FINAL PRODUCT/PROCESS CHANGE NOTIFICATION Generic Copy 21-NOV-2001 SUBJECT: ON Semiconductor Final Product/Process Change Notification #12082 TITLE: Final Notification: Motorola BMC To Tesla: LM285, MC33030, MC33160, MC3488A, UC3844 and UC3845 EFFECTIVE DATE: 20-Jan-2002 AFFECTED CHANGE CATEGORY: On Semiconductor Fab Site AFFECTED PRODUCT DIVISION: Analog Products ADDITIONAL RELIABILITY DATA: Available Contact your local ON Semiconductor Sales Office or Joe Duffalo <[email protected]> SAMPLES: Contact your local ON Semiconductor Sales Office or Alan Garlington <[email protected]> FOR ANY QUESTIONS CONCERNING THIS NOTIFICATION: Contact Sales Office or Alan Garlington <[email protected]> DISCLAIMER: Final Product/Process Change Notification (FPCN) -Final Notification completing the notification process. Distributed at least 60 days from the effective date of the change. ON Semiconductor will consider this change approved unless specific conditions of acceptance are provided in writing within 30 days of receipt of this notice. To do so, contact your local ON Semiconductor Sales Office. DESCRIPTION AND PURPOSE: This is a Final PCN (Product Change Notice) to notify customers of the qualification of certain Analog devices being transferred to the Tesla Wafer Fab in the Czech Republic. An initial PCN (# 11528) was published on 19 July 2001 providing information on all the devices being transferred and the overall scope of the program. The devices listed below have been fully qualified and are now ready to transfer to Tesla from the Motorola BMC wafer fab. The existing design database in use at BMC was transferred to Tesla with no change to the functional circuit design. No change in the device functionality nor electrical distributions have been found but it is recommended that customers evaluate the devices in their applications to insure proper operation. Samples are available upon request. At the expiration of this PCN(60 Days), fabrication of these devices will occur at either the Tesla Wafer Fab or the BMC Fab depending on capacity and demand requirements. Issue Date: 21 November, 2001 Page 1 of 5 Final Product/Process Change Notification #12082 QUALIFICATION PLAN: Reliability Testing Requirements Summary: Test Name Test Test Conditions Accept SS Lots High Temp Operating Life HTOL Ta=150 80 10 Preconditioning PC PC devices prior c=0 to TC, AC, and HAST. 0 & End Point Highly Accelerated Stress Test HAST Ta=131; RH=85% Biased 0, 96 80 3 Autoclave AC Ta=121; RH=100% 0, 96 80 3 Temperature Cycle TC Ta=-65 to +150 C For 500 cycles 500 80 9 Electrostatic Discharge ESD HBM; MM & CDM c=0 Read Point 504 3 Units/voltage level 1 Reliability testing will be performed on 7 different device types which represent the greatest volume or die size within each category. Specific devices (**) to be tested are: LP2950 MC33074 MC33269 MC34161P MC79xx NCP1117 TL431 1 lot 3 lots 3 lots 1 lot 1 lot 1 lot 1 lot ** Reliability data will also be supplemented by ON Semiconductors ongoing Reliability Audit Program. RELIABILITY DATA SUMMARY: BMC to Tesla Wafer Fab Transfer -- Reliability Data Samp Rej Size Technology Flow Device Fab Test Conditions Std Linear Std Linear Std Linear Std Linear EPI 85/92 EPI 85/92 EPI 85/92 EPI 85/92 MC33033P MC33033P