8 PIN DIP HIGH SPEED LOW INPUT CURRENT LOGIC GATE PHOTOCOUPLER EL220X SERIES Features • 1kV/μs min. common mode transient immunity • Guaranteed performance from -40 to 85℃ • Wide VCC range (4.5V to 20V) • 5Mbd typical signal rate • Low input current (1.6mA) • High isolation voltage between input and output (Viso = 5000 V rms ) • Pb free and RoHS compliant. • UL 1577 approved (No. 214129) • VDE approved (No. 40028391) • SEMKO approved • NEMKO approved • DEMKO approved • FIMKO approved Description The EL220X are consists of an infrared emitting diode optically coupled to a high speed integrated photo detector logic gate. It is packaged in an 8-pin DIP package and available in SMD options. The detector of EL2200 has a three state output stage and has a detector threshold with hysteresis. The three state output eliminates the need for a pull up resistor and allows for direct drive of data busses. The hysteresis provides differential mode noise immunity and eliminates the potential for output signal chatter. Applications • Ground Loop Elimination • LSTTL to LSTTL or CMOS • Line Receiver, Data Transmission • Isolated Buss Driver • Pulse Transformer Replacement • Microprocessor System Interface • Computer Peripheral Interface • High Speed Logic Ground Isolation 1 Copyright © 2010, Everlight All Rights Reserved. Release Date : September 9, 2013. Issue No: DPC-0000230 Rev.1 www.everlight.com DATASHEET 8 PIN DIP HIGH SPEED LOW INPUT CURRENT LOGIC GATE PHOTOCOUPLER EL220X SERIES Functional Diagram Schematic EL2200 EL2201/02 Truth Table EL2200 2 Input H L H L Enable H H L L EL2201/02 Input H L Output H L Output Z Z H L Copyright © 2010, Everlight All Rights Reserved. Release Date : September 9, 2013. Issue No: DPC-0000230 Rev.1 www.everlight.com DATASHEET 8 PIN DIP HIGH SPEED LOW INPUT CURRENT LOGIC GATE PHOTOCOUPLER EL220X SERIES Absolute Maximum Ratings (TA=25℃) Parameter Symbol Rating Unit Forward Current IF 50 mA Reverse Voltage VR 5 V Three State Enable Voltage VE 20 V Output Current IO 25 mA Output Voltage VO 20 V Supply Voltage VCC 20 V PT 210 mW Isolation Voltage (Note 2) VISO 5000 V rms Operating Temperature TOPR -40 ~ +85 °C Storage Temperature TSTG -55 ~ +125 °C Soldering Temperature (Note 3) TSOL 260 °C Input Output Total Package Power dissipation(Note 1) 3 Copyright © 2010, Everlight All Rights Reserved. Release Date : September 9, 2013. Issue No: DPC-0000230 Rev.1 www.everlight.com DATASHEET 8 PIN DIP HIGH SPEED LOW INPUT CURRENT LOGIC GATE PHOTOCOUPLER EL220X SERIES Electrical Characteristics (TA = -40 to 85°C, VCC = 4.5V to 20V, IF(ON) = 1.6mA to 5mA, VEH = 2V to 20V, VEL = 0V to 0.8V, IF(OFF) = 0mA unless otherwise specified) (Note 4) Input Parameter Symbol Min. Typ. Max. Unit Forward Voltage VF - 1.4 1.7 V IF = 5mA Reverse Voltage VR 5.0 - - V IR = 10μA VF/TA - -1.8 - mV/°C IF =10mA CIN - 60 - pF Symbol Min. Typ. Max. - 2.3 3 3.7 4.5 6 6 4.5 7.5 - - 0.1 -0.32 - - 20 - - 100 - 0.005 250 Temperature Coefficient of Forward Voltage Input Capacitance Condition VF=0, f=1MHz Output Parameter High Level Supply Current ICCH Low Level Supply Current ICCL High Level Enable Current(EL2200 only) IEL Low Level Enable Current(EL2200 only) High Level Enable Voltage(EL2200 only) Low Level Enable Voltage(EL2200 only) 4 IEH - Unit mA mA mA Condition VCC=5.5V VCC=20V VCC=5.5V VCC=20V IF=5mA,IO=Open VE=Don’t care IF=0mA,IO=Open VE=Don’t