the same requirements as Endurance. diagram of dimensions Dimensions: mm Rubber Stand-off Rubber End Seal Vinyl Sleeve F±0.5 F±0.5 Dø±0.5 dø L Dø < 20 Dø + 0.5 Dø ≥ 20 Dø + 1 L ≤ 16 L + 1.5Max. L > 16 L + 2Max. Dø = 8 & 10 L + 2.5Max. 15Min. 5Min. Dø F dø 5.0 2.0 0.5 6.3 2.5 8.0 3.5 10.0 5.0 0.6 12.0 13.0 16.0 18.0 7.5 0.8 73 CASE SIZE & PERMISSIBLE RIPPLE CURRENT OF STANDARD PRODUCTS CAP. (µF) 6.3 (8) SIZE RIPPLE ESR 10 (13) SIZE RIPPLE ESR 56 100 5 x 11 210 0.58 120 150 5 x 11 210 6.3 x 11 330 6.3 x 11 340 0.22 470 6.3 x 11 510 0.16 8 x 11 640 16 (20) SIZE RIPPLE ESR 5 x 11 210 0.580 6.3 x 11 250 0.230 6.3 x 11 340 0.220 6.3 x 11 469 0.185 8 x 11 582 0.150 8 x 11 640 0.130 *8 x 15 840 0.087 8 x 20 950 0.078 *10 x 12 865 0.080 10 x 15 1210 0.060 8 x 20 1050 0.069 10 x 15 1210 0.060 0.58 220 680 D x L: mm RATED VOLTAGE W V (SURGE VOLTAGE W V) 0.13 8 x 11 8 x 15 340 640 840 0.22 0.13 0.087 820 10 x 12 865 0.08 10 x 12 865 0.08 1000 8 x 15 840 0.087 8 x 20 1050 0.069 8 x 20 1050 0.069 10 x 15 1210 0.06 *10 x 15 1210 0.060 10 x 19.5 1400 0.046 13 x 15 1450 0.049 1200 10 x 19.5 1400 0.046 10 x 25 1650 0.042 0.069 10 x 25 1650 0.042 10 x 30 1910 0.031 1210 0.06 13 x 15 1450 0.049 13 x 20 1900 0.035 10 x 19.5 1400 0.046 16 x 15 1940 0.042 1800 13 x 15 1450 0.049 2200 *10 x 19.5 1400 0.046 10 x 30 1910 0.031 13 x 25 2230 0.027 10 x 25 1650 0.042 13 x 20 1900 0.042 18 x 15 2210 0.043 16 x 15 1940 0.042 18 x 15 2210 0.043 13 x 30 2650 0.024 16 x 20 2530 0.027 1500 2700 8 x 20 1050 0.069 10 x 15 1210 0.06 8 x 20 1050 *10 x 15 10 x 30 1910 0.031 16 x 15 1940 0.042 Note: 1. Ripple Current: (mA/rms) 105°C, 100KHz 2. ESR: 100KHz / 20°C (Ω Max.) 3. * Down Size: 1000 Hours less than standard 4. For case size 13 x 15, 16 x 15 and 18 x 15, tolerance of height = ±3 mm 74 CASE SIZE & PERMISSIBLE RIPPLE CURRENT OF STANDARD PRODUCTS CAP. (µF) 3300 3900 4700 5600 6800 8200 10000 D x L: mm RATED VOLTAGE W V (SURGE VOLTAGE W V) 6.3 (8) SIZE RIPPLE ESR 10 (13) SIZE RIPPLE ESR 16 (20) SIZE RIPPLE ESR 10 x 25 1650 0.042 10 x 30 1910 0.031 13 x 36 2880 0.020 13 x 20 1900 0.035 13 x 25 2230 0.027 13 x 25 2230 0.027 13 x 30 2650 0.024 13 x 40 3350 0.017 18 x 15 2210 0.043 16 x 20 2530 0.027 16 x 25 2930 0.021 18 x 20 2860 0.026 16 x 32 3450 0.017 18 x 25 3140 0.019 13 x 30 2650 0.024 13 x 35 2880 0.02 13 x 35 2880 0.02 13 x 40 3350 0.017 16 x 