5 PIN SOP HIGH SPEED 10MBit/s LOGIC GATE PHOTOCOUPLER ELM6XX series Features: • High speed 10Mbit/s • Guaranteed performance from -40 to 85 • Logic gate output • High isolation voltage between input and output (Viso=3750 V rms ) • Pb free and RoHS compliant. • UL approved (No. 214129) • VDE approved (No. 132249) • SEMKO approved • NEMKO approved • DEMKO approved • FIMKO approved • CSA approved (No. 2037145) ℃ Schematic Description The ELM600, ELM601 and ELM611 are consists of an infrared emitting diode optically coupled to a high speed integrated photo detector logic gate with a strobable output. The devices are packaged in a 5-pin small outline package which conforms to the standard footprint. Applications • Ground loop elimination Pin Configuration • LSTTL to TTL, LSTTL or 5 volt CMOS 1, Anode • Line receiver, data transmission 3, Cathode • Data multiplexing 4, Gnd • Switching power supplies 5, Vout • Pulse transformer replacement 6, VCC • Computer peripheral interface Truth Table Input Output H L L H Everlight Electronics Co., Ltd. Document No DPC-0000114 ： 1 Rev. 1 http://www.everlight.com October 3, 2011 5 PIN SOP HIGH SPEED 10MBit/s LOGIC GATE PHOTOCOUPLER ELM6XX series Absolute Maximum Ratings (Ta=25°C) Parameter Symbol Rating Unit Forward current IF 50 mA Reverse voltage VR 5 V Power dissipation PD 100 mW Power dissipation PC 85 mW Output current IO 50 mA Output voltage VO 7.0 V Supply voltage VCC 7.0 V PO 85 mW VISO 3750 V rms Operating temperature TOPR -40 ~ +85 °C Storage temperature TSTG -55 ~ +125 °C TSOL 260 °C Input Output Output Power Dissipation Isolation voltage *1 Soldering temperature *2 Notes *1 AC for 1 minute, R.H.= 40 ~ 60% R.H. In this test, pins 1 & 3 are shorted together, and pins 4 , 5 & 6 are shorted together. *2 For 10 seconds. Everlight Electronics Co., Ltd. Document No DPC-0000114 ： 2 Rev. 1 http://www.everlight.com October 3, 2011 5 PIN SOP HIGH SPEED 10MBit/s LOGIC GATE PHOTOCOUPLER ELM6XX series Electrical Characteristics (Ta=-40 to 85°C unless specified otherwise) Input Parameter Symbol Min. Typ.* Max. Unit Forward voltage VF - 1.45 1.8 V IF = 10mA Reverse voltage VR 5.0 - - V IR = 10µA, TA=25 ∆VF/∆TA - -1.9 - mV/°C CIN - 70 - pF Symbol Min. Typ.* Max. Unit Condition High level supply current ICCH - 6.0 9 mA IF=0mA, VCC=5.5V Low level supply current ICCL - 7.5 10 mA IF=10mA, VCC=5.5V Parameter Symbol Min. Typ.* Max. Unit HIGH Level Output Current IOH - 2.1 30 uA VCC=5.5V, VO=5.5V, IF=250uA LOW Level Output Current VOL - 0.4 0.6 V VCC = 5.5V, IF=5mA, ICL(Sinking)=13mA Input Threshold Current IFT - 2.4 5 mA VCC= 5.5V, VO=0.6V, IOL(Sinking)=13mA Temperature coefficient of forward voltage Input capacitance Condition ℃ IF =10mA VF=0, f=1MHz Output Parameter Transfer Characteristics Everlight Electronics Co., Ltd. Document No DPC-0000114 ： 3 Rev. 1 Condition http://www.everlight.com October 3, 2011 5 PIN SOP HIGH SPEED 10MBit/s LOGIC GATE PHOTOCOUPLER ELM6XX series Switching Characteristics (Ta=-40 to 85°C, VCC=5V, IF=7.5mA unless specified otherwise) Parameter Symbol Min. Typ.* Max. Unit TPHL - 41 100 ns CL = 15pF, RL=350Ω, TA=25°C TPLH - 50 100 ns CL = 15pF, RL=350Ω, TA=25°C |Tphl – Tplh| - 9 35 ns CL = 15pF, RL=350Ω tPSK - - 40 ns CL = 15pF, RL=350Ω Output rise time (Fig.12) tr - 40 - ns CL = 15pF, RL=350Ω Output fall time (Fig.12) tf - 10 - ns CL = 15pF, RL=350Ω - - - Propagation delay time to 3 output High level* (Fig.12) Propagation delay time to 3 output Low level* (Fig.12) Pulse width distortion Propagation Delay Skew* 4 M600 Common Mode Transient Immunity at Logic *6 High (Fig.14) Common Mode Transient Immunity at Logic *7 Low (Fig.14) M601 CMH 5,000 M611 20,000 M600 - M601 CML M611 V/µS - - V/µS 5,000 20,000 Condition IF = 7.5mA , VOH=2.0V, RL=350Ω, TA=25°C VCM=10Vp-p IF = 7.5mA , VOH=2.0V, RL=350Ω, TA=25°C VCM=50Vp-p IF = 7.5mA , VOH=2.0V, RL=350Ω, TA=25°C VCM=1000Vp-p IF = 0mA , VOL=0.8V, RL=350Ω, TA=25°C VCM=10Vp-p IF = 0mA , VOL=0.8V, RL=350Ω, TA=25°C VCM=50Vp-p IF = 0mA , VOL=0.8V, RL=350Ω, TA=25°C VCM=1000Vp-p *All typicals at Ta = 25°C, VCC = 5 V. Everlight Electronics Co., Ltd. Document No DPC-0000114 ： 4 Rev. 1 http://www.everlight.com October 3, 2011 5 PIN SOP HIGH SPEED 10MBit/s LOGIC GATE PHOTOCOUPLER ELM6XX series Typical Performance Curves Everlight Electronics Co., Ltd. Document