Filename: tfs 153e.doc Version 1.1 VI TELEFILTER 18.01.2007 Filter specification TFS 153E 1/5 Measurement condition Ambient temperature: Input power level: Terminating impedance: * Input: Output: 25 0 °C dBm 330 Ω || -13,5 pF 380 Ω || -15,2 pF Characteristics Remark: The reference level for the relative attenuation arel of the TFS 153E is the minimum of the pass band attenuation amin. The minimum of the pass band attenuation amin is defined as the insertion loss ae. The centre frequency fc is the arithmetic mean value of the upper and lower frequencies at the 3 dB filter attenuation level relative to the insertion loss ae. The temperature coefficient of frequency Tcf is valid for both the reference frequency fc and the frequency response of the filter in the operating temperature range. The frequency shift of the filter in the operating temperature range is not included in the production tolerance scheme. Data typ. value Insertion loss (reference level) ae 21,1 Nominal frequency fN - Centre frequency fC 153,5 PB Passband dB max. MHz - Pass band ripple (p-p) fC 25 dB 153,5 MHz ± 0,1 MHz ±2,5015 MHz 0,3 dB max. 0,7 dB 5,30 5,65 6,21 6,68 dB dB dB dB min. min. max. max. 5,03 5,60 6,30 9,70 MHz MHz MHz MHz dB dB dB dB dB dB dB µs max. max. min. min. min. min. min. max. BW Bandwidth 0,7 dB 3 dB 15 dB 45 dB Relative attenuation fC … fC ± 2,5015 MHz … fC ± fC ± 144,500 MHz … fC fC 3,150 MHz … fC ± fC ± 3,350 MHz … fC ± fC ± 3,750 MHz … fC ± fC ± 4,825 MHz … fC + fC + Absolute group delay within PB tolerance / limit 2,5015 2,800 4,825 3,350 3,750 4,825 428,500 arel MHz MHz MHz MHz MHz MHz MHz 60 Group delay ripple within PB (p-p) Operating temperature range OTR max. - Frequency inversion temperature TCf ** 0,7 3,0 45 15 25 40 45 2,7 120 dB dB dB dB dB dB dB µs ns - 25 °C ... + 80°C - Storage temperature range Temperature coefficient of frequency 0,3 2,5 60 17 30 55 55 2,5 - 40 °C ... + 85°C 20 °C -0,036 ppm/K 2 - *) The terminating impedances depend on parasitics and q-values of matching elements and the board used, and are to be understood as reference values only. Should there be additional questions do not hesitate to ask for an application note or contact our design team. **) ∆fc(Hz) = Tcf(ppm/K2) x (T - TA)2 x fCAT (MHz) Generated: Checked / Approved: Tele Filter GmbH Potsdamer Straße 18 D 14 513 TELTOW / Germany Tel: (+49) 3328 4784-0 / Fax: (+49) 3328 4784-30 E-Mail: [email protected] VI TELEFILTER reserves the right to make changes to the product(s) and/or information contained herein without notice. No liability is assumed as a result of their use or application. No rights under any patent accompany the sale of any such product(s) or information. Filename: tfs 153e.doc Version 1.1 VI TELEFILTER 18.01.2007 Filter specification TFS 153E 2/5 Filter characteristic 0 0 3.31 -6 -1 3.22 -2 3.13 -3 3.04 -4 2.95 -5 2.86 -6 2.77 -48 -7 2.68 -54 -8 2.59 -9 2.5 -12 -18 -30 -36 -42 -60 143.5 145.5 147.5 149.5 151.5 153.5 155.5 frequency in MHz 157.5 159.5 161.5 -10 150.5 163.5 151.1 151.7 152.3 152.9 153.5 154.1 frequency in MHz 154.7 155.3 155.9 delay in µs magnitude in dB magnitude in dB -24 2.41 156.5 Construction and pin connection (All dimensions in mm) 9 ±0,2 24,64 ±0,2 TFS 153E ● V03 1 2,6 Max. Date code 2,31 3,53X4,83 1 2 3 4 5 10 9 8 7 6 1,02 1,91 ±0,2 1 2 3 4 5 6 7 8 9 10 Input RF Return Ground Ground Ground Output Output RF Return Ground Ground Ground Input Date code: V W X ... Year + week 2007 2008 2009 50 Ω Test circuit L1 10 1 5 SAW L2 6 C2 C1 2, 3, 4, 7, 8, 9 Tele Filter GmbH Potsdamer Straße 18 D 14 513 TELTOW / Germany Tel: (+49) 3328 4784-0 / Fax: (+49) 3328 4784-30 E-Mail: [email protected] VI TELEFILTER reserves the right to make changes to the product(s) and/or information contained herein without notice. No liability is assumed as a result of their use or