Series AMER120-AZ up to 5A | AC-DC LED driver FEATURES: • • • • AC-DC Constant current LED Driver Input range 90-277VAC/47-440Hz High Efficiency up to 91% Operating temperature -40 to 85°C • • • • Over Temperature Protection Waterproof Case rated IP68 Power Factor Correction SCP, Over Current Protection Models Single output Model Max Output Power (W) * Output Voltage Range (V) Output Current (A) Input Voltage (VAC/Hz) Input Voltage (VDC) Efficiency (%) AMER120-50250AZ AMER120-36340AZ AMER120-24500AZ 125 122.4 120 36-50 24-36 12-24 2.5 3.4 5 90-277/47-440 90-277/47-440 90-277/47-440 120-390 120-390 120-390 91 90 90 *Exceeding the maximum output power will permanently damage the converter NOTE: All specifications in this datasheet are measured at an ambient temperature of 25°C, humidity<75%, nominal input voltage and at rated output load unless otherwise specified. Input Specifications Parameters Inrush current <2ms Leakage current AC current Power Factor External fuse Start up time Surge voltage Conditions Typical 115VAC 230VAC 115VAC 230VAC 115VAC 230VAC 115VAC 240VAC 45 60 0.5 0.75 1.8 0.7 Maximum Units A mA A 0.98 0.94 250V/3A 400 2sec 440 ms V Maximum Units Output Specifications Parameters Current accuracy Line regulation Load regulation Ripple & Noise * Hold-up time Current adjustment range Minimum Load Voltage Conditions Typical ±3 ±1 ±3 75 80 100-0 LL-HL 0-100% load 20MHz Bandwidth % % % mV p-p ms % See the models table * Tested with 0.1µF (M/C) or (C/C) and 47µF (E/C) parallel capacitors at the end. Isolation Specifications Parameters Tested I/O voltage Isolation Resistance Isolation Capacitance www.aimtec.com F 052.1e R3.J Conditions Typical 3sec/3.2mA 500VDC >1000 1000 Tel: +1 514 620 2722 1 of 9 Rated Units 3000 VAC MΩ pF Toll free: + 1 888 9 AIMTEC (924 6832) North America only Series AMER120-AZ up to 5A | AC-DC LED driver General Specifications Parameters Conditions Switching frequency Over current protection Over voltage protection Short circuit protection Short circuit restart Over temperature protection Operating temperature Maximum case temperature Storage temperature Temperature coefficient Cooling Humidity Case material Potting Wires Weight Dimensions (L X H X W) MTBF Typical Maximum 100 110% of Iout 110% of Vout Continuous Auto recovery >105°C -40 to +85 With derating over 55°C Units KHz o 100 -40 to +95 ±0.02 Free air convection 95 Aluminum Epoxy (IP67 rated) UL1015 18AWG Input & 14AWG output *20CM 750 7.13 x 2.32 x 1.85 inches 181.00 x 59.00 x 47.00 mm >400,000 hrs (MIL-HDBK-217F at +25°C) C C o C % / oC o % RH g Safety Specifications Parameters Agency approvals Standards cULus , CE UL8750, UL60950-1, EN55022, class B, EN60529(IP68), EN61347-1, EN61347-2-13 Dimensions www.aimtec.com F 052.1e R3.J Tel: +1 514 620 2722 2 of 9 Toll free: + 1 888 9 AIMTEC (924 6832) North America only Series AMER120-AZ up to 5A | AC-DC LED driver Application Circuit Maximum Pot Value (kΩ) Model Number AMER120-50250AZ AMER120-36340AZ AMER120-24500AZ 31.75 25.00 26.00 Temperature graph Free Air Convection 55 º C 100 80 Safe Operating Area 60 40 20 0 -40 -20 0 20 40 60 80 85 100 Ambient Temperature º C www.aimtec.com F 052.1e R3.J Tel: +1 514 620 2722 3 of 9 Toll free: + 1 888 9 AIMTEC (924 6832) North America only Series AMER120-AZ up to 5A | AC-DC LED driver Efficiency vs. Input Voltage and Output Current (CC Load) AMER120-50250AZ AMER120-36340AZ www.aimtec.com F 052.1e R3.J Tel: +1 514 620 2722 4 of 9 Toll free: + 1 888 9 AIMTEC (924 6832) North America only Series AMER120-AZ up to 5A | AC-DC LED driver Efficiency vs. Input Voltage and Output Current (CC Load) Continued AMER120-24500AZ PFC Value vs. Output Load Current (CC Load) AMER120-50250AZ www.aimtec.com F 052.1e R3.J Tel: +1 514 620 2722 5 of 9 Toll free: + 1 888 9 AIMTEC (924 6832) North America only Series AMER120-AZ up to 5A | AC-DC LED driver PFC Value vs. Output Load Current (CC Load) Continued AMER120-36340AZ AMER120-24500AZ www.aimtec.com F 052.1e R3.J Tel: +1 514 620 2722 6 of 9 Toll free: + 1 888 9 AIMTEC (924 6832) North America only Series AMER120-AZ up to 5A | AC-DC LED driver Constant Current Mode vs. Constant Voltage Mode AMER120-50250AZ AMER120-36340AZ www.aimtec.com F 052.1e R3.J Tel: +1 514 620 2722 7 of 9 Toll free: + 1 888 9 AIMTEC (924 6832) North America only Series AMER120-AZ up to 5A | AC-DC LED driver Constant Current Mode vs. Constant Voltage Mode Continued AMER120-24500AZ Output Current vs. Radj AMER120-50250AZ www.aimtec.com F 052.1e R3.J Tel: +1 514 620 2722 8 of 9 Toll free: + 1 888 9 AIMTEC (924 6832) North America only Series AMER120-AZ up to 5A | AC-DC LED driver Output Current vs. Radj Continued AMER120-36340AZ AMER120-24500AZ NOTE: 1. Datasheets are updated as needed and as such, specifications are subject to change without notice. Once printed or downloaded, datasheets are no longer controlled by Aimtec; refer to www.aimtec.com for the most current product specifications. 2. Product labels shown, including safety agency certifications on labels, may vary based on the date manufactured. 3. Mechanical drawings and specifications are for reference only. 4. All specifications are measured at an ambient temperature of 25°C, humidity<75%, nominal input voltage and at rated output load unless otherwise specified. 5. Aimtec may not have conducted destructive testing or chemical analysis on all internal components and chemicals at the time of publishing this document. CAS numbers and other limited information are considered proprietary and may not be available for release. 6. This product is not designed for use in critical life support systems, equipment used in hazardous environments, nuclear control systems or other such applications which necessitate specific safety and regulatory standards other the ones listed in this datasheet. 7. Warranty is in accordance with Aimtec’s standard Terms of Sale available at www.aimtec.com. www.aimtec.com F 052.1e R3.J Tel: +1 514 620 2722 9 of 9 Toll free: + 1 888 9 AIMTEC (924 6832) North America only