虹冠電子工業股份有限公司 Champion Microelectronic Corporation Specialized in Integrated High Efficient Switching Power Management Solutions 高整合高效率交換型電源管理方案之專業 I C 設計 Product Selector Guide Rev.9 Contents Product Tree --------------------------------------- 3 General Ordering Information ---------------- 4 PFC Introduce ------------------------------------- 5 Product Guide Power Management ICs ---------------------- 6 Bus & Interface Products --------------------- 7 Battery Management ICs --------------------- 7 Low Dropout Regulators ---------------------- 8 Voltage Comparator & Reference -------- 10 Power MOSFETs ----------------------------- 11 Schottky Barrier Diodes -------------------- 12 ~1~ Product Tree ~3~ General Ordering Information I. PART NUMBER EXPLANATION CMX XXXX (X) X X (XX) Tape & Reel (optional) Package Type* TR: Tape & Reel Tem perature Range TA: Tape Ammo. C= 0℃ to 70℃ E= -20℃ to 70℃ I= -40℃ to 85℃ Num ber or letter indicates electrical grade of part (optional) Product part num ber Product Category Blank: ICs T: MOSFETs S: Schottky H: Hybrid Cham pion Mic roelectronic Prefix * See Section II Board Part Number Explanation CMX XXXX - X X XX - XX Others Voltage Channel No. O/P connector function A: 6 PUSH TERMINAL B: 6 PUSH TERMINAL & VIDEO Product part num ber Product Category B: Board Cham pion Mic roelectronic Prefix II. PACKAGE TYPE EXPLANATION Letter Suffix Description P R Plastic DIP Shrink Small Outline Pac kage (SSOP) S T Small Outline Pac kage (SOIC) Thin Shrink Small Outline Package (TSSOP) M N SOT/TSOT Package TO Package Z Single Inline Pac kage (SIP) III. TAPE & REEL - STANDARD PACKAGE TYPES; QUANTITY PER REEL ~4~ Reel Quantity SOT-23-3 3,000 SOT-23-5 3,000 SOT-89 1,000 SOT-223 2,500 S08 1,000 (7") S08 2,500 (13") Description S14 2,500 TR Tape & Reel S16 2,500 TA Tape Am mo. T16 2,500 Suffix Champion Microelectronic can s upply product on tape & reel. The following table shows packages available on tape & reel along with m inimum reel quantities , reel s ize. Cham pion Microelectronic provides this taping per industry standard specific ations. All line items for tape & reel should be bas ed on multiples of reel quantity. Package Type T20 2,500 Package Tape Ammo. TO252 2,500 Type Box TO263 800 TO92 2,000 SC-70 3,000 PFC Introduce What’s PFC? Power factor correction (PFC) is a technique of counteracting the undesirable effects of electric loads that create a power factor (PF) that is less than 1. Power factor correction may be applied either by an electrical power transmission utility to improve the stability and efficiency of the transmission network; or, correction may be installed by individual electrical customers to reduce the costs