96RC-ST-2C-P-TR Test Report Test Requestor Lydia.Liu Job Title Testing Engineer Tenthy.Zhang Job Title AKDC DQA Engineer Approved by Sophie.Song Job Title AKDC DQA assistant manager Release Date Revision Release Status 2013-1-15 V1.0 Formal Release Page 1 of 18 Drawings and specifications herein are property of Advantech and shall not be reproduced or copied or used without prior written permission. Revision History: Revision Date 2013/1/15 Revision 1.0 Description First version released Creator Tenthy.Zhang Page 2 of 18 Drawings and specifications herein are property of Advantech and shall not be reproduced or copied or used without prior written permission. Content Test Item List Summary...................................................................................................... 5 Product Information ........................................................................................................... 7 Test Software ...................................................................................................................... 10 Test Item ..............................................................................................................................11 Chapter 1: Function test ..............................................................................................11 1.1 Device Information confirm ........................................................................... 11 1.2 Basic function test ............................................................................................ 12 1.2.1 RAID Level test ............................................................................................... 12 1.2.2 Rebuild test....................................................................................................... 12 1.2.3 Drive Interface test .......................................................................................... 13 1.3 LED &Jumpers and Connectors ................................................................... 13 Chapter 2: Compatibility test .................................................................................... 14 2.1 With OS compatibility test ............................................................................. 14 2.2 With motherboard compatibility test ............................................................ 14 2.3 With PCIE Bus test ......................................................................................... 16 Chapter 3: Performance test ...................................................................................... 17 3.1 HD Tach ........................................................................................................... 17 3.2 HD Tune ........................................................................................................... 17 3.2.2 Read Test .......................................................................................................... 17 3.2.3 Write test .......................................................................................................... 17 Chapter 4: Reliability test .......................................................................................... 18 4.1 Room temperature test ................................................................................... 