EVLVIP37LE5V3A Wide range single-output demonstration board based on the VIPER37LE Data brief Features ■ Universal input mains range: – input voltage 90 - 264 VAC – frequency 45 - 65 Hz ■ Single-output voltage: 5 V @ 3 A continuous operation ■ Standby mains consumption: < 30 mW @ 230 VAC ■ Average efficiency: > 75% ■ Complying with EuP Lot 6 requirements ■ Fully protected against faults (overload, overvoltage, transformer saturation and overheating) ■ EMI: according to EN55022-Class-B EVLVIP37LE5V3A protection, brownout protection, hysteretic thermal protection, shorted secondary rectifier detection, and transformer saturation protection: all of which are in auto-restart mode. Description This board implements a 15 W single-output wide range mains power supply to be used as an auxiliary adapter in applications such as LCD, plasma or LED TVs, desktop computers, etc., when the main power supply is OFF or in standby mode and the auxiliary power supply must provide energy only to some specific parts of the equipment such as USB ports, remote receiver, etc. The board uses the new VIPER37LE, an offline high voltage converter from the VIPerPlus family, specifically designed for fixed frequency flyback converters, which combines a high-performance low voltage PWM controller chip and a max. 4.5 Ω RDS(on), 800 V BV(DSS), avalanche-rugged power MOSFET in the same package. The application is optimized for less than 30 mW standby consumption and meets the EPA 2.0 limits, therefore helping to meet the most stringent energy saving requirements. The board implements several protections that considerably increase end-product safety and reliability: overload protection, overvoltage May 2012 Doc ID 023155 Rev 2 For further information contact your local STMicroelectronics sales office. 1/6 www.st.com 6 C6 22nF – X2 2/6 3 4 2 1 Doc ID 023155 Rev 2 R11 33k C10 10nF R12 39k CONT BR R13 47k C11 33nF FB C13 2.2nF OPTO KB817A GND DRAIN U1 VIPER37LE R5 3.3 CONTROL VDD R2 3.9M D5 BAT46RL C7 2.2nF OPTO3 KB817A VR1 TS431 R6 330 C3 1200uF R10 100k C9 10nF R8 12k C4 1200uF R14 39k R9 120k GND C5 100uF EVLVIP37LE5V3A electrical diagram D6 18V C12 22uF R4 150k D4 1N4148 D3 STTH1L06 D1 1.5KE220 5V Figure 1. AC IN R7 220 JMP C14 22nF D7 1N4148 C1 220pF. L1 2.2uH Schematic diagram AC IN + NTC 10 R3 2M R1 2.2M C2 33uF D2 STPS30L40CT 1 F1 1.5 A FUSE CM 2X25mH - BR TF Schematic diagram EVLVIP37LE5V3A AM11341v1 EVLVIP37LE5V3A Output characteristics Figure 2. Line and load regulation 5.15 115Vac 230Vac 5.10 Output voltage [V] 5.05 5.00 4.95 0.0 0.5 1.0 1.5 2.0 2.5 3.0 3.5 Output current [mA] AM11343v1 Figure 3. No load consumption 65 60 No brownout With brownout 55 50 Input power [mW] 2 Output characteristics 45 40 35 30 25 20 15 10 50 100 150 200 Input voltage [Vac] Doc ID 023155 Rev 2 250 300 AM11345v1 3/6 Output characteristics Figure 4. EVLVIP37LE5V3A Efficiency 79 78 Efficiency [%] 77 76 EPA 2.0 limit 75 115Vac 230Vac average @115Vac average @230Vac 74 73 72 0 2 4 6 8 10 Output power [W] 4/6 Doc ID 023155 Rev 2 12 14 16 AM11344v1 EVLVIP37LE5V3A 3 Revision history Revision history Table 1. Document revision history Date Revision Changes 26-Apr-2012 1 Initial release. 16-May-2012 2 Updated features list in cover page. Updated Figure 1: EVLVIP37LE5V3A electrical diagram on page 2 Doc ID 023155 Rev 2 5/6 EVLVIP37LE5V3A Please Read Carefully: Information in this document is provided solely in connection with ST products. STMicroelectronics NV and its subsidiaries (“ST”) reserve the right to make changes, corrections, modifications or improvements, to this document, and the products and services described herein at any time, without notice. All ST products are sold pursuant to ST’s terms and conditions of sale. Purchasers are solely responsible for the choice, selection and use of the ST products and services described herein, and ST assumes no liability whatsoever relating to the choice, selection or use of the ST products and services described herein. No license, express or implied, by estoppel or otherwise, to any intellectual property rights is granted under this document. If any part of this document refers to any third party products or services it shall not be deemed a license grant by ST for the use of such third party products or services, or any intellectual property contained therein or considered as a warranty covering the use in any manner whatsoever of such third party products or services or any intellectual property contained therein. UNLESS OTHERWISE SET FORTH IN ST’S TERMS AND CONDITIONS OF SALE ST DISCLAIMS ANY EXPRESS OR IMPLIED WARRANTY WITH RESPECT TO THE USE AND/OR SALE OF ST PRODUCTS INCLUDING WITHOUT LIMITATION IMPLIED WARRANTIES OF MERCHANTABILITY, FITNESS FOR A PARTICULAR PURPOSE (AND THEIR EQUIVALENTS UNDER THE LAWS OF ANY JURISDICTION), OR INFRINGEMENT OF ANY PATENT, COPYRIGHT OR OTHER INTELLECTUAL PROPERTY RIGHT. UNLESS EXPRESSLY APPROVED IN WRITING BY TWO AUTHORIZED ST REPRESENTATIVES, ST PRODUCTS ARE NOT RECOMMENDED, AUTHORIZED OR WARRANTED FOR USE IN MILITARY, AIR CRAFT, SPACE, LIFE SAVING, OR LIFE SUSTAINING APPLICATIONS, NOR IN PRODUCTS OR SYSTEMS WHERE FAILURE OR MALFUNCTION MAY RESULT IN PERSONAL INJURY, DEATH, OR SEVERE PROPERTY OR ENVIRONMENTAL DAMAGE. ST PRODUCTS WHICH ARE NOT SPECIFIED AS "AUTOMOTIVE GRADE" MAY ONLY BE USED IN AUTOMOTIVE APPLICATIONS AT USER’S OWN RISK. Resale of ST products with provisions different from the statements and/or technical features set forth in this document shall immediately void any warranty granted by ST for the ST product or service described herein and shall not create or extend in any manner whatsoever, any liability of ST. ST and the ST logo are trademarks or registered trademarks of ST in various countries. Information in this document supersedes and replaces all information previously supplied. The ST logo is a registered trademark of STMicroelectronics. All other names are the property of their respective owners. © 2012 STMicroelectronics - All rights reserved STMicroelectronics group of companies Australia - Belgium - Brazil - Canada - China - Czech Republic - Finland - France - Germany - Hong Kong - India - Israel - Italy - Japan Malaysia - Malta - Morocco - Philippines - Singapore - Spain - Sweden - Switzerland - United Kingdom - United States of America www.st.com 6/6 Doc ID 023155 Rev 2