charged to them by their electricity supplier." Explanation When an electric load has a PF lower than 1, the apparent power delivered to the load is greater than the real power that the load consumes. Only the real power is capable of doing work, but the apparent power determines the amount of current that flows into the load, for a given load voltage. Energy losses in transmission lines increase with increasing current. Power companies therefore require that customers, especially those with large loads, maintain the power factors of their respective loads within specified limits or be subject to additional charges. Engineers are often interested in the power factor of a load as one of the factors that affect the efficiency of power transmission. Power factor correction returns the power factor of an electric AC power transmission system to very near unity by switching in or out banks of capacitors or inductors which act to cancel the inductive or capacitive effects of the load. For example, the inductive effect of motor loads may be offset by locally connected capacitors. It is also possible to effect power factor correction with an unloaded synchronous motor connected across the supply. The power factor of the motor is varied by adjusting the field excitation and can be made to behave like a capacitor when over excited." It is not possible to cancel out harmonic current using these techniques, so different techniques must be used to correct nonlinear loads" What advantage is Champion can provide ■ ■ ■ ■ ■ Champion provide Champion provide Champion provide Champion provide Champion provide best solution to your customer best C/P ratio to your customer best support to your customer best FAE team to you next solution to you for your new customer ~5~ Product Guide 09 SIP- PFC / PWM Combo PDIP -08 SOP -08 SOP -10 SSO P-10 PDIP -16 SOP -16 Power Management ICs Part # Features Package CM6800 Pin-to-pin compatible with ML4800 with short circuit protection, UVLO=13V, fpfc=fpwm ☆ ☆ CM6800A 80+ PFC/PWM controller, pin to pin with CM6800, fpfc=fpwm ☆ ☆ CM6802A 80++ PFC/PWM controller, pin to pin with CM6800A, fpfc=fpwm ☆ ☆ CM6802B 80++ PFC/PWM controller, pin to pin with CM6800A, fpfc=2 x fpwm ☆ ☆ CM6805A 10 pin Passive PFC to Active PFC, PFC/PWM controller, fpfc=fpwm=67.5K ☆ CM6805B 10 pin Passive PFC to Active PFC, PFC/PWM controller, fpfc=fpwm=100K ☆ CM6806 10 pin Green Mode PFC/PWM Combo Controller, with Tri-Fault Protection, fpfc=2 x fpwm 55K:110K ☆ CM6807 10 pin Green Mode PFC/PWM Combo Controller, 85+ efficiency Low Cost AC Adapter Controller ☆ CM6903A 9 pinDIP PFC/PWMCombo Controller, with feed forward function, fpfc=fpwm=67.5K ☆ CM6903B 9 pinDIP PFC/PWMCombo