LED Driver BCR 320U E6327 / BCR 321U E6327 Datasheet Revision 2.1, 2015-01-28 Power Management & Multimarket Edition 2015-01-28 Published by Infineon Technologies AG 81726 Munich, Germany © 2015 Infineon Technologies AG All Rights Reserved. Legal Disclaimer The information given in this document shall in no event be regarded as a guarantee of conditions or characteristics. With respect to any examples or hints given herein, any typical values stated herein and/or any information regarding the application of the device, Infineon Technologies hereby disclaims any and all warranties and liabilities of any kind, including without limitation, warranties of non-infringement of intellectual property rights of any third party. Information For further information on technology, delivery terms and conditions and prices, please contact the nearest Infineon Technologies Office (www.infineon.com). Warnings Due to technical requirements, components may contain dangerous substances. For information on the types in question, please contact the nearest Infineon Technologies Office. Infineon Technologies components may be used in life-support devices or systems only with the express written approval of Infineon Technologies, if a failure of such components can reasonably be expected to cause the failure of that life-support device or system or to affect the safety or effectiveness of that device or system. Life support devices or systems are intended to be implanted in the human body or to support and/or maintain and sustain and/or protect human life. If they fail, it is reasonable to assume that the health of the user or other persons may be endangered. BCR 320U E6327 / BCR 321U E6327 Revision History Page or Item Subjects (major changes since previous revision) Revision 2.1, 2015-01-28 All Using full sales names BCR 320U E6327 / BCR 321U E6327 instead of short form BCR320U / BCR321U Page 7 Halogen free logo removed Trademarks of Infineon Technologies AG AURIX™, C166™, CanPAK™, CIPOS™, CIPURSE™, EconoPACK™, CoolMOS™, CoolSET™, CORECONTROL™, CROSSAVE™, DAVE™, DI-POL™, EasyPIM™, EconoBRIDGE™, EconoDUAL™, EconoPIM™, EconoPACK™, EiceDRIVER™, eupec™, FCOS™, HITFET™, HybridPACK™, I²RF™, ISOFACE™, IsoPACK™, MIPAQ™, ModSTACK™, my-d™, NovalithIC™, OptiMOS™, ORIGA™, POWERCODE™; PRIMARION™, PrimePACK™, PrimeSTACK™, PRO-SIL™, PROFET™, RASIC™, ReverSave™, SatRIC™, SIEGET™, SINDRION™, SIPMOS™, SmartLEWIS™, SOLID FLASH™, TEMPFET™, thinQ!™, TRENCHSTOP™, TriCore™. Other Trademarks Advance Design System™ (ADS) of Agilent Technologies, AMBA™, ARM™, MULTI-ICE™, KEIL™, PRIMECELL™, REALVIEW™, THUMB™, µVision™ of ARM Limited, UK. AUTOSAR™ is licensed by AUTOSAR development partnership. Bluetooth™ of Bluetooth SIG Inc. CAT-iq™ of DECT Forum. COLOSSUS™, FirstGPS™ of Trimble Navigation Ltd. EMV™ of EMVCo, LLC (Visa Holdings Inc.). EPCOS™ of Epcos AG. FLEXGO™ of Microsoft Corporation. FlexRay™ is licensed by FlexRay Consortium. HYPERTERMINAL™ of Hilgraeve Incorporated. IEC™ of Commission Electrotechnique Internationale. IrDA™ of Infrared Data Association Corporation. ISO™ of INTERNATIONAL ORGANIZATION FOR STANDARDIZATION. MATLAB™ of MathWorks, Inc. MAXIM™ of Maxim Integrated Products, Inc. MICROTEC™, NUCLEUS™ of Mentor Graphics Corporation. MIPI™ of MIPI Alliance, Inc. MIPS™ of MIPS Technologies, Inc., USA. muRata™ of MURATA MANUFACTURING CO., MICROWAVE OFFICE™ (MWO) of Applied Wave Research Inc., OmniVision™ of OmniVision Technologies, Inc. Openwave™ Openwave Systems Inc. RED HAT™ Red Hat, Inc. RFMD™ RF Micro Devices, Inc. SIRIUS™ of Sirius Satellite Radio Inc. SOLARIS™ of Sun Microsystems, Inc. SPANSION™ of Spansion LLC Ltd. Symbian™ of Symbian Software Limited. TAIYO YUDEN™ of Taiyo Yuden Co. TEAKLITE™ of CEVA, Inc. TEKTRONIX™ of Tektronix Inc. TOKO™ of TOKO KABUSHIKI KAISHA TA. UNIX™ of X/Open Company Limited. VERILOG™, PALLADIUM™ of Cadence Design Systems, Inc. VLYNQ™ of Texas Instruments Incorporated. VXWORKS™, WIND RIVER™ of WIND RIVER SYSTEMS, INC. ZETEX™ of Diodes Zetex Limited. Last Trademarks Update 2011-11-11 Datasheet 3 Revision 2.1, 2015-01-28 BCR 320U E6327 / BCR 321U E6327 Table of Contents Table of Contents Table of Contents . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4 List of Figures . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 5 List of Tables . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 6 1 1.1 1.2 1.3 LED Driver . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . Features . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . Applications . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . General Description . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 7 7 7 7 2 Electrical Characteristics . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 9 3 Typical characteristics . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 11 4 Application hints . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 23 5 Package . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 24 Terminology . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 25 Datasheet 4 Revision 2.1, 2015-01-28 BCR 320U E6327 / BCR 321U E6327 List of Figures List of Figures Figure 1-1 Figure 3-1 Figure 3-2 Figure 3-3 Figure 3-4 Figure 3-5 Figure 3-6 Figure 3-7 Figure 3-8 Figure 3-9 Figure 3-10 Figure 3-11 Figure 3-12 Figure 3-13 Figure 3-14 Figure 3-15 Figure 3-16 Figure 3-17 Figure 3-18 Figure 3-19 Figure 3-20 Figure 3-21 Figure 3-22 Figure 3-23 Figure 4-1 Figure 4-2 Figure 5-1 Figure 5-2 Figure 5-3 Datasheet Pin configuration and typical application. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 8 Total Power Dissipation Ptot = f(TS). . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 11 Permissible Pulse Load RthJS = f(tp) . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 11 Permissible Pulse Load Ptotmax / PtotDC= f(tp) . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 12 BCR 320U: Output Current versus Vout Iout = f(Vout), VEN = 12 V, Rext = Parameter . . . . . . . . . . . . 13 BCR 320U: Output Current versus Rext Iout = f(Rext), VEN = 12 V, Vout = Parameter . . . . . . . . . . . . 13 BCR 320U: Output Current versus Vout Iout = f(Vout), VEN = 12 V, Rext = open, TA = Parameter . . . 14 BCR 320U: Output Current versus Vout Iout = f(Vout), VEN = 12 V, Rext = 20 Ω, TA = Parameter. . . . 