TFS70AP.doc version 1.0 VI TELEFILTER 23.04.2004 Filter Specification TFS 70 AP 1/5 Measurement condition 23 °C 0 dBm Ambient temperature: Input power level: Terminating impedance: * Input: Output: 142 Ω || -56 pF 105 Ω || -64 pF Characteristics Remark: The nominal frequency fN is fixed at 70,00 MHz. The insertion loss ae is defined as loss value determined at fN. Reference level for the relative attenuation arel of the TFS 70AP is the insertion loss ae. The centre frequency fc is the arithmetic mean value of the upper and lower frequencies at the 1,5 dB filter attenuation level relative to the insertion loss ae. All specified data are met within the operating temperature range. Data Insertion loss ae typ. value 19,5 dB Nominal frequency fN - 70,00 MHz Pass band PB - fN ± 0,61 MHz Amplitude ripple PB 0,5 dB max. 0,7 dB 1 deg max. 5 deg 50 dB min. 30 dB Deviation from linear phase Triple transit suppression Relative attenuation fN ± 0,630 max. 22 tolerance/limit dB arel MHz 0,7 f ± 0,750 MHz N f ± 0,900 MHz N Operating temperature range Storage temperature range Temperature coefficient of frequency **) TCf dB max. 1,5 dB 40 dB min. 35 dB 60 dB min. 50 dB - - 5 °C ... + 65 °C - - 40 °C ... + 85 °C -0,04 ppm/K 2 - *) The terminating impedances depend on parasitics and q-values of matching elements and the board used, and are to be understood as reference values only. Should there be additional questions do not hesitate to ask for an application note or contact our design team. **) ∆fc(Hz) = Tcf (ppm/K²) x (T-TA)² x fcat(MHz) generated: checked / approved: Tele Filter GmbH Potsdamer Straße 18 D 14 513 TELTOW / Germany Tel: (+49) 3328 4784-0 / Fax: (+49) 3328 4784-30 E-Mail: [email protected] VI TELEFILTER reserves the right to make changes to the product(s) and/or information contained herein without notice. No liability is assumed as a result of their use or application. No rights under any patent accompany the sale of any such product(s) or information. TFS70AP.doc version 1.0 VI TELEFILTER 23.04.2004 Filter Specification TFS 70 AP 2/5 Filter characteristic B d ni e d ut i n g a m 0 0 66.39 -10 -1 58.89 -20 -2 51.39 -30 -3 43.89 -4 -6 36.39 ° 28.89ni e s 21.39a h p B d ni e d ut i n g a m -40 -50 -60 -5 -7 13.89 -80 -8 6.39 -90 -9 -1.11 -70 -100 66 66.8 67.6 68.4 69.2 70 70.8 frequency in MHz 71.6 72.4 73.2 74 -10 69 69.2 69.4 69.6 69.8 70 70.2 frequency in MHz 70.4 70.6 70.8 -8.61 71 Construction and pin connection (All dimensions in mm) 73,28 Max. 19,94 Max. Date code: Year+week 4,57 ±1 5 ±0,30 1 ø 0,45 ±0,05 58,42 ±0,13 15,24 ±0,13 27,94 ±0,13 1 2 3 4 5 6 7 8 9 18 17 16 15 14 13 12 11 10 5,08 ±0,13 20,32 ±0,13 17,78 ±0,13 10,16 ±0,13 10,16 ±0,13 10,16 ±0,13 S T U ... 2004 2005 2006 Pin 1 Pin 2 Pin 3 Pin 4 Pin 5 Pin 6 Pin 7 Pin 8 Pin 9 Pin 10 Pin 11 Pin 12 Pin 13 Pin 14 Pin 15 Pin 16 Pin 17 Pin 18 Ground Input Ground Ground Ground Ground Ground Ground Ground Ground Output Ground Ground Ground Ground Ground Ground Ground 50 Ohm Test circuit 2 11 1,3,4,5,6,7,8,9,10, 12,13,14,15,16,17,18 Tele Filter GmbH Potsdamer Straße 18 D 14 513 TELTOW / Germany Tel: (+49) 3328 4784-0 / Fax: (+49) 3328 4784-30 E-Mail: [email protected] VI TELEFILTER reserves the right to make changes to the product(s) and/or information contained herein without notice. No liability is assumed as a result of their use or application. No rights under any patent accompany the sale of any such product(s) or information. TFS70AP.doc version 1.0 VI TELEFILTER Filter Specification 23.04.2004 TFS 70 AP 3/5 Stability characteristics After the following tests the filter shall meet the whole specification: 1. Shock: 500g, 18 ms, half sine wave, 3 shocks each plane; DIN IEC 68 T2 - 27 2. Vibration: 10 Hz to 500 Hz, 0,35 mm or 5 g respectively, 1 octave per min, 10 cycles per plan, 3 plans; DIN IEC 68 T2 - 6 3. Change of temperature: 4. Resistance to solder heat (reflow): -55 °C to 125°C / 30 min. each / 10 cycles DIN IEC 68 part 2 – 14 Test N reflow possible: twice max.; for temperature conditions refer to the attached "Air reflow temperature conditions" on page 4; Tele Filter GmbH Potsdamer Straße 18 D 14 513 TELTOW / Germany Tel: (+49) 3328 4784-0 / Fax: (+49) 3328 4784-30 E-Mail: [email protected] VI TELEFILTER reserves the right to make changes to the product(s) and/or information contained herein without notice. No liability is assumed as a result of their use or application. No rights under any patent accompany the sale of any such product(s) or information. TFS70AP.doc version 1.0 VI TELEFILTER 23.04.2004 Filter Specification TFS 70 AP 4/5 Air reflow temperature conditions 1st and 2nd air reflow profile pre-heating periods main-heating periods 150 °C - 170 °C over 200 °C 60 sec. - 90 sec. 20 sec. - 25 sec. Name: Temperature: Time: peak temperature 255 °C ± 5 °C Chip-mount air reflow profile 260 240 220 200 temperature / °C 180 160 140 120 100 80 60 40 20 0 0 20 40 60 80 100 120 140 160 180 200 220 240 time / sec. Table for temperature vs. time during the air reflow process Tolerance of temperatures: ± 5 °C time / sec. 0 10 20 30 40 50 60 70 80 90 100 110 120 130 temperature / °C 23 34 46 60 80 103 121 134 143 150 154 156 158 159 time / sec. 140 150 160 170 180 190 195 200 205 210 215 220 230 240 temperature / °C 160 161 164 170 180 205 230 255 230 205 180 165 140 120 Tele Filter GmbH Potsdamer Straße 18 D 14 513 TELTOW / Germany Tel: (+49) 3328 4784-0 / Fax: (+49) 3328 4784-30 E-Mail: [email protected] VI TELEFILTER reserves the right to make changes to the product(s) and/or information contained herein without notice. No liability is assumed as a result of their use or application. No rights under any patent accompany the sale of any such product(s) or information. TFS70AP.doc VI TELEFILTER version 1.0 Filter Specification 23.04.2004 TFS 70 AP 5/5 History Version Reason of Changes Name Date 1.0 Generation of specification Steiner 23.04.2004 Tele Filter GmbH Potsdamer Straße 18 D 14 513 TELTOW / Germany Tel: (+49) 3328 4784-0 / Fax: (+49) 3328 4784-30 E-Mail: [email protected] VI TELEFILTER reserves the right to make changes to the product(s) and/or information contained herein without notice. No liability is assumed as a result of their use or application. No rights under any patent accompany the sale of any such product(s) or information.