18 Page 3 of 18 Drawings and specifications herein are property of Advantech and shall not be reproduced or copied or used without prior written permission. Test Result Definition Item Description Pass Compatibility test properly without any problem. Fail Compatibility test can’t work properly and can’t meet the product spec, please describe the issue to the “Remark” item in detail. No test No test (no test tool or device or driver not ready); please write reason to the “Remark” item. N/A Spec not support. Limitation Compatibility issue Limitation, it needs formal approval mail or other formal reply from PM or Applicant or Manufacturer. Page 4 of 18 Drawings and specifications herein are property of Advantech and shall not be reproduced or copied or used without prior written permission. Test Item List Summary Num. Chapter 1 Result Test item Function test Pass 1.1 Device Information confirm Pass 1.2 Basic function test Pass 1.2.1 RAID Level test Pass 1.2.2 Rebuild test Pass 1.2.3 Drive interface test Pass 1.2.4 Hybrid RAID test Pass LED &Jumpers and Connectors Pass Compatibility test Pass 2.1 With OS compatibility test Pass 2.2 With motherboard compatibility test Pass 2.3 With PCIE Bus test Pass Performance test Pass 3.1 HD Tach Pass 3.2 HD Tune Pass 3.2.1 Read test Pass 3.2.2 Write test Pass Reliability test Pass Room temperature test Pass 1.3 Chapter 2 Chapter 3 Chapter 4 4.1 Remark Engineer summary: Page 5 of 18 Drawings and specifications herein are property of Advantech and shall not be reproduced or copied or used without prior written permission. Appendix 1: Motherboard List MB/SBC Core Chipset PCA-6010 945GC+ICH7 PCA-6011 Intel G41+ICH7 PCA-6194 Intel Q965+ICH8DO PCI-7031 Atom D510+ICH8M Remark Appendix 2: HDD List P-TD Part Number Band MN/PN Remark 96ND500G-ST-WD5K3 WD WD5000LPVT 2.5'' SATA HDD 96ND1T-ST-WD5K WD WD10JPVT 2.5'' SATA HDD 96ND1T-ST-WD5KE WD WD10JUCT 2.5'' SATA HDD 96ND750G-ST-WD5K WD WD7500BPVT 2.5'' SATA HDD 96ND500G-ST-WD5KE WD WD500LUCT 2.5'' SATA HDD 96ND750G-ST-WD7K WD WD7500BPKT 2.5'' SATA HDD 96ND320G-ST-WD7K WD WD3200BEKT 2.5'' SATA HDD 96ND320G-ST-WD5K3 WD WD3200BPVT 2.5'' SATA HDD 96HD2000G-ST-SG7K2 Seagate ST2000DM001 3.5'' SATA HDD 96HD2000G-ST-SG7K3 Seagate ST2000VX000 3.5'' SATA HDD 96HD1T-ST-WD7K WD WD10EZEX 3.5'' SATA HDD 96HD1000G-ST-SG7K6 Seagate ST1000DM003 3.5'' SATA HDD Page 6 of 18 Drawings and specifications herein are property of Advantech and shall not be reproduced or copied or used without prior written permission. Product Information Advantech Part Number 96RC-ST-2C-P-TR Manufacturer Tekram Model Number TR-822 Device support SATA hard drives Number of ports Independent internal 2 ports high speed Native Serial ATA Array interface to the host 32 bit, 66MHz fully compliant PCI host interface RAID controller Silicon Image SiI3512A RAID Levels RAID levels 0, 1 Drive data transfer rate Serial ATA data rates 1.5Gbps Cache NA OS Support Windows® Vista/Server 2003/2000/XP/7/2008, Linux Operating voltage 5V / 470mA Operating Temperature 5~50°C PCB version A100-10C BIOS version 4.3.84 Card size 120mm x 64mm ROHS Status (Yes/No) Yes Page 7 of 18 Drawings and specifications herein are property of Advantech and shall not be reproduced or copied or used without prior written permission. Photo: Page 8 of 18 Drawings and specifications herein are property of Advantech and shall not be reproduced or copied or used without prior written permission. Test Platform MB/SBC PCA-6011VG PCB version A101-3 CPU Intel E2160 1.80GHz BIOS version 6011V111 DRAM Apacer DDR3 1333 2GB DIMM Core Chipset Intel G41+ICH7 Backplane PCA-6105P3X_A101-2 