MC33033P MC33033P Tesla Tesla Tesla Tesla HTOL 150C; Biased, 1008 Hrs TC -65C to +150C, 1000 Cyc HTS 150C; No Bias, 1008 Hrs AC 121C; 100% RH, 144 Hrs 0 0 0 0 240 240 80 240 Std Linear Std Linear Std Linear Std Linear EPI 85/92 EPI 85/92 EPI 85/92 EPI 85/92 MC33064D MC33064D MC33064D MC33064D Tesla Tesla Tesla Tesla HTOL 150C; Biased, 1008 Hrs TC-65C to +150C, 1000 Cyc HTS 150C; No Bias, 1008 Hrs AC 121C; 100% RH, 144 Hrs 0 0 0 0 240 240 80 240 Issue Date: 21 November, 2001 Page 2 of 5 Final Product/Process Change Notification #12082 Samp Rej Size Technology Flow Device Fab Test Conditions Std Linear Std Linear Std Linear Std Linear Epi 85 DL Epi 85 DL Epi 85 DL Epi 85 DL MC44603A MC44603A MC44603A MC44603A Tesla Tesla Tesla Tesla HTOL 125C; Biased, 1000 Hrs TC -65C to +150C, 500 Cyc AC 121C;100% RH;15 psi, 96 Hrs HAST 130C; 85%RH biased, 96 Hrs 0 231 0 231 0 231 0 231 Std Linear Std Linear Std Linear Std Linear Std Linear Std Linear Epi 78/79 Epi 78/79 Epi 78/79 Epi 78/79 Epi 78/79 Epi 78/79 MC1413D MC1413 MC1413 MC1413 MC1413 MC1413 Tesla Tesla Tesla Tesla Tesla Tesla HTOL 150C; Biased, 1008 Hrs TC -65C to +150C, 500 Cyc AC 121C; 100% RH, 96 Hrs HAST 130C; 85%RH; Biased,96 Hrs THB 85C; 85%RH; Biased,1008 Hrs HTS 150C; No Bias, 1008 Hrs 0 0 0 0 0 0 154 154 154 154 154 154 Std Linear Std Linear Std Linear Std Linear Std Linear Std Linear Epi 78/79 Epi 78/79 Epi 78/79 Epi 78/79 Epi 78/79 Epi 78/79 MC33079P MC33079P MC33079P MC33079P MC33079P MC33079P Tesla Tesla Tesla Tesla Tesla Tesla HTOL 150C; Biased, 1008 Hrs TC -65C to +150C,1000, Cyc HTS 150C; No Bias,1008 Hrs AC 121C; 100% RH,96 Hrs HAST 130C; 85% RH; Biased,96 Hrs THB 85C; 85% RH; Biased,1008 Hrs 0 0 0 0 0 0 240 240 240 240 240 240 Std Linear Std Linear Std Linear Std Linear Std Linear Std Linear Epi 78/79 Epi 78/79 Epi 78/79 Epi 78/79 Epi 78/79 Epi 78/79 UC3843AN UC3843AN UC3843AN UC3843AN UC3843AN UC3843AN Tesla Tesla Tesla Tesla Tesla Tesla HTOL 150C; Biased,1008 Hrs TC -65C to +150C,1000 Cycles HTS 150C; No Bias,1008 Hrs AC 121C; 100% RH,96 Hrs HAST 130C; 85% RH; Biased,96 Hrs THB 85C; 85% RH; Biased,1008 Hrs 0 0 0 0 0 0 240 240 240 240 240 240 ELECTRICAL CHARACTERISTIC SUMMARY: MC34160 - 1 lot Characterization data, Major parameters Parameter Unit Mean Drain Current(active) ma 1.563 Drain Current(standby) ua 198.2 Ref Output Voltage V 2.62 Regulator Output V V 5.05 Reg Line Regulation mv 3.3 Reg Load Regulation mv 13.3 Comp. Offset Voltage mv 3.58 Comp. Output (Low) mv 148.5 Chip Disable KOhms 121.1 Chip Disable Input ua 22.4 S.D. .010 2.09 .006 .016 .137 .642 2.08 1.31 .974 .224 Min. 1.536 195.3 2.62 5.02 2.8 12.2 .051 145.5 118.1 21.9 Max. 1.582 206.5 2.64 5.10 3.6 14.6 8.246 150.8 123.0 22.9 Specification Min. Max. 3.0 350. 2.47 2.73 4.75 5.25 40. 50. -20. 20. 400. 50. 250. 100. MC3488A - 1 lot Characterization data, Major parameters Parameter Unit Power Supply Current ma Output Leakage Current ua Output Voltage(High state) V Output Voltage(Low State) V Output Resistance ohm Output Short Current ma Transition Time (100k) us Low to High Transition Time (100K) us High to Low Issue Date: 21 November, 2001 Mean S.D. 9.181 .067 -.6.55 .016 5.397 .013 -5.061 .012 28.5 .189 28.7 .657 10.0 .099 10.2 .066 Min. 9.050 -.690 5.380 -5.091 28.14 27.7 9.83 Specification Max. Min. Max. 9.320 18.0 -.620 -100. 