M ICROWAVE A Division of Crystek Corporation CPLL58-1800-1860 0.582" × 0.800" SMD Features 1.800 GHz - 1.860 GHz Range in Bands Standard 3 Wire Interface Small layout 0.582" × 0.8" Applications Digital Radio Equipment Fixed Wireless Access Satellite Communications Systems Base Stations Personal Communications Systems Portable Radios Test Instruments Wireless Infrastructure The CPLL58 is a complete PLL/Synthesizer needing only an external frequency reference and supply voltages for the internal PLL (phase lock loop) and VCO (voltage controlled oscillator). The Crystek CPLL58 is programmed using a standard three line interface (Data, Clock and Load Enable). The CPLL58 family has been initially released to cover 1 GHz to 5 GHz in bands. It is housed in a compact 0.582-in. × 0.8-in. × 0.15-in. SMD package which saves board space. Typical phase noise at 4 GHz is -90 dBc/Hz at 10 kHz offset with 0 dBm minimum output power. Rev D Page 1 of 10 CRYSTEK CORPORATION 12730 Commonwealth Drive • Fort Myers, Florida 33913 Phone: 239-561-3311 • 800-237-3061 Fax: 239-561-1025 • www.crystek.com M ICROWAVE A Division of Crystek Corporation CPLL58-1800-1860 0.582" × 0.800" SMD PERFORMANCE SPECIFICATION MIN Frequency Range: 1.800 TYP MAX UNITS 1.860 GHz Step Size: 10 kHz Settling Time, to within ± 1kHz (Freq. step < 25MHz): 1 msec Output Power: 0 +3.0 +6.0 dBm @1kHz offset -82 -80 dBc/Hz @10kHz offset -103 -98 dBc/Hz @100kHz offset -127 -122 dBc/Hz @1MHz offset -147 -142 dBc/Hz Output Phase Noise: (See Plot Below) Power Supply: V1=VCO Supply 4.75 5.0 5.25 Volts V2=PLL Supply 2.7 3.0 3.3 Volts Supply Current: I1=VCO Input Current 20 mA I2=PLL Input Current 15 mA Reference Feedthru -80 -70 dBc 2nd -20 -15 dBc Reference Frequency 10 nd Harmonic Suppression (2 Harmonic): Input Reference Level 0.8 Input Impedance RF Output Impedance Operating Temperature Range: -40 MHz V2 Vp-p 100k Ohm 50 Ohm +85 °C 0.6 Volts Logic Inputs (Clock, Data, and LE): Input “High” Voltage 1.4 Input “Low” Voltage Locked Detector (LD): Locked Un-Locked Rev D 1.4 Volts 0.4 Volts Page 2 of 10 CRYSTEK CORPORATION 12730 Commonwealth Drive • Fort Myers, Florida 33913 Phone: 239-561-3311 • 800-237-3061 Fax: 239-561-1025 • www.crystek.com M ICROWAVE A Division of Crystek Corporation Rev D CPLL58-1800-1860 0.582" × 0.800" SMD Page 3 of 10 CRYSTEK CORPORATION 12730 Commonwealth Drive • Fort Myers, Florida 33913 Phone: 239-561-3311 • 800-237-3061 Fax: 239-561-1025 • www.crystek.com M ICROWAVE A Division of Crystek Corporation 0.582" × 0.800" SMD GND V1 GND GND GND 0.411 GND GND LE 0.582 LE = Load