TOCOS ® RV16 Series PA N E L C O N T R O L S 16mm Diameter, Single-Turn, Carbon Industrial Panel Controls RV16YPL RV16YN RV16YNME Features 16mm diameter, single-turn industrial panel controls Carbon film element Linear or audio tapers Single and tandem units, single shaft; dual unit, dual shaft Optional switch, center detent, and shaft lock available 3.2mm diameter metal shafts in slot, flat or round end styles Standard 10mm or 15mm shaft length Panel or PC board mounting styles Lug or pin terminals Right angle mount pin configurations Specifications Electrical Environmental Standard Resistance Range . . . . . . . . . . B = 100Ω to 2MΩ A,C = 2kΩ to 2MΩ Temperature Range . . . . . . . . . . . . . . . . . . 10C to 85C Resistance Tolerance . . . . . . . . . . . . . . . . . 10% standard End Resistance . . . . . . . . . . . . . . . . . . . . . . . . . . . . 3Ω max. Resistance Taper . . . . B = linear; A = CW audio (logarithm); C = CCW audio (logarithm) Peak Noise (C.R.V.) . . . . . . . 3% or 3Ω, whichever is greater Power Rating . . . . . . . . . . . . . B = 0.1 watt; A,C = 0.05 watt at 40C, 0 watt at 85C Maximum Input Voltage . . . . . . . . 200VDC or power rating, whichever is smaller Insulation Resistance . . . . . . . 100MΩ minimum at 500VDC Dielectric Strength . . . . . . . . . . . . . . . . . . 500VAC, 1 minute Adjustment Travel . . . . . . . . . . . . . . . . . . . . . . . . . 24010 Mechanical Mechanical Travel . . . . . . . . . . . . . . . . . . . . . . . . . 26010 Shaft Torque Single Unit . . . . . 20.4 to 204 gf • cm (0.283 to 2.828 oz • in) Other Units . . . . 20.4 to 357 gf • cm (0.283 to 4.949 oz • in) Low Temperature Exposure . . .10C, 1 hour without load ∆T/R )2.5% Load Life . . . . . . . . . . 40C, 90 minutes on, 30 minutes off, 1,000 hours with rated load ∆T/R )15% Moisture Resistance . . . . . . . . . . . . . . .40C, 90-95%RH, 96 hours without load ∆T/R )10% Thermal Shock . . . . . . . . . . . . . . . . . . . . . . . 10C ~85C, 5 cycles without load ∆T/R )10% Shock . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 50G, 11 m /s ∆T/R )2.5% Vibration . . . . . . . . . . . . . . . . . . .10-55Hz, 1.5mm amplitude, 3 directions, 2 hours each ∆T/R )2.5% Soldering Heat Resistance . . . . . . . . . . . 350C, 3 seconds; 260C, 5 seconds (PCB units) ∆T/R )2% Stop Strength . . . . . . . . . . . 3.06 kgf • cm (42.42 oz • in) max. Rotational Life . . . . 15,000 cycles (500 cycles for shaft lock models only) without load ∆T/R )10% Mounting Nut Torque . . . . . 10.2 kgf • cm (141.4 oz • in) max. Standard Rotary Switches Solderability . . . . . . . . . . . . . . . . . . . . . . . 235C, 5 seconds Switch Rating . . . . . . . . . . . . . 110VAC, 0.5A, SPDT or SPST Marking . . . . . . . . . . . . . Model type, taper, resistance code, terminal identification, date code Contact Resistance . . . . . . . . . . . . . . . . . . . . . . 0.05Ω max. Operating Torque . . . . . . . . 1,530 gf • cm (21.21 oz • in) max. Operating Life . . . . . . . . . . . . . . . 10,000 cycles without load ∆T/R = Total Resistance Change TOCOS AMERICA, INC. 1177 East Tower Road, Schaumburg, IL 60173 Tel: 847-884-6664 Fax: 847-884-6665 19 E-mail: [email protected] www.tocos.com RV16 Series Dimensions RV16YN & RV16YN-4C (with Center Detent) Panel Mount, Single Unit, Single Shaft Right Angle Ear-Lug Terminals Unit: mm Recommended Panel Mounting Hole RV16YL Panel Mount, Single Unit, Single Shaft with Shaft Lock Right Angle Ear-Lug Terminals Recommended Panel Mounting Hole RV16YNMH & RV16YNSH Panel Mount, Single Unit with Switch, Single Shaft Right Angle Ear-Lug Terminals, Rear Exit Lug Terminals for 0.5A SPDT or SPST Switch Recommended Panel Mounting Hole * The SPST switch (SH code designation) does not have a B terminal. TOCOS AMERICA, INC. 20 1177 East Tower Road, Schaumburg, IL 60173 Tel: 847-884-6664 Fax: 847-884-6665 E-mail: [email protected] www.tocos.com RV16 Series Dimensions RV16YP Unit: mm PCB Mount, Single Unit, Single Shaft Right Angle Mount Pin Terminals, 3-Pin Inline Pattern, 2-Pin Standoff Rear Support Bracket Recommended PCB Mounting Holes RV16YPL PCB Mount, Single Unit, Single Shaft with Shaft Lock Right Angle Mount Pin Terminals, 3-Pin Inline Pattern, 2-Pin Standoff Rear Support Bracket Recommended PCB Mounting Holes RV16YG Panel Mount, Ganged Tandem Unit, Single Shaft Right Angle Ear-Lug Terminals on Each Unit Recommended Panel Mounting Hole TOCOS AMERICA, INC. 1177 East Tower Road, Schaumburg, IL 60173 Tel: 847-884-6664 Fax: 