PSP1000 1 0 0 0 W S i n g l e O utput with PFC Function series Universal AC input Protections:Short circuit/Over load/Over voltage/Over temperature Built-in active PFC function Built-in constant current limiting circuit Current sharing up to units or 2000W Built-in active current sharing and parallel function Built-in remote ON-OFF control Built-in remote sense function AC input active surge current limiting Model Number Output Volts Output Amps 5 Volts(DC) 12 Volts(DC) 13.5 Volts(DC) 15 Volts(DC) 24 Volts(DC) 27 Volts(DC) 48 Volts(DC) 145 Amps 75Amps 67 Amps 60 Amps 37.6 Amps 33.6 Amps 19 Amps OVP Min Load DC Volt Adjust Load Reg Efficiency SINGLE OUTPUT PSP1000-5 PSP1000-12 PSP1000-13.5 PSP1000-15 PSP1000-24 PSP1000-27 PSP1000-48 WWW.ASTRODYNE.COM 5.75~6.75Volt(DC) 13.8~16.2Volt(DC) 15.5~18.2Volt(DC) 18~21Volt(DC) 27.6~32.4Volt(DC) 31~36.5Volt(DC) 57.6~67.2Volt(DC) 0~145Amps 0~75Amps 0~67Amps 0~60Amps 0~37.6Amps 0~33.6Amps 0~19Amps 4.75~5.5Volt(DC) 10~13.2Volt(DC) 12~15Volt(DC) 13.5~18Volt(DC) 20~26.4Volt(DC) 24~30Volt(DC) 41~56Volt(DC) ±2.0% ±0.5% ±0.5% ±0.5% ±0.5% ±0.5% ±0.5% 77% 84% 84% 84% 85% 86% 86% ASTRODYNE USA: 1-800-823-8082 ASTRODYNE PACIFIC: 886-2-26983458 PSP1000 1 0 0 0 W S i n g l e O utput with PFC Function INPUT SPECIFICATIONS Input Voltage Range (Note 4) Frequency Range Inrush Current, typ: (cold start) Input Current Leakage current Min Load Power Factor (typ.) @ FL series GENERAL SPECIFICATIONS Safety UL60950-1, 90 ~ 264VAC 127~370 Volts(DC) 47-63Hz 32Amps/115VAC; 63Amps/230VAC 11.2 Amps@115VAC 5.6 Amps@230VAC < 2mAmps / 240VAC See Selection Chart 0.96/230VAC; 0.96/115VAC OUTPUT SPECIFICATIONS Voltage and Current See Selection Chart Line Regulation ±0.5%: 5Volts(DC) ±0.3%: 12~15Volts(DC) ±0.2%: 24~48Volts(DC) Load Regulation See Selection Chart Voltage Tolerance (Note 2) ±6.0%: 5Volts(DC) ±3.0%: 12Volts(DC) ±2%: 13.5~15Volts(DC) ±1%: 24~48Volts(DC) Ripple/Noise (Note 1) 100mVpk-pk: 5Volts(DC) 150mVpk-pk: 12~27Volts(DC) 200mVpk-pk: 48Volts(DC) Hold Up Time @ FL 24mS/230VAC, 24ms/115VAC Setup, Rise Time @ FL 1500mS, 50mS/230VAC 1500mS, 50ms/115VAC Over Voltage Protection See Selection Chart Shutdown o/p voltage, re-power Over Current Protection 115~140% rated output power Constant current limiting,auto-recov Over Temperature Protection 95°C detect on heatsink of PFC MOSFET 90°C detect the winding of output choke Shutdown o/p voltage auto-recover after cool down DC Voltage Adjust See Selection Chart Peak Load (Note 3) 5Volts(DC): 800W 12~48Volts(DC): 1000W All specifications are typical at nominal input, full load, and 25°C unless otherwise noted WWW.ASTRODYNE.COM Insulation Resistance EMI Harmonic Current Efficiency Isolation EMS Remote Control TUV EN60950-1 Approved ≥ 100MΩ / 500Volts(DC) Compliance to EN55022B (CISPR22B) Compliance to EN61000-3-2,-3 See Selection Chart 3000VAC Input - Output 1500VAC Input - Ground 500VAC Output - Ground Compliance to EN61000-4-2,3,4,5,6,8,11 ENV50204, light Industry Level, Criteria A RC+/RC-: 0~0.8Volts(DC) =Power ON 4~10Volts(DC) =Power Off sink curent <20mA ENVIRONMENTAL SPECIFICATIONS Oper. Temperature Storage Temperature Relative Humidity Temperature Coefficient MTBF Vibration -10°C to +60°C (See Derate Curve) -20°C to +85°C, 10~95% RH 20~90% RH non cond ±0.03% / °C (0-50°C) 59.6KHrs min,MIL-HDBK-217F(25°C) 10~500Hz, 2G10min./1cycle, period for 60min. each along X, Y, Z axes PHYSICAL SPECIFICATIONS Size Weight 278 x 129 x 127 mm (10.95”x 5.08”x 5”) 183.42 oz (5200g) Note 2. Ripple & noise are measured at 20MHz of bandwidth by using a 12” twisted pair-wire terminated with a 0.1uf & 47uf parallel capacitor. 3. Tolerance : includes set up tolerance, line regulation and load regulation. 4. 10% Duty cycle maximum within every 30 seconds(max.). Average output power should not exceed the rated power. 6. Derating may be needed under low input voltages. Please check the derating curve for more details. Astrodyne products are not authorized or warranteed for use as critical components in life support systems, equipment used in hazardous environments, nuclear controls systems, or other mission-critical applications. ASTRODYNE USA: 1-800-823-8082 ASTRODYNE PACIFIC: 886-2-26983458 1 0 0 0 W S i n g l e O utput with PFC Function PSP1000 WWW.ASTRODYNE.COM ASTRODYNE USA: 1-800-823-8082 ASTRODYNE PACIFIC: 886-2-26983458 series 1 0 0 0 W S i n g l e O utput with PFC Function PSP1000 WWW.ASTRODYNE.COM ASTRODYNE USA: 1-800-823-8082 ASTRODYNE PACIFIC: 886-2-26983458 series