DEVR10 Electric Vehicle Contactor • • • • • • • High current and high voltage capability Compact structure - Low noise Magnetic arc blowout Max 900VDC @ 100A Reliable contacts in inert gas No special installation required RoHS Compliant Contacts Contact number & arrangement SPST-NO (1NO) Contact material AgSnO2 Max. switching voltage 900VDC Min. switching voltage 12VDC Min. switching current 100mA Rated continuous current 100A * 1 (voltage dependant) Max. switching current 200A (3 mins) #8 AWG (8.4mm2) wire, at +40°C Max. short circuit current 1250A (1/2 sine, 50/60Hz) Voltage drop ≤80mV@100A) Coil Rated voltage 12 ~ 72VDC Operating range of supply voltage See coil data ‘Table 1’ Rated coil power consumption 5.5 ~ 6.0W Insulation Insulation resistance (Initial / End of Life) 100MΩ / 50MΩ at 500VDC Dielectric strength coil - contact 2,000Vrms / 4000VDC contact - contact 5,600Vrms / 8000VDC General Data Operating time mS ≤ 25ms. (includes bounce time - 5ms max) Release time mS ≤ 20ms. Electrical Life ops 50,000 @ 50A/400VDC : 6000 @ 100A/400VDC Mechanical life ops 1 x 106 Dimensions Weight Ambient Temperature L x W x H 53.85 x 40 x 52.41mm (see drawings for detail) 190g ±2g operating / storage -40 to +85°C Shock resistance 20G, 11ms ½ sine, peak Vibration resistance 20G, sine, peak (55~2,000 Hz) Noise (at 100mm) 70dB(a) * Consult factory for higher current capabilities 1 Recommended wire - #8AWG (8.4mm2) 2 Failure to observe correct polarity for load terminal connections will result in degraded life. Page 1 of 3 American Electronic Components Inc., 1101 Lafayette St. Elkhart, IN46516 www.durakoolrelays.com Sales Department Tel: +1 574 295 6330 Toll: (888) 847 6552 Ref: DEVR10 121415JHM Specifications are subject to change without notice. E&OE. DEVR10 Electric Vehicle Contactor Coil Data - DEVR10 Table 1 Must Operate Voltage Max. (VDC) Maximum Allowable Voltage (VDC) Must Release Voltage Min. (VDC) CoilResistance (Ω ± 5% @ 20°C) Coil Current (mA) Coil Power (W @ 20°C) 9.6 16 1.2 26 461 5.5 18 19.2 28 2.4 96 250 6.0 21 22.4 31 2.24 136 206 5.7 48 33 38.4 52 4.8 392 122 6.0 72 21 55.2 79 5.76 868 83 6.0 Coil Voltage Code Nominal Voltage (VDC) 1012 12 8 1024 24 1028 28 1048 1072 20°C 85°C Ordering Codes D E V R 1 0 - 5 0 6 1 - S 8 - - Contact Material 50 - AgSnO2 Contact Arrangement 61 - SPST-NO, Polarity conscious Cover Protection and Mounting S - Flange mount on base Connection Mode 8 - M5 Stud Coil Code See Coil Table 1 Coil Wire Length R - 400mm Other lengths available Coil Wire Termination 1 - None Other terminations to special order Notes: 1) 2) 3) 4) 6) 7) 8) 9) 10) Page 2 of 3 Spring Washers are an essential requirement for installation - see Page 3. Torque setting for the M5 Power Terminals is 3.4 to 4.5Nm. Loose terminals will generate excessive heat leading to premature failure and risk of fire. The maximum torque setting for the M4 mounting bolts (not supplied) is 2.3Nm. to avoid damage to the contactor body. Please ensure the correct polarity of the wiring to the power terminals. Contact life is greatly reduced if incorrectly connected. Contact ratings are with #8 AWG wire. Ensure adequate circuit protection in case of contact malfunction. The contact chamber contains an inert gas. For maximum life, do not exceed the ambient temperature range of -40 to +85°C. Contact ratings are based upon a resistive load. For inductive loads an inrush protection device is recommended. American Electronic Components Inc., 1101 Lafayette St. Elkhart, IN46516 www.durakoolrelays.com Sales Department Tel: +1 574 295 6330 Toll: (888) 847 6552 Ref: DEVR10 121415JHM Specifications are subject to change without notice. E&OE. DEVR10 Electric Vehicle Contactor Fig. 1 Estimated life DEVR10 Estimated Life (resistive load) 400VDC 100000 10000 Operations 1000 100 10 1 0 200 400 600 Amps at 400VDC 800 1000 1200 Fig. 2 Overall Dimensions M5 Bolt Important: Observe correct polarity for load terminals M5 Lockwasher M5 Washer Busbar (Customer supplied) Correct sequence for power terminal hardware assembly NB: Hardware is NOT supplied with the contactor. NB: Hardware is NOT supplied with the contactor. All dimensions in millimeters Page 3 of 3 American Electronic Components Inc., 1101 Lafayette St. Elkhart, IN46516 www.durakoolrelays.com Sales Department Tel: +1 574 295 6330 Toll: (888) 847 6552 Ref: DEVR10 121415JHM Specifications are subject to change without notice. E&OE.