PMK320E 3 2 0 Wa t t E n c l o s ed Switching Power Supply with PFC series 320 Watts Output Power Single Outputs Universal 90-264VAC Input 5VDC to 48VDC Outputs 4242VDC Input to Output Isolation Active Power Factor Correction 3.86”W x 8.03”L x 1.57”H Model Number Output Voltage Output Amps (max) Ripple & Noise max. Efficiency SINGLE OUTPUT PMK320S-5E PMK320S-12E PMK320S-15E PMK320S-24E PMK320S-36E PMK320S-48E 5 VDC 12 VDC 15 VDC 24 VDC 36 VDC 48 VDC 60 26.7 21.4 13.4 8.9 6.7 71% 77% 79% 79% 81% 81% Astrodyne products are not authorized or warranteed for use as critical components in life support systems, equipment used in hazardous environments, nuclear controls systems, or other mission-critical applications. WWW.ASTRODYNE.COM 100mV pk-pk 120mV pk-pk 150mV pk-pk 150mV pk-pk 150mV pk-pk 150mV pk-pk All specifications are typical at nominal input, full load, and 25°C unless otherwise noted ASTRODYNE USA: 1-800-823-8082 ASTRODYNE PACIFIC: 886-2-26983458 3 2 0 Wa t t E n c l o s ed Switching Power Supply with PFC 90-264 VAC; Nom: 100-240VAC 47-63 Hz 0.95, min. Nom I/P, FL 30A / 60A Cold Start, FL* 5.4 Amps max. / 1.8 Amps max. <0.3mA, 240Vin, 50Hz OUTPUT SPECIFICATIONS Voltage and Current Line Regulation (LL-HL) Load Regulation 10%-FL Preset Accuracy (Note 3) Ripple/Noise (Notes 1, & 4) Over Voltage Protection Over Current Protection Short Circuit Protection Turn On Delay Time Rise Time Hold Up Time Over-Shoot/Under Shoot Remote Sense Remote Shutdown See Selection Chart ±1%, max. ±1~1.5%, max. ±1%, typ (2% 5 Vout) See Selection Chart 130% max. Auto Recovery * 160% max. Auto Recovery * Auto Recover after fault condition is removed * <4S <25mS, typ (Nom I/P, FL) 20mS, typ (Nom I/P, FL) <10% of Nominal Output Compensates for up to 0.5V drop Open Collector, Logic “1” = ON “0” = Off. No Termination necessary to maintain constant “On” operation GENERAL SPECIFICATIONS Isolation (Note 2) Insulation Resistance Efficiency (FL. Nom I/P) Safety UL/cUL: UL-EU: CE: CB: series ENVIRONMENTAL SPECIFICATIONS INPUT SPECIFICATIONS Input Voltage Range Frequency Range Power Factor Correction IInrush Current (115/230 I/P) Input Current (LL/HL) Leakage Current PMK320E I/P-O/P: 4242VDC I/P-Ground: 2121VDC O/P-Ground: 707VDC ≥20MΩ See Selection Chart UL60950-1 2nd ed./ C22.2 60950-1 2nd ed. EN60950-1 2nd ed. EN60601-1-2 IEC60950-1 2nd ed. WWW.ASTRODYNE.COM Oper. Temperature -20 to +70°C (See Derate Curve) Storage Temperature -25 to +85°C * Relative Humidity 10% to +90%, * Storage: 5-95% EMS Harmonics Class D, 61000-3-2 Fluctuations 61000-3-3 ESD 61000-4-2 RS 61000-4-3 EFT 61000-4-4 Surge 61000-4-5 CS 61000-4-6 MS 61000-4-8 DIPS 61000-4-11 EMI EN55022 Class B MTBF Mil Std 217F, 25°C 65,000 Hrs, min. Vibration 4G Peak, 50-500Hz, 3 Axes Drop Test 70 CM PHYSICAL SPECIFICATIONS Size Construction Weight 8.03”(L) x 3.86”(W) x 1.57”(H) Enclosed 1.75 lb, (794g) NOTES 1. All measurements should be made directly at the terminals of the power supply 2. Isolation for up to 1 minute duration. 3. Preset Accuracy measured at nominal load, 120VAC input. 4. O/P Noise measured directly at the pins/terminals at nominal load, 0.1uF ceramic bypass and 47uF electrolytic, pk-pk @ 20MHz bandwidth. * These are stress ratings. Exposure of the devices to any of these conditions may adversely affect long term reliability. Proper operation under conditions other than the standard operating conditions is neither warranteed nor implied. ASTRODYNE USA: 1-800-823-8082 ASTRODYNE PACIFIC: 886-2-26983458 PMK320E 3 2 0 Wa t t E n c l o s ed Switching Power Supply with PFC series MECHANICAL DIMENSIONS 2.00 50.8 M3 hole size .93 23.6 .50 12.7 5.95 151.1 .94 23.9 4.33 110 1.57 40 .83 21 1.50 38 7.01 178 FG ACN ACL +Vo(5V) COM COM COM +Vo +Vo 3.86 98 -S +S S/D GND 8.03 203.9 UNITS:mm (in) WWW.ASTRODYNE.COM PROPRIETARY AND CONFIDENTIAL THE INFORMATION CONTAINED IN THIS DRAWING IS THE SOLE PROPERTY OF DIMENSIONS ARE IN INCHES TOLERANCES: FRACTIONAL ANGULAR: MACH BEND TWO PLACE DECIMAL THREE PLACE DECIMAL MATERIAL NAME DRAWN CHECKED ENG APPR. MFG APPR. Q.A. COMMENTS: DATE ASTRODYNE USA: 1-800-823-8082 ASTRODYNE PACIFIC: 886-2-26983458 PMK320E ASTRODYNE PACIFIC CORP EEELLLEEECCCTTTRRRIIICCCAAALLL SSSPPPEEECCCIIIFFFIIICCCAAATTTIIIO O N ON N D EE PPAACCIIFFIICC CCO RRPP DYYN NSwitching OPower 3 2 0 Wa t t E nAAScSTTl oRRsOOed Supply with PFC 7. Derating OUTPUT DERATING CURVE series Curve 120% Load(%) 100% 80% 60% 40% 20% 0% -20℃ -10℃ ℃ 10℃ 20℃ 30℃ 40℃ 50℃ 60℃ 70℃ Ambient (℃) Input voltage (VAC) 60Hz Ta=25℃ 1. 5V 2. 12、15、24、36、48V WWW.ASTRODYNE.COM 1313 ASTRODYNE USA: 1-800-823-8082 ASTRODYNE PACIFIC: 886-2-26983458