care VE=0.4V VE=2.7V μA VE=5.5V VE=20V VEH 2.0 - - V VEL - - 0.8 V Copyright © 2010, Everlight All Rights Reserved. Release Date : September 9, 2013. Issue No: DPC-0000230 Rev.1 www.everlight.com DATASHEET 8 PIN DIP HIGH SPEED LOW INPUT CURRENT LOGIC GATE PHOTOCOUPLER EL220X SERIES Transfer Characteristics (TA = -40 to 85°C, VCC = 4.5V to 20V, IF(ON) = 1.6mA to 5mA, VEH = 2V to 20V, VEL = 0V to 0.8V, IF(OFF) = 0mA unless otherwise specified) (Note 4) Parameter Symbol Typ. Max. - 1.5 100 2 500 Unit Condition VO=5.5V Output Leakage Current IOHH Low Level Output Current VOL - 0.33 0.5 V VCC = 4.5V, IF=0mA, VE=0.4V, IOL=6.4mA Input Threshold Current IFT - - 1.6 mA VCC = 4.5V, VO = 0.5V, VE = 0.4V, IOL = 6.4mA Logic High Output Voltage VOH 2.4 VCC－1.8 - V IOH = -2.6mA IOZL - - -20 μA VO = 0.4V, IF = 5mA, VEN = 2V - - 20 25 - 100 500 - 40 - - -10 - - -25 - - - 0.03 - High Impedance State Output Current 5 Min. (EL2200 only) IOZH Logic Low Short Circuit Output Current IOSL Logic High Short Circuit Output Current IOSH Input Current Hysteresis IHYS μA VCC=4.5V IF=5mA VO=20V VO = 2.4V μA mA mA VO = 5.5V VO = 20V VO = VCC = 5.5V VO = VCC = 20V VCC = 5.5V VCC = 20V mA IF = 5mA, VEN = 2V IF = 0mA (Note 5) IF = 5mA, VO = GND (Note 5) VCC = 4.5V Copyright © 2010, Everlight All Rights Reserved. Release Date : September 9, 2013. Issue No: DPC-0000230 Rev.1 www.everlight.com DATASHEET 8 PIN DIP HIGH SPEED LOW INPUT CURRENT LOGIC GATE PHOTOCOUPLER EL220X SERIES Switching Characteristics (TA = -40 to 85°C, VCC = 4.5V to 20V, IF(ON) = 1.6mA to 5mA, IF(OFF) = 0mA unless otherwise specified) (Note 4) Parameter Symbol Min. Typ. Max. Unit TPLH - 100 300 ns (Note 6&8) , Fig. 11 TPHL - 105 300 ns (Note 7&8), Fig. 11 Output Rise Time tr - 45 - ns (Note 9) , Fig. 11 Output Fall Time tf - 10 - ns (Note 10) , Fig. 11 tPZH - 20 - ns Fig. 12 tPZL - 25 - ns Fig. 12 tPHZ - 130 - ns Fig. 12 tPLZ - 35 - ns Fig. 12 Common Mode Transient Immunity at Output High CMH 1000 - - V/µS Common Mode Transient Immunity at Output Low CML 1000 - - V/µS Propagation Delay Time to Output High Level Propagation Delay Time to Output Low Level Enable Propagation Delay Time to Output High Level Condition (EL2200 only) Enable Propagation Delay Time to Output Low Level (EL2200 only) Disable Propagation Delay Time to Output High Level (EL2200 only) Disable Propagation Delay Time to Output Low Level (EL2200 only) 6 IF=5mA VOH(Min.)=2V (Note 11) IF=0mA VOL(Max.)=2V (Note 12) Copyright © 2010, Everlight All Rights Reserved. Release Date : September 9, 2013. Issue No: DPC-0000230 Rev.1 |VCM|=50V VCC=5V TA = 25°C (Fig. 13) www.everlight.com DATASHEET 8 PIN DIP HIGH SPEED LOW INPUT CURRENT LOGIC GATE PHOTOCOUPLER EL220X SERIES Typical Electro-Optical Characteristics Curves 7 Copyright © 2010, Everlight All Rights Reserved. Release Date : September 9, 2013. Issue No: DPC-0000230 Rev.1 www.everlight.com DATASHEET 8 PIN DIP HIGH SPEED LOW INPUT CURRENT LOGIC GATE PHOTOCOUPLER EL220X SERIES 8 Copyright © 2010, Everlight All Rights Reserved. Release Date : September 9, 2013. Issue No: DPC-0000230 Rev.1 www.everlight.com DATASHEET 8 PIN DIP HIGH SPEED LOW INPUT CURRENT LOGIC GATE PHOTOCOUPLER EL220X SERIES The Probe and Jig Capacitances are Included in C1 and C2 All Diodes are 1N916 and 1N3064. R1 IF(ON) 2.25KΩ 1mA 1.2KΩ 3mA 720Ω 5mA Fig. 11 Test Circuit and Waveforms for tPLH, tPHL, tr, and