Controller, with feed forward function, fpfc=fpwm=100K ☆ CM6300* 90++ efficiency AC Adapter for 50W to 200W applications ☆ CM6307* 94++ efficiency AC Adapter for 120W to 200W applications ☆ Only PFC Controller Features Package CM6501 8 pin SOIC Single PFC with follower boost function CM6502 8 pin DIP Single PFC with AC Brownout ☆ SIP- 09 ☆ Interleaved PFC Part # CM6565* Features PDIP -08 SOP -08 SOP -10 SSO P-10 PDIP -16 SOP -16 Part # PDIP -08 SOP -08 SOP -10 SSO P-10 PDIP -16 SOP -16 SIP- 09 Note*: New product will be available in the Q2 of year 2008 Package ☆ 2 Phase 16 pin Interleaved PFC controller; a 90+ controller PFC/Standby Cmobo Controller Package ☆ 10 pin PFC/Standby combo controller SIP- 09 CM6803 Features Secondary SRC/LLC/SR Controller Part # CM6900 Features PDIP -08 SOP -08 SOP -10 SSO P-10 PDIP -16 SOP -16 Part # PDIP -08 SOP -08 SOP -10 SSO P-10 PDIP -16 SOP -16 SIP- 09 Note*: New product will be available in the Q1 of year 2009 Package LLC/SRC + SR controller with both FM and PWM; a 90+ controller ~6~ ☆ Supply I OUT IVCCA IP VDD fsw Voltage (V) (A) (µ A) (µA) (MHz) CM8500 2V~6V 3.0 200 500 0.6 CM8501 2V~6V 1.5 220 500 1.2 Part # Features CM8501A 2V~6V 1.5 220 500 1.2 CM8501C 2V~6V 1.5 220 500 1.2 OP-1 TSS Switching Bus Terminators SOP -16 SOP -08 6 Bus & Interface Products Package 1. Source & Sink Current 2. Integrated Power MOSFETs 3. Output Voltage Programmable ☆ ☆ ☆ ☆ ☆ 4. Separate Voltages of VCCQ and PVDD ☆ 5. Shutdown for Standby or Suspend Mode Operation 6. Thermal Shutdown Protection Supply I OUT IVCCA IOP Voltage (V) (A) (µ A) (mA) CM8560 6 3.0 190 1.0 CM8561 6 1.5 190 1.2 2. Integrated Power MOSFETs CM8562 6 2.0 190 1.2 3. Output Voltage Programmable 4. Current Limit Protection and Short Circuit Protection Part # Features CM8562P 6 2.0 190 1.2 CM8562B 6 1.8 190 1.2 CM8562C 6 1.8 190 1.2 CM8562A 6 2.0 190 1.2 TO-2 63 TO-2 52 Linear Bus Terminators PSO P-08 SOP -08 7. Soft Start Package ☆ 1. Source & Sink Current ☆ ☆ ☆ ☆ ☆ ☆ 5. Shutdown for Standby or Suspend Mode Operation 6. Thermal Shutdown Protection 7. Minimum Exteral Components ☆ Supply I OUT IV CCA IP VDD fsw Voltage (V) (A) (µA) (µA) (MHz) CM2593 1.23V~37V 2.0 70 200 0.052 CM2596 1.23V~28V 3.0 70 200 0.150 CM2596S 1.23V~37V 3.0 70 200 0.150 Part # Features 1. Wide Input Voltage Range to 40V 2. Low Standby Current 3. Thermal S hutdown and Current Limit Protection 1. Wide Input Voltage Range to 32V 2. Low Standby Current 3. Thermal S hutdown and Current Limit Protection 1. Wide Input Voltage Range to 40V 2. Low Standby Current 3. Thermal S hutdown and Current Limit Protection ~7~ TO-2 63 SOT25 Low-Noise PWM Step-Down Regulators TSSO P-16 TO-2 20 SOP -08 TSSO P-08 SOP -16 Battery