Series CCRS-33S/CRS-33S COAX SWITCHES Miniature DC–18 GHz Latching 2P3T Coaxial Switch PART NUMBER DESCRIPTION CCRS-33S Commercial Latching 2P3T, DC-18GHz CRS-33S Elite Latching 2P3T, DC-18GHz The CCRS-33S/CRS-33S is a broadband, 2P3T, electromechanical coaxial switch designed to switch a microwave signal from a common input to either of two outputs. The characteristic impedance is 50 Ohms. The switches are small with the minimum spacing that is compatible with SMA connectors, and can also be used as a SPDT switch with external terminations. ENVIRONMENTAL AND PHYSICAL CHARACTERISTICS ELECTRICAL CHARACTERISTICS Operating Temperature Commercial Model, CCRS-33S Elite Model, CRS-33S Form Factor –40°C to 65°C –55°C to 85°C 2P3T, break before make Vibration (MIL-STD-202 Method 214, Condition D, non-operating) 10 g’s RMS Frequency Range CCRS-33S CRS-33S DC–18 GHz DC–18 GHz Shock (MIL-STD-202 Method 213, Condition D, non-operating) 500 g’s Characteristic Impedance 50 Ohms Operate Time 10 ms (max.) Standard Actuator Life Actuator Life w/ Additional Features 5,000,000 cycles 1,000,000 cycles Connector Type SMA Humidity (Moisture Seal) Available Weight 2.65 oz. (75.1g) (max.) Actuation Voltage Available 12 15 24 28 V Actuation Current, max. @ ambient 420 350 280 200 mA PERFORMANCE CHARACTERISTICS Frequency DC–6 GHz 6–12 GHz 12–18 GHz 0.1 0.2 0.3 Insertion Loss, dB, max. Isolation, dB, min. VSWR , max. 85 80 75 1.1:1 1.2:1 1.3:1 PART NUMBERING SYSTEM CCRS-33 S 6 C - T ** Options Series Connectors Actuator Type Actuator Voltage Connector S: SMA Female Actuator Voltage 6: 28 Vdc Latching 7: 15 Vdc Latching 8: 12 Vdc Latching 9: 24 Vdc Latching Actuator Type O: Standard Contacts C: Indicator Contacts D: Self Cutoff Only E: Indicators and Self Cutoff **SEE PARTS LIST ON PAGE 8 Options T: TTL Drivers with Diodes D: Transient Suppression Diodes R: Positive + Common M: Moisture Seal S: 9 Pin D-Sub Connector For other options, contact factory. © 2012 TELEDYNE RELAYS (800) 284-7007 • www.teledynecoax.com CCRS-33S/CRS-33S Page 1 CCRS-33S\CRS-33S\062012\Q2 Series CCRS-33S/CRS-33S COAX SWITCHES Miniature DC–18 GHz Latching 2P3T Coaxial Switch SCHEMATICS AND MECHANICAL OUTLINE 2X SOLDER TERMINALS SOLDER WIRE MAXIMUM TEMP 250ºC FOR NO MORE THAN 5 SEC H = 1.75 STD & Indicator Model H = 1.90 All OTHER Models Indicators TTL Analog 1 6 “-S OPTION” 9-PIN D-SUB CONNECTOR (EXAMPLE: 9 PIN D-SUB PINOUT FOR LATCHING 2P3T TRUTH TABLE (with TTL option) OPTIONS Pin No. 1 2 3 4 5 6 7 8 9 Basic Indicators 1 2 C 1 2 C CCRS-33S/CRS-33S Page 2 A B C TTL Common 1 2 Vsw CCRS-33S60-S) Indicators & TTL Common 1 2 Vsw A B C Logic Input 1 2 0 0 Indicator RF Path 1-2 2-3 3-4 (if applicable) 4-5 No Change A B N/A 1 0 On Off On Off A&C 0 1 Off On Off On B&C 1 1 SPECIFICATIONS ARE SUBJECT TO CHANGE WITHOUT NOTICE Forbidden N/A © 2012 TELEDYNE COAX SWITCHES CCRS-33S\CRS-33S\062012\Q2 Series CCRS-33S/CRS-33S COAX SWITCHES Miniature DC–18 GHz Latching 2P3T Coaxial Switch TYPICAL NARROWBAND RF INSERTION LOSS PERFORMANCE CURVES Insertion Loss ( 6-12 GHz ) 0.0 0.0 -0.1 -0.1 -0.2 -0.2 Insertion