VGA Chipset G41 integrated Other MB/SBC PCA-6010G2 PCB version A101-2 CPU Intel E2140 1.60GHz BIOS version V1.14 DRAM Transcend DDR2 667 2GB DIMM Core Chipset Intel 945GC+ICH7 Backplane PCA-6113P4R_C202-1 VGA Chipset 945GC integrated Other MB/SBC PCI-7031G2 PCB version A101-2 CPU Intel Atom N450 1.66GHz BIOS version V1.10 DRAM Transcend DDR2 667 1GB SODIMM Core Chipset Atom N450+ICH8M Backplane PCI-7110P3S6-00_A101-1 VGA Chipset N450 integrated Other MB/SBC PCA-6194 PCB version A101-2 CPU Intel E4700 2.60GHz BIOS version V1.28 DRAM Apacer DDR2 800 2GB DIMM Core Chipset Intel Q965+ICH8DO Backplane PCA-6114P4_C101-1 VGA Chipset Q965 integrated Other Page 9 of 18 Drawings and specifications herein are property of Advantech and shall not be reproduced or copied or used without prior written permission. Test Software Utilities Version / Description Power On/Off (For Reliability test) Passmark BurnIn Test Pro (For Reliability test) V7.0 build 1015 HD Tach (For Performance test) V3.0.4.0 HD Tune (For Performance test) V5.0 Page 10 of 18 Drawings and specifications herein are property of Advantech and shall not be reproduced or copied or used without prior written permission. Test Item Chapter 1: Function test 1.1 Device Information confirm The test ensures the product meets SPEC. Check RAID card properties in GUI Storage Management Utility, and paste the screenshot of test result as below. Test result (MB/SBC: PCA-6011): Page 11 of 18 Drawings and specifications herein are property of Advantech and shall not be reproduced or copied or used without prior written permission. 1.2 Basic function test 1.2.1 RAID Level test The test ensures the RAID controllers Support for RAID levels can be create and working normally. Please see the test criteria as below: 1. The HDD disk can be detected, and the BIOS of Raid card should show the correct drive model and capacity etc information. 2. Make sure the HDD disk can build Raid, Check Raid disk size should be as below: RAID Level Size fault-tolerant capability RAID 0 1+1=2 0 RAID 1 1+1=1 1 RAID 5 1+1+1=(N-1)*1 1(any one) RAID 10 2+2=2 2 RAID 50 3+3=(N-2)*1 2(Each one of the array) Note “N” represent disk quantity; “* 1” meaning is multiplied by the single disk capacity. (Table 1) 3. OS can be installed into the RAID disk without any problem. 4. Run Burn-in test 30 minutes with the raid disk, Set disk loading 100%, all disks file size 15%, the result must be passed. 5. Run Power on/off test at least 10 times, RAID cannot lose and boot into the OS. 6. Refer to Table 1 fault-tolerant capability，RAID can boot into OS when removed the hard disk. MB/SBC: PCA-6011_PCA-6105P3X_A101-2 Raid level HDD OS Result Win7 32bit SP1 Pass Win7 64bit Pass Remark 96ND500G-ST-WD5K3 RAID 0 96ND1T-ST-WD5K 96ND1T-ST-WD5KE RAID 1 96ND750G-ST-WD5K 1.2.2 Rebuild test Pass Criteria: when a drive fails, the controller firmware automatically replaces and rebuilds the data from the failed drive to the hot spare. Raid level MB/SBC HDD OS Result 96ND320G-ST-WD7K 96ND320G-ST-WD7K RAID 1 PCA-6011 Remark Win XP 32bit 96ND320G-ST-WD5K3 Pass Replace 96ND320G-ST-WD7K Page 12 of 18 Drawings and specifications herein are property of Advantech and shall not be reproduced or copied or used without prior written permission. 1.2.3 Drive Interface test The test ensures each port on the SAS RAID controller supports SAS devices, SATA II devices or both. Pass Criteria: 1. The HDD disk can be detected, and the BIOS of Raid card should show the correct drive model and capacity etc information. 