Thomas Research Products SSL Solutions Faster Than The Speed Of Light ® PLED-200W Series– Fixed Output & Dimmable Total Power: 200 Watts Input Voltage: 100 - 277 Vac Nom. Outputs: Single from 12-445 Vdc Indoor or Outdoor Applications, NEMA6, IP66 High Power Factor UL8750, EN61347, CSA 22.2 EN61000-3-2, EN61000-3-3 Class C Switch Mode LED Drivers Constant Current & Constant Voltage with Isolation Black Magic Thermal Advantage™ Aluminum Housing Electrical Specifications 100-277 Vac Nom. (90-305 V Min/Max) Frequency: 50/60 Hz Nom. (47-63 Hz Min/Max) Power Factor: >0.90 @ full load, 100V through 277V Inrush Current: <45.0 Amps max @ 230 Vac, cold start, full load Input Current: 0.95 Amps max @ 230 Vac, 1.83 A max @ 120 Vac Maximum Power: 200W Current Accuracy: ± 2% Over input line variation Load Regulation: ± 3% THD: < _ 20% @ full load Leakage Current: 600 µA Typical Hold Up Time: Half Cycle Protection: utput Protection: Over-Voltage, Over-Current, O and Short Circuit reset by power cycling Y Input Voltage Range: -30ºC to +60ºC Maximum Case Temp. 90°C Storage Temperature: -40ºC to +85ºC Humidity: 5% to 95% Cooling: Convection Vibration Frequency: 5 to 55 Hz/2g, 30 minutes MTBF: 280,000 Hours at full load and 40ºC ambient conditions per MIL-217F Notice 2 EMC: FCC 47CFR Part 15 Class B compliant Impact Resistance: 1g/s Weight: TBD IM L 0-10V & Resistance dimmable version comes with an extra two wires +Purple/-Gray on the output side. -D 0-10V Dimming is compatible with most quality 0-10V wall dimmers. See page 3 for additional specifications. E -D: P R -PD: PWM Dimmable version comes with an extra two wires +Purple/-Gray on the output side. PD PWM version is PWM Dimmable via a positive 10% to 100% Duty Cycle, 200Hz to 1KHz, 0-10V Pulse. See page 4 for additional specifications. E332160 Note: LED drivers are designed and intended to operate LED loads only. Non-LED loading may be outside the specified design limits of our LED driver, and therefore cannot covered by any warranty. If you desire to use our LED drivers to operate non-LED loads please contact us to discuss compatibility. R Output Current Output Voltage Max Output Typical (mA ±5%) Range (Vdc) Power (W) Efficiency PLED200W-445-C0450-XX 450 222 - 445 200W 92% PLED200W-285-C0700-XX 700 142 - 285 200W 92% PLED200W-190-C1050-XX 1050 95 - 190 200W 91% PLED200W-142-C1400-XX 1400 71 - 142 200W 91% PLED200W-114-C1750-XX 1750 57 - 114 200W 91% IN Operating Temperature: Ordering Options: Model Number A Environmental Specifications Constant Current Versions - Product Specifications PLED200W-095-C2100-XX 2100 47 - 95 200W 91% PLED200W-081-C2450-XX 2450 40 - 81 200W 90% PLED200W-071-C2800-XX 2800 35 - 71 200W 90% PLED200W-063-C3150-XX 3150 31 - 63 200W 90% PLED200W-057-C3500-XX 3500 28 - 57 200W 90% PLED200W-047-C4200-XX 4200 23 - 47 200W 89% PLED200W-40-C4900-XX 4900 20 - 40 200W 89% PLED200W-035-C5600-XX 5600 17 - 35 200W 89% PLED200W-032-C6300-XX 6300 16 - 32 200W 88% PLED200W-024-C8330-XX 8330 12 - 24 200W 88% -XX indicates dimming options are available. See options at left. Blank = fixed current output Constant Voltage Versions - Product Specifications Model Number Output Voltage Output Current Max Output Typical (Vdc ±5%) Range (mA) Power (W) Efficiency PLED200W-445 445 225-450 200W 92% PLED200W-285 285 350-700 200W 92% PLED200W-190 190 525-1050 200W 91% PLED200W-142 