E-CMOS CORPORATION EC3581-D VER：1.1 2-IN-1 PnP SERIAL MOUSE CONTROLLER WITH AUTO-REF. FEATURES •RS232C interface. •2-in-1 i.e. Microsoft System or Mouse System. •CMOS technology. •Low power dissipation. •Seven button combinations. •Wheel or Optical/Mechanical. • Can work on optical mouse. •Will send out PnP code after rising edge of RTS. • Zener diode built in. • Operating frequency: 32768Hz . • Auto-Reference function GENERAL DESCRIPTION EC3581 is a single chip 2-IN-1 Mouse Controller, designed and fabricated in CMOS ASIC technology. 飛虹積體電路股份有限公司 TEL：(03)5783622 Page 1 of 14 FAX：(03)5783630 E-CMOS CORPORATION EC3581-D VER：1.1 PAD DESCRIPTIONS PAD NAME I/O FUNCTION Mode selection input. If MODE pin is HIGH, EC3581 will operate in Microsoft System mode. If MODE pin is LOW, EC3581 will operate in Mouse System mode. If MODE pin is floating during the Power On Reset period and one of the buttons is pressed, the EC3581 will operate in Microsoft System mode. Otherwise, it will operate in Mouse System mode. MODE I XIN I Crystal oscillator input. XOUT O Crystal oscillator output. RTS I Input from RTS (Request To Send) of RS232C. The RXD pin will send a 4D hexadecimal code in Microsoft System Mode after a LOW to HIGH transition of the RTS pin. After 4D code is received, the RTS pin will remain HIGH. RXD O Serial data output to Receive Data of RS232C. Normally LOW. VSS P Ground pin. BR I Right button selection. BR pin is HIGH when right button is pressed and becomes LOW when it is released. EC3581 will only report through RXD on a rising edge or falling edge of the input signal. The status of BR will be LOW on a falling edge and HIGH on a rising edge. BM I Middle button input. BL I Left button input. GND I Reference voltage for ZENER. PX1 I Input from the first X axis photo-encoder. In both Microsoft System and Mouse System, PX1 and PX2 constitute positive (negative) counts for rightward (leftward) movement on the screen. PX2 I Input from the second X axis photo-encoder. PY1 I Input from the first Y axis photo-encoder. In Microsoft System, PY1 and PY2 constitute positive (negative) counts for downward (upward) moveme nt on the screen. In Mouse System, PY1 and PY2 constitute positive (negative) counts for upward (downward) movement on the screen. PY2 I Input from the second Y axis photo-encoder. VDD P +5V power supply. 飛虹積體電路股份有限公司 TEL：(03)5783622 Page 2 of 14 FAX：(03)5783630 EC3581-D VER：1.1 E-CMOS CORPORATION BLOCK DIAGRAM PX1 PX2 PY1 PY2 X/Y AXIS DECODER BR BM BL DECODER TEST RTS MODE CONTROL CENTER X/Y COUNTER SHIFT REGISTER REGISTER and CODE SYSTEM CLOCK VDD VSS XIN XOUT ABSOLUTE MAXIMUM RATINGS PARAMETER SYMBOL MIN MAX UNIT Vdd 0 6.5 V Ambient Temperature Tamb 0 70 ℃ Storage Temperature Tstg -40 125 ℃ Pd --- 100 mW Supply Voltage Power Dissipation (Tamb = 70 ℃ ) Note: This is a stress rating only and functional operation of the device at these or any other conditions above those indicated in the operation sections of this specification is not implied. Exposure to absolute maximum rating conditions for extended periods of time may affect reliability. 