FPF1007-FPF1009 IntelliMAX™ Advanced Load Products Features General Description 1.2 to 5.5 V Input Voltage Range The FPF1007/8/9 are low RDS P-Channel MOSFET load switches offered in a selection of 10 µs, 80 µs, and 1 ms slew rate turn-on options for transient / in-rush current control. To support trends in mobile application requirements, the minimum operating input voltage has been reduced down to 1.2 V, the input current leakage has been minimized to extend battery life, and the ESD-protection has been designed to withstand a minimum of 8 kV (HBM) and 2 kV (CDM). Typical RON = 30 mΩ at VIN = 5.5 V Typical RON = 40 mΩ at VIN = 3.3 V Fixed Three Different Turn-on Rise Time 10 µs / 80 µs / 1 ms Low < 10 µA at VIN = 3.3 V Quiescent Current Internal ON Pin Pull Down Output Discharge Function ESD Protection above 8000 V HBM and 2000 V CDM The switch is controlled by an active-high logic input (ON pin), allowing direct interface with a low-voltage control signal. An internal ON pin pull-down resistor protects against unintentional device turn-on in the initial state. An on-chip pull-down resistor on the output is enabled when the switch is turned-off and provides quick, robust discharge of the output load. RoHS Compliant Applications PDAs Cell Phones GPS Devices MP3 Players Digital Cameras Peripheral Ports Hot-Swap Supplies Notebook Computers Pin 1 BOTTOM TOP Ordering Information Part Switch RON at 5.5 V [Typ.] Rise Time [Typ.] Output Discharge [Typ.] ON Pin Activity FPF1007 30 mΩ, PMOS 10 µs 60 Ω Active HIGH FPF1008 30 mΩ, PMOS 80 µs 60 Ω Active HIGH FPF1009 30 mΩ, PMOS 1 ms 60 Ω Active HIGH © 2008 Fairchild Semiconductor Corporation FPF1007-FPF1009 • Rev. 1.0.3 1 www.fairchildsemi.com FPF1007-FPF1009 — IntelliMAX™ Advanced Load Products October 2012 IN OUT FPF1007-FPF1009 OFF ON 1.2 V~5.5 COUT ON RL GND CIN 0.1 µF Functional Block Diagram VIN Turn-ON Slew Rate Controlled Driver CONTROL LOGIC ON VOUT ESD Protection Output Discharge FPF1007-FPF1009 GND © 2008 Fairchild Semiconductor Corporation FPF1007-FPF1009 • Rev. 1.0.3 2 www.fairchildsemi.com FPF1007-FPF1009 — IntelliMAX™ Advanced Load Products Typical Application Circuit FPF1007-FPF1009 — IntelliMAX™ Advanced Load Products Pin Configuration GND 6 1 ON VOUT 5 2 VIN VOUT 4 3 VIN MicroFET 2x2 6L BOTTOM VIEW Pin Description Pin Name 4, 5 VOUT 2, 3 VIN 6 GND 1 ON © 2008 Fairchild Semiconductor Corporation FPF1007-FPF1009 • Rev. 1.0.3 Function Switch Output: Output of the power switch Supply Input: Input to the power switch and the supply voltage for the IC Ground ON/OFF Control Input 3 www.fairchildsemi.com Parameter VIN, VOUT, ON to GND Min. Max. Unit -0.3 6.0 V 1.5 A Maximum Continuous Switch Current Power Dissipation at TA = 25°C(1) 1.2 W Storage Junction Temperature -65 +150 °C Operating Temperature Range -40 +85 °C 86 °C/W Thermal Resistance, Junction to Ambient Electrostatic Discharge Protection HBM 8000 V CDM 2000 V Note: Package power dissipation on 1-square inch pad, 2 oz. copper board. Recommended Operating Range Parameter Min. Max. Unit VIN 1.2 5.5 V Ambient Operating Temperature, TA -40 +85 °C © 2008 