5.440 4.0 6.0 -5.040 -6.0 -4.0 28.84 50.0 30.4 15.0 150.0 10.35 8.0 14.0 10.1 10.32 8.0 14.0 Page 3 of 5 Final Product/Process Change Notification #12082 MC33030 -- 1 lot Characterization data, Major parameters Parameter Unit Power Supply Current ma Input offset voltage mv Over Voltage Shutdown V Over Voltage Hysteresis V Op Voltage Low Thresh. V Input Hysteresis mv Over Current Threshold V Delay Pin Source Cur. Ua Mean 16.74 -1.69 17.51 .65 7.19 30.35 7.45 5.12 S.D. Min. .11 16.54 .61 -2.80 .038 17.5 .031 .60 .002 7.19 1.03 27.0 .013 7.43 .071 4.90 Specification Min. Max. 25.0 -10.0 10.0 16.5 20.5 .3 1.0 8.0 25. 45. 6.8 8.2 6.9 Max. 16.96 -4.40 17.6 .70 7.19 34.4 7.49 5.26 UC3844N -- 1 lot Characterization data, Major parameters Parameter Unit Power Supply Current ma Supply Zener Voltage V V Reference V Output Short Circuit ma Oscillator Freq KHz Error Amp input Voltage V Output voltage (low) V Output voltage (High) V Duty cycle (Max) % Mean 14.35 35.05 5.001 -98.92 50.94 2.50 1.64 13.65 48.69 S.D. .187 .070 .012 .569 .339 .007 .008 .004 .048 Min. 14.0 34.9 4.97 -100.2 50.2 2.48 1.62 13.64 48.6 Specification Max. Min. Max. 14.8 17.0 35.2 30.0 5.02 4.95 5.05 -97.4 -180. -30.0 51.8 47.0 57.0 2.52 2.45 2.55 1.66 2.20 13.66 12.0 48.8 46.0 50.0 UC3845 -- 1 lot Characterization data, Major parameters Parameter Unit Mean Power Supply Current ma 14.51 Supply Zener Voltage V 35.00 V Reference V 5.001 Output Short Circuit ma -102.12 Oscillator Freq KHz 51.12 Error Amp input Voltage V 2.50 Output voltage (low) V 1.64 Output voltage (High) V 13.65 Duty cycle (Max) % 48.67 S.D. .202 .071 .011 .791 .335 .007 .006 .004 .043 Min. 14.2 34.8 4.97 -103.5 50.3 2.48 1.63 13.64 48.6 Max. 15.2 35.2 5.04 -98.8 52.0 2.52 1.66 13.66 48.7 Specification Min. Max. 17.0 30.0 4.95 5.05 -180. -30.0 47.0 57.0 2.45 2.55 2.20 12.0 46.0 50.0 LM385D-1.2 -- 1 lot Characterization data, Major parameters Parameter Unit Breakdown Voltage V Breakdown V Chg @ 1ma mv Breakdown V Chg @ 20ma mv Mean S.D. Min. 1.236 .002 1.232 .373 .047 .232 5.61 .184 5.215 Max. 1.240 .458 5.974 Specification Min. Max. 1.205 1.260 1.0 20.0 CHANGED PART IDENTIFICATION: Normal assembly lot traceability codes can be used to identify the wafer fab source. RELATED NOTIFICATIONS: 11528 - INITIAL NOTIFICATION FOR TRANSFER OF ANALOG DEVICES FROM MOTOROL A BMC TO TESLA Issue Date: 21 November, 2001 Page 4 of 5 Final Product/Process Change Notification #12082 AFFECTED DEVICE LIST (WITHOUT SPECIALS): PART FLM285D-1.2, FLM285D-1.2R2, FLM285D-2.5, FLM285D-2.5R2, FLM385BD-2.5, FLM385BD-2.5R2, LM285D-1.2, LM285D-1.2R2, LM285D-2.5, LM285D-2.5R2, LM285Z-1.2, LM285Z-1.2RA, LM285Z-2.5, LM285Z-2.5RA, LM285Z-2.5RP, LM385BD-1.2, LM385BD-1.2R2, LM385BD-2.5, LM385BD-2.5R2, LM385BZ-1.2, LM385BZ-1.2RA, LM385BZ-1.2RP, LM385BZ-2.5, LM385BZ-2.5RA, LM385D-1.2, LM385D-1.2R2, LM385D-2.5, LM385D-2.5R2, LM385Z-1.2, LM385Z-1.2RA, LM385Z-1.2RP, LM385Z-2.5, LM385Z-2.5RA, LM385Z-2.5RP, MC33030DW, MC33030DWR2, MC33030P, MC33160DW, MC33160DWR2, MC33160P, MC34160DW, MC34160DWR2, MC34160P, MC3488AD, MC3488ADR2, MC3488AP1, UC2844D, UC2844DR2, UC2844N, UC2845D, UC2845DR2, UC2845N, UC3844D, UC3844DR2, UC3844N, UC3845D, UC3845DR2, UC3845N Issue Date: 21 November, 2001 Page 5 of 5