tf (Note 13) Fig. 12 Test Circuit and Waveform for tPHZ and tPLZ, tPLZ and tPZL 9 Copyright © 2010, Everlight All Rights Reserved. Release Date : September 9, 2013. Issue No: DPC-0000230 Rev.1 www.everlight.com DATASHEET 8 PIN DIP HIGH SPEED LOW INPUT CURRENT LOGIC GATE PHOTOCOUPLER EL220X SERIES 50V VCM 0V Switch at A, IF = 1.6mA VOH VO(Min) Output VO Switching at B, IF = 0mA VO(Max) VOL Fig. 13 Test Circuit Common Mode Transient Immunity (Note 13) Fig. 14 Recommended LSTTL to LSTTL Circuit. (Note 13) 10 Fig. 15 LSTTL to CMOS Interface Circuit. (Note 13) Copyright © 2010, Everlight All Rights Reserved. Release Date : September 9, 2013. Issue No: DPC-0000230 Rev.1 www.everlight.com DATASHEET 8 PIN DIP HIGH SPEED LOW INPUT CURRENT LOGIC GATE PHOTOCOUPLER EL220X SERIES Fig. 16 Recommended LED Drive Circuit. Fig. 17 Series LED Drive With Open Collector Gate. (4.7KΩ Resister Shunts IOH from the LED) Note 1. Derate total package power dissipation, PT, linearly above 70°C free air temperature at a rate of 4.5 mW/°C. 2. AC for 1 minute, R.H.= 40 ~ 60% R.H. In this test, pins 1, 2, 3 & 4 are shorted together, and pins 5, 6, 7 & 8 are shorted together. 3. For 10 seconds. 4. The VCC supply must be bypassed by a 0.1μF capacitor or larger. This can be either a ceramic or solid tantalum capacitor with good high frequency characteristic and should be connected as close as possible to the package VCC and GND pins. 5. Duration of output short circuit time should not exceed 10 ms. 6. tPLH– Propagation delay is measured from the 50% level on the LOW to HIGH transition of the input current pulse to the 1.3 V level on the LOW to HIGH transition of the output voltage pulse. 7. tPHL– Propagation delay is measured from the 50% level on the HIGH to LOW transition of the input current pulse to the 1.3 V level on the HIGH to LOW transition of the output voltage pulse. 8. When the peaking capacitor is omitted, propagation delay times may increase by 100 ns. 9. tr– Rise time is measured from the 10% to the 90% levels on the LOW to HIGH transition of the output pulse. 10. tf– Fall time is measured from the 90% to the 10% levels on the HIGH to LOW transition of the output pulse. 11. CMH – The maximum tolerable rate of rise of the common mode voltage to ensure the output will remain in the HIGH state (i.e., VOUT > 2.0V). 12. CML – The maximum tolerable rate of rise of the common mode voltage to ensure the output will remain in the LOW output state (i.e., VOUT < 0.8V). 13. For testing EL2201/02 the enable pin must be floating. 11 Copyright © 2010, Everlight All Rights Reserved. Release Date : September 9, 2013. Issue No: DPC-0000230 Rev.1 www.everlight.com DATASHEET 8 PIN DIP HIGH SPEED LOW INPUT CURRENT LOGIC GATE PHOTOCOUPLER EL220X SERIES Order Information Part Number EL2200Y(Z)-V EL2201Y(Z)-V EL2202Y(Z)-V Note Y Z V 12 = Lead form option (S, S1, M or none) = Tape and reel option (TA, TB or none). = VDE (optional) Option None Description Packing quantity Standard DIP-8 45 units per tube M Wide lead bend (0.4 inch spacing) 45 units per tube S (TA) Surface mount lead form + TA tape & reel option 1000 units per reel S (TB) Surface mount lead form + TB tape & reel option 1000 units per reel S1 (TA) Surface mount lead form (low profile) + TA tape & reel option 1000 units per reel S1 (TB) Surface mount lead form (low profile) + TB tape & reel option 1000 