(l c/ 20 STERN AVE. SPRINGFIELD, NEW JERSEY 07081 U.S.A. TELEPHONE: (973) 376-2922 (212) 227-6005 FAX: (973) 376-8960 MJ10042 MJ10045 MJ10048 25, GO, and 100 AMPERE NPN SILICON POWER DARLINGTON TRANSISTOR 25 KVA ENERGY MANAGEMENT SERIES SWITCHMODE DARLINGTON TRANSISTORS 25, 60 and 100 Ampere Operating Current 260,4BO and 850 VOLTS 260 WATTS These Darlington transistors are designed for Industrial service under practical operating environments found in switching high power inductive loads off 120, 230 and 460 Volt lines. Designer's Data for "Worst-Gate" Conditions The Designer's Data Sheet permits the design of mostciroults enlirelyf rom the information presented. Umlt dots— representing device characteristics boundaries—are given to facilitate "worst'Case" design. EMITTER COLLECTOR SIVLtl: PIN I. BASE 2. EMITTER 3. COLLECTOR 4. COLLECTOR 'Emitter-Collector Diode Is a high power diode. MAXIMUM RATINGS Mechanical Ratings NOTES: 1. DIMENSIONS A AND B ARE DATUM! AND T IS BOTH A DATUM SURFACE AND SEATING PLANE. 1. POSITIONAL TOLERANCE FOR MOUNTING HOLF.S; I4100M looioi @|T|A Rating Value Unit Mounting Torque (To heat sink with 6-32 Screw) (Note 1) 8.0 in.-lb Lead Torque (Lead to bus with S mm Screw) (Mole 2) 20 in, Ib 41 grams 0.6 "C/VV Per Unit Weight • 3. DIMENSIONING A A«CITOLt ANSI Yli.5,19!!. 4. CONTROLLING DIMENSION: INCH EXCEPT FOR METRICALLY THREADED INSERTS. MILLIMETERS THERMAL CHARACTERISTICS Thermal Resistance, Junction to Case. Mica Insulators available as separate items, 0.003- thick. Motorola Pert Number 14CSB12387BOO3. INCHES .HO. JIB. itj Notes: 1. A Belleville washer of 0.281' O.O., O.I 38' I.D., 0.013" thick and 43 pounds flat is recommended. 2. The maximum penetration of the screw should be limited to 0.60^ 3. To adapt the collector and emitter terminals to quick connect terminals, AMP 2BO Series Faston tab P/N 61499-1 it suggested. 4. The mounting holes of this package are compatible with TO-2O4 (formerly TO-3) mounting holes. NJ Semi-Conductors reserves the right to change test conditions, parameter limits and package dimensions without notice. Information furnished by NJ Semi-Conductors is believed to be both accurate and reliable at the time of going to press. However, NJ Semi-Conductors assumes no responsibility for any errors or omissions discovered in its use NJ Semi-Conductors encourages customers to verify that datasheets are current before placing orders. Quality Semi-Conductors MJ10042, MJ10045, MJ10048 MAXIMUM RATINGS (Continued) (Tc - 26°C unless otherwise noted.) Symbol MJ10042 MJ1004E MJ10048 Unit Collector. Emitter Volume (IB = 0) VCEO 850 460 250 Vdc Collector-Emitter Voltage (RBE- 10 Ohms) VCER VCB VEB 900 500 300 Vdc 900 500 300 Vdc 'Clop) 25 Riling Collector-Base Voltage Emitter-Base Voltage Collector Current — Operating (Tc - 1 1 5°C) (TC = SS'C) (Tc = 66°C) 8.0 Vdc A 60 100' Collector Current — Continuous — Peak Repetitive — Peak Nonrepelitive ic Base Current — Continuous — Peak Nonrepethlve IB 25 EO A Total Device Dissipation Derate above TC = 26°C For 1 -minute overload PD 250 2.0 333 Watts W/»C Watts -66(0*150 -SB to 200 °C 37.6 76 126 , Operating Junction and Storage Temperature Range For 1 -minute overload TJ. Tstg 75 160 26O 100 300 600 A ELECTRICAL CHARACTERISTICS (Tc * 2S°C unless otherwise noted) Characteristic Symbol Unit OFF CHARACTERISTICS Collector-Emitter Sustaining Voltage (1] (lc = 1 25 m Adc) MJ10042 MJ1O045 MJ1O048 VCEO(SUS) Vdc 650 4SO 260 - Collector Cutoff Current (VCE = Rated VCB. VBE(off) = < 5 Vdc) (VCE = Bated VCB. VBE(off) = ' -5 Vdc, Tc * 1 50°C) ICEV Collector Cutoff Current 'CER — 10 mA IE BO — 3SO mA (VCE « Rated VCER. RBE = 10 n, TC - 100°C) Emitter Cutod Current (VEB = 4.0 vac, 'c*0) - mA 2.0 10 SAFE OPERATING AREA Second Breakdown Collector Current with Base Forward-Biased FBSOA Clamped Inductive SOA with Base Reverse-Biased RE SO A See Figures 33. 35 & 37 Overload Safe Operating Area OLSOA See Figures 38, 39, 40. 41 , 42 & 43 See Figures 32, 34 & 36 DYNAMIC CHARACTERISTICS Output Capacitance (VCB = 10 Vdc. IE = 0. f,ast - 1 .0 kHz) Cob — 2000 (1) Pulse Teftt. PulS* width of 300 pfl, duty eycla £2.0%. * This rating fs with a 50% duty cycle, and Is limited by power dissipation. Higher operating currents are allowable it tower duty cycl«. pF