14 BCR 320U: Output Current versus Vout Iout = f(Vout), VEN = 12 V, Rext = 3 Ω, TA = Parameter. . . . . 15 BCR 320U: Output Current versus VEN Iout = f(VEN), Vout = 2 V, Rext = open, TA = Parameter . . . . 15 BCR 320U: Output Current versus VEN Iout = f(VEN), Vout = 2 V, Rext = 20 Ω, TA = Parameter. . . . . 16 BCR 320U: Output Current versus VEN Iout = f(VEN), Vout = 2 V, Rext = 3 Ω, TA = Parameter. . . . . . 16 BCR 320U: Output Current versus VEN Iout = f(VEN), Vout = 2 V, Rext = Parameter . . . . . . . . . . . . . 17 BCR 320U: Enable Current versus VEN IEN = f(VEN), Rext = open, Iout = 0 A, TA = Parameter . . . . . 17 BCR 321U: Output Current versus Vout Iout = f(Vout), VEN = 3.3 V, Rext = Parameter . . . . . . . . . . . . 18 BCR 321U: Output Current versus Rext Iout = f(Rext), VEN = 3.3 V, Vout = Parameter . . . . . . . . . . . . 18 BCR 321U: Output Current versus Vout Iout = f(Vout), VEN = 3.3 V, Rext = open, TA = Parameter . . . 19 BCR 321U: Output Current versus Vout Iout = f(Vout), VEN = 3.3 V, Rext = 20 Ω, TA = Parameter . . . 19 BCR 321U: Output Current versus Vout Iout = f(Vout), VEN = 3.3 V, Rext = 3 Ω, TA = Parameter . . . . 20 BCR 321U: Output Current versus VEN Iout = f(VEN), Vout = 2 V, Rext = open, TA = Parameter . . . . 20 BCR 321U: Output Current versus VEN Iout = f(VEN), Vout = 2 V, Rext = 20 Ω, TA = Parameter. . . . . 21 BCR 321U: Output Current versus VEN Iout = f(VEN), Vout = 2 V, Rext = 3 Ω, TA = Parameter. . . . . . 21 BCR 321U: Output Current versus VEN Iout = f(VEN), Vout = 2 V, Rext = Parameter . . . . . . . . . . . . . 22 BCR 321U: Enable Current versus VEN IEN = f(VEN), Rext = open, Iout = 0 A, TA = Parameter . . . . . 22 Application Circuit: Enabling / PWM by Micro Controller . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 23 Application Circuit: Enabling by Connecting to VS . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 23 Package Outline for SC74 (dimensions in mm) . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 24 Package Footprint for SC74 (dimensions in mm) . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 24 Tape and Reel Information for SC74 (dimensions in mm) . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 24 5 Revision 2.1, 2015-01-28 BCR 320U E6327 / BCR 321U E6327 List of Tables List of Tables Table 2-1 Table 2-2 Table 2-3 Table 2-4 Datasheet Maximum Ratings at TA = 25 °C, unless otherwise specified . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 9 Thermal Resistance at TA = 25 °C, unless otherwise specified. . . . . . . . . . . . . . . . . . . . . . . . . . . . 9 Electrical Characteristics at TA = 25 °C, unless otherwise specified . . . . . . . . . . . . . . . . . . . . . . . . 9 DC Characteristics with stabilized LED load at TA = 25 °C, unless otherwise specified . . . . . . . . 