飛虹積體電路股份有限公司 TEL：(03)5783622 Page 3 of 14 FAX：(03)5783630 EC3581-D VER：1.1 E-CMOS CORPORATION DC ELECTRICAL CHARACTERISTICS (Note: Vdd = 5 V, unless otherwise specified) PARAMETER SYMBOL MIN TYP MAX UNIT Operating Voltage Vdd 4.5 5 5.5 V Operating Current (No load) Iop --- --- 2.0 mA PX1/PX2/PY1/PY2 Input Range Vir 0.1 --- 3.2 V PX1/PX2/PY1/PY2 Input Amplitude Via 0.6 --- --- V PX1/PX2/PY1/PY2 Input Resistance --- --- --- --- KΩ BL/BM/BR/MODE/RTS Vih 3.2 --- --- V BL/BM/BR/MODE/RTS Vil --- --- 1.3 V Rbut 125 200 270 KΩ RXD Output Current (sourcing) Voh=(RTS-1)V Ioh 1.0 --- --- mA RXD Output Current (sinking) (Vol = 0.5V) Iol 1.0 --- --- mA PX1/PX2/PY1/PY2/BL/BM/BR/ MODE//XIN Input Leakage Current (Vih = 5V) Iih --- --- 2 uA Zener Diode Voltage (Iz =4mA) Vz 5.0 5.2 5.4 V BL/BM/BR Internal Pull-down Resistor 飛虹積體電路股份有限公司 TEL：(03)5783622 Page 4 of 14 FAX：(03)5783630 EC3581-D VER：1.1 E-CMOS CORPORATION AC ELECTRICAL CHARACTERISTICS PARANRTER SYMBOL MIN TYP MAX UNIT Oscillator Frequency Fosc --- 32.768 --- KHz BR/BL/BM Button Debounce Time Tbd 40 --- --- ms Tracking Speed (200 DPI wheel; Microsoft System Mode) Vts --- 64.5 --- CM/S RXD Transmission Rate Fmx --- 1213 --- Hz Transmission Time (Mouse System) Tms --- 41.2 --- ms Transmission Time (Microsoft) Tm --- 24. 72 32.95 --- ms Start Bit Time Ts --- 0.824 --- ms Data Bit Time Td --- 0.824 --- ms Stop Bit Time Tp --- 0.824 --- ms Mode Code Delay Time T1 --- 13.7 --- ms Pattern In Pulse Width Tpi 0.12 --- --- ms Note: 1. After the power on, the mouse will send PnP code automatically. 2.The mouse will send PnP code at 15ms after RTS goes from low to high. DATA FORMAT Baud rate: 1200 bps asynchronous Output data: Microsoft System Mouse System 3 or 4 bytes per packet 5 bytes per packet 1 Start bit 1 Start bit 7 Data bits 8 Data bits 2 Stop bits 2 Stop bits 飛虹積體電路股份有限公司 TEL：(03)5783622 Page 5 of 14 FAX：(03)5783630 EC3581-D VER：1.1 E-CMOS CORPORATION Byte format: MICROSOFT SYSTEM Data Bit 6 5 4 3 2 1 0 1st byte 1 BL BR Y7 Y6 X7 X6 2nd byte 0 X5 X4 X3 X2 X1 X0 3rd byte 0 Y5 Y4 Y3 Y2 Y1 Y0 4th byte 0 BM 0 0 0 0 0 MOUSE SYSTEM Data Bit 7 6 5 4 3 2 1 0 1st byte 1 0 0 0 0 BL BM BR 2nd byte X7 X6 X5 X4 X3 X2 X1 X0 3rd byte Y7 Y6 Y5 Y4 Y3 Y2 Y1 Y0 4th byte X7 X6 X5 X4 X3 X2 X1 X0 5th byte Y7 Y6 Y5 Y4 Y3 Y2 Y1 Y0 Transmit sequence of each byte: 1st bit Microsoft System Mouse System start bit start bit data bit 0 data bit 0 | | data bit 6 data bit 6 data bit 7 last bit stop bit 飛虹積體電路股份有限公司 TEL：(03)5783622 stop bit Page 6 of 14 FAX：(03)5783630 EC3581-D VER：1.1 E-CMOS CORPORATION BR/BM/BL Data format: Microsoft System Mouse