36 3610 0.015 16 x 20 2530 0.027 16 x 25 2930 0.021 18 x 32 4170 0.015 18 x 20 2860 0.026 16 x 40 4080 0.013 18 x 36 4220 0.014 18 x 40 4280 0.012 13 x 40 3350 0.017 16 x 32 3450 0.017 16 x 25 2930 0.021 18 x 25 3140 0.019 18 x 20 2860 0.026 16 x 32 3450 0.017 16 x 36 3610 0.015 18 x 32 4170 0.015 16 x 36 3610 0.015 16 x 40 4080 0.013 18 x 25 3410 0.017 18 x 36 4220 0.014 12000 18 x 32 4170 0.015 18 x 40 4280 0.012 15000 18 x 36 4220 0.014 Note: 1. Ripple Current: (mA/rms) 105°C, 100KHz 2. ESR: 100KHz / 20°C (Ω Max.) 3. For case size 13 x 15, 16 x 15 and 18 x 15, tolerance of height = ±3 mm 75 CASE SIZE & PERMISSIBLE RIPPLE CURRENT OF STANDARD PRODUCTS CAP. (µF) D x L: mm RATED VOLTAGE W V (SURGE VOLTAGE W V) 25 (32) SIZE RIPPLE ESR 35 (44) SIZE RIPPLE ESR 2.2 50 (63) SIZE RIPPLE ESR 5 x 11 85 2.280 4.7 5 x 11 130 2.400 5 x 11 135 2.000 10 5 x 11 275 0.390 5 x 11 100 1.200 5 x 11 180 0.700 22 33 5 x 11 210 0.580 6.3 x 11 245 0.490 6.3 x 11 275 0.390 6.3 x 11 300 0.520 56 6.3 x 11 340 0.220 6.3 x 11 295 0.300 68 6.3 x 11 500 0.170 82 6.3 x 11 540 0.160 6.3 x 11 580 0.150 8 x 11 555 0.170 8 x 15 730 0.120 10 x 12 760 0.120 8 x 20 910 0.091 10 x 15 1050 0.084 10 x 19.5 1220 0.060 13 x 15 1260 0.061 47 100 5 x 11 6.3 x 11 210 340 0.580 0.220 120 150 8 x 11 640 0.160 8 x 11 640 0.130 180 220 8 x 11 640 0.130 270 330 470 820 840 0.087 10 x 12 865 0.080 8 x 20 1050 0.069 8 x 15 840 0.087 *10 x 15 1210 0.060 *10 x 19.5 1400 0.058 10 x 12 865 0.080 10 x 19.5 1400 0.046 10 x 25 1440 0.055 8 x 20 1050 0.069 13 x 15 1450 0.049 13 x 20 1660 0.045 *10 x 12 1050 0.070 16 x 15 1690 0.055 10 x 15 1210 0.060 13 x 25 1950 0.034 18 x 15 1930 0.054 13 x 30 2310 0.030 13 x 36 2510 0.025 16 x 20 2210 0.034 560 680 *8 x 15 10 x 25 1650 0.042 10 x 19.5 1400 0.046 10 x 30 1910 0.031 13 x 15 1450 0.049 13 x 20 1900 0.035 16 x 15 1940 0.042 13 x 20 1900 0.035 10 x 25 1650 0.042 Note: 1. Ripple Current: (mA/rms) 105°C, 100KHz 2. ESR: 100KHz / 20°C (Ω Max.) 3. * Down Size: 1000 Hours less than standard 4. For case size 13 x 15, 16 x 15 and 18 x 15, tolerance of height = ±3 mm 76 CASE SIZE & PERMISSIBLE RIPPLE CURRENT OF STANDARD PRODUCTS CAP. (µF) 1000 1200 1500 1800 2200 25 (32) SIZE RIPPLE ESR 35 (44) SIZE RIPPLE ESR 50 (63) SIZE RIPPLE ESR 10 x 19.5 1400 0.046 13 x 25 2230 0.027 13 x 40 2920 0.021 10 x 30 1910 0.031 18 x 15 2210 0.043 16 x 