847-884-6665 21 E-mail: [email protected] www.tocos.com RV16 Series Dimensions RV16YGP Unit: mm PCB Mount, Ganged Tandem Unit, Single Shaft Right Angle Mount Pin Terminals on Each Unit, 3-Pin Inline Pattern, 2-Pin Standoff Rear Support Bracket Recommended PCB Mounting Holes RV16YGMH Panel Mount, Ganged Tandem Unit with Rear Unit Switch, Single Shaft Right Angle Ear-Lug Terminals on Each Unit, Rear Exit Lug Terminals for 0.5A SPDT Switch Recommended Panel Mounting Hole * Connect the A and C terminals only for a SPST switch. Do not use the B terminal. RV16YD Panel Mount, Dual Unit, Dual Concentric Shaft Right Angle Ear-Lug Terminals on Each Unit Recommended Panel Mounting Hole TOCOS AMERICA, INC. 22 1177 East Tower Road, Schaumburg, IL 60173 Tel: 847-884-6664 Fax: 847-884-6665 E-mail: [email protected] www.tocos.com RV16 Series Dimensions RV16YDMH & RV16YDSH Unit: mm Panel Mount, Dual Unit with Rear Unit Switch, Dual Concentric Shaft Right Angle Ear-Lug Terminals on Each Unit, Rear Exit Lug Terminals for 0.5A SPDT or SPST Switch Recommended Panel Mounting Hole * The SPST switch (SH code designation) does not have a B terminal. TOCOS AMERICA, INC. 1177 East Tower Road, Schaumburg, IL 60173 Tel: 847-884-6664 Fax: 847-884-6665 23 E-mail: [email protected] www.tocos.com RV16 Series Part Numbering System RV 16 Y N -4C MH 20 S B 103 K NOTE: FMS = From Mounting Surface Resistance Tolerance: K = 10% (standard). Resistance Code: Expressed in ohms. A three digit code where the first two digits are significant figures, and the third digit indicates the number of zeros that follow these figures (i.e., 100 = 10Ω; 101 = 100Ω; 102 = 1,000Ω; 103 = 10,000Ω; 105 = 1,000,000Ω ). See table for standard resistance values. For Single Unit: Specify taper and resistance code as shown. For Ganged Tandem Unit or Dual Unit: Specify a taper code and resistance code for each unit starting with the front unit followed by the rear unit. If both units have the same taper and resistance codes, add “X2” suffix per example below. Examples: B103A503 or if both units are the same: B103X2 Resistance Taper: B = Linear. A = CW Audio (logarithm). C = CCW Audio (logarithm). Shaft End Style: S = Slotted; F = Flatted; R = Round. For Single Shaft: Specify the shaft length (FMS) and shaft end style as shown. For Dual Concentric Shafts: Specify the shaft length (FMS) and shaft end style for the inner shaft followed by the shaft length (FMS) and shaft end style for the outer shaft. Use a dash (-) to separate the code groups for the inner and outer shaft specifications. Example: 30R-20R Standard Shaft Length: 10 = 10mm FMS. 15 = 15mm FMS. Up to 30mm shaft length available (special order ). Switch Type: MH = SPDT, 110VAC, 0.5A, Rear Exit Lug Terminals. SH = SPST, 110VAC, 0.5A, Rear Exit Lug Terminals. Blank = No Switch. Detent: -4C = Center Detent. Blank = No Detent. Style: N = Panel Mount, Single Unit, Single Shaft, Right Angle Ear-Lug Terminals. L = Panel Mount, Single Unit, Single Shaft with Shaft Lock, Right Angle Ear-Lug Terminals. P = PCB Mount, Single Unit, Single Shaft, Right Angle Mount Pin Terminals, 3-Pin Inline Pattern, 2-Pin Standoff Rear Support Bracket. PL = PCB Mount, Single Unit, Single Shaft with Shaft Lock, Right Angle Mount Pin Terminals, 3-Pin Inline Pattern, 2-Pin Standoff Rear Support Bracket. G = Panel Mount, Ganged Tandem Unit, Single Shaft, Right Angle Ear-Lug Terminals on Each Unit. GP = PCB Mount, Ganged Tandem Unit, Single Shaft, Right Angle Mount Pin Terminals on Each Unit, 3-Pin Inline Pattern, 2-Pin Rear Standoff Support Bracket. D = Panel Mount, Dual Unit, Dual Concentric Shaft, Right Angle Ear-Lug Terminals on Each Unit. Operating Temperature Range: Y = 10C to 85C. Size: 16 = 16mm Diameter. TOCOS Series Name: RV = Carbon Film Element. Standard Resistance Values and Part Numbering Codes Standard Nominal Total Resistance Values and Part Numbering Codes Resistance ( Ω ) Code Resistance ( Ω ) Code Resistance ( Ω ) Code Resistance ( Ω ) Code Resistance ( Ω ) Code 100 200 500 101 201 501 1,000 2,000 5,000 102 202 502 10,000 20,000 50,000 103 203 503 100,000 200,000 500,000 104 204 504 1,000,000 2,000,000 105 205 Refer to Shaft End Styles Specifications and Hardware Specifications for details and availability. For additional information, refer to Guidelines and Precautions for Using Panel Controls. TOCOS AMERICA, INC. 24 1177 East Tower Road, Schaumburg, IL 60173 Tel: 847-884-6664 Fax: 847-884-6665 E-mail: [email protected] www.tocos.com