No DPC-0000114 ： 5 Rev. 1 http://www.everlight.com October 3, 2011 5 PIN SOP HIGH SPEED 10MBit/s LOGIC GATE PHOTOCOUPLER Everlight Electronics Co., Ltd. Document No DPC-0000114 ： 6 Rev. 1 ELM6XX series http://www.everlight.com October 3, 2011 5 PIN SOP HIGH SPEED 10MBit/s LOGIC GATE PHOTOCOUPLER ELM6XX series Fig. 11 Test circuit and waveforms for tPHL, tPLH, tr, and tf IF=7.5mA Input (IF) IF=3.75mA tPHL tPLH Output (Vo) 1.5V 90% Output (Vo) 10% tf tr Fig. 12 Test circuit Common mode Transient Immunity Peak VC M 5V Vo Switching Pos. (A), IF=0 CM H VO(Mi VO(Ma Switching Pos. (B), VC I =7.5mA 0.5V Notes: *3 The tPLH propagation delay is measured from 3.75 mA point on the falling edge of the input pulse to the 1.5V point on the rising edge of the output pulse. *4 The tPHL propagation delay is measured from 3.75 mA point on the rising edge of the input pulse to the 1.5 V point on the falling edge of the output pulse *5 tPSK is equal to the magnitude of the worst case difference in tPHL and/or tPLH that will be seen between units at any given temperature within the worst case operating condition range. *6 CMH– The maximum tolerable rate of rise of the common mode voltage to ensure the output will remain in the HIGH state (i.e., VOUT > 2.0V). *7 CML– The maximum tolerable rate of fall of the common mode voltage to ensure the output will remain in the LOW output state (i.e., VOUT < 0.8V). Everlight Electronics Co., Ltd. Document No DPC-0000114 ： 7 Rev. 1 http://www.everlight.com October 3, 2011 CML 5 PIN SOP HIGH SPEED 10MBit/s LOGIC GATE PHOTOCOUPLER ELM6XX series Order Information Part Number ELM6XX(Z)-V Note XX = Part no.(00, 01 or 11) Z = Tape and reel option (TA, TB or none). V = VDE (optional) Option Description Packing quantity None Standard DIP-8 100 units per tube (TA) Surface mount lead form + TA tape & reel option 3000 units per reel (TB) Surface mount lead form + TB tape & reel option 3000 units per reel Everlight Electronics Co., Ltd. Document No DPC-0000114 ： 8 Rev. 1 http://www.everlight.com October 3, 2011 5 PIN SOP HIGH SPEED 10MBit/s LOGIC GATE PHOTOCOUPLER ELM6XX series Package Drawing (Dimensions in mm) Recommended pad layout for surface mount leadform Everlight Electronics Co., Ltd. Document No DPC-0000114 ： 9 Rev. 1 http://www.everlight.com October 3, 2011 5 PIN SOP HIGH SPEED 10MBit/s LOGIC GATE PHOTOCOUPLER ELM6XX series Device Marking EL M611 YWWV Notes M611 denotes Device Number Y denotes 1 digit Year code WW denotes 2 digit Week code V denotes VDE (optional) Everlight Electronics Co., Ltd. Document No DPC-0000114 ： 10 Rev. 1 http://www.everlight.com October 3, 2011 5 PIN SOP HIGH SPEED 10MBit/s LOGIC GATE PHOTOCOUPLER ELM6XX series Tape & Reel Packing Specifications Option TA Option TB Direction of feed from reel Direction of feed from reel Tape dimensions Dimension No. A B Do D1 E F Dimension(mm) 10.4±0.1 10.0±0.1 1.5±0.1 1.5±0.1 1.75±0.1 7.5±0.1 Dimension No. Po P1 P2 t W K Dimension(mm) 4.0±0.1 12.0±0.1 2.0±0.1 0.4±0.1 Everlight Electronics Co., Ltd. Document No DPC-0000114 ： 11 Rev. 1 16.0+0.3/ -0.1 4.5±0.1 http://www.everlight.com October 3, 2011 5 PIN SOP HIGH SPEED 10MBit/s LOGIC GATE PHOTOCOUPLER ELM6XX series Solder Reflow Temperature Profile 260 °C (peak,10 Sec Max) >255 °C ( 30s Max ) 217°° 200°° 1-3 °C/Sec 60 – 100 Sec 150°° 60 – 140 Sec 1-3 °C/Sec TIME (S) Everlight Electronics Co., Ltd. Document No DPC-0000114 ： 12 Rev. 1 http://www.everlight.com October 3, 2011 5 PIN SOP HIGH SPEED 10MBit/s LOGIC GATE PHOTOCOUPLER ELM6XX series DISCLAIMER 1. Above specification may be changed without notice. EVERLIGHT will reserve authority on material change for above specification. 2. When using this product, please observe the absolute maximum ratings and the instructions for using outlined in these specification sheets. EVERLIGHT assumes no responsibility for any damage resulting from use of the product which does not comply with the absolute maximum ratings and the instructions included in these specification sheets. 3. These specification sheets include materials protected under copyright of EVERLIGHT corporation. Please don’t reproduce or cause anyone to reproduce them without EVERLIGHT’s consent. Everlight Electronics Co., Ltd. Document No DPC-0000114 ： 13 Rev. 1 http://www.everlight.com October 3, 2011