Loss (dB) Insertion Loss (dB) Insertion Loss ( DC-6 GHz ) -0.3 -0.4 -0.5 -0.6 -0.7 -0.8 -0.9 -0.3 -0.4 -0.5 -0.6 -0.7 -0.8 -0.9 -1.0 -1.0 0 1 2 3 4 5 6 6 Frequency (GHz) 7 8 9 10 11 12 Frequency (GHz) Insertion Loss ( 12-18 GHz ) 0.0 Insertion Loss (dB) -0.1 -0.2 -0.3 -0.4 -0.5 -0.6 -0.7 -0.8 -0.9 -1.0 12 13 14 15 16 17 18 Frequency (GHz) RF NOTES © 2012 TELEDYNE RELAYS (800) 284-7007 • www.teledynecoax.com CCRS-33S/CRS-33S Page 3 CCRS-33S\CRS-33S\062012\Q2 Series CCRS-33S/CRS-33S COAX SWITCHES Miniature DC–18 GHz Latching 2P3T Coaxial Switch TYPICAL NARROWBAND RF ISOLATION PERFORMANCE CURVES Isolation ( 6-12 GHz ) 0 -20 -20 -40 -40 Isolation (dB) Isolation (dB) Isolation ( DC-6 GHz ) 0 -60 -80 -60 -80 -100 -100 -120 -120 -140 -140 0 1 2 3 4 5 6 6 7 8 Frequency (GHz) 9 10 11 12 Frequency (GHz) Isolation ( 12-18 GHz ) 0 -20 Isolation (dB) -40 -60 -80 -100 -120 -140 12 13 14 15 16 17 18 Frequency (GHz) RF NOTES CCRS-33S/CRS-33S Page 4 SPECIFICATIONS ARE SUBJECT TO CHANGE WITHOUT NOTICE © 2012 TELEDYNE COAX SWITCHES CCRS-33S\CRS-33S\062012\Q2 Series CCRS-33S/CRS-33S COAX SWITCHES Miniature DC–18 GHz Latching 2P3T Coaxial Switch TYPICAL NARROWBAND RF VSWR PERFORMANCE CURVES VSWR ( 6-12 GHz ) 2.0 1.9 1.9 1.8 1.8 1.7 1.7 1.6 1.6 VSWR VSWR VSWR ( DC-6 GHz ) 2.0 1.5 1.4 1.5 1.4 1.3 1.3 1.2 1.2 1.1 1.1 1.0 1.0 0 1 2 3 4 5 6 6 Frequency (GHz) 7 8 9 10 11 12 Frequency (GHz) VSWR ( 12-18 GHz ) 2.0 1.9 1.8 VSWR 1.7 1.6 1.5 1.4 1.3 1.2 1.1 1.0 12 13 14 15 16 17 18 Frequency (GHz) RF NOTES © 2012 TELEDYNE RELAYS (800) 284-7007 • www.teledynecoax.com CCRS-33S/CRS-33S Page 5 CCRS-33S\CRS-33S\062012\Q2 Series CCRS-33S/CRS-33S COAX SWITCHES Miniature DC–18 GHz Latching 2P3T Coaxial Switch TYPICAL POWER PERFORMANCE CURVE Power Handling vs. Frequency 3000 2000 Power (W) 1000 800 600 400 STAN DAR DS 300 MA 200 SW ITC HES 100 80 60 40 30 20 10 .1 .2 .3 .4 .6 .8 1 2 4 6 8 10 18 Frequency GHz Estimates based on the following reference conditions: • Ambient temperature of 40°C or less • Sea level operation • Load VSWR of 1.20:1 maximum • No high-power (hot) switching Please contact Teledyne Coax Switches for derating factors when applications do not meet the foregoing reference conditions. CCRS-33S/CRS-33S Page 6 SPECIFICATIONS ARE SUBJECT TO CHANGE WITHOUT NOTICE © 2012 TELEDYNE COAX SWITCHES CCRS-33S\CRS-33S\062012\Q2 Series CCRS-33S/CRS-33S COAX SWITCHES Miniature DC–18 GHz Latching 2P3T Coaxial Switch GLOSSARY Actuator An actuator is the electromechanical mechanism that transfers the RF contacts from one position to another upon DC command. Arc Suppression Diode A diode is connected in parallel with the coil. This diode limits the “reverse EMF spike” generated when the coil deenergizes to 0.7 volts. The diode cathode is connected to the positive side of the coil and the anode is connected to the negative side. Date Code All switches are marked with either a unique serial number or a date code. Date codes are in accordance with MILSTD-1285 Paragraph 5.2.5 and consist of four digits. The first two digits define the year and the last two digits define the week of