10 6 Revision 2.1, 2015-01-28 BCR 320U E6327 / BCR 321U E6327 LED Driver 1 LED Driver 1.1 Features • • • • • • • • • • LED drive current preset to 10 mA Continuous output current up to 250 mA with an external resistor Easy paralleling of drivers to increase current Supply voltage up to 25 V Low side current control Digital PWM input up to 10 kHz frequency (BCR 321U E6327) Up to 1 W power dissipation in a small SC74 package Negative thermal coefficient of -0.2 %/K reduces output current at higher temperatures RoHS compliant (Pb-free) package Automotive qualified according AEC Q101 1.2 • • • • SC74-3D Applications Architectural LED lighting Channel letters for advertising, LED strips for decorative lighting Retail lighting in fridge, freezer case and vending machines Emergency lighting (e.g. steps lighting, exit way signs etc.) 1.3 General Description The BCR 320U E6327 / BCR 321U E6327 provides a low-cost solution for driving 0.5 W LEDs with a typical LED current of 150 mA to 200 mA. Internal breakdown voltage is higher than 16 V which is the maximum voltage the LED driver can sustain when the output is directly connected to supply voltage. The BCR 320U E6327 / BCR 321U E6327 can be operated with a supply voltage of more than 16 V considering the voltage drop of the LED load which reduces the output voltage to the maximum rating of the driver. The enable pin of BCR 320U E6327 can withstand a maximum voltage of 25 V which can be increased adding a series resistor in front of the enable pin reducing the voltage at the enable pin below 25 V. The digital input pin of BCR 321U E6327 allows dimming via a micro controller with frequencies up to 10 kHz. A reduction of the output current at higher temperatures is the result of the negative temperature coefficient of 0.2 %/K of the LED driver. With no need for additional external components like inductors, capacitors and free wheeling diodes, the BCR 320U E6327 / BCR 321U E6327 LED drivers are a cost-efficient and PCB-area saving solution for driving 0.5 W LEDs. Datasheet 7 Revision 2.1, 2015-01-28 BCR 320U E6327 / BCR 321U E6327 LED Driver Pin Configuration Typical Application +VS EN 1 6 Rex t IEN EN OUT 2 5 OUT OUT 3 4 GND Iout 1 OUT 2,3,5 Rex t 6 GND Rex t (optional ) Vdrop 4 BCR 320 U E6327 Figure 1-1 Pin configuration and typical application Sales Name Marking BCR 320U E6327 30 1 = EN 2; 3; 5 = OUT 4 = GND 6 = Rext SC74 BCR 321U E6327 31 1 = EN 2; 3; 5 = OUT 4 = GND 6 = Rext SC74 Datasheet Pin Configuration 8 Package Revision 2.1, 2015-01-28 BCR 320U E6327 / BCR 321U E6327 Electrical Characteristics 2 Electrical Characteristics Table 2-1 Maximum Ratings at TA = 25 °C, unless otherwise specified Parameter Symbol Values Unit Min. Typ. Max. - - 25 4.5 Enable voltage BCR 320U E6327 BCR 321U E6327 VEN Output current Iout - - 300 mA Output voltage Vout - - 16 V Reverse voltage between all terminals VR - - 0.5 V Total power dissipation Ptot - - 1000 mW Junction temperature TJ - - 150 °C Storage temperature range TSTG -65 - 150 °C Note / Test Condition V TS ≤ 100 °C Attention: Stresses above the max. values listed here may cause permanent damage to the device. Exposure to absolute maximum rating conditions for extended periods may affect device reliability. Maximum ratings are absolute ratings; exceeding only one of these values may cause irreversible damage to the integrated circuit. Table 2-2 Thermal Resistance at TA = 25 °C, unless otherwise specified Parameter Symbol Values Min. Typ. Unit Note / Test Condition Max. 1) Junction - soldering point RthJS 