, Una, TELEPHONE: (973) 376-2922 (212)227-6005 FAX: (973) 376-8960 20 STERN AVE. SPRINGFIELD, NEW JERSEY 07081 U.S.A. MAC229 Triacs MAC229A Silicon Bidirectional Triode Thyristors . . . designed primarily for industrial and consumer applications for full wave control of ac loads such as appliance controls, heater controls, motor controls, and other power switching applications. TRIACs 8 AMPERES RMS 200 thru 800 VOLTS • All Diffused and Glass-Passivated Junctions for Parameter Uniformity and Stability • Small, Rugged, Thermowatt Construction for Low Thermal resistance and High Heat Dissipation • Center Gate Geometry for Uniform Current Spreading • Gate Triggering Guaranteed in Three Modes (MAC229 Series) or Four Modes (MAC229A Series) (TO-220AB) MAXIMUM RATINGS (Tj = 25°C unless otherwise noted.) Rating Peak Repetitive Off-State VoltageO) (Tj = -40to 110°C 1/2 Sine ave 50 to 60 Hz, Gate Open) MAC229-4, MAC229A4 MAC229-6, MAC229A6 MAC229-8, MAC229A8 MAC229-10, MAC229A10 On-State RMS Current (TQ = 80°C) Full Cycle Sine Wave 50 to 60 Hz Peak Non-repetitive Surge Current (One Full Cycle 60 Hz, Tj = 110°C) Circuit Fusing (t = 8.3 ms) Peak Gate Current (t « 2 u.s) Peak Gate Voltage (t « 2 u,s) Peak Gate Power (t ^ 2 us) Average Gate Power (Tc = 80°C, t S 8.3 ms) Operating Junction Temperature Range Storage Temperature Range Mounting Torque Symbol Value VDRM 200 400 600 800 ! T(RMS) 8 Amps ITSM 80 Amps |2t 26 A2S 'GM VGM PGM ±2 Amps ±10 Volts 20 Watts PG(AV) 0.5 Watts TJ -40 to 110 °C Tstg -40 to 150 "C 8 in. Ib. 1. VDRM for all types can be applied on a continuous basis. Blocking voltages shall not be tested with a constant current source such that the voltage ratings of the devices are exceeded. Quality Semi-Conductors Unit Volts (cont.) MAC229 Series MAC229A Series THERMAL CHARACTERISTICS Symbol Max Unit Thermal Resistance, Junction to Case RGJC 2.2 Thermal Resistance, Junction to Ambient R9JA 60 °c/w °c/w Characteristic ELECTRICAL CHARACTERISTICS ( = 25°C and either polarity of MT2 to MT1 voltage unless otherwise noted.) Characteristic Peak Blocking CurrentO ) (VD = Rated VDRM. Gate Open) Symbol Min Typ Max Unit — — 10 2 uA mA — — 1.8 Volts !DRM Tj = 25°C Tj = 110°C Peak On-State Voltage (ITM = 11 A Peak, Pulse Width =5 2 ms, Duty Cycle s 2%) VTM Gate Trigger Current (Continuous dc) (VD = 12V, RL = 100 £1) MT2(+), G(+); MT2(+), G(-); MT2(-), G(-) MT2(-), G(+) "A" SUFFIX ONLY IGT Gate Trigger Voltage (Continuous dc) VGT mA — — (VD = 12V, RL = 100 n) MT2(+), G(+); MT2(+), G(-); MT2(-), G(-) MT2(-), G(+) "A" SUFFIX ONLY (VD = Rated VDRM, TC = 110°C, RL = 10 k) MT2(+), G(+); MT2(+), G(-); MT2(-), G(-); MT2(-), G(+) "A" SUFFIX ONLY Volts (VD = 12 vdc, ITM =2°° mA, Gate °Pen) Gate-Controlled Turn-On Time (VD = Rated VDRM. <TM = 16 A Peak. !G = 30 mA) Critical Rate of Rise of Off-State Voltage (VQ = Rated VDRM, Exponential Waveform, TC = 110°C) Critical Rate of Rise of Commutation Voltage (VD = Rated VDRM, ITM = 11 -3 A, Commutating di/dt = 4.1 A/ms, Gate Unenergized, TC = 80°C) — 2 2.5 0.2 0.2 All Types MAC229 series Holding Current 10 15 IH — — 15 mA <gt — 1.5 — us dv/dt — 25 — V/us dv/dt(c) V/us 5 1. Ratings apply for open gate conditions. Devices shall not be tested with a constant current source for blocking voltage such that the voltage applied exceeds the rated blocking voltage. 80 1.0 2.0 3.0 4.0 5.0 6.0 lj(RMS). RMS ON-STATE CURRENT (AMP) 7.0 0 2.0 3.0 4.0 5.0 6.0 IT(RMS). RMS ON-STATE CURRENT (AMP) 7.0 8.0 OPLFT; 21 EJJFOTPQDHiBOEILPUfSBOCkDHICFSIBOTJ Z25/6N-12: 93/ 3/ DPOUSPM4DH!E,NFOT.PO;!,DDI / v E,NFar,PO![ IEFGDFTBII POFIX i FSFBIWI GPEZ!BOEWBE!JSSFHVI*SXlfT!BSF BMtPXFE/ U-, v-1 QDI2/ 31 4/ 51 NBJQLFSN.DBM2 N&01FSNJDBM3 HBLF N&OLFSNJDBM3 EJ>I R C D E fi H 1 K L M 0 R R T IJ V W [ JDDIFT NJ3 NBY 1/681 1/731 1/491 1/516 1/271 1/2:1 1/136 1/146 1/253 1/258 1/1:6 1/216 1/221 1/266 1/125 1/133 1/611 1/673 1/166 1/166 1/2:1 1/321 1/211 1/231 1/191 1/221 1/166 1/166 1/346 1/366 1/111 1/161 >» 1/156 >2S 1/191 NJWNFLFST NJD NBY 2»59 26/86 :/77 21/39 6/18 6/93 1/75 1/99 4/72 4/84 3/53 3m 3/91 4/4 1/47 1/66 23/81 25/38 2/26 2/4: 5/94 6/44 3/66 4/15 3/15 3/8: 2/26 2/4: 6/:8 7/58 1/11 2/38 >» 2/26 Ski 3/15