units per reel Copyright © 2010, Everlight All Rights Reserved. Release Date : September 9, 2013. Issue No: DPC-0000230 Rev.1 www.everlight.com DATASHEET 8 PIN DIP HIGH SPEED LOW INPUT CURRENT LOGIC GATE PHOTOCOUPLER EL220X SERIES Package Dimension (Dimensions in mm) Standard DIP Type Option M Type 13 Copyright © 2010, Everlight All Rights Reserved. Release Date : September 9, 2013. Issue No: DPC-0000230 Rev.1 www.everlight.com DATASHEET 8 PIN DIP HIGH SPEED LOW INPUT CURRENT LOGIC GATE PHOTOCOUPLER EL220X SERIES Option S Type Option S1 Type 14 Copyright © 2010, Everlight All Rights Reserved. Release Date : September 9, 2013. Issue No: DPC-0000230 Rev.1 www.everlight.com DATASHEET 8 PIN DIP HIGH SPEED LOW INPUT CURRENT LOGIC GATE PHOTOCOUPLER EL220X SERIES Recommended Pad Layout for Surface Mount Leadform Device Marking EL 2200 YWWV Notes EL 2200 Y WW V 15 denotes EVERLIGHT denotes Device Number denotes 1 digit Year code denotes 2 digit Week code denotes VDE (optional) Copyright © 2010, Everlight All Rights Reserved. Release Date : September 9, 2013. Issue No: DPC-0000230 Rev.1 www.everlight.com DATASHEET 8 PIN DIP HIGH SPEED LOW INPUT CURRENT LOGIC GATE PHOTOCOUPLER EL220X SERIES Tape & Reel Packing Specifications Option TB Option TA Direction of feed from reel Direction of feed from reel Tape Dimension 16 Dimension No. A B Do D1 E F Dimension(mm) 10.4±0.1 10.0±0.1 1.5+0.1/-0 1.5±0.25/-0 1.75±0.1 7.5±0.1 Dimension No. Po P1 P2 t W K Dimension(mm) 4.0±0.1 12.0±0.1 2.0±0.05 0.4±0.05 16.0±0.3/ 4.5±0.1 Copyright © 2010, Everlight All Rights Reserved. Release Date : September 9, 2013. Issue No: DPC-0000230 Rev.1 www.everlight.com DATASHEET 8 PIN DIP HIGH SPEED LOW INPUT CURRENT LOGIC GATE PHOTOCOUPLER EL220X SERIES Precautions for Use 1. Soldering Condition 1.1 (A) Maximum Body Case Temperature Profile for evaluation of Reflow Profile Note: Reference: IPC/JEDEC J-STD-020D Preheat Temperature min (Tsmin) 150 °C Temperature max (Tsmax) 200°C Time (Tsmin to Tsmax) (ts) Average ramp-up rate (Tsmax to Tp) 60-120 seconds 3 °C/second max Other Liquidus Temperature (TL) 217 °C Time above Liquidus Temperature (t L) 60-100 sec Peak Temperature (TP) 260°C Time within 5 °C of Actual Peak Temperature: T P - 5°C 30 s Ramp- Down Rate from Peak Temperature 6°C /second max. Time 25°C to peak temperature Reflow times 8 minutes max. 3 times 17 Copyright © 2010, Everlight All Rights Reserved. Release Date : September 9, 2013. Issue No: DPC-0000230 Rev.1 www.everlight.com DATASHEET 8 PIN DIP HIGH SPEED LOW INPUT CURRENT LOGIC GATE PHOTOCOUPLER EL220X SERIES DISCLAIMER 1. Above specification may be changed without notice. EVERLIGHT will reserve authority on material change for above specification. 2. When using this product, please observe the absolute maximum ratings and the instructions for using outlined in these specification sheets. EVERLIGHT assumes no responsibility for any damage resulting from use of the product which does not comply with the absolute maximum ratings and the instructions included in these specification sheets. 3. These specification sheets include materials protected under copyright of EVERLIGHT corporation. Please don’t reproduce or cause anyone to reproduce them without EVERLIGHT’s consent. 18 Copyright © 2010, Everlight All Rights Reserved. Release Date : September 9, 2013. Issue No: DPC-0000230 Rev.1 www.everlight.com