Enable, CMOS Input DATA = Serial Data Input CLK = Clock LD = Lock Detect REF = Reference Input V1 = Analog Supply Input (VCO) V2 = Digital Supply Input (PLL) RF = RF Output RF GND 0.331 GND GND GND LD GND 0.251 CLK 0.171 DATA CRYSTEK CPLL58 1800-1860 YYWW REF 0.00 GND 0.00 V2 [Pin1] BOTTOM VIEW 0.200 0.280 0.360 0.440 0.520 0.600 0.800 TOP VIEW CPLL58-1800-1860 TOP ORIENTATION MARK 0.052 0.150 0.000 0.052 0.000 0.000 Pad Detail RECOMMENDED REFLOW SOLDERING PROFILE Ramp-Up 3°C/Sec Max. TEMPERATURE 260°C Critical Temperature Zone Ramp-Down 6°C/Sec. 217°C 200°C 150°C Preheat 180 Secs. Max. 90 Secs. Max. 8 Minutes Max. 260°C for 10 Secs. Max. Rev D Page 4 of 10 CRYSTEK CORPORATION 12730 Commonwealth Drive • Fort Myers, Florida 33913 Phone: 239-561-3311 • 800-237-3061 Fax: 239-561-1025 • www.crystek.com M ICROWAVE A Division of Crystek Corporation CPLL58-1800-1860 0.582" × 0.800" SMD ENVIRONMENTAL COMPLIANCE Parameter Conditions Mechanical Shock MIL-STD-883, Method 2002 Mechanical Vibration MIL-STD-883, Method 2007 Solderability MIL-STD-883, Method 1014 Resistance to Solvents MIL-STD-883, Method 2016 Timing Characteristics for CPLL58-1800-1860 Parameter1 Limit at TMIN to TMAX (B Version) Unit t1 t2 t3 t4 t5 t6 t7 20 10 10 25 25 10 20 ns min ns min ns min ns min ns min ns min ns min 1 Test Conditions/Comments LE setup time DATA to CLOCK setup time DATA to CLOCK hold time CLOCK high duration CLOCK low duration CLOCK to LE setup time LE pulse width Guaranteed by design, but not production tested. t4 t5 CLOCK t1 DATA DB23 (MSB) t2 t3 DB22 DB2 DB1(CONTROL BIT C2) DB0(LSB) (CONTROL BIT C1) t7 LE t6 LE Figure 1. Timing Diagram Rev D Page 5 of 10 CRYSTEK CORPORATION 12730 Commonwealth Drive • Fort Myers, Florida 33913 Phone: 239-561-3311 • 800-237-3061 Fax: 239-561-1025 • www.crystek.com M ICROWAVE A Division of Crystek Corporation CPLL58-1800-1860 0.582" × 0.800" SMD Register Summary FAST-LOCK N-DIVIDER REG 9-BIT RF N VALUE CONTROL BITS 12-BIT RF FRAC VALUE DB21 DB20 DB19 DB18 DB17 DB16 DB15 DB14 DB13 DB12 DB11 DB10 DB9 DB8 DB7 DB6 DB5 DB4 DB3 DB2 DB1 DB0 FL1 N9 N8 N7 N6 N5 N4 N3 N2 N1 F12 F11 F10 F9 F8 F7 F6 F5 F4 F3 F2 F1 C2(0) C1(0) DB23 DB22 DB21 DB20 DB19 DB18 DB17 DB16 DB15 DB14 DB13 DB12 DB11 DB10 DB9 DB8 DB7 DB6 DB5 DB4 DB3 DB2 DB1 DB0 P3 M3 M2 M1 P2 P1 R4 R3 R2 R1 M12 M11 M10 M9 M8 M7 M6 M5 M4 M3 M2 M1 C2(0) C1(1) CONTROL BITS RF POWERDOWN RF CHARGE PUMP THREESTATE RF COUNTER RESET DB15 DB14 DB13 DB12 DB11 DB10 DB9 DB8 DB7 DB6 DB5 DB4 DB3 DB2 DB1 DB0 0 0 0 0 U6 CP3 CP2 CP1 CP0 U5 U4 U3 U2 U1 C2(1) C1(0) CHARGE PUMP CURRENT SETTING RESERVED RESERVED