the year (YYWW). Thus, 1032 identifies switches that passed through final inspection during the 32nd week of 2010. Indicator Indicators tell the system which position the switch is in. Other names for indicators are telemetry contacts or tellback circuit. Indicators are usually a set of internally mounted DC contacts linked to the actuator. They can be wired to digital input lines, status lights, or interlocks. Unless otherwise specified, the maximum indicator contact rating is 30 Vdc, 50 mA, or 1.5 Watts into a resistive load. Isolation Isolation is the measure of the power level at the output connector of an unconnected RF channel as referenced to the power at the input connector. It is specified in dB below the input power level. Latching A latching switch remains in the selected position whether or not voltage is maintained. This can be accomplished with either a magnetic or mechanical latching mechanism. TTL Switch Driver Option As a special option, switch drivers can be provided for both failsafe and latching switches, which are compatible with industry-standard low-power Schottky TTL circuits. Performance Parameters vs Frequency Generally speaking, the RF performance of coaxial switches is frequency dependent. With increasing frequency, VSWR and insertion loss increase while isolation decreases. All data sheets specify these three parameters as “worst case” at the highest operating frequency. If the switch is to be used over a narrow frequency band, better performance can be achieved. Actuator Current vs Temperature The resistance of the actuator coil varies as a function of temperature. There is an inverse relationship between the operating temperature of the switch and the actuator drive current. For switches operating at 28 VDC, the approximate actuator drive current at temperature, T, can be calculated using the equation: IT = IA [1 + .00385 (T-20)] Where: IT = Actuator current at temperature, T IA = Room temperature actuator current – see data sheet T = Temperature of interest in °C Magnetic Sensitivity An electro-mechanical switch can be sensitive to ferrous materials and external magnetic fields. Neighboring ferrous materials should be permitted no closer than 0.5 inches and adjacent external magnetic fields should be limited to a flux density of less than 5 Gauss. Self-Cutoff The self-cutoff option disables the actuator current on completion of actuation. Either a series contact (linked to the actuator) or an IC driver circuit provides the current cutoff. This option results in minimum power consumption by the RF switch. Cutthroat is another name used in the industry for this option. Pulse latching is a term used to describe a switch without this feature. Switching Time Switching time is the total interval beginning with the arrival of the leading edge of the command pulse at the switch DC input and ending with the completion of the switch transfer, including contact bounce. It consists of three parts: (1) inductive delay in the coil, (2) transfer time of the physical movement of the contacts, and (3) the bounce time of