System 1 = Depressed 1 = Released 0 = Released 0 = Depressed In Microsoft system: X7 - X0 = X axis movement in 2's complement, positive for rightward. Y7 - Y0 = Y axis movement in 2's complement, positive for downward. In Mouse System: X7 - X0 = X axis movement in 2's complement, positive for rightward. Y7 - Y0 = Y axis movement in 2's complement, positive for upward. TIMING DIAGRAM DATE TYPE: A. Plug and play code: PnP code will be determined by each customer. Otherwise, this code will be E-CMOS’s code. E-CMOS PnP code Non-PnP ID “m”, “3” 4D,33 Begin PnP 08h 08 PnP Rev 1.0 01,24 EISA ID “ECM” 25,23,2D Product ID 0001 10,10,10,11 Extend “\” 3C Extend “\” 3C Class Name “MOUSE” 2D,2F,35,33,25 Extend “\” 3C Driver ID “PNP0F0C” 30,2E,30,10,26,10,23 Checksum 380 18,10 End PnP 09h 09 飛虹積體電路股份有限公司 TEL：(03)5783622 Page 7 of 14 FAX：(03)5783630 EC3581-D VER：1.1 E-CMOS CORPORATION B. DATAOUT DIAGRAM (1) BYTES STRUCTURE: Mouse System 1st byte 2nd byte 3rd byte 4th byte 5th byte Tms Microsoft System 1st byte 2nd byte 3rd byte 4th byte Tmx (2) BITS STRUCTURE : Mouse System Ts Td Td Td Td Td 1 2 3 4 Td Td Td Td Td Td Td 0 1 2 3 4 5 6 0 Data bit No. Td 5 Td 6 Td Tp Tp Tp 7 Microsoft System Ts Data bit No. 飛虹積體電路股份有限公司 TEL：(03)5783622 Page 8 of 14 FAX：(03)5783630 E-CMOS CORPORATION EC3581-D VER：1.1 LAYOUT DESIGN GUIDELINES Mounting of Die and Layout for Wire Bond Pads 1. A ground potential is required for the die, area for the PCB die pad should be .010" larger than the die, on all sides. 2. For wire bonding manufacturability, the PCB pads should be placed in line with die pads. A. Normal distance between die pad and PCB bond pads: .020" to .100" B. Typical PCB pad size: .005" to .010" square 3. Usual Length of a wire bond: .020" to .100" 儲存環境注意事項 1. Dies 應存放於 Tray 盤內以真空包裝及置於恆溫箱中以常溫 25℃儲存，以避免氧化。 飛虹積體電路股份有限公司 TEL：(03)5783622 Page 9 of 14 FAX：(03)5783630 E-CMOS CORPORATION 飛虹積體電路股份有限公司 TEL：(03)5783622 EC3581-D VER：1.1 Page 10 of 14 FAX：(03)5783630 E-CMOS CORPORATION 飛虹積體電路股份有限公司 TEL：(03)5783622 EC3581-D VER：1.1 Page 11 of 14 FAX：(03)5783630 E-CMOS CORPORATION EC3581-D VER：1.1 CHIP LOCATION EC3581-D 飛虹積體電路股份有限公司 TEL：(03)5783622 Page 12 of 14 FAX：(03)5783630 EC3581-D VER：1.1 E-CMOS CORPORATION FINGER AND PAD CONTRAST TABLE Probe Ball Number Finger Number Pad Name Coordinate B01 F01 NONE --- B02 F02 MODE 256.1,1465.5 B03 F03 XIN 94.95 , 1458.65 B04 F04 XOUT 94.95,967.9 B05 F05 RTS 86.65,690.25 B06 F06 NONE --- B07 F07 RXD 223.2,86.5 B08 F08 VSS 525.95,86.6 B09 F09 BR 765.85,83.45 B10 F10 BM 960.05,88 B11 F11 BL 960.1,393.7 NONE F12 GND 955.9,658.45 B12 F13 PX1 960.15,792 B13 F14 PX2 960.1,1009.7 B14 F15 PY1 960.1,1315.4 B15 F16 PY2 926.25,1465.5 B16 F17 VDD 688.65,1447.7 飛虹積體電路股份有限公司 TEL：(03)5783622 Page 13 of 14 FAX：(03)5783630 E-CMOS CORPORATION 飛虹積體電路股份有限公司 TEL：(03)5783622 EC3581-D VER：1.1 Page 14 of 14 FAX：(03)5783630