Tfs140G1.doc Version 1.1 VI TELEFILTER Filter specification 12.07.2002 TFS 140G1 1/5 1. Measurement condition Ambient temperature T A: Input power level: Terminating impedances at fc * ) : 23 °C 0 dBm. for input: Source impedance: Load impedance: for output: 50 50 102 - 9,7 pF. 122 - 9,5. pF. 2. Characteristics Remark: Reference level for the relative attenuation arel of the TFS 140G1 is the minimum of the pass band attenuation amin. The minimum of the pass band attenuation amin is defined as the insertion loss ae. The reference frequency fc is the arithmetic mean value of the upper and lower frequencies at the 3 dB filter attenuation level relative to the insertion loss ae . The temperature coefficient of frequency Tcf is valid both for the reference frequency f c and the frequency response of the filter in the operating temperature range. The frequency shift of the filter in the operating temperature range is not included in the production tolerance scheme Data typ. value Insertion loss (Reference level) Centre frequency ae fc at ambient temperature TA (fCAT) Pass band : 1 3 20 40 45 140,01 max. 25 MHz 140 ± 0,09 dB MHz fC - 0,85 MHz.....fC + 0,85 MHz fC .... fC ± 0,70 MHz 0,5...0,6 dB max. 1 dB MHz MHz MHz MHz MHz min. min. 1,40 1,70 MHz MHz max. max. 2,70 4,60 MHz MHz dB dB max. max. 1 3 dB dB dB dB dB min. min. min. 40 45 60 dB dB dB at ambient temperature: dB dB dB dB dB 1,50 1,74 2,29 2,55 2,65...3,10 Relative attenuation fC ..... fC ± 0,70 MHz ..... fC ± 1,35 fC ± 2,3 fC ± 39 dB PB Amplitude ripple (p-p) in: Bandwidth 20,5 tolerance / limit MHz ..... MHz ..... MHz ..... fC ± 0,70 fC ± 0,85 arel MHz MHz fC ± 2,3 fC ± 39 fC ± 41 MHz MHz MHz 0,6 2,5 45...55 52...60 65...70 2,55 µs 80 ns 1,8°...2,5° ( r.m.s. 0,8° ) Group delay ( mean value in PB ): Group delay ripple in PB (p-p): Deviation from linear phase in PB (p-p): S11 in PB : S22 in PB : Triple transit attenuation compared to main signal Crosstalk Substrate material Frequency inversion temperature ( To ) Temperature coefficient of frequency ( Tc f ) Frequency deviation of fc over temperature: ** ) 2 2 50 55...65 dB dB dB dB max. 3,0 max. 150 max. 6° µs ns p-p min. dB 40 Quartz 25°...30° C -0,036...-0,045 ppm/K² fc(Hz) = Tcf(ppm/K) x (T - To)² x fTo (MHz) - 40 °C ... + 85 °C - 40 °C ... + 85 °C Operating temperature range Storage temperature range *) The terminating impedances depend on parasitics and q-values of matching elements and the board used, and are to be understood as reference values only. Should there be additional questions do not hesitate to ask for an application note or contact our design team. ** ) fTo is reference frequency fc at frequency inversion temperature (To ) Generated: Dunzow W. Checked / approved: Dr. Bert Wall VI TELEFILTER Potsdamer Straße 18 D 14 513 TELTOW / Germany Tel: (+49) 3328 4784-0 / Fax: (+49) 3328 4784-30 E-Mail: [email protected] VI TELEFILTER reserves the right to make changes to the product(s) and/or information contained herein without notice. No liability is assumed as a result of their use or application. No rights under any patent accompany the sale of any such product(s) or information. Tfs140G1.doc Version 1.1 VI TELEFILTER Filter specification TFS 140G1 12.07.2002 2/5 3. Package : ( all dimensions in mm ) TFS 140G P22 1 +0,20 Date code: M N P Date code 19 - 0,10 1 Year+week 2001 2001 2002 1,02 Pin 10 Pin 1 Pin 5 Pin 6 Pin 2 - 4, 7 - 9 Input Input RF Return Output Output RF Return Package Ground 1,91 7,62 4. 50 matching network ( see Application Note ) : 1 2 3 4 L2 50 50 L1 10 Scheme 1 1 C1 9 8 2 7 3 4 L2 C2 50 50 C3 L1 Scheme 2 10 9 8 C4 7 For final test we use scheme 1. VI TELEFILTER Potsdamer Straße 18 D 14 513 TELTOW / Germany Tel: (+49) 3328 4784-0 / Fax: (+49) 3328 4784-30 E-Mail: [email protected] VI TELEFILTER reserves the right to make changes to the product(s) and/or information contained herein without notice. No liability is assumed as a result of their use or application. No rights under any patent accompany the sale of any such product(s) or information. Tfs140G1.doc Version 1.1 VI TELEFILTER Filter specification 