Management ICs Package ☆ ☆ ☆ ☆ ☆ Part # CM3706 Supply I OUT IV CCA IP VDD fsw Voltage (V) (A) (µA) (µA) (MHz) 2.5V~5.5V 0.6 270 1.5 Features TO-2 63 SOT25 Low-Noise PWM Step-Down Regulators TSSO P-16 TO-2 20 SOP -08 TSSO P-08 SOP -16 Battery Management ICs Package ☆ 1.Hi gh Effic iency: Up to 96% 2.1.5Mhz Cons tant Swi tc hing Frequency 3.600mA Output Current at VIN= 3V 4.Integrated Mai n s wi tc h and sy nc hronous recti fi er. No Sc hottk y Diode Required 5.2.5V to 5.5V Input Voltage Range 6.Output Voltage as Low as 0.6V 7.100% Duty Cy cl e i n Dropout 8.Low Qui esc ent Current: 300µ A 9.Slope Compensated Current Mode Control for Ex cel lent Line and Load Transient Res ponse 10.Short Ci rcuit Protecti on 11.Thermal Fault P rotec ti on 12.< 1µ A Shutdown Current CM3708 2V~6V 3.0 200 500 0.600 1. Sourc e & S ink Current CM3718 2V~6V 1.5 220 500 1.100 2. Integrated Power MOS FE Ts ☆ ☆ ☆ ☆ 3. Output Vol tage P rogrammable 4. S eparate Vol tages of V CCQ and PVDD 5. S hutdown for S tandby or S uspend Mode Operati on 6. Thermal Shutdown P rotec ti on 7. S oft S tart Part # CM1117 Supply V OUT Vre f (Adj.) Voltage(V) (V) (V) 18 Adj. 1.238~1.262 IOUT (A) 1.0 1.8/2.5/3.3V 12 CM1117L 7 1.8/2.5/3.3V ☆ 1.238~1.262 1.0 ☆ 1.238~1.262 1.0 ☆ Adj. 1.8/2.5/3.3V 1. Full Current Rating Over Line & Temp. ~8~ 63 TO-2 52 20 Package 2. Fast Transient Response Adj. CM1117F Features TO-2 Low Dropout Linear Regulators TO-2 SOT -223 Low Dropout Regulators VOUT (V) I OUT Max. Max. V IN Tol Adj. Fixed (A) Dropout (V) (V) % Part # Features -89 SOT353 SOT SOT -23-5 CMOS LDO Regulators SOT -23-3 Shutd own Low Dropout Regulators Package 150mA SINGLE OUTPUT LDO CM2816AC 1.2 0.15 0.3 7 2.0 CM2816A 1.5 0.15 0.3 7 2.0 CM2816D 1.8 0.15 0.3 7 2.0 CM2816F 2.0 0.15 0.3 7 2.0 CM2816K 2.5 0.15 0.3 7 2.0 CM2816N 2.7 0.15 0.3 7 2.0 CM2816P 2.8 0.15 0.3 7 2.0 CM2816S 3.0 0.15 0.3 7 2.0 CM2816U 3.3 0.15 0.3 7 2.0 CM2816V 3.6 0.15 0.3 7 2.0 1. Very Low Dropout Voltage 2.Guaranteed 300mAOutput 3. High Output Voltage Accuracy 4. 30µA Quiescent Current 5. Thermal Shutdown 6. Current Limiting 7. Factory Pre-set Output Voltage 8. Short Circuit Current Fold-Back 9. Low Temperature Coefficient 10. Noise Reduction Bypass Capacitor 11. Power-Saving Shutdown Mode 12. Stability with Low ESR Capacitors ☆ ☆ ☆ ☆ ☆ ☆ ☆ ☆ ☆ ☆ ☆ ☆ ☆ ☆ ☆ ☆ ☆ ☆ ☆ ☆ ☆ ☆ ☆ ☆ ☆ ☆ ☆ ☆ ☆ ☆ ☆ ☆ ☆ ☆ ☆ ☆ ☆ ☆ ☆ ☆ ☆ ☆ ☆ ☆ ☆ ☆ ☆ ☆ ☆ ☆ ☆ ☆ ☆ ☆ ☆ ☆ ☆ ☆ ☆ ☆ ☆ ☆ ☆ ☆ ☆ ☆ ☆ ☆ ☆ ☆ ☆ ☆ ☆ ☆ ☆ ☆ ☆ ☆ ☆ ☆ 300mA SINGLE OUTPUT LDO CM2836AC 1.2 0.3 0.3 7 2.0 CM2836A 1.5 0.3 0.3 7 2.0 CM2836D 1.8 0.3 0.3 7 2.0 CM2836F 2.0 0.3 0.3 7 2.0 CM2836K 2.5 0.3 0.3 7 2.0 CM2836N 2.7 0.3 0.3 7 2.0 CM2836P 2.8 0.3 0.3 7 2.0 CM2836S 3.0 0.3 0.3 7 2.0 CM2836U 3.3 0.3 0.3 7 2.0 CM2836V 3.6 0.3 0.3 7 2.0 1. Very Low Dropout Voltage 2.Guaranteed 300mAOutput 3. High Output Voltage Accuracy 4. 