8 PIN SOP DUAL CHANNEL HIGH SPEED 1Mbit/s TRANSISTOR PHOTOCOUPLER EL053X series Schematic Features •Compliance Halogen Free . (Br <900 ppm ,Cl <900 ppm , Br+Cl < 1500 ppm) • High speed 1Mbit/s • High isolation voltage between input and output (Viso=3750 Vrms ) • Guaranteed performance from 0°C to 70°C • Wide operating temperature range of -55°C to 100°C • Compliance with EU REACH • Pb free and RoHS compliant • UL and cUL approved(No. E214129) • VDE approved (No. 40028116) • SEMKO approved • NEMKO approved • DEMKO approved • FIMKO approved Pin Configuration 1. Anode 2. Cathode 3. Cathode 4. Anode 5. Gnd 6. Vout 2 7. Vout 1 8. VCC Description The EL053X devices each consist of an infrared emitting diode, optically coupled to a high speed photo detector transistor. A separate connection for the photodiode bias and output-transistor collector increase the speed by several orders of magnitude over conventional phototransistor couplers by reducing the base-collector capacitance of the input transistor. The devices are packaged in an 8-pin small outline package which conforms to the standard SO-8 footprint. Applications • Line receivers • Telecommunication equipments • Power transistor isolation in motor drives • Replacement for low speed phototransistor photo couplers • Feedback loop in switch-mode power supplies • Home appliances • High speed logic ground isolation 1 Copyright © 2010, Everlight All Rights Reserved. Release Date : May 13, 2013. Issue No: DPC-0000167 Rev.4 www.everlight.com DATASHEET 8 PIN SOP DUAL CHANNEL HIGH SPEED 1Mbit/s TRANSISTOR PHOTOCOUPLER EL053X series Absolute Maximum Ratings (Ta=25℃) Parameter Symbol Rating Unit IF 25 mA IFP 50 mA IFtrans 1 A Reverse voltage VR 5 V Power dissipation PIN 45 mW Power dissipation PO 100 mW VEBR 5 V Average Output current IO(AVG) 8 mA Peak Output current IO(PK) 16 mA Output voltage VO -0.5 to 20 V Supply voltage VCC -0.5 to 30 V *1 VISO 3750 V rms Operating temperature TOPR -55 ~ +100 °C Storage temperature TSTG -55 ~ +125 °C TSOL 260 °C Forward current Input Peak forward current (50% duty, 1ms P.W) Peak transient current (≤1µs P.W,300pps) Emitter-Base reverse voltage Output Isolation voltage Soldering temperature *2 Notes: *1 AC for 1 minute, R.H.= 40 ~ 60% R.H. In this test, pins 1, 2, 3, 4 are shorted together, and pins 5, 6, 7, 8 are shorted together. *2 For 10 seconds 2 Copyright © 2010, Everlight All Rights Reserved. Release Date : May 13, 2013. Issue No:DPC-0000167 Rev.4 www.everlight.com DATASHEET 8 PIN SOP DUAL CHANNEL HIGH SPEED 1Mbit/s TRANSISTOR PHOTOCOUPLER EL053X series Electrical Characteristics (TA=0 to 70°C unless specified otherwise) Input Symbol Min. Typ. Max. Unit Condition Forward voltage VF - 1.4 1.8 V IF = 16mA Reverse Voltage VR 5.0 - - V IR = 10µA ∆VF/∆TA - -1.6 - mV/°C IF =16mA CIN - 60 - pF VF=0V, f=1MHz Symbol Min Typ. Max. Unit Condition - 0.001 0.5 Parameter Temperature coefficient of forward voltage Input Capacitance Output Parameter Logic High Output Current µA IOH Logic Low Supply Current ICCL Logic High Supply Current ICCH - 0.01 1 - - 50 - 120 200 - 0.01 1 - - 2 µA µA IF=0mA, VO=VCC=5.5V, TA=25°C IF=0mA, VO=VCC=15V, TA=25°C IF=0mA, VO=VCC=15V IF=16mA, VO=Open, VCC=15V IF=0mA, VO=Open, VCC=15V, TA=25°C IF=0mA, VO=Open, VCC=15V