NOISE AND SPUR MODE NOISE AND SPUR MODE LOCK DETECT PRECISION 12-BIT INTERPOLATOR MODULUS VALUE/FAST-LOCK TIMER PHASE DETECTOR POLARITY 4-BIT R VALUE CP/2 MUXOUT REFIN DOUBLER LOAD CONTROL PRESCALER DB22 RESERVED DB23 RESERVED CONTROL BITS CONTROL BITS DB10 DB9 DB8 DB7 DB6 DB5 DB4 DB3 DB2 DB1 DB0 T9 T8 T7 T6 T5 T4 T3 T2 T1 C2(1) C1(1) Specifications subject to change without notice. Rev D Page 6 of 10 CRYSTEK CORPORATION 12730 Commonwealth Drive • Fort Myers, Florida 33913 Phone: 239-561-3311 • 800-237-3061 Fax: 239-561-1025 • www.crystek.com M ICROWAVE A Division of Crystek Corporation CPLL58-1800-1860 0.582" × 0.800" SMD FAST-LOCK N-Divider Register Map 9-BIT RF N VALUE (INT) CONTROL BITS 12-BIT FRAC VALUE (FRAC) DB23 DB22 DB21 DB20 DB19 DB18 DB17 DB16 DB15 DB14 DB13 DB12 DB11 DB10 DB9 DB8 DB7 DB6 DB5 DB4 DB3 DB2 DB1 DB0 FL1 N9 N8 N7 N6 N5 N4 N3 N2 N1 F12 F11 F10 F9 F8 F7 F6 F5 F4 F3 F2 F1 C2(0) C1(0) F12 F11 F10 0 0 0 0 . . . 1 1 1 1 0 0 0 0 . . . 1 1 1 1 0 0 0 0 . . . 1 1 1 1 …….. …….. …….. …….. …….. …….. …….. …….. …….. …….. …….. N9 N8 N7 N6 N5 N4 N3 N2 N1 INTERGER VALUE (INT) 0 0 0 0 . . . 1 1 1 0 0 0 0 . . . 1 1 1 0 0 0 0 . . . 1 1 1 0 1 1 1 . . . 1 1 1 1 0 0 0 . . . 1 1 1 1 0 0 0 . . . 1 1 1 1 0 0 0 . . . 1 1 1 1 0 1 1 . . . 0 1 1 0 1 0 1 . . . 1 0 1 31 32 33 34 . . . 509 510 511 FL1 FAST-LOCK 0 1 NORMAL OPERATION FAST-LOCK ENABLED F3 F2 F1 FRACTIONAL VALUE (FRAC) 0 0 0 0 . . . 1 1 1 1 0 0 1 1 . . . 0 0 1 1 0 1 0 1 . . . 0 1 0 1 0 1 2 3 . . . 4092 4093 4094 4095 Specifications subject to change without notice. Rev D Page 7 of 10 CRYSTEK CORPORATION 12730 Commonwealth Drive • Fort Myers, Florida 33913 Phone: 239-561-3311 • 800-237-3061 Fax: 239-561-1025 • www.crystek.com M ICROWAVE A Division of Crystek Corporation CPLL58-1800-1860 0.582" × 0.800" SMD PRESCALER DB23 DB22 DB21 DB20 DB19 DB18 DB17 DB16 DB15 DB14 DB13 DB12 DB11 DB10 DB9 DB8 DB7 DB6 DB5 DB4 DB3 DB2 DB1 DB0 P3 M3 M2 M1 0 P1 R4 R3 R2 R1 M12 M11 M10 M9 M8 M7 M6 M5 M4 M3 M2 M1 C2(0) C1(0) LOAD CONTROL RESERVED R-Divider Register Map MUXOUT 4-BIT R VALUE P3 LOAD CONTROL P1 PRESCALER M12 M11 M10 0 1 NORMAL OPERATION LOAD FAST LOCK TIMER 0 1 4/5 8/9 0 0 0 . . . 1 1 1 1 0 0 0 . . . 1 1 1 1 0 0 0 . . . 1 1 1 1 R4 R3 R2 R1 R VALUE DIVIDE RATIO 0 0 0 0 . . . 1 1 1 1 0 0 0 1 . . . 1 1 1 1 0 1 1 0 . . . 0 0 1 1 1 0 1 0 . . . 0 1 0 1 1 2 3 4 . . . 12 13 14 15 M3 M2 M1 MUXOUT 0 0 0 0 1 1 1 1 0 0 1 1 0 0 1 1 0 1 0 1 0 1 0 1 THREE-STATE OUTPUT DIGITAL LOCK DETECT N DIVIDER OUTPUT LOGIC HIGH R DIVIDER OUTPUT ANALOG LOCK DETECT FASTLOCK SWITCH LOGIC LOW CONTROL BITS 12-BIT INTERPOLATOR MODULUS VALUE (MOD)/FAST-LOCK TIMER …….. …….. …….. …….. …….. …….. …….. …….. …….. …….. M3 M2 M1 INTERPOLATOR MODULUS VALUE (MOD) 0 0 1 . . . 