30µA Quiescent Current 5. Thermal Shutdown 6. Current Limiting 7. Factory Pre-set Output Voltage 8. Short Circuit Current Fold-Back 9. Low Temperature Coefficient 10. Noise Reduction Bypass Capacitor 11. Power-Saving Shutdown Mode 12. Stability with Low ESR Capacitors 300mA SINGLE OUTPUT LDO CM2835S 3.3 0.3 0.3 7 1.5 CM2838S 3.3 0.3 0.3 7 1.5 ~9~ 1. Very Low Dropout Voltage 2.Guaranteed 300mAOutput 3. High Output Voltage Accuracy 4. 30µA Quiescent Current 5. Thermal Shutdown 6. Current Limiting 7. Factory Pre-set Output Voltage 8. Short Circuit Current Fold-Back 9. Low Temperature Coefficient 10. Noise Reduction Bypass Capacitor 11. Power-Saving Shutdown Mode 12. Stability with Low ESR Capacitors ☆ ☆ ☆ ☆ CMOS LDO Regulators V OUT I OUT Max. Max. V IN (V) (A) Dropout (V) (V) Part # Features SOT89 SOT223 Low Dropout Regulators Package 600mA SINGLE OUTPUT LDO CM2861K 2.5 0.6 0.8 7 CM2861S 3.3 0.6 0.6 7 CM2865K 2.5 0.6 0.8 7 CM2865S 3.3 0.6 0.6 7 ☆ ☆ 1. Very Low Dropout Voltage 2.Guaranteed 600mAOutput 3. High Output Voltage Accuracy 4. 30µA Quiescent Current 5. Over-Temperature Protection 6. Current Limiting 7. Factory Pre-set Output Voltage 8. Short Circuit Current Fold-Back 9. Low Temperature Coefficient ☆ ☆ ☆ ☆ ☆ ☆ Cathode Part # CM431 Typ. Vre f Max.I k (V) (V) (mA) 37 2.5 100 Voltage Features SOP08 TO-9 2 SOT89 Voltage Reference SOT23-5 SOT23-3 Voltage Comparator & Reference Package ☆ ☆ ☆ ☆ ☆ ☆ ☆ ☆ ☆ ☆ ☆ ☆ 1. Adjustable Output Voltage to 36V 2. Sink Current Capability from 1mA to 100mA 3. Dynamic Output Impedance 0.2Ω Typ. CM431A 18 2.5 100 1. Adjustable Output Voltage to 16V 2. Sink Current Capability from 1mA to 100mA 3. Dynamic Output Impedance 0.2Ω Typ. CM431L 20 1.25 100 1. Adjustable Output Voltage to 20V 2. Sink Current Capability from 1mA to 100mA 3. Dynamic Output Impedance 0.25Ω Typ. ~10~ ☆ Power MOSFETs V (BR)DS S ID @ 25℃ RDS (ON) @ 10V (V) (A) (Ω) Max. Part # Package HIGH VOLTAGE SINGLE N-CHANNEL CMT05N50 500 5 1.50 TO-220, TO-220FP CMT08N50 500 8 0.80 TO-220, TO-220FP CMT14N50 500 14 0.40 TO-3P CMT01N60 600 1 8.00 TO-251, TO-252 CMT02N60 600 2 4.40 TO-252, TO-220, TO-220FP CMT04N60 600 4 2.40 TO-220, TO-220FP CMT06N60 600 6 1.20 TO-220, TO-220FP 6 28 SOP-08 -5.3 90 SOP-08 -4.5 90 SOP-08 LOW VOLTAGE DUAL N-CHANNEL CMT9926 20 LOW VOLTAGE DUAL P-CHANNEL CMT4953 -30 LOW VOLTAGE SINGLE P-CHANNEL CMT9435 30 LOW POWER SINGLE N-CHANNEL CMT2302 20 2.8 85 SOT-23-3 CMT2304 30 2.5 117 SOT-23-3 CMT2N7002 60 0.115 7.5 SOT-23-3 CMT2N7002W 60 0.115 7.5 SOT-323 LOW POWER SINGLE P-CHANNEL CMT2301 -20 -2.3 13 SOT-23-3 CMT2303 -30 -1.7 24 SOT-23-3 ~11~ Schottky Barrier Diodes 8.0AM P Schottky Barrier Diodes Part # SR820 SR830 SR840 SR850 SR860 SR880 SR8100 10.0AMP Schottky Part # SR1020 SR1030 SR1040 SR1050 SR1060 SR1080 SR10100 SR10150 SR10200 16.0AMP Schottky Part # SR1620 SR1630 SR1640 SR1650 SR1660 SR1680 SR16100 SR16150 SR16200 20.0AMP Schottky Part # SR2020 SR2030 SR2040 SR2050 SR2060 SR2080 SR20100 SR20150 SR20200 30.0AMP Schottky Part # SR3020 SR3030 SR3040 SR3050 SR3060 SR3080 SR30100 PIV (V) 20 30 40 50 60 80 100 Barrier Diodes PIV (V) 20 30 40 50 60 80 100 150 200 Barrier Diodes PIV (V) 20 30 40 50 60 80 100 150 200 Barrier Diodes PIV (V) 20 30 40 50 60 80 100 150 200 Barrier Diodes PIV (V) 20 30 40 50 60 80 100 Io(A) 8 8 8 8 8 8 8 IFSM (APK ) 150 150 150 150 150 150 150 VFM (V) 0.58 0.58 0.58 0.70 0.70 0.87 0.87 IR @ 25℃ (mA) 5.0 5.0 5.0 5.0 5.0 0.5 0.5 Package DO-201 DO-201 DO-201 DO-201 DO-201 DO-201 DO-201 Io(A) 10 10 10 10 10 10 10 10 10 IFSM (APK ) 120 120 120 120 120 120 120 120 120 VFM (V)@5A 0.55 0.55 0.55 0.70 0.70 0.87 0.87 0.87 0.87 IR @ 25℃ (mA) 0.3 0.3 0.3 0.15 0.15 0.05 0.05 0.1 0.1 Package TO-220 TO-220 TO-220 TO-220 TO-220 TO-220 TO-220 TO-220 TO-220 Io(A) 16 16 16 16 16 16 16 16 16 IFSM (APK ) 150 150 150 150 150 150 150 150 150 VFM (V)@8A 0.55 0.55 0.55 0.70 0.70 0.85 0.85 0.95 0.95 IR @ 25℃ (mA) 0.5 0.5 0.5 0.5 0.5 0.1 0.1 0.1 0.1 Package TO-220 TO-220 TO-220 TO-220 TO-220 TO-220 TO-220 TO-220 TO-220 Io(A) 20 20 20 20 20 20 20 20 20 IFSM (APK ) 150 150 150 150 125 125 125 175 175 VFM (V)@10A 0.65 0.65 0.65 0.75 0.75 0.93 0.93 0.95 0.95 IR @ 25℃ (mA) 0.5 0.5 0.5 0.3 0.3 0.2 0.2 0.1 0.1 Package TO-220 TO-220 TO-220 TO-220 TO-220 TO-220 TO-220 TO-220 TO-220 Io(A) 30 30 30 30 30 30 30 IFSM (APK ) 230 230 230 230 230 230 230 VFM (V) 0.58 0.58 0.58 0.70 0.70 0.87 0.87 IR @ 25℃ (mA) 1.0 1.0 1.0 1.0 1.0 1.0 1.0 Package TO-220 TO-220 TO-220 TO-220 TO-220 TO-220 TO-220 ~12~ ISO9001:2002 registered Champion Microelectronic Corp. Headquarters - HsinChu, Taiwan 5F, No.11, Park Avenue II, Hsinchu Science-Based Industrial Park, Hsinchu City, Taiwan 300 Phone: +886-3-567-9979 Fax: +886-3-567-9909 http: //www.championmicro.com.tw http: //www.champion-micro.com Worldwide Sales & Marketing Division - Taipei, Taiwan 7F-6, No.32, Sec.1, Chenggong Rd., Nangang District, Taipei City 115, Taiwan Phone: +886-2-2788-0558 Fax: +886-2-2788-2985 Email: [email protected] http: //www.championmicro.com.tw http: //www.champion-micro.com R&D Center - San Jose, CA, USA 4020 Moorpark Avenue, Suite 105, San Jose, CA 95117, U.S.A. Phone: +1-408-9851898 Fax: +1-408-9851683 Shenzhen Office 17F-30, No.3037, Shennan Rd., Shenzhen P.R. China 518033 Phone: +86-755-83980936 Fax: +86-755-83981296 Jul y, 2007, Rev.9