Transfer Characteristics (TA=0 to 70°C unless specified otherwise) Min Typ. Max. 7 - 50 19 - 50 EL0530 5 - - EL0531 15 - - EL0530 - 0.18 0.4 - 0.30 0.4 EL0530 - - 0.5 EL0531 - - 0.5 Parameter Symbol EL0530 Current Transfer Ratio Logic Low Output Voltage 3 EL0531 CTR EL0531 Unit IF = 16mA ,VO = 0.4V, VCC=4.5V, TA=25°C % IF = 16mA ,VO = 0.5V, VCC=4.5V V VOL Condition IF = 16mA ,IO = 1.1mA, VCC=4.5V, TA=25°C IF = 16mA ,IO = 3mA, VCC=4.5V, TA=25°C IF = 16mA ,IO = 0.8mA, VCC=4.5V IF=16mA ,IO=2.4mA, VCC=4.5V Copyright © 2010, Everlight All Rights Reserved. Release Date : May 13, 2013. Issue No:DPC-0000167 Rev.4 www.everlight.com DATASHEET 8 PIN SOP DUAL CHANNEL HIGH SPEED 1Mbit/s TRANSISTOR PHOTOCOUPLER EL053X series Switching Characteristics (TA=0 to 70°C unless specified otherwise, IF=16mA, Vcc=5V) Parameter Propagatio n Delay Time to Logic Low Propagatio n Delay Time to Logic High Common Mode Transient Immunity at Logic High Common Mode Transient Immunity at Logic Low (Fig.9)*3 4 Symbol Min Typ. Max. Unit - - 1.5 - - 2.0 - - 0.8 RL=1.9KΩ, TA=25°C - - 1.0 RL=1.9KΩ - - 1.5 RL=4.1KΩ, TA=25°C - - 2.0 RL=4.1KΩ, TA=25°C EL0530 tPHL EL0531 µs EL0530 tPLH µs RL=4.1KΩ - 0.8 RL=1.9KΩ, TA=25°C - - 1.0 RL=1.9KΩ 1,000 10,000 V/µs CMH EL0531 1,000 - - EL0530 1,000 10,000 V/µs CML EL0531 RL=4.1KΩ - EL0531 EL0530 Condition 1,000 - - IF = 0mA , VCM=10Vp-p, RL=4.1KΩ, TA =25°C IF = 0mA , VCM=1500Vp-p, RL=1.9KΩ, TA =25°C IF = 16mA , VCM=10Vp-p, RL=4.1KΩ, TA =25°C IF = 16mA , VCM=1500Vp-p, RL=1.9KΩ, TA=25°C Copyright © 2010, Everlight All Rights Reserved. Release Date : May 13, 2013. Issue No:DPC-0000167 Rev.4 www.everlight.com DATASHEET 8 PIN SOP DUAL CHANNEL HIGH SPEED 1Mbit/s TRANSISTOR PHOTOCOUPLER EL053X series Typical Electro-Optical Characteristics Curves 5 Copyright © 2010, Everlight All Rights Reserved. Release Date : May 13, 2013. Issue No:DPC-0000167 Rev.4 www.everlight.com DATASHEET 8 PIN SOP DUAL CHANNEL HIGH SPEED 1Mbit/s TRANSISTOR PHOTOCOUPLER EL053X series 6 Copyright © 2010, Everlight All Rights Reserved. Release Date : May 13, 2013. Issue No:DPC-0000167 Rev.4 www.everlight.com DATASHEET 8 PIN SOP DUAL CHANNEL HIGH SPEED 1Mbit/s TRANSISTOR PHOTOCOUPLER EL053X series Figure 8 Switching Time Test Circuit & Waveform Figure 9 Transient Immunity Test Circuit & Waveform Note: *3 Common mode transient immunity in logic high level is the maximum tolerable (positive) dVcm/dt on the leading edge of the common mode pulse signal VCM, to assure that the output will remain in a logic high state (i.e., VO > 2.0V). Common mode transient immunity in logic low level is the maximum tolerable (negative) dVcm/dt on the trailing edge of the common mode pulse signal, VCM, to assure that the output will remain in a logic low state (i.e., VO < 0.8V). 