PSP500 5 0 0 W w i t h P F C and Parallel Function series Universal AC input Protections:Short circuit/Over load/Over voltage/Over temperature Built-in active PFC function, PF>0.95 Foced air cooling by built-in DC fan Current sharing up to 2000W(3+1) With power good and fail signal output Built-in remote ON-OFF control Built-in remote sense function Model Number Output Volts Output Amps 5 Volts(DC) 12 Volts(DC) 13.5 Volts(DC) 15 Volts(DC) 24 Volts(DC) 27 Volts(DC) 48 Volts(DC) 80 Amps 41.5 Amps 37 Amps 33 Amps 20.8 Amps 18.5 Amps 10.5 Amps OVP Min Load DC Volt Adjust Load Reg Efficiency SINGLE OUTPUT PSP500-5 PSP500-12 PSP500-13.5 PSP500-15 PSP500-24 PSP500-27 PSP500-48 WWW.ASTRODYNE.COM 5.75~6.75Volt(DC) 13.8~16.2Volt(DC) 15.5~18.2Volt(DC) 18~21Volt(DC) 27.6~32.4Volt(DC) 31~36.5Volt(DC) 57.6~67.2Volt(DC) 0~80Amps 0~41.5Amps 0~37Amps 0~33Amps 0~20.8Amps 0~18.5Amps 0~10.5Amps 4.75~5.5Volt(DC) 10~13.2Volt(DC) 12~15Volt(DC) 13.5~18Volt(DC) 20~26.4Volt(DC) 24~30Volt(DC) 41~56Volt(DC) ±2.0% ±0.5% ±0.5% ±0.5% ±0.5% ±0.5% ±0.5% 76% 82% 82% 82% 84% 84% 86% ASTRODYNE USA: 1-800-823-8082 ASTRODYNE PACIFIC: 886-2-26983458 PSP500 5 0 0 W w i t h P F C and Parallel Function INPUT SPECIFICATIONS Input Voltage Range (Note 4) Frequency Range Inrush Current, typ: (cold start) Input Current Leakage current Min Load Power Factor (typ.) @ FL 90 ~ 264VAC 127~370 Volts(DC) 47-63Hz 20Amps/115VAC; 40Amps/230VAC 7.0 Amps@115VAC 3.5 Amps@230VAC < 1mAmps / 240VAC See Selection Chart 0.95/230VAC; 0.98/100VAC OUTPUT SPECIFICATIONS Voltage and Current Line Regulation Load Regulation Voltage Tolerance (Note 2) Ripple/Noise (Note 1) Hold Up Time @ FL Setup, Rise Time @ FL Over Voltage Protection Over Current Protection Over Temperature Protection DC Voltage Adjust See Selection Chart ±0.5%: 5Volts(DC) ±0.3%: 12~15Volts(DC) ±0.2%: 24~48Volts(DC) See Selection Chart 2.0%: 5Volts(DC) 1.0%: 12~48Volts(DC) 100mVpk-pk: 5Volts(DC) 150mVpk-pk: 12~27Volts(DC) 200mVpk-pk: 48Volts(DC) 24mS 1500mS, 50mS See Selection Chart Shutdown o/p voltage, re-power 110~125% rated output power Constant Current limiting, auto-recov RTH2≥95°C detect on heatsink of Q1, Q7 power transistor & L3 output choke, shutdown o/p voltage, auto-recover after cool down See Selection Chart GENERAL SPECIFICATIONS Safety UL60950-1, TUV EN60950-1 Approved All specifications are typical at nominal input, full load, and 25°C unless otherwise noted WWW.ASTRODYNE.COM Insulation Resistance EMI Harmonic Current Efficiency Isolation EMS Remote Control series ≥100MΩ/500Volts(DC)/25°C/70%RH Compliance to EN55022B(CISPR22B) Compliance to EN61000-3-2,-3 See Selection Chart 3000VAC Input - Output 1500VAC Input - Ground 500VAC Output - Ground Compliance to EN61000-4-2,3,4,5,6,8,11 ENV50204, ENV55024 light Industry Level, Criteria A RC+/RC-: 0~0.8Volts(DC)=Power ON 4~10Volts(DC)=Power Off sink current <4~10mA ENVIRONMENTAL SPECIFICATIONS Oper. Temperature Storage Temperature Relative Humidity Temperature Coefficient MTBF Vibration -10°C to +60°C (See Derate Curve) -20°C to +85°C, 10~95% RH 20~90% RH, with 30CFM non cond ±0.03% / °C (0-50°C) 130.1KHrs min,MIL-HDBK-217F(25°C) 10~500Hz, 2G10min./1cycle, period for 60min. each along X, Y, Z axes PHYSICAL SPECIFICATIONS Size Weight 278 x 127 x 63.5 mm (10.95”x 5”x 2.5”) 91.71 oz (2600g) Note 1. Ripple & noise are measured at 20MHz of bandwidth by using a 12” twisted pair-wire terminated with a 0.1uf & 47uf parallel capacitor. 2. Tolerance : includes set up tolerance, line regulation and load regulation. 3. In parallel connection, maybe only one unit operated, if the total output load less than 5% of rated load condition. 4. Derating may be needed under low input voltages. Please check the derating curve for more details. Astrodyne products are not authorized or warranteed for use as critical components in life support systems, equipment used in hazardous environments, nuclear controls systems, or other mission-critical applications. ASTRODYNE USA: 1-800-823-8082 ASTRODYNE PACIFIC: 886-2-26983458 5 0 0 W w i t h P F C and Parallel Function WWW.ASTRODYNE.COM PSP500 series ASTRODYNE USA: 1-800-823-8082 ASTRODYNE PACIFIC: 886-2-26983458 5 0 0 W w i t h P F C and Parallel Function WWW.ASTRODYNE.COM PSP500 series ASTRODYNE USA: 1-800-823-8082 ASTRODYNE PACIFIC: 886-2-26983458 5 0 0 W w i t h P F C and Parallel Function WWW.ASTRODYNE.COM PSP500 series ASTRODYNE USA: 1-800-823-8082 ASTRODYNE PACIFIC: 886-2-26983458