2. OS can be installed into the RAID disk without any problem. 3. Run Burn-in test 30 minutes with the raid disk, Set disk loading 100%, all disks file size 15%, the result must be passed. 4. Run Power on/off test at least 10 times, RAID cannot lose and boot into the OS. MB/SBC: PCA-6011 Drive Raid level HDD OS Result Win 2003 32bit Pass Win7 32bit SP1 Pass Win XP 64bit Pass Win XP 32bit Pass Remark 96HD2000G-ST-SG7K2 RAID 0 96HD2000G-ST-SG7K3 2.5’’SATA 96HD1T-ST-WD7K RAID1 96HD1000G-ST-SG7K6 96ND500G-ST-WD5KE RAID 0 96ND750G-ST-WD7K 3.5”SATA 96ND320G-ST-WD7K RAID1 96ND320G-ST-WD5K3 1.3 LED &Jumpers and Connectors The test ensures whether the LED &Jumpers and Connectors can meet the RAID card spec. 1. LED can work properly as spec define 2. Jumper can work properly as spec define MB/SBC: PCA-6194 Jumper/ Connector Type Test description Result Remark 4-pin connector JP4 HDD Activity LED header Connects to an LED that indicates drive Pass activity Page 13 of 18 Drawings and specifications herein are property of Advantech and shall not be reproduced or copied or used without prior written permission. Chapter 2: Compatibility test 2.1 With OS compatibility test The test ensures mainstream windows OS can be installed into the RAID, and the Raid card can working without any problem. Please see the test criteria as below: 1. OS can be installed into the RAID and the Partition and format function is normal. 2. The RAID Card of driver installation without any problem, and device work normally. 3. Run Burn-in test 30 minutes with the raid disk, Set disk loading 100%, all disks file size 15%, the result must be passed. Test platform PCA-6010 OS Driver Result Windows 7 Ultimate 32bit SP1 1.0.65.1 Pass Windows 7 Ultimate 64bit 1.0.17.1 Pass Windows 2003 enterprise 32bit SP2 1.0.60.0 Pass Windows XP Standard Edition 64bit 1.0.12.0 Pass Windows XP Professional Edition 32bit 1.0.60.0 Pass 2.2 With motherboard compatibility test The test ensures the the configuration of RAID solution can work properly with different framework and chipsets of Motherboard. Please see the test criteria as below: 1. The HDD disk can be detected, and the BIOS of Raid card should show the correct drive model and capacity etc information. 2. The RAID configuration can be successfully to create and initialization normal : 3. OS can be installed into the RAID and driver working without any problem. 4. Run Burn-in test 30 minutes with the raid disk, Set disk loading 100%, all disks file size 15%, the result must be passed. 5. Run Power on/off test at least 10 times, RAID cannot lose and boot into the OS. Page 14 of 18 Drawings and specifications herein are property of Advantech and shall not be reproduced or copied or used without prior written permission. MB/SBC: PCA-6011_PCA-6105P3X_A101-2 Item Level HDD IN SLOT OS Result PCI1(64bit) Win 2003 32bit Pass PCI3(64bit) Win7 32bit SP1 Pass PCI2(64bit) Win XP 32bit Pass PCI1(64bit) Win7 64bit Pass 96HD1T-ST-WD7K RAID 0 96HD2000G-ST-SG7K3 3.5'' SATA Solution 96HD2000G-ST-SG7K2 RAID 1 96HD1000G-ST-SG7K6 96ND500G-ST-WD5K3 RAID 0 96ND500G-ST-WD5KE 2.5''SATA Solution 96ND1T-ST-WD5KE RAID 1 96ND750G-ST-WD7K MB/SBC: PCA-6010_PCA-6113P4R_C202-1 Item Level HDD IN SLOT 96HD1T-ST-WD7K RAID 0 PCI2(32bit) 96HD2000G-ST-SG7K3 OS Result Win7 32bit SP1 Pass 3.5'' SATA Solution 96HD2000G-ST-SG7K2 RAID 1 PCI1(32bit) Win XP 64bit Pass PCI2(32bit) Win7 64bit Pass PCI4(32bit) Win