application. No rights under any patent accompany the sale of any such product(s) or information. Filename: tfs 153e.doc Version 1.1 VI TELEFILTER 18.01.2007 Filter specification TFS 153E 3/5 Stability characteristics, reliability After the following tests the filter shall meet the whole specification: 1. Shock: 500g, 1 ms, half sine wave, 3 shocks each plane; DIN IEC 68 T2 - 27 2. Vibration: 10 Hz to 500 Hz, 0,35 mm or 5 g respectively, 1 octave per min, 10 cycles per plan, 3 plans; DIN IEC 68 T2 - 6 3. Change of temperature: 4. Resistance to solder heat (reflow): 5. ESD -55 °C to 125°C / 30 min. each / 10 cycles DIN IEC 68 part 2 – 14 Test N reflow possible: three times max.; for temperature conditions refer to the attached "Air reflow temperature conditions" on page 4; ANSI/ESD S20.20-1999, class 1A for HBM This filter is RoHS compliant (2002/95/EG, 2005/618/EG) Packing Tape & Reel: IEC 286 – 3, with exception of value for N and minimum bending radius; tape type II, embossed carrier tape with top cover tape on the upper side; max. pieces of filters per reel: reel of empty components at start: reel of empty components at start including leader: trailer: Pull Off Direction Po Date Code P1 P2 Ao Ct Bo So Do E t Ko W Tape (all dimensions in mm) W : 44,00 ± 0,3 Po : 4,00 ± 0,1 Do : 1,50 +0,1/-0 E : 1,75 ± 0,1 F : 20,20 ± 0,15 P2 : 2,00 ± 0,15 P1 : 16,00 ± 0,1 D1(min) : 2,00 Ao : 9,30 ± 0,1 Bo : 24,90 ± 0,1 So : 40,40 ± 0,1 Ct : 38,0 ± 0,1 <MAXPIECESPERREEL> min. 300 mm min. 500 mm min. 300 mm Type Reel (all dimensions in mm) A : 330 W1 : 44,4 +2/-0 W2(max) : 50,4 N(min) : 100 C : 13,0 +0,5/-0,2 PIN Marker D1 W2 C A N W1 The minimum bending radius is 45 mm. Tele Filter GmbH Potsdamer Straße 18 D 14 513 TELTOW / Germany Tel: (+49) 3328 4784-0 / Fax: (+49) 3328 4784-30 E-Mail: [email protected] VI TELEFILTER reserves the right to make changes to the product(s) and/or information contained herein without notice. No liability is assumed as a result of their use or application. No rights under any patent accompany the sale of any such product(s) or information. Filename: tfs 153e.doc Version 1.1 VI TELEFILTER 18.01.2007 Filter specification TFS 153E 4/5 Air reflow temperature conditions Conditions Average ramp-up rate (30°C to 217°C) > 100°C > 150°C > 217°C Peak temperature Time within 5°C of actual peak temperature Cool-down rate (Peak to 50°C) Time from 30°C to Peak temperature Exposure less than 3°C/second between 300 and 600 seconds between 240 and 500 seconds between 30 and 150 seconds max. 260°C between 10 and 30 seconds less than 6°C/second no greater than 300 seconds Chip-mount air reflow profile Temperature / °C max. 260°C 217°C max. 300 s 10 ... 30 s Time / s 30 ... 150 s Tele Filter GmbH Potsdamer Straße 18 D 14 513 TELTOW / Germany Tel: (+49) 3328 4784-0 / Fax: (+49) 3328 4784-30 E-Mail: [email protected] VI TELEFILTER reserves the right to make changes to the product(s) and/or information contained herein without notice. No liability is assumed as a result of their use or application. No rights under any patent accompany the sale of any such product(s) or information. Filename: tfs 153e.doc VI TELEFILTER Version 1.1 Filter specification 18.01.2007 TFS 153E 5/5 History Version Reason of changes Name Date 1.0 - development specification Pfeiffer 03.01.2007 1.1 - add of terminating impedances and typical values - filter characteristics corrected Pfeiffer 18.01.2007 Tele Filter GmbH Potsdamer Straße 18 D 14 513 TELTOW / Germany Tel: (+49) 3328 4784-0 / Fax: (+49) 3328 4784-30 E-Mail: [email protected] VI TELEFILTER reserves the right to make changes to the product(s) and/or information contained herein without notice. No liability is assumed as a result of their use or application. No rights under any patent accompany the sale of any such product(s) or information.