50 K/W 1) For calculation of RthJA please refer to Application Note AN077 (Thermal Resistance Calculation) Table 2-3 Electrical Characteristics at TA = 25 °C, unless otherwise specified Parameter Symbol Values Min. Typ. Max. - - - 1.2 1.2 - Unit Note / Test Condition V IC = 1 mA, IB = 0 Collector-emitter breakdown voltage VBR(CEO) 16 Enable current BCR 320U E6327 BCR 321U E6327 IEN DC current gain hFE 200 350 500 - IC = 50 mA, VCE = 1 V Internal resistor Rint 85 95 105 Ω IRint = 10 mA Bias resistor BCR 320U E6327 BCR 321U E6327 RB - 10 1.5 - Datasheet mA VEN = 12 V VEN = 3.3 V kΩ 9 Revision 2.1, 2015-01-28 BCR 320U E6327 / BCR 321U E6327 Electrical Characteristics Table 2-3 Electrical Characteristics at TA = 25 °C, unless otherwise specified (cont’d) Parameter Symbol Output current BCR 320U E6327 BCR 321U E6327 Output current at Rext = 3 Ω BCR 320U E6327 BCR 321U E6327 Iout Voltage drop (VRext) Vdrop Table 2-4 Min. Typ. Max. 9 9 10 10 11 11 - 250 250 - 0.85 0.95 1.05 Unit Note / Test Condition mA Vout = 1.4 V VEN = 12 V VEN = 3.3 V Vout > 1.4 V VEN = 12 V VEN = 3.3 V V Iout = 10 mA DC Characteristics with stabilized LED load at TA = 25 °C, unless otherwise specified Parameter Symbol Lowest sufficient supply voltage overhead VSmin Output current change versusTA BCR 320U E6327 BCR 321U E6327 ∆Iout/Iout Output current change versus VS BCR 320U E6327 BCR 321U E6327 ∆Iout/Iout Datasheet Values Values Min. Typ. Max. - 1.4 - - -0.2 -0.2 - - 1 1 10 - Unit Note / Test Condition V Iout > 18 mA %/K Vout > 2.0 V VEN = 12 V VEN = 3.3 V %/V Vout > 2.0 V VEN = 12 V VEN = 3.3 V Revision 2.1, 2015-01-28 BCR 320U E6327 / BCR 321U E6327 Typical characteristics 3 Typical characteristics 1200 1000 Ptot [mW] 800 600 400 200 0 0 20 40 60 80 TS [°C] 100 120 140 Figure 3-1 Total Power Dissipation Ptot = f(TS) RthJS [K/W] 100 10 D=0 D = 0.005 D = 0.01 D = 0.02 D = 0.05 D = 0.1 D = 0.2 D = 0.5 1 0.1 -6 10 10 -5 10 -4 -3 10 tp [s] 10 -2 10 -1 0 10 Figure 3-2 Permissible Pulse Load RthJS = f(tp) Datasheet 11 Revision 2.1, 2015-01-28 BCR 320U E6327 / BCR 321U E6327 Typical characteristics Ptotmax / PtotDC 1000 D=0 D = 0.005 D = 0.01 D = 0.02 D = 0.05 D = 0.1 D = 0.2 D = 0.5 100 10 1 10-6 10-5 10-4 10-3 tp [s] 10-2 10-1 100 Figure 3-3 Permissible Pulse Load Ptotmax / PtotDC= f(tp) Datasheet 12 Revision 2.1, 2015-01-28 BCR 320U E6327 / BCR 321U E6327 Typical characteristics 0.3 Rext = 3 Ω Rext = 4 Ω Iout [A] 0.2 Rext = 6 Ω Rext = 10 Ω 0.1 Rext = 20 Ω 0 Rext = open 0 1 2 3 4 5 6 7 Vout [V] 8 9 10 11 12 Figure 3-4 BCR 320U: Output Current versus Vout Iout = f(Vout), VEN = 12 V, Rext = Parameter 0.35 0.3 Iout [A] 0.25 0.2 0.15 0.1 0.05 0 Vout = 1.4 V Vout = 5.4 V 1 10 Rext [Ω] 100 Figure 3-5 BCR 320U: Output Current versus Rext Iout = f(Rext), VEN = 12 V, Vout = Parameter Datasheet 13 Revision 2.1, 2015-01-28 BCR 320U E6327 / BCR 321U E6327 Typical characteristics 0.015 Iout [A] 0.01 0.005 0 -40 °C 25 °C 85 °C 0 2 4 6 Vout [V] 8 10 12 Figure 3-6 BCR 320U: Output Current versus Vout Iout = f(Vout), VEN = 12 V, Rext = open, TA = Parameter 0.06 0.05 Iout [A] 0.04 0.03 0.02 0.01 0 -40 °C 25 °C 85 °C 0 2 4 6 Vout [V] 8 10 12 Figure 3-7 BCR 320U: Output