7 Copyright © 2010, Everlight All Rights Reserved. Release Date : May 13, 2013. Issue No:DPC-0000167 Rev.4 www.everlight.com DATASHEET 8 PIN SOP DUAL CHANNEL HIGH SPEED 1Mbit/s TRANSISTOR PHOTOCOUPLER EL053X series Order Information Part Number EL053X(Z)-V Note X Z V 8 = Part No. (X = 0 or 1) = Tape and reel option (TA, TB or none) = VDE (optional) Option None -V Standard Standard + VDE Description Packing quantity 100 units per tube 100 units per tube (TA) TA tape & reel option 2000 units per reel (TB) TB tape & reel option 2000 units per reel (TA)-V TA tape & reel option + VDE 2000 units per reel (TB)-V TB tape & reel option + VDE 2000 units per reel Copyright © 2010, Everlight All Rights Reserved. Release Date : May 13, 2013. Issue No:DPC-0000167 Rev.4 www.everlight.com DATASHEET 8 PIN SOP DUAL CHANNEL HIGH SPEED 1Mbit/s TRANSISTOR PHOTOCOUPLER EL053X series Package Dimension (Dimensions in mm) Recommended pad layout for surface mount leadform 9 Copyright © 2010, Everlight All Rights Reserved. Release Date : May 13, 2013. Issue No:DPC-0000167 Rev.4 www.everlight.com DATASHEET 8 PIN SOP DUAL CHANNEL HIGH SPEED 1Mbit/s TRANSISTOR PHOTOCOUPLER EL053X series Device Marking EL 0531 YWWV Notes EL 0531 Y WW V 10 denotes EVERLIGHT denotes Device Number denotes 1 digit Year code denotes 2 digit Week code denotes VDE (optional) Copyright © 2010, Everlight All Rights Reserved. Release Date : May 13, 2013. Issue No:DPC-0000167 Rev.4 www.everlight.com DATASHEET 8 PIN SOP DUAL CHANNEL HIGH SPEED 1Mbit/s TRANSISTOR PHOTOCOUPLER EL053X series Tape & Reel Packing Specifications Option TA Option TB Direction of feed from reel Direction of feed from reel Tape dimensions Dimension No. A0 A1 B0 D0 D1 E F Dimension(mm) 6.2±0.1 4.1±0.1 5.28±0.1 1.5±0.1 1.5±0.3 1.75±0.1 5.5±0.1 Dimension No. Po P1 P2 t W K0 K1 Dimension(mm) 4.0±0.1 8.0±0.1 2.0±0.1 0.4±0.1 3.7±0.1 0.3±0.1 11 12.0+0.3/ -0.1 Copyright © 2010, Everlight All Rights Reserved. Release Date : May 13, 2013. Issue No:DPC-0000167 Rev.4 www.everlight.com DATASHEET 8 PIN SOP DUAL CHANNEL HIGH SPEED 1Mbit/s TRANSISTOR PHOTOCOUPLER EL053X series Precautions for Use 1. Soldering Condition 1.1 (A) Maximum Body Case Temperature Profile for evaluation of Reflow Profile Note: Reference: IPC/JEDEC J-STD-020D Preheat Temperature min (Tsmin) 150 °C Temperature max (Tsmax) 200°C Time (Tsmin to Tsmax) (ts) Average ramp-up rate (Tsmax to Tp) 60-120 seconds 3 °C/second max Other Liquidus Temperature (TL) 217 °C Time above Liquidus Temperature (t L) 60-100 sec Peak Temperature (TP) 260°C Time within 5 °C of Actual Peak Temperature: TP - 5°C 30 s Ramp- Down Rate from Peak Temperature 6°C /second max. Time 25°C to peak temperature Reflow times 8 minutes max. 3 times . 12 Copyright © 2010, Everlight All Rights Reserved. Release Date : May 13, 2013. Issue No:DPC-0000167 Rev.4 www.everlight.com DATASHEET 8 PIN SOP DUAL CHANNEL HIGH SPEED 1Mbit/s TRANSISTOR PHOTOCOUPLER EL053X series DISCLAIMER 1. Above specification may be changed without notice. EVERLIGHT will reserve authority on material change for above specification. 2. When using this product, please observe the absolute maximum ratings and the instructions for using outlined in these specification sheets. EVERLIGHT assumes no responsibility for any damage resulting from use of the product which does not comply with the absolute maximum ratings and the instructions included in these specification sheets. 3. These specification sheets include materials protected under copyright of EVERLIGHT corporation. Please don’t reproduce or cause anyone to reproduce them without EVERLIGHT’s consent. 13 Copyright © 2010, Everlight All Rights Reserved. Release Date : May 13, 2013. Issue No:DPC-0000167 Rev.4 www.everlight.com