12.07.2002 TFS 140G1 3/5 5. Stability characteristics : After the following tests the filter shall meet the whole specification: 1. Shock: 500g, 18 ms, half sine wave, 3 shocks each plane; DIN IEC 68 T2 - 27 2. Vibration: 10 Hz to 500 Hz, 0,35 mm or 5g respectively, 1 octave per min, 10 cycles per plan, 3 plans; DIN IEC 68 T2 - 6 3. Change of temperature -55 °C to 125°C / 30 min. each / 10 cycles DIN IEC 68 part 2 – 14 Test N 4. Resistance to solder heat (reflow): reflow possible: twice max.; for temperature conditions refer to the attached "Air reflow temperature conditions" on page 4; 6. Packing : Tape & Reel: DIN IEC 286 - 3, with exception of value for N and minimum bending radius; tape type II, embossed carrier tape with top cover tape on the upper side; max. pieces of filters per reel: reel of empty components at start: reel of empty components at start including leader: Trailer 2000 min 300 mm min 500 mm min 300 mm Tape (all dimensions in mm) W Po Do E So F G (min) P2 P1 D1(min) Ao Bo Ko t Ct : : : : : : : : : : : : : : : 32 ± 0,3 4 ± 0,1 1,5 + 0,1 1,75 ± 0,1 28,4 ± 0,1 14,2 ± 0,1 0,6 2 ± 0,1 12 ± 0,1 2,0 7,1 ± 0,1 19,6 ± 0,1 2,0 ± 0,1 0,35 ± 0,35 25,5 ± 0,1 pull off direction X-X Po t o W S Ko P1 P2 Do E X o B t C D1 view direction Ao X SPEC-Gurt 0061/ 19X6,5 Q09016:02.001 Jul.10,01 W2 Reel (all dimensions in mm): A W1 W2(max) N(min) C : : : : : 330 32,4 + 2 38,4 100 13 ± 0,5 / - 0,2 C N A W1 The minimum bending radius is 45 mm. The mounting surface of the filters faces the bottom side of the embossed carrier tape. Markings on the filters can be read if the upper side of the carrier tape is regarded with the sprocket holes on its right. VI TELEFILTER Potsdamer Straße 18 D 14 513 TELTOW / Germany Tel: (+49) 3328 4784-0 / Fax: (+49) 3328 4784-30 E-Mail: [email protected] VI TELEFILTER reserves the right to make changes to the product(s) and/or information contained herein without notice. No liability is assumed as a result of their use or application. No rights under any patent accompany the sale of any such product(s) or information. Tfs140G1.doc Version 1.1 VI TELEFILTER Filter specification 12.07.2002 TFS 140G1 4/5 7. Air reflow temperature conditions 1st and 2nd air reflow profile Name: Temperature: Time: pre-heating periods 150 °C - 170 °C 60 sec. - 90 sec. main-heating periods over 200 °C 20 sec. - 25 sec. peak temperature 255 °C ± 5 °C Chip-mount air reflow profile 260 240 220 200 temperature / °C 180 160 140 120 100 80 60 40 20 0 0 20 40 60 80 100 120 140 160 180 200 220 240 time / sec. Table for temperature vs. time during the air reflow process Tolerance of temperatures: ± 5 °C time / sec. 0 10 20 30 40 50 60 70 80 90 100 110 120 130 temperature / °C 23 34 46 60 80 103 121 134 143 150 154 156 158 159 time / sec. 140 150 160 170 180 190 195 200 205 210 215 220 230 240 temperature / °C 160 161 164 170 180 205 230 255 230 205 180 165 140 120 VI TELEFILTER Potsdamer Straße 18 D 14 513 TELTOW / Germany Tel: (+49) 3328 4784-0 / Fax: (+49) 3328 4784-30 E-Mail: [email protected] VI TELEFILTER reserves the right to make changes to the product(s) and/or information contained herein without notice. No liability is assumed as a result of their use or application. No rights under any patent accompany the sale of any such product(s) or information. Tfs140G1.doc Version 1.1 VI TELEFILTER Filter specification TFS 140G1 12.07.2002 5/5 8. History : Version Reason of changes Name Date 1.0 Generate preliminary specification according to customer requirements. Dunzow W. 15.01.2002 1.0 Generate filter specification after measured. Add typical filter values and termination impedances. Change matching configurations. Dunzow W. 12.07.2002 VI TELEFILTER Potsdamer Straße 18 D 14 513 TELTOW / Germany Tel: (+49) 3328 4784-0 / Fax: (+49) 3328 4784-30 E-Mail: [email protected] VI TELEFILTER reserves the right to make changes to the product(s) and/or information contained herein without notice. No liability is assumed as a result of their use or application. No rights under any patent accompany the sale of any such product(s) or information.