1 1 1 1 1 1 0 . . . 0 0 1 1 0 1 0 . . . 0 1 0 1 2 3 4 . . . 4092 4093 4094 4095 Specifications subject to change without notice. Rev D Page 8 of 10 CRYSTEK CORPORATION 12730 Commonwealth Drive • Fort Myers, Florida 33913 Phone: 239-561-3311 • 800-237-3061 Fax: 239-561-1025 • www.crystek.com M ICROWAVE A Division of Crystek Corporation CPLL58-1800-1860 0.582" × 0.800" SMD REFIN DOUBLER CP/2 PHASE DETECTOR POLARITY LOCK DETECT PRECISION RF POWERDOWN RF CHARGE PUMP THREESTATE RF COUNTER RESET Control Register Map DB15 DB14 DB13 DB12 DB11 DB10 DB9 DB8 DB7 DB6 DB5 DB4 DB3 DB2 DB1 DB0 S4 S3 S2 S1 U6 CP3 CP2 CP1 CP0 U5 U4 U3 U2 U1 C2(1) C1(0) RESYNC CHARGE PUMP CURRENT SETTING CONTROL BITS U6 REFIN DOUBLER U1 COUNTER RESET 0 1 DISABLED ENABLED 0 1 DISABLED ENABLED U2 RF CHARGE PUMP THREE- STATE 0 1 DISABLED THREE-STATE U3 RF POWER-DOWN 0 1 NORMAL OPERATION POWER-DOWN S4 S3 S2 S1 RESYNC U4 LOCK DETECT PRECISION 0 0 0 . . . 1 1 1 0 0 0 . . . 1 1 1 0 1 1 . . . 0 1 1 1 0 1 . . . 1 0 1 1 2 3 . . . 13 14 15 0 1 24 PFD CYCLES 40 PFD CYCLES 2.7kΩ ICP (mA) 5.1kΩ 10kΩ 0 1 0 1 0 1 0 1 1.18 2.46 3.54 4.72 5.90 7.08 8.26 9.45 0.63 1.25 1.88 2.50 3.13 3.75 4.38 5.00 0.32 0.64 0.96 1.28 1.59 1.92 2.23 2.55 0 1 0 1 0 1 0 1 0.59 1.23 1.77 2.36 2.95 3.54 4.13 4.73 0.31 0.63 0.94 1.25 1.57 1.88 2.19 2.50 0.16 0.32 0.48 0.64 0.80 0.96 1.12 1.28 CP3 CP2 CP1 CP0 0 0 0 0 0 0 0 0 0 0 0 0 1 1 1 1 0 0 1 1 0 0 1 1 1 1 1 1 1 1 1 1 0 0 0 0 1 1 1 1 0 0 1 1 0 0 1 1 U5 PHASE DETECTOR POLARITY 0 1 NEGATIVE POSITIVE Specifications subject to change without notice. Rev D Page 9 of 10 CRYSTEK CORPORATION 12730 Commonwealth Drive • Fort Myers, Florida 33913 Phone: 239-561-3311 • 800-237-3061 Fax: 239-561-1025 • www.crystek.com M ICROWAVE A Division of Crystek Corporation CPLL58-1800-1860 0.582" × 0.800" SMD NOISE AND SPUR MODE NOISE AND SPUR MODE RESERVED Noise and Spur Register RESERVED CONTROL BITS DB10 DB9 DB8 DB7 DB6 DB5 DB4 DB3 DB2 DB1 DB0 T9 T8 T7 T6 T5 T4 T3 T2 T1 C2(1) C1(1) DB10, DB5, DB4, DB3 0 RESERVED RESERVED THESE BITS MUST BE SET TO 0 FOR NORMAL OPERATION. DB9, DB8, DB7, DB6, DB2 NOISE AND SPUR SETTING 00000 11100 11111 LOWEST SPUR MODE LOW NOISE AND SPUR MODE LOWEST NOISE MODE Programming Crystek p/n: CPLL58-1800-1860 TBD Specifications subject to change without notice. Rev D Page 10 of 10 CRYSTEK CORPORATION 12730 Commonwealth Drive • Fort Myers, Florida 33913 Phone: 239-561-3311 • 800-237-3061 Fax: 239-561-1025 • www.crystek.com