Current versus Vout Iout = f(Vout), VEN = 12 V, Rext = 20 Ω, TA = Parameter Datasheet 14 Revision 2.1, 2015-01-28 BCR 320U E6327 / BCR 321U E6327 Typical characteristics 0.3 Iout [A] 0.2 0.1 0 -40 °C 25 °C 85 °C 0 2 4 6 Vout [V] 8 10 12 Figure 3-8 BCR 320U: Output Current versus Vout Iout = f(Vout), VEN = 12 V, Rext = 3 Ω, TA = Parameter 0.015 Iout [A] 0.01 0.005 0 -40 °C 25 °C 85 °C 0 5 10 15 20 25 VEN [V] Figure 3-9 BCR 320U: Output Current versus VEN Iout = f(VEN), Vout = 2 V, Rext = open, TA = Parameter Datasheet 15 Revision 2.1, 2015-01-28 BCR 320U E6327 / BCR 321U E6327 Typical characteristics 0.06 0.05 Iout [A] 0.04 0.03 0.02 0.01 0 -40 °C 25 °C 85 °C 0 5 10 15 20 25 VEN [V] Figure 3-10 BCR 320U: Output Current versus VEN Iout = f(VEN), Vout = 2 V, Rext = 20 Ω, TA = Parameter 0.3 Iout [A] 0.2 0.1 0 -40 °C 25 °C 85 °C 0 5 10 15 20 25 VEN [V] Figure 3-11 BCR 320U: Output Current versus VEN Iout = f(VEN), Vout = 2 V, Rext = 3 Ω, TA = Parameter Datasheet 16 Revision 2.1, 2015-01-28 BCR 320U E6327 / BCR 321U E6327 Typical characteristics 0.3 Rext = open Rext = 20 Ω Rext = 10 Ω Rext = 6 Ω Rext = 4 Ω Rext = 3 Ω Iout [A] 0.2 0.1 0 0 5 10 15 20 25 VEN [V] Figure 3-12 BCR 320U: Output Current versus VEN Iout = f(VEN), Vout = 2 V, Rext = Parameter 3 2.5 IEN [mA] 2 1.5 1 0.5 0 -40 °C 25 °C 80 °C 0 5 10 15 20 25 VEN [V] Figure 3-13 BCR 320U: Enable Current versus VEN IEN = f(VEN), Rext = open, Iout = 0 A, TA = Parameter Datasheet 17 Revision 2.1, 2015-01-28 BCR 320U E6327 / BCR 321U E6327 Typical characteristics 0.3 Rext = 3 Ω Rext = 4 Ω Iout [A] 0.2 Rext = 6 Ω Rext = 10 Ω 0.1 Rext = 20 Ω 0 Rext = open 0 1 2 3 4 5 6 7 Vout [V] 8 9 10 11 12 Figure 3-14 BCR 321U: Output Current versus Vout Iout = f(Vout), VEN = 3.3 V, Rext = Parameter 0.35 0.3 Iout [A] 0.25 0.2 0.15 0.1 0.05 0 Vout = 1.4 V Vout = 5.4 V 1 10 Rext [Ω] 100 Figure 3-15 BCR 321U: Output Current versus Rext Iout = f(Rext), VEN = 3.3 V, Vout = Parameter Datasheet 18 Revision 2.1, 2015-01-28 BCR 320U E6327 / BCR 321U E6327 Typical characteristics 0.015 Iout [A] 0.01 0.005 0 -40 °C 25 °C 85 °C 0 2 4 6 Vout [V] 8 10 12 Figure 3-16 BCR 321U: Output Current versus Vout Iout = f(Vout), VEN = 3.3 V, Rext = open, TA = Parameter 0.06 0.05 Iout [A] 0.04 0.03 0.02 0.01 0 -40 °C 25 °C 85 °C 0 2 4 6 Vout [V] 8 10 12 Figure 3-17 BCR 321U: Output Current versus Vout Iout = f(Vout), VEN = 3.3 V, Rext = 20 Ω, TA = Parameter Datasheet 19 Revision 2.1, 2015-01-28 BCR 320U E6327 / BCR 321U E6327 Typical characteristics 0.3 Iout [A] 0.2 0.1 0 -40 °C 25 °C 85 °C 0 2 4 6 Vout [V] 8 10 12 Figure 3-18 BCR 321U: Output Current versus Vout Iout = f(Vout), VEN = 3.3 V, Rext = 3 Ω, TA = Parameter 0.015 Iout [A] 0.01 0.005 0 -40 °C 25 °C 85 °C 0 1 2 3 4 5 VEN [V] Figure 3-19 BCR 321U: Output Current versus VEN Iout = f(VEN), Vout = 2 V, Rext = open, TA = Parameter Datasheet 20 Revision 2.1, 2015-01-28 BCR 320U E6327 / BCR 321U E6327 Typical characteristics 0.06 0.05 Iout [A] 0.04 0.03 0.02 0.01 0 -40 °C 25 °C 85 °C 0 1 2 3 4 5 VEN [V] Figure 3-20 BCR 321U: Output Current versus VEN Iout = f(VEN), Vout = 2 V, Rext = 20 Ω, TA = Parameter 0.3 Iout [A] 0.2 0.1 0 -40 °C 25 °C 85 °C 0 1 2 3 4 5 