EVL185W-LEDTV 185 W power supply with PFC and standby supply for LED TV based on the L6564, L6599A and Viper27L Data brief Features ■ Universal input mains range: 90÷264 Vac frequency 45÷65 Hz ■ Output voltage 1: 130 V ±8 % at 620 mA for backlight ■ Output voltage 2: 24 V ±8 % at 2 A for audio supply ■ Output voltage 3: 12 V ±1 % at 4 A for panel supply ■ Output voltage 4: 5 V ±2 % at 2 A for microprocessor supply ■ Mains harmonics: acc. to EN61000-3-2 ClassD or JEITA-MITI Class-D ■ Standby mains consumption: <170 mW at 230 Vac with 50 mW load ■ Overall efficiency at full load: >90% ■ EMI: according to EN55022-Class-B ■ Safety: according to EN60065 ■ Dimensions: 115x204 mm, 25 mm maximum component height from PCB The PFC stage delivers 400 V constant voltage and acts as the pre-regulator for both the LLC stage and the standby supply. ■ PCB: single side, 70 µm, CEM-1, mixed PTH/SMT introduction An external signal, referred to secondary ground, turns the PFC and the LLC stage on and off. ■ RoHS compliant the logic circuitry, and a bigger section composed of a front-end PFC, using the new TM L6564 and an LLC resonant converter, using the L6599A, delivering three output voltages: 12 V dedicated to supplying the TV panel, 24 V to supplying the audio power amplifiers, and 130 V dedicated to the backlight. Description The EVL185W-LEDTV is a high-end demonstration board tailored to the specifications of a typical LED TV application. The peculiarities of this design are the very high average efficiency of about 90%, without synchronous rectification, and very low no load consumption of 100 mW at 230 Vac. The result is that this converter is compliant to the most demanding ENERGY STAR® eligibility criteria. The architecture is made up of two sections, based on a three-stage approach: a 10 W standby supply using the new VIPer27L, which delivers the 5 V standby dedicated to supplying the microprocessor and April 2011 Doc ID 018695 Rev 1 For further information contact your local STMicroelectronics sales office. 1/5 www.st.com 5 Efficiency 1 EVL185W-LEDTV Efficiency Thanks to the chipset used, the main peculiarities of this design are the very high efficiency as well as the very low input consumption during standby operation. Table 1. Overall efficiency measured at 230 Vac mains voltage 230 V - 50 Hz 12 V Test 24 V 130 V Eff. [W] [W] [%] [A] 128.89 0.15 5.05 0.50 46.09 52.00 88.6 1.00 129.95 0.31 5.04 1.00 93.30 101.50 91.9 24.38 1.50 131.05 0.47 5.04 1.50 141.67 151.90 93.3 24.48 2.00 132.18 0.62 5.04 2.00 187.96 201.50 93.3 [A] 24.19 0.50 2.01 24.28 11.90 3.01 11.88 3.99 [A] 11.95 1.00 50% load eff. 11.93 75% load eff. 100% load eff. 25% load eff. Pin Iout Iout Iout Iout Pout Vout [V] Vout [V] Vout [V] Vout [V] 5V [A] Average eff. Table 2. 91.8 Overall efficiency measured at 115 Vac mains voltage 115 V - 60 Hz Test 12 V 24 V 130 V 5V Pout Pin Eff. [W] [W] [%] Vout [V] Iout Vout [V] Iout [A] Vout [V] Iout [A] Vout [V] Iout [A] 25% load eff. 11.95 1.00 24.19 0.50 128.89 0.15 5.05 0.50 46.09 52.35 88.0 50% load eff. 11.93 2.01 24.28 1.00 129.95 0.31 5.04 1.00 93.30 102.85 90.7 75% load eff. 11.90 3.01 24.38 1.50 131.05 0.47 5.04 1.50 141.67 154.92 91.4 100% load eff. 11.87 3.99 24.47 2.00 132.15 0.62 5.04 2.00 187.76 206.84 90.8 Average eff. 2/5 [A] 90.2 Doc ID 018695 Rev 1 EVL185W-LEDTV Efficiency 0IN;M7= Figure 1. Standby consumption 6(Z 6(Z 0OUT;M7= !-6 Doc ID 018695 Rev 1 3/5 Revision history 2 EVL185W-LEDTV Revision history Table 3. 4/5 Document revision history Date Revision 04-Apr-2011 1 Changes Initial release. Doc ID 018695 Rev 1 EVL185W-LEDTV Please Read Carefully: Information in this document is provided solely in connection with ST products. STMicroelectronics NV and its subsidiaries (“ST”) reserve the right to make changes, corrections, modifications or improvements, to this document, and the products and services described herein at any time, without notice. All ST products are sold pursuant to ST’s terms and conditions of sale. Purchasers are solely responsible for the choice, selection and use of the ST products and services described herein, and ST assumes no liability whatsoever relating to the choice, selection or use of the ST products and services described herein. No license, express or implied, by estoppel or otherwise, to any intellectual property rights is granted under this document. If any part of this document refers to any third party products or services it shall not be deemed a license grant by ST for the use of such third party products or services, or any intellectual property contained therein or considered as a warranty covering the use in any manner whatsoever of such third party products or services or any intellectual property contained therein. UNLESS OTHERWISE SET FORTH IN ST’S TERMS AND CONDITIONS OF SALE ST DISCLAIMS ANY EXPRESS OR IMPLIED WARRANTY WITH RESPECT TO THE USE AND/OR SALE OF ST PRODUCTS INCLUDING WITHOUT LIMITATION IMPLIED WARRANTIES OF MERCHANTABILITY, FITNESS FOR A PARTICULAR PURPOSE (AND THEIR EQUIVALENTS UNDER THE LAWS OF ANY JURISDICTION), OR INFRINGEMENT OF ANY PATENT, COPYRIGHT OR OTHER INTELLECTUAL PROPERTY RIGHT. UNLESS EXPRESSLY APPROVED IN WRITING BY AN AUTHORIZED ST REPRESENTATIVE, ST PRODUCTS ARE NOT RECOMMENDED, AUTHORIZED OR WARRANTED FOR USE IN MILITARY, AIR CRAFT, SPACE, LIFE SAVING, OR LIFE SUSTAINING APPLICATIONS, NOR IN PRODUCTS OR SYSTEMS WHERE FAILURE OR MALFUNCTION MAY RESULT IN PERSONAL INJURY, DEATH, OR SEVERE PROPERTY OR ENVIRONMENTAL DAMAGE. ST PRODUCTS WHICH ARE NOT SPECIFIED AS "AUTOMOTIVE GRADE" MAY ONLY BE USED IN AUTOMOTIVE APPLICATIONS AT USER’S OWN RISK. Resale of ST products with provisions different from the statements and/or technical features set forth in this document shall immediately void any warranty granted by ST for the ST product or service described herein and shall not create or extend in any manner whatsoever, any liability of ST. ST and the ST logo are trademarks or registered trademarks of ST in various countries. Information in this document supersedes and replaces all information previously supplied. The ST logo is a registered trademark of STMicroelectronics. All other names are the property of their respective owners. © 2011 STMicroelectronics - All rights reserved STMicroelectronics group of companies Australia - Belgium - Brazil - Canada - China - Czech Republic - Finland - France - Germany - Hong Kong - India - Israel - Italy - Japan Malaysia - Malta - Morocco - Philippines - Singapore - Spain - Sweden - Switzerland - United Kingdom - United States of America www.st.com Doc ID 018695 Rev 1 5/5