Product datasheet PT-FIT 35/220…240 S POWERTRONIC PT-FIT S | ECG for HID lamps, for installation in luminaires Areas of application _ Shop lighting _ Health and fitness areas (in dry, corrosion-protected place) _ Effect and accent lighting __ Product benefits _ Optimized cost/benefit factor _ Compact dimensions and low weight for small luminaire designs _ Automatic safety shutdown of lamps in the event of a defect or at end of life (EoL) Product features _ Energy Efficiency Index EEI: A2 _ Supply voltage: 220…240 V _ Line frequency: 50…60 Hz _ RI suppression: to EN 55015/CISPR 15 _ Safety: to EN 61347-2-12 _ Line harmonics according to EN 61000-3-2 _ Immunity according to EN 61547 June 4, 2016, 09:25:22 PT-FIT 35/220…240 S © 2016, OSRAM GmbH. All rights reserved. Page 1 of 5 Product datasheet Technical data Electrical data __ Lamp wattage 39 W Line current 0.19 A 1) Ignition voltage 4.5 kVp Operating frequency 0.200…0.240 kHz System wattage 43.00 W ECG efficiency 92 % Input voltage AC 198…264 V Nominal voltage 220…240 V Mains frequency 50…60 Hz Power factor λ 0.95 Inrush current 30 A 3) Max. ECG no. on circuit breaker 10 A (B) 15 4) Max. ECG no. on circuit breaker 16 A (B) 26 4) Max. no. of ECGs on 16A MCB with EBN-OS 65 4) Protective conductor current 0.3 mA U-OUT (working voltage) 250 V Max. working voltage between LH and LL 250 V Max. working voltage betw. LL/LH & earth 250 V Max. capacitance of wire ECG/lamp 120 pF 2) 1) At 230 V AC 2) Minimum 3) t width 4) Type B = 150 µs (measured at 50 % I ) peak Dimensions & weight Length 110.0 mm Width 75.0 mm June 4, 2016, 09:25:22 PT-FIT 35/220…240 S © 2016, OSRAM GmbH. All rights reserved. Page 2 of 5 Product datasheet Height 30.0 mm Mounting hole spacing, length 99.0 mm Mounting hole spacing, width 64.0 mm Cable cross-section, input side 0.5…1.0 / 0.5…1.5 mm² 1) Cable cross-section, output side 0.5…1.0 / 0.5…1.5 mm² 1) Wire preparation length, input side 8.5…9.5 mm Wire preparation length, output side 8.5…9.5 mm Product weight 245.00 g 1) With ferrule / Without ferrule Colors & materials Casing material Metal Temperatures & operating conditions Ambient temperature range -15…+65 °C Maximum temperature at tc test point 85 °C Lifespan ECG lifetime __ 30000 h 1) 1) At maximum T / 10% failure rate c Additional product data Design / version Built-in unit Capabilities Max. cable length to lamp/LED module 1.5 m Overheating protection Power reduction and switch off at T > 85 °C at the tc point ECG reset time > 0.5 s Dimmable No Restriction on ignition time 20 min Suitable for fixtures with prot. class I Certificates & standards Approval marks – approval VDE / VDE-EMC / EAC / C-Tick Type of protection IP20 EEI – Energy Label A2 Standards Acc. to EN 61347-2-12/Acc. to EN 55015/Acc. to EN 61000-3-2/Acc. to EN 61547 June 4, 2016, 09:25:22 PT-FIT 35/220…240 S © 2016, OSRAM GmbH. All rights reserved. Page 3 of 5 Product datasheet Wiring Diagram Wiring diagram __ Safety advice Ballast losses and lamp heat radiation can lead to heat accumulation in a completely closed case. Therefore it is necessary to ensure that the temperature at the measuring point t of the ECG does not exceed the maximum value. Attention! For safety reasons disconnect the device before replacing the lamp! Download Data File Tender documents Tender Document for POWERTRONIC EVG.eng Certificates EMC-Marks approval Certificates VDE-Marks approval Certificates EAC PT family June 4, 2016, 09:25:22 PT-FIT 35/220…240 S © 2016, OSRAM GmbH. All rights reserved. Page 4 of 5 Product datasheet Declarations of conformity Declaration of conformity Installation/Operation notice Technical guide - POWERTRONIC for HID-lamps (GB) Operating instructions EAC - PTI S PT-FIT S Logistical Data Product code Product description Packaging unit (Pieces/Unit) Dimensions (length x width x height) Volume Gross weight 4008321386625 PT-FIT 35/220…240 S Shipping carton box 20 412 mm x 136 mm x 152 mm 8.52 dm³ 5169.89 g The mentioned product code describes the smallest quantity unit which can be ordered. One shipping unit can contain one or more single products. When placing an order, for the quantity please enter single or multiples of a shipping unit. Disclaimer Subject to change without notice. Errors and omission excepted. Always make sure to use the most recent release. __ June 4, 2016, 09:25:22 PT-FIT 35/220…240 S © 2016, OSRAM GmbH. All rights reserved. Page 5 of 5