VEN [V] Figure 3-21 BCR 321U: Output Current versus VEN Iout = f(VEN), Vout = 2 V, Rext = 3 Ω, TA = Parameter Datasheet 21 Revision 2.1, 2015-01-28 BCR 320U E6327 / BCR 321U E6327 Typical characteristics 0.3 Rext = open Rext = 20 Ω Rext = 10 Ω Rext = 6 Ω Rext = 4 Ω Rext = 3 Ω Iout [A] 0.2 0.1 0 0 1 2 3 VEN [V] 4 5 6 Figure 3-22 BCR 321U: Output Current versus VEN Iout = f(VEN), Vout = 2 V, Rext = Parameter 4 IEN [mA] 3 2 1 0 -40 °C 25 °C 80 °C 0 0.5 1 1.5 2 2.5 3 3.5 VEN [V] 4 4.5 5 5.5 6 Figure 3-23 BCR 321U: Enable Current versus VEN IEN = f(VEN), Rext = open, Iout = 0 A, TA = Parameter Datasheet 22 Revision 2.1, 2015-01-28 BCR 320U E6327 / BCR 321U E6327 Application hints 4 Application hints +V S µC IEN EN Iout 1 OUT 2,3,5 Rex t 6 GND Rex t (optional ) Vdrop 4 BCR 321U E6327 Figure 4-1 Application Circuit: Enabling / PWM by Micro Controller +V S EN IEN Iout 1 OUT 2,3,5 Rex t 6 GND R ex t (optional ) V drop 4 BCR 320U E6327 Figure 4-2 Application Circuit: Enabling by Connecting to VS Application hints BCR 320U E6327 / BCR 321U E6327 serve as an easy to use constant current sources for LEDs. In stand alone application an external resistor can be connected to adjust the current from 10 mA to 250 mA. Rext can be determined by using Figure 3-5 or Figure 3-15. Connecting a low tolerance resistor Rext will improve the overall accuracy of the current sense resistance formed by the parallel connection of Rint and Rext leading to an improved current accuracy. Please take into account that the resulting output currents will be slightly lower due to the self heating of the component and the negative thermal coefficient. Please visit our web site www.infineon.com/lowcostleddriver for application notes and for up-to-date application information. Datasheet 23 Revision 2.1, 2015-01-28 BCR 320U E6327 / BCR 321U E6327 Package Package 2.9 ±0.2 (2.25) B 1.1 MAX. 0.15 +0.1 -0.06 5 4 1 2 3 0.35 +0.1 -0.05 Pin 1 marking 0.2 1.6 ±0.1 6 2.5 ±0.1 (0.35) 0.25 ±0.1 5 A B 6x M 0.1 MAX. 0.95 0.2 1.9 M A SC74-PO V04 Figure 5-1 Package Outline for SC74 (dimensions in mm) 2.9 1.9 0.5 0.95 SC74-FPR V04 Figure 5-2 Package Footprint for SC74 (dimensions in mm) 0.2 2.7 8 4 Pin 1 marking 3.15 1.15 SC74-TP Figure 5-3 Tape and Reel Information for SC74 (dimensions in mm) Datasheet 24 Revision 2.1, 2015-01-28 BCR 320U E6327 / BCR 321U E6327 Terminology Terminology ∆Iout/Iout Output current change hFE DC current gain IEN Enable current Iout Output current IR Reverse current LED Light Emitting Diode PCB Printed Circuit Board Ptot Total power dissipation PWM Pulse Width Modulation RB Bias resistor Rext External resistor Rint Internal resistor RoHs Restriction of Hazardous Substance directive RthJS Thermal resistance junction to soldering point TA Ambient temperature TJ Junction temperature TS Soldering point temperature Tstg Storage temperature VBR(CEO) Collector-emitter breakdown voltage VBR Breakdown voltage Vdrop Voltage drop VEN Enable voltage Vout Output voltage VR Reverse voltage VS Supply voltage VSmin Lowest sufficient supply voltage overhead Datasheet 25 Revision 2.1, 2015-01-28 w w w . i n f i n e o n . c o m Published by Infineon Technologies AG