the RF contacts. © 2012 TELEDYNE RELAYS (800) 284-7007 • www.teledynecoax.com CCRS-33S/CRS-33S Page 7 CCRS-33S\CRS-33S\062012\Q2 Series CCRS-33S/CRS-33S COAX SWITCHES Miniature DC–18 GHz Latching 2P3T Coaxial Switch LATCHING CCRS-33S/CRS-33S PART NUMBER LIST PART NO. * PART NO. PART NO. PART NO. 1 CCRS-33SXC 43 CCRS-33SXE-DMS 85 CRS-33SXC-DRMS 127 CRS-33SXE-M 2 CCRS-33SXC-D 44 CCRS-33SXE-DR 86 CRS-33SXC-DRS 128 CRS-33SXE-MS 3 CCRS-33SXC-DM 45 CCRS-33SXE-DRM 87 CRS-33SXC-DS 129 CRS-33SXE-R 4 CCRS-33SXC-DMS 46 CCRS-33SXE-DRMS 88 CRS-33SXC-M 130 CRS-33SXE-RM 5 CCRS-33SXC-DR 47 CCRS-33SXE-DRS 89 CRS-33SXC-MS 131 CRS-33SXE-RMS 6 CCRS-33SXC-DRM 48 CCRS-33SXE-DS 90 CRS-33SXC-R 132 CRS-33SXE-RS 7 CCRS-33SXC-DRMS 49 CCRS-33SXE-M 91 CRS-33SXC-RM 133 CRS-33SXE-S 8 CCRS-33SXC-DRS 50 CCRS-33SXE-MS 92 CRS-33SXC-RMS 134 CRS-33SXE-T 9 CCRS-33SXC-DS 51 CCRS-33SXE-R 93 CRS-33SXC-RS 135 CRS-33SXE-TM 10 CCRS-33SXC-M 52 CCRS-33SXE-RM 94 CRS-33SXC-S 136 CRS-33SXE-TMS 11 CCRS-33SXC-MS 53 CCRS-33SXE-RMS 95 CRS-33SXC-T 137 CRS-33SXO 12 CCRS-33SXC-R 54 CCRS-33SXE-RS 96 CRS-33SXC-TM 138 CRS-33SXO-D 13 CCRS-33SXC-RM 55 CCRS-33SXE-S 97 CRS-33SXC-TMS 139 CRS-33SXO-DM 14 CCRS-33SXC-RMS 56 CCRS-33SXE-T 98 CRS-33SXC-TS 140 CRS-33SXO-DMS 15 CCRS-33SXC-RS 57 CCRS-33SXE-TM 99 CRS-33SXD 141 CRS-33SXO-DR 16 CCRS-33SXC-S 58 CCRS-33SXE-TMS 100 CRS-33SXD-D 142 CRS-33SXO-DRM 17 CCRS-33SXC-T 59 CCRS-33SXO 101 CRS-33SXD-DM 143 CRS-33SXO-DRMS 18 CCRS-33SXC-TM 60 CCRS-33SXO-D 102 CRS-33SXD-DMS 144 CRS-33SXO-DRS 19 CCRS-33SXC-TMS 61 CCRS-33SXO-DM 103 CRS-33SXD-DR 145 CRS-33SXO-DS 20 CCRS-33SXC-TS 62 CCRS-33SXO-DMS 104 CRS-33SXD-DRM 146 CRS-33SXO-M 21 CCRS-33SXD 63 CCRS-33SXO-DR 105 CRS-33SXD-DRMS 147 CRS-33SXO-MS 22 CCRS-33SXD-D 64 CCRS-33SXO-DRM 106 CRS-33SXD-DRS 148 CRS-33SXO-R 23 CCRS-33SXD-DM 65 CCRS-33SXO-DRMS 107 CRS-33SXD-DS 149 CRS-33SXO-RM 24 CCRS-33SXD-DMS 66 CCRS-33SXO-DRS 108 CRS-33SXD-M 150 CRS-33SXO-RMS 25 CCRS-33SXD-DR 67 CCRS-33SXO-DS 109 CRS-33SXD-MS 151 CRS-33SXO-RS 26 CCRS-33SXD-DRM 68 CCRS-33SXO-M 110 CRS-33SXD-R 152 CRS-33SXO-S 27 CCRS-33SXD-DRMS 69 CCRS-33SXO-MS 111 CRS-33SXD-RM 153 CRS-33SXO-T 28 CCRS-33SXD-DRS 70 CCRS-33SXO-R 112 CRS-33SXD-RMS 154 CRS-33SXO-TM 29 CCRS-33SXD-DS 71 CCRS-33SXO-RM 113 CRS-33SXD-RS 155 CRS-33SXO-TMS 30 CCRS-33SXD-M 72 CCRS-33SXO-RMS 114 CRS-33SXD-S 156 CRS-33SXO-TS 31 CCRS-33SXD-MS 73 CCRS-33SXO-RS 115 CRS-33SXD-T 32 CCRS-33SXD-R 74 CCRS-33SXO-S 116 CRS-33SXD-TM 33 CCRS-33SXD-RM 75 CCRS-33SXO-T 117 CRS-33SXD-TMS 34 CCRS-33SXD-RMS 76 CCRS-33SXO-TM 118 CRS-33SXE 35 CCRS-33SXD-RS 77 CCRS-33SXO-TMS 119 CRS-33SXE-D 36 CCRS-33SXD-S 78 CCRS-33SXO-TS 120 CRS-33SXE-DM 37 CCRS-33SXD-T 79 CRS-33SXC 121 CRS-33SXE-DMS 38 CCRS-33SXD-TM 80 CRS-33SXC-D 122 CRS-33SXE-DR 39 CCRS-33SXD-TMS 81 CRS-33SXC-DM 123 CRS-33SXE-DRM 40 CCRS-33SXE 82 CRS-33SXC-DMS 124 CRS-33SXE-DRMS 41 CCRS-33SXE-D 83 CRS-33SXC-DR 125 CRS-33SXE-DRS 42 CCRS-33SXE-DM 84 CRS-33SXC-DRM 126 CRS-33SXE-DS X = 6 (28Vdc), 7 (15Vdc), 8 (12Vdc) and 9 (24Vdc) CCRS-33S/CRS-33S Page 8 SPECIFICATIONS ARE SUBJECT TO CHANGE WITHOUT NOTICE © 2012 TELEDYNE COAX SWITCHES CCRS-33S\CRS-33S\062012\Q2