Fairchild Semiconductor Corporation FPF1007-FPF1009 • Rev. 1.0.3 4 www.fairchildsemi.com FPF1007-FPF1009 — IntelliMAX™ Advanced Load Products Absolute Maximum Ratings VIN = 1.2 V to 5.5 V, TA = -40 to +85°C unless otherwise noted. Typical values are at VIN = 3.3 V and TA = 25°C. Parameter Symbol Conditions Min. Typ. Max. Units Basic Operation Operating Voltage Quiescent Current IQ Off Supply Current IQ(off) Off Switch Current ISD(off) On-Resistance 1.2 VIN RON IOUT = 0 mA, VIN = 3.3 V, VON = Enabled V µA IOUT = 0 mA, VIN = 5.5 V, VON = Enabled 15 VON = GND, VOUT = OPEN 1 µA µA VON = GND, VOUT = GND 0.1 1.0 VIN = 5.5 V, IOUT = 200 mA, TA = 25°C 30 40 VIN = 3.3 V, IOUT = 200 mA, TA = 25°C 40 55 VIN = 1.5 V, IOUT = 200 mA, TA = 25°C 100 130 VIN = 1.2 V, IOUT = 200 mA, TA = 25°C 175 250 VIN = 3.3 V, IOUT = 200 mA, TA = -40°C to +85°C RPD VIN = 3.3 V, VON = 0 V, TA = 25°C ON Input Logic Low Voltage VIL VIN = 1.2 V to 5.5 V ON Input Logic High Voltage VIH VIN = 1.2 V to 5.5 V Output Pull Down Resistance 5.5 8 20 mΩ 65 Ω 60 0.4 1 V V ON Input Leakage (On) VON = VIN = 5.5 V 10 µA ON Input Leakage (Off) VON = GND 1 µA Dynamic FPF1007 Turn On Rise Time 12 µs VIN = 3.3 V, RL = 500 Ω, RL_CHIP = 60 Ω, 10 µs COUT = 0.1 µF, TA = 25°C tON tR Turn Off tOFF 40 µs Fall Time tF 15 µs tON 125 µs VIN = 3.3 V, RL = 500 Ω, RL_CHIP = 60 Ω, 80 µs COUT = 0.1 µF, TA = 25°C 40 µs 15 µs FPF1008 Turn On Rise Time tR Turn Off tOFF Fall Time tF FPF1009 Turn On Rise Time tON tR Turn Off tOFF Fall Time tF © 2008 Fairchild Semiconductor Corporation FPF1007-FPF1009 • Rev. 1.0.3 2 ms VIN = 3.3 V, RL = 500 Ω, RL_CHIP = 60 Ω, 1 ms COUT = 0.1 µF, TA = 25°C 40 µs 15 µs 5 www.fairchildsemi.com FPF1007-FPF1009 — IntelliMAX™ Advanced Load Products Electrical Characteristics 14 1.0 12 0.9 SUPPLY CURRENT ( uA) SUPPLY CURRENT ( uA) VON = 0V VON = VIN 10 8 6 4 2 0.8 0.7 VIN = 5.5V 0.6 VIN = 3.3V 0.5 0.4 VIN = 1.2V 0.3 VON = 0V 0.2 0 1 2 3 4 5 -40 6 -15 Figure 1. Quiescent Current vs. Input Voltage 60 85 0.80 VON = VIN VIN = 5.5V VON SUPPLY VOLTAGE ( V) 12 SUPPLY CURRENT ( uA) 35 Figure 2. Quiescent Current vs. Temperature 14 10 VIN = 3.3V 8 6 VIN = 1.2V 4 2 0 0.75 VONH(VIH) 0.70 VONL(VIL) 0.65 0.60 0.55 0.50 -40 -15 10 35 60 85 1 2 TJ, JUNCTION TEMPERATURE (oC) 3 4 5 6 VIN, SUPPLY VOLTAGE (V) Figure 4. VON Voltage vs. Input Voltage Figure 3. Quiescent Current vs. Temperature 0.85 0.90 0.80 VON SUPPLY VOLTAGE ( V) VON SUPPLY VOLTAGE ( V) 10 TJ, JUNCTION TEMPERATURE (oC) SUPPLY VOLTAGE (V) 0.75 VIN = 5.5V 0.70 0.65 VIN = 3.3V VIN = 1.2V 0.60 0.55 0.85 0.80 VIN=5.5V 0.75 VIN=3.3V 0.70 VIN=1.2V 0.65 0.60 0.50 -40 -15 10 35 60 -40 85 10 35 60 85 o Figure 5. VON Low Voltage vs. Temperature © 2008 Fairchild Semiconductor Corporation FPF1007-FPF1009 • Rev. 1.0.3 -15 TJ, JUNCTION TEMPERATURE ( C) TJ, JUNCTION TEMPERATURE (oC) Figure 6. VON High Voltage vs. Temperature 6 www.fairchildsemi.com FPF1007-FPF1009 — IntelliMAX™ Advanced Load Products Typical Characteristics 240 6.5 210 180 VON = 5.5V 5.5 RON(mOhms) ON PIN CURRENT ( uA) 7.5 4.5 3.5 2.5 150 120 90 60 1.5 VON = 0V 0.5 85°C 25°C 30 -40°C 0 -0.5 -40 -15 10 35 60 