25 2555 0.025 13 x 20 1900 0.035 18 x 20 2490 0.036 16 x 15 1940 0.042 18 x 15 2210 0.043 13 x 30 2650 0.024 16 x 32 3010 0.022 16 x 20 2530 0.027 18 x 25 2740 0.026 13 x 35 2880 0.020 16 x 36 3510 0.019 *13 x 20 1900 0.035 13 x 25 2230 0.027 13 x 30 2650 0.024 13 x 40 3350 0.017 16 x 40 3710 0.016 16 x 20 2530 0.027 16 x 25 2930 0.021 18 x 32 3635 0.021 18 x 20 2860 0.026 18 x 36 3680 0.017 18 x 40 3800 0.014 13 x 35 2880 0.020 16 x 32 3450 0.017 18 x 20 2860 0.026 18 x 25 3140 0.019 13 x 40 3350 0.017 16 x 36 3610 0.015 16 x 25 2930 0.021 18 x 32 4170 0.015 16 x 32 3450 0.017 16 x 40 4080 0.013 18 x 25 3140 0.019 18 x 36 4220 0.014 3900 18 x 32 4170 0.015 18 x 40 4280 0.012 4700 18 x 36 4220 0.014 5600 18 x 40 4280 0.012 2700 3300 D x L: mm RATED VOLTAGE W V (SURGE VOLTAGE W V) Note: 1. Ripple Current: (mA/rms) 105°C, 100KHz 2. ESR: 100KHz / 20°C (Ω Max.) 3. * Down Size: 1000 Hours less than standard 4. For case size 13 x 15, 16 x 15 and 18 x 15, tolerance of height = ±3 mm 77 CASE SIZE & PERMISSIBLE RIPPLE CURRENT OF STANDARD PRODUCTS CAP. (μF) D x L: mm RATED VOLTAGE W V (SURGE VOLTAGE W V) 63 (79) SIZE 100 (125) SIZE RIPPLE ESR 5 x 11 55 2.30 6.3 x 11 115 1.20 8 x 11 232 0.63 39 8 x 15 300 0.45 47 10 x 12 288 0.43 8 x 20 362 0.33 10 x 15 357 0.31 RIPPLE ESR 6.8 15 5 x 11 55 2.30 27 33 56 6.3 x 11 8 x 11 115 232 1.20 0.63 68 82 8 x 15 300 0.45 10 x 19.5 466 0.21 10 x 12 288 0.43 13 x 15 466 0.23 10 x 25 531 0.20 100 120 8 x 20 362 0.33 10 x 30 663 0.15 10 x 15 357 0.31 13 x 20 690 0.16 16 x 16 795 0.14 10 x 19.5 466 0.21 13 x 25 784 0.12 13 x 15 466 0.23 18 x 15 920 0.12 10 x 25 531 0.20 13 x 30 905 0.10 16 x 20 1040 0.091 150 180 220 270 330 390 470 10 x 30 663 0.15 13 x 35 1050 0.083 13 x 20 690 0.16 16 x 25 1250 0.073 16 x 16 795 0.14 13 x 25 784 0.12 13 x 40 1180 0.071 18 x 20 1240 0.08 18 x 16 920 0.12 16 x 32 1570 0.054 18 x 25 1490 0.057 13 x 30 905 0.10 16 x 36 1790 0.045 16 x 20 1040 0.091 18 x 32 1630 0.047 13 x 35 1050 0.083 16 x 40 2020 0.04 16 x 25 1250 0.073 13 x 40 1180 0.071 18 x 36 1790 0.04 18 x 20 1240 0.080 820 16 x 32 1570 0.054 18 x 40 2330 0.036 18 x 25 1490 0.057 1000 16 x 36 1790 0.045 18 x 32 1630 0.047 16 x 40 2020 0.04 560 680 1200 Note: 1. Ripple Current: (mA/rms) 105°C, 100KHz 2. ESR: 100KHz / 20°C (Ω Max.) 3. For case size 13 x 15, 16 x 15 and 18 x 15, tolerance of height = ±3 mm