DC-DC Converter Bricks, Open/Enclosed BCQ SERIES, 1/4 BRICK, TWO OUTPUTS, UP TO 65W FEATURES: 5 year warranty 1500Vdc isolation voltage Two outputs Efficiency up to 87% Operating temperature range -40 Under voltage, over current, short circuit, ℃ to +85 ℃ over voltage protection Remote on/off Adjustable output voltage Model Input voltage (Vdc) Vout/Iout 1 (Vdc/A) Vout/Iout 2 (Vdc/A) Efficiency Typ. 3.3/8.0 1.2/8.0 85% 3.3/8.0 1.2/13.0 85% 3.3/8.0 1.5/8.0 85% 3.3/8.0 1.5/12.0 85% 3.3/8.0 1.8/8.0 85% 3.3/8.0 1.8/10.0 85% 3.3/8.0 2.5/8.0 85% 3.3/9.0 2.5/8.0 85% 5.0/3.0 3.3/3.5 85% 5.0/6.0 3.3/7.0 85% BCQ48-33V8-12V8 BCQ48-33V8-12V13 BCQ48-33V8-15V8 BCQ48-33V8-15V12 BCQ48-33V8-18V8 BCQ48-33V8-18V10 BCQ48-33V8-25V8 BCQ48-33V9-25V8 BCQ48-50V3-33V4 BCQ48-50V6-33V7 48(36~72) Notes: other input and output models may available on request. ELECTRICAL Input voltage range 48Vdc Remote control Negative logic Output power Input voltage range 30-65W Input voltage range ±1% Full load range ±3% Output voltage accuracy 36-72Vdc OFF: High level or left close ON: Low level or grounded Output voltage adjustable Positive Line regulation Full load Vo1,vo2 ±0.2% Load regulation 10%-100% full load Vo1,vo2 ±0.5% Dynamic response (transient/recovery time) ±10% 25%-50%-75% load capability Ripple and noise Parallel test, 20MHz wide range Operating frequency Typical value Isolation voltage Input to output www.pairuigroup.com Page: ∆Vo/∆t: ±4.0%/500μs 80mVp-p max. 300KHz typ. 1500Vdc 1/4 Date: 11/07/2015 DC-DC Converter Bricks, Open/Enclosed BCQ SERIES, 1/4 BRICK, TWO OUTPUTS, UP TO 65W ELECTRICAL Isolation resistance --- 10MΩ Safety --- Temperature coefficient --- Operating temperature range Auxiliary heat sink Storage temperature range --- Over temperature protection Typical Under voltage protection --- Yes Over current protection --- Yes Short circuit protection --- Yes Over voltage protection --- Yes Relative humidity --- 95% max. MTBF Bellcore TR-332, 25 IEC-60950-1, UL-60950-1 EN-60950-1, GB4943 200ppm ℃ to +85℃ -40℃ to +100℃ 110℃ typ. -40 ℃ 2000KHrs Notes: All the parameters are measured at 25℃ ambient temperature, humidity < 75%, nominal input voltage, full load and after warm-up, unless otherwise specified. MECHANICAL LOW CURRENT www.pairuigroup.com LARGE CURRENT Page: 2/4 Date: 11/07/2015 DC-DC Converter Bricks, Open/Enclosed BCQ SERIES, 1/4 BRICK, TWO OUTPUTS, UP TO 65W MECHANICAL CONNECTION PIN # DUAL 1 -Vin 2 REM 3 +Vin 4 +Vo2 5 GND 6 TRIM 7 +Vo1 Note: * Unit is mm(inch). DERATING CURVE www.pairuigroup.com EFFICIENCY CURVE Page: 3/4 Date: 11/07/2015 DC-DC Converter Bricks, Open/Enclosed BCQ SERIES, 1/4 BRICK, TWO OUTPUTS, UP TO 65W NOTES RECOMMENDED TEST AND APPLICATION CIRCUIT 1. TVS&FUSE be helpful with over voltage protection and inrush limiting. Recommended FUSE better be 1.5~2times of the rated current . 2. The input filter capacitor C6 could select the aluminum electrolytic capacitors or tantalum capacitors, and the withstand voltage should be greater than the highest input voltage. Recommended capacitor should be between 22μF~100μF. 3. C1,C2 for the input filter capacitor,0.1~1μF high-frequency ceramics capacitor or chip capacitor are recommended. The withstand voltage of output filter C5, C7 should be greater than the highest output voltage. Recommended capacitor of C7 better within 100μF and C5 connected with the chip to reduce the input voltage peak, recommended 0.1~1μF high-frequency ceramics capacitor or chip capacitor. www.pairuigroup.com Page: 4/4 Date: 11/07/2015