1 85 2 3 5 6 Figure 8. RON vs. VIN Figure 7. On Pin Current vs. Temperature 100 1000 FPF1007 TOFF 10 FPF1008 TURN-ON/OFF TIMES ( uS) TURN-ON/OFF TIMES (uS) 4 VIN, SUPPLY VOLTAGE (V) o TJ, JUNCTION TEMPERATURE ( C) TON VIN = 3.3V RL = 500 Ohms COUT = 0.1uF 1 0.1 VIN = 3.3V RL = 500 Ohms COUT = 0.1uF TON 100 TOFF 10 -40 -15 10 35 60 85 -40 -15 TJ, JUNCTION TEMPERATURE (oC) 10 35 60 85 TJ, JUNCTION TEMPERATURE (oC) Figure 9. FPF1007 tON / tOFF vs. Temperature Figure 10. FPF1008 tON / tOFF vs. Temperature 100 FPF1007 TON RISE / FALL TIMES ( uS) TURN-ON/OFF TIMES ( uS) FPF1009 1000 VIN = 3.3V RL = 500 Ohms COUT = 0.1uF TOFF 10 TFALL 10 TRISE VIN = 3.3V RL = 500 Ohms COUT = 0.1uF 1 -40 -15 10 35 60 85 -40 TJ, JUNCTION TEMPERATURE (oC) 10 35 60 85 TJ, JUNCTION TEMPERATURE (oC) Figure 11. FPF1009 tON / tOFF vs. Temperature © 2008 Fairchild Semiconductor Corporation FPF1007-FPF1009 • Rev. 1.0.3 -15 Figure 12. FPF1007 tRISE / tFALL vs. Temperature 7 www.fairchildsemi.com FPF1007-FPF1009 — IntelliMAX™ Advanced Load Products Typical Characteristics 1000 10000 FPF1009 RISE / FALL TIMES ( uS) RISE / FALL TIMES ( uS) FPF1008 TRISE 100 TFALL 10 VIN = 3.3V RL = 500 Ohms COUT = 0.1uF 1 TRISE 1000 VIN = 3.3V RL = 500 Ohms COUT = 0.1uF 100 TFALL 10 1 -40 -15 10 35 60 85 -40 TJ, JUNCTION TEMPERATURE (oC) 35 60 85 Figure 14. FPF1009 tRISE / tFALL vs. Temperature VON = 3.3 V VIN = 3.3 V CIN = 1 µF COUT = 0.1 µF RL = 499 Ω VIN 2 V/div 10 TJ, JUNCTION TEMPERATURE (oC) Figure 13. FPF1008 tRISE / tFALL vs. Temperature VON 2 V/div -15 VON = 3.3 V VIN = 3.3 V CIN = 1 µF COUT = 0.1 µF RL = 499 Ω VON 2 V/div VIN 2 V/div IOUT 10 mA/div IOUT 50 mA/div VOUT 2 V/div VOUT 2 V/div 50µs/div 50µs/div Figure 15. FPF1007 Turn-On Response Figure 16. FPF1007 Turn-Off Response Load current discharged through on-chip output discharge resistor VON = 3.3 V VIN = 3.3 V CIN = 1 µF COUT = 1 µF RL = 10 Ω VON 2V/div VIN 2V/div VON 2V/div VON = 3.3 V VIN = 3.3 V CIN = 1 µF COUT = 1 µF RL = 10 Ω VIN 2V/div IOUT 200mA/div IOUT 200mA/div VOUT 2V/div VOUT 2V/div 50µs/div 50µs/div Figure 17. FPF1007 Turn-On Response (COUT = 1 µF) © 2008 Fairchild Semiconductor Corporation FPF1007-FPF1009 • Rev. 1.0.3 Figure 18. FPF1007 Turn-Off Response 8 www.fairchildsemi.com FPF1007-FPF1009 — IntelliMAX™ Advanced Load Products Typical Characteristics VON = 3.3 V VIN = 3.3 V CIN = 1 µF COUT = 0.47 µF RL = 499 Ω VON 2 V/div VIN 2 V/div VON 2 V/div VIN 2 V/div IOUT 10 mA/div IOUT 50 mA/div VOUT 2 V/div VOUT 2 V/div VON = 3.3 V VIN = 3.3 V CIN = 1 µF COUT = 0.47 µF RL = 499 Ω 100µs/div 500µs/div Figure 19. FPF1008 Turn-On Response Figure 20. FPF1008 Turn-Off Response Load current discharged through on-chip output discharge resistor VON = 3.3 V VIN = 3.3 V CIN = 1 µF COUT = 4.7 µF RL = 10 Ω VON 2 V/div VIN 2 V/div VON 2 V/div VIN 2 V/div IOUT 500 mA/div IOUT 10 mA/div VOUT 2 V/div VOUT 2 V/div 100 µs/div 100 µs/div Figure 21. FPF1008 Turn-On Response (COUT = 4.7 µF) Figure 22. FPF1008 Turn-Off Response VIN 2 V/div VIN 2 V/div IOUT 500 mA/ IOUT 10 mA/div VOUT 2 V/div VOUT 2 V/div 2 ms/div 500µs/div Figure 23. FPF1008 Turn-On Response (COUT = 10 µF) © 2008 Fairchild Semiconductor Corporation FPF1007-FPF1009 • Rev. 1.0.3 VON = 3.3 V VIN = 3.3 V CIN = 1 µF COUT = 0.47 µF RL = 499 Ω VON 2 V/div VON = 3.3 V VIN = 3.3 V CIN = 1 µF COUT = 10 µF RL = 10 Ω VON 2 V/div VON = 3.3 V VIN = 3.3 V CIN = 1 µF COUT = 4.7 µF RL = 10 Ω Figure 24. FPF1009 Turn-On Response 9 www.fairchildsemi.com FPF1007-FPF1009 — IntelliMAX™ Advanced Load Products Typical Characteristics VON = 3.3 V VIN = 3.3 V CIN = 1 µF COUT = 0.47 µF RL = 499 Ω VON 2 V/div VIN 2 V/div VON = 3.3 V VIN = 3.3 V CIN = 1 µF COUT = 47 µF RL = 10 Ω VON 2 V/div VIN 2 V/div IOUT 50 mA/div IOUT 500 mA/ VOUT 2 V/div VOUT 2 V/div 500µs/div 2 ms/div Figure 25. FPF1009 Turn-Off Response Figure 26. FPF1009 Turn-On Response (COUT = 47 µF) Load current discharged through on-chip output discharge resistor VON = 3.3 V VIN = 3.3 V CIN = 1 µF COUT = 47 µF RL = 10 Ω VON 2 V/div VIN 2 V/div VON 2V/div VON = 3.3 V VIN = 5 V CIN = 1 µF COUT = 100 µF RL = 10 Ω VIN 2V/div IOUT 500 mA/div IOUT 500mA/div VOUT 2 V/div VOUT 2V/div 2 ms/div 2 ms/div Figure 27. FPF1009 Turn-Off Response Figure 28. FPF1009 Turn-On Response (COUT = 100 µF, VIN = 5 V) Timing Diagram 90% VOUT 90% 10% where: tON tOFF tdon tdoff tR tF tON tOFF 10% tF tR 3.3 V 50% 50% VON = = = = = = = = Turn-On Time Turn-Off Time Turn-On Delay Time Turn-Off Delay Time Rise Time VOUT Fall Time tR + tdon tF + tdoff tF 90% 10% VOUT tdon © 2008 Fairchild Semiconductor Corporation FPF1007-FPF1009 • Rev. 1.0.3 tdoff 10 www.fairchildsemi.com FPF1007-FPF1009 — IntelliMAX™ Advanced Load Products Typical Characteristics FPF1007-FPF1009 — IntelliMAX™ Advanced Load Products Dimensional Outline and Pad Layout 0.10 C 2.00 2X 1.68 A B 0.84 6 PIN 1 IDENT 4 2.00 0.90 1.21 2.25 (0.52) 0.10 C TOP VIEW 0.45 1 2X 0.8 MAX 3 0.42 0.65 RECOMMENDED LAND PATTERN 0.10 C (0.20) 0.08 C 0.05 0.00 SEATING PLANE C SIDE VIEW PIN #1 ID 1 1.50 1.30 (0.70) PIN 1 IDENT 1 0.45 0.20 3 (0.40) 6 0.90 0.70 PIN #1 ID 1 4 0.65 1.30 0.25~0.38 0.10 0.05 C A B C OPTIONS OF PIN ONE IDENTIFIERS BOTTOM VIEW A. DOES NOT FULLY CONFORM TO JEDEC REGISTRATION, MO-229. B. DIMENSIONS ARE IN MILLIMETERS. C. DIMENSIONS AND TOLERANCES PER ASME Y14.5M, 1994 D. LANDPATTERN RECOMMENDATION IS BASED ON FSC DESIGN ONLY E. DRAWING FILENAME: MKT-MLP06Krev3. Package drawings are provided as a service to customers considering Fairchild components. Drawings may change in any manner without notice. Please note the revision and/or date on the drawing and contact a Fairchild Semiconductor representative to verify or obtain the most recent revision. Package specifications do not expand the terms of Fairchild’s worldwide terms and conditions, specifically the warranty therein, which covers Fairchild products. Always visit Fairchild Semiconductor’s online packaging area for the most recent package drawings: http://www.fairchildsemi.com/packaging/. © 2008 Fairchild Semiconductor Corporation FPF1007-FPF1009 • Rev. 1.0.3 11 www.fairchildsemi.com FPF1007-FPF1009 — IntelliMAX™ Advanced Load Products © 2008 Fairchild Semiconductor Corporation FPF1007-FPF1009 • Rev. 1.0.3 12 www.fairchildsemi.com