142 700-1400 200W 91% PLED200W-114 114 875-1750 200W 91% PLED200W-095 95 1050-2100 200W 91% PLED200W-081 81 1225-2450 200W 90% PLED200W-071 71 1400-2800 200W 90% PLED200W-063 63 1575-3150 200W 90% PLED200W-057 57 1750-3500 200W 90% PLED200W-047 47 2100-4200 200W 89% PLED200W-040 40 2450-4900 200W 89% PLED200W-035 35 2800-5600 200W 89% PLED200W-032 32 3150-6300 200W 88% PLED200W-024 24 4165-8330 200W 88% Specifications subject to change without notice. Thomas Research Products • 11548 Smith Dr. • Huntley, IL 60142 • T: 847-515-3057 • F: 847-515-3047 • www.trpssl.com 7-29-13 Thomas Research Products SSL Solutions Faster Than The Speed Of Light ® PLED-200W Pg 2 of 4 Dimensions - Inches (mm) WIRE SPECS: AC Input: UL2733 Jacketed #18AWG DC Output: UL2733 Jacketed #18AWG Dimming Control: UL2733 Jacketed #22AWG Dimming Purple (Dim+) Gray (Dim-) INPUT Black (ACL) White (ACN) Green (GND) OUPUT Red (V+) Blue (V-) UL Conditions of Acceptability See website for additional information Thomas Research Products • 11548 Smith Dr. • Huntley, IL 60142 • T: 847-515-3057 • F: 847-515-3047 • www.trpssl.com Thomas Research Products SSL Solutions Faster Than The Speed Of Light ® PLED-200W Pg 3 of 4 "-D" Option: 0-10VDC and Resistance Dimming Parameters Minimum Typical Maximum 0mA -2.0V — — 2mA +15V Source Current out of 0-10V Purple Wire Absolute Voltage Range on 0-10V (+) Purple Wire Typical Dimming Circuit Dim (+) Purple PLED200W-xxx-Cxxxx-D IP710 Wall Dimmer Dim (-) Gray (Dimmer must be current-sink type control) Output Current / 0-10VDC Dimming Input Output Current % 100 90 80 70 60 50 40 30 20 10 0 0V 1V 2V 3V 4V 5V 6V Dimming Input (Vdc) 7V 8V 9V 10V Notes: 1. 0-10V dimmable version comes with an extra two wires +Purple/-Gray on the output side. 2. Compatible with most 0-10V Wall Slide dimmers and direct 0-10V analog signal. Recommended dimmer is Leviton IP710 or equivalent 3. 0-10V dimmable version is not intended to dim to zero (off). Will be Iout <10% @ Vdim <1.0V 4. 0-10V dimmable version output will be 100% with Purple/Gray open and minimum with Purple/Gray Shorted. Thomas Research Products • 11548 Smith Dr. • Huntley, IL 60142 • T: 847-515-3057 • F: 847-515-3047 • www.trpssl.com Thomas Research Products SSL Solutions Faster Than The Speed Of Light ® PLED-200W Pg 4 of 4 "-PD" Option: PWM Dimming Parameters Absolute Maximum Voltage Range on PWM Input (Purple Wire) Input LOW Level Voltage Range (Purple Wire) Input HIGH Level Voltage Range (Purple Wire) Sink Current into PWM Input (Purple Wire) PWM Input Signal Frequency PWM Input Signal Positive Duty Cycle Minimum Typical Maximum -2.0V -2.0 +9.0 0mA 200Hz 0% 10V 0V 10V — — 10-90% +28V +7.5V 28V 1.2mA 1000Hz 100% PWM Positive Dimming Typical Circuit PWM (+) Purple PLED200W-xxx-Cxxxx-PD PWM In Return (-) Gray Output Current / Positive Duty Cycle Output Current % 100 90 80 70 60 50 40 30 20 10 0 0% 10% 20% 30% 40% 50% 60% Positive Duty Cycle 70% 80% 90% 100% Notes: 1. PWM Dimmable version comes with an extra 2 wires +Purple/-Gray on the output side. 2. Below 10% Duty cycle proper dimming operation is not assured. Unit is not intended to turn off at <10% Duty Cycle. 3. PWM dimmable version output will be 100% with Purple/Gray open and minimum with Purple/Gray Shorted. Thomas Research Products • 11548 Smith Dr. • Huntley, IL 60142 • T: 847-515-3057 • F: 847-515-3047 • www.trpssl.com