TOCOS ® RVQ103YN Series PA N E L C O N T R O L S Long Life 10mm Diameter, Single-Turn, Carbon Panel Controls RVQ103YP RVQ103YN Features Long life 10mm diameter, single-turn industrial panel controls Carbon film element 200,000 cycle rotational life Single unit, single shaft Linear taper Molded plastic construction for housing and bushing Lightweight 3mm diameter metal shafts in slot, flat or round end styles Standard 10mm or 15mm shaft length Panel mount style Rear exit vertical lug terminals PCB mounting style available as special order Specifications Electrical Environmental Standard Resistance Range . . . . . . . . . . . . 5kΩ and 10kΩ Temperature Range . . . . . . . . . . . . . . . . . . 10C to 85C Resistance Tolerance . . . . . . . . . . . . . . . . . 20% standard Temperature Characteristics . . . . . . . . . . .85C, 5 hours ∆T/R )10% End Resistance . . . . . . . . . . . . . . . . . . . . . . . Not applicable Resistance Taper . . . . . . . . . . . . . . . . . . . . . . . . . . B = linear Independent Linearity . . . . . . . . . . . . . . . . . . . . 3% max. Peak Noise (C.R.V.) . . . . . . . 1% or 2Ω, whichever is greater Power Rating . . . . . . . 0.125 watt at 40C, 0 watt at 85C Maximum Input Voltage . . . . . . . . . 35VDC or power rating, whichever is smaller Insulation Resistance . . . . . . . 100MΩ minimum at 500VDC Dielectric Strength . . . . . . . . . . . . . . . . . . 500VAC, 1 minute Adjustment Travel . . . . . . . . . . . . . . . . . . . . . . 320 nominal Mechanical Temperature Cycle . . . . . . . . . . . . . . . . . . . .10C ,85C, 30 minutes each, 5 cycles ∆T/R )10% Load Life . . . . . . . . . . . . . . . . 40C, 0.125 watt, 1,000 hours ∆T/R )10% Moisture and Load Life . . . . . . . . . . . . 40C, 90-95%RH, 0.125 watt, 500 hours ∆T/R )10% Vibration . . . . . . . . .10-55Hz, 1.5mm amplitude, 3 directions ∆T/R )5% Soldering Heat Resistance . . . . . . . 350C5C, 3 seconds ∆T/R )2% Mechanical Travel . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 360 Rotational Life . . . . . . . . . . . . . 200,000 cycles without load ∆T/R )5% Shaft Torque . . . . . . . . . . . . . . . 15 gf • cm (0.208 oz • in) max. ∆T/R = Total Resistance Change Stop Strength . . . . . . . . . . . . . . . . . . . . Continuous, no stop Shaft Strength (push) . . . . . . . . . . . . . . . 29.4 N (3 kgf ) min. Shaft Strength (tensile) . . . . . . . . . . . . . 29.4 N (3 kgf ) min. Shaft End Play . . . . . . . . . 0.3(shaft length/15) mm max. Mounting Nut Torque . . . . . . 3.5 kgf • cm (48.52 oz • in) min. Marking . . . . . Model type, taper, resistance code, date code Note: A long life panel control should only be used in a circuit as a potentiometer (3-terminal voltage divider ). TOCOS AMERICA, INC. 86 1177 East Tower Road, Schaumburg, IL 60173 Tel: 847-884-6664 Fax: 847-884-6665 E-mail: [email protected] www.tocos.com RVQ103YN Series Dimensions RVQ103YN Unit: mm Panel Mount, Single Unit, Single Shaft Rear Exit Vertical Lug Terminals, 3-Lug Triangular Pattern Recommended Panel Mounting Hole Part Numbering System RV Q 103 Y N 15 S B 103 M NOTE: FMS = From Mounting Surface Resistance Tolerance: M = 20% (standard). Resistance Code: Expressed in ohms. A three digit code where the first two digits are significant figures, and the third digit indicates the number of zeros that follow these figures (i.e., 100 = 10Ω; 101 = 100Ω; 102 = 1,000Ω; 103 = 10,000Ω ). See table for standard resistance values. Resistance Taper: B = Linear. Shaft End Style: S = Slotted. F = Flatted. R = Round. Standard Shaft Length: 10 = 10mm FMS. 15 = 15mm FMS. Up to 30mm shaft length available (special order ). Style: N = Panel Mount, Single Unit, Single Shaft, Rear Exit Vertical Lug Terminals, 3-Lug Triangular Pattern (standard). P = PCB Mount, Single Unit, Single Shaft, Rear Exit Vertical Mount Pin Terminals, 3-Pin Triangular Pattern (special order ). Operating Temperature Range: Y = 10C to 85C. Size and Style: 10 = 10mm Diameter; 3 = Style of 10mm Size. Rotational Life: Q = Long Life, 200,000 cycles. TOCOS Series Name: RV = Carbon Film Element. Standard Resistance Values and Part Numbering Codes Standard Nominal Total Resistance Values and Part Numbering Codes Resistance ( Ω ) Code Resistance ( Ω ) Code 5,000 502 10,000 103 Refer to Shaft End Styles Specifications and Hardware Specifications for details and availability. For additional information, refer to Guidelines and Precautions for Using Panel Controls. TOCOS AMERICA, INC. 1177 East Tower Road, Schaumburg, IL 60173 Tel: 847-884-6664 Fax: 847-884-6665 87 E-mail: [email protected] www.tocos.com