XP 32bit Pass IN SLOT OS Result PPCI2(32bit) Win7 64bit Pass PPCI2(32bit) Win XP 64bit Pass 96HD1000G-ST-SG7K6 96ND500G-ST-WD5K3 RAID 0 96ND500G-ST-WD5KE 2.5''SATA Solution 96ND1T-ST-WD5KE RAID 1 96ND750G-ST-WD7K MB/SBC: PCI-7031_PCI-7110P3S6-00_A101-1 Item Level HDD 96HD2000G-ST-SG7K2 3.5'' SATA Solution RAID 1 96HD1000G-ST-SG7K6 96ND1T-ST-WD5KE 2.5''SATA Solution RAID 1 96ND750G-ST-WD7K Page 15 of 18 Drawings and specifications herein are property of Advantech and shall not be reproduced or copied or used without prior written permission. MB/SBC: PCA-6194_PCA-6114P4_C101-1 Item Level HDD IN SLOT 96HD1T-ST-WD7K 3.5'' SATA Solution RAID 0 PCI1(32bit) 96HD2000G-ST-SG7K3 OS Result Win7 32bit Pass SP1 96ND500G-ST-WD5K3 2.5''SATA Solution RAID 1 PPCI2(32bit) Win XP 64bit Pass 96ND500G-ST-WD5KE 2.3 With PCIE Bus test The test ensures whether the PCIE bus can work properly without any error with the raid card. Please see the test criteria as below: 1. Run copy test and the RAID can work normally in OS. 2. Run Power on/off test at least 5 times, RAID cannot lose. MB/SBC PCA-6011 PCA-6010 PCI-7031 PCA-6194 Backplane PCA-6105P3X-A101-2 PCIE list Result PCI1(64bit) Pass PCI2(64bit) Pass PCI3(64bit) Pass PCI1(32bit) Pass PCI2(32bit) Pass PCI3(32bit) Pass PCI4(32bit) Pass PPCI1(32bit) Pass PPCI2(32bit) Pass PPCI3(32bit) Pass PCI1(32bit) Pass PCI2(32bit) Pass PCI3(32bit) Pass PCI4(32bit) Pass Remark PCA-6113P4R_C202-1 PCI-7110P3S6-00_A101-1 PCA-6114P4_C101-1 Page 16 of 18 Drawings and specifications herein are property of Advantech and shall not be reproduced or copied or used without prior written permission. Chapter 3: Performance test RAID information configured: RAID Level: RAID 1 HDD: 96HD2000G-ST-SG7K2+96HD1000G-ST-SG7K6 3.1 HD Tach HD Tach version 3.0.4.0 MB/SBC RAID Level Burst Speed Average Read Random Access CPU Utilization (MB/s) (MB/s) Time (ms) PCA-6011 RAID 1 105.9 102.8 2% 14.6 PCI-7031 RAID 1 100.1 99.7 5% 14.7 PCA-6194 RAID 1 90.3 89.7 2% 12.0 3.2 HD Tune 3.2.1 Read Test HD Tune version 5.0 MB/SBC RAID Minimum Maximum Average Level Transfer Rate Transfer Rate Transfer Rate (MB/s) (MB/s) (MB/s) Access Time Burst Speed CPU Usage (ms) (MB/s) PCA-6011 RAID 1 92.4 97.2 96.4 14.4 2.3% 97.8 PCI-7031 RAID 1 94.3 95.2 95.0 14.5 4.0% 95.1 PCA-6194 RAID 1 83.5 85.4 85.4 11.8 2.3% 84.3 3.2.2 Write test HD Tune version 5.0 MB/SBC RAID Minimum Maximum Average Level Transfer Rate Transfer Rate Transfer Rate (MB/s) (MB/s) (MB/s) Access Time Burst Speed CPU Usage (ms) (MB/s) PCA-6011 RAID 1 92.4 97.2 96.4 14.4 2.3% 97.8 PCI-7031 RAID 1 94.3 95.2 95.0 14.5 4.0% 95.1 PCA-6194 RAID 1 83.5 85.4 85.4 11.8 2.3% 84.3 Page 17 of 18 Drawings and specifications herein are property of Advantech and shall not be reproduced or copied or used without prior written permission. Chapter 4: Reliability test 4.1 Room temperature test The test ensures the RAID card can working stable. Please see the test criteria as below: 1. Run power on/off 100 times，successful boot rate 100%; 2. Run Passmark Burn_in, Set disk loading 100%, all disks file size 15%; the result of all disks should be passed when running Burn_in for 12 hours. MB/SBC RAID Level PCA-6011 RAID 0 PCI-7031 RAID 1 HDD 96ND500G-ST-WD5K3+ 96ND1T-ST-WD5K 96ND1T-ST-WD5KE+ 96ND750G-ST-WD7K OS Result Win7 32bit SP1 Pass Win7 64bit Pass Page 18 of 18 Drawings and specifications herein are property of Advantech and shall not be reproduced or copied or used without prior written permission. Remark