PC/104 CPU Modules PCM-4153 NEW Battery Pin AMD LX800 PC/104-Plus Module, w/ Onboard Memory/Flash and Wide Temperature Range Features Power con AMD low power LX800/500 MHz Processor Clear CMOS Inverter con LCD con Standby power con LAN 2 LAN 1 Supports dual 10/100 Mbps Ethernet 1 GB Flash & 512MB DDR memory onboard Supports three RS-232, one RS-232/422/485, and four USB 2.0 ports Supports Embedded Software API and Utility USB USB 4 COM port IDE LPT con Software APIs: LIN-out SMBus H/W Monitor Brightness Watchdog KB/MS Line-in/MIC GPIO Backlight On/Off Utility: RS422/485 BIOS flash Monitoring Specifications General I/O Ethernet CPU 2nd Cache Memory System Chipset BIOS System Memory Power Management SSD Flash Watchdog Timer Expansion Interface Battery I/O Interface USB Audio GPIO Chipset Speed Interface Chipset Memory Size Display Resolution Mechanical and Environmental Power Dimensions (L x W) Weight Operating Temperature Operating Humidity Power Supply Voltage Power Consumption AMD Geode™ LX800, 500 MHz 128 KB on processor AMD Geode LX800 AWARD® 4-Mbit Flash BIOS 512 MB DDR333 SDRAM onboard APM 1.2 1 GB Flash Onboard 255-level interval timer, setup by software. 104-pin 16-bit PC/104 module connector and 120-pin PCI PC/104-Plus module connector Lithium 3 V/196 mAH 1 x EIDE, 1 x LPT, 1 x RS-232/422/485, 3 x RS232, 1 x K/B, 1 x Mouse 4 x USB 2.0 Supports AC97 audio stereo sound 8-bit general purpose Input/Output Intel 82551ER 10/100 Mbps 2 x internal box header AMD Geode LX800 Optimized Shared Memory Architecture, supports 64 MB frame buffer using system memory CRT display mode: pixel resolution up to 1920 x 1440 x 32 bpp at 85 Hz, 1600 x 1200 x 16 bpp at 100 Hz and up to 1024 x 768 x 32 bpp at 60 Hz for TFT LCD LCD Interface: 18/24 bit TTL interface Dual simultaneous display: CRT + LCD 96 mm x 115 mm 0.162 kg (with heat sink) 0 ~ 60° C (32 ~ 140° F) 0% ~ 90% relative humidity, non-condensing AT: 5V only to boot up (12 V is optional for LCD inverter and add on card) (Geode LX800, 256 MB DDR333) Max (Test in HCT): +5 V @ 1.51 A, +12 V @ 0.1 A Typical (WinXP Idle Mode): +5 V @ 1.35 A, +12 V @ 0.1 A Embedded Single Board Computers All product specifications are subject to change without notice Last updated : 09-Nov-2009 PCM-4153 Board Diagram LCD Connector (DF13-40P) PC104 Connector 24 Bit TTL Analog RGB VGA Box Header DDR400 DDR SDRAM On-board 512MB AMD Geode LX800 PCI BUS PCI to ISA Bridge IT8888G PC104+ Connector Master IDE / DMA33 IDE On-board 1GB flash memory GPIO USB 2.0 Box Header 10/100 LAN 82551ER Box Header USB 2.0 x 4 port AC-Link AMD Geode CS5536 / CS5535 Slave 10/100 LAN 82551ER ALC203 SMBus PCA9554 LPC Bus BIOS COM1/COM2 COM3/COM4 PS/2 KB&MS LPC Super I/O (SCH3114) Watchdog LPT Box Header Ordering Information Part No. CPU Chipset AMD PCM-4153F-L0A2E CS5536 LX800 AMD PCM-4153FZ-L0A2E CS5536 LX800 AMD PCM-4153FZ2-L0A2E CS5536 LX800 Onboard Memory CRT TTL USB2.0 RS-232 RS-232/ LPT/ Onboard 422/485 KB/MS Flash Audio PC/104+ connector Thermal Solution 512 MB Yes 18/24 bit - 2 FE 4 3 1 Yes 1 GB Yes Yes Passive 512 MB Yes 18/24 bit - 2 FE 4 3 1 Yes 1 GB Yes Yes Passive 512 MB Yes 18/24 bit - 2 FE 4 3 1 Yes 1 GB Yes Yes Passive LVDS LAN Packing List Part No. 1700003491 1700000918 1701400181 1703040157 1703060053 1700060202 1700005158 1700260250 1701440350 1700000898 1703100121 Description 1 x PCM-4153 SBC 1 x Wire AT Power cable 1 x Audio cable 1 x Four COM cable 1 x RS-422/485 COM cable 1 x Keyboard/Mouse cable 1 x Y cable (for KB/MS extension) 2 x Ethernet RJ-45 Conn. conversion cable 1 x LPT port cable 1 x IDE cable 1 x VGA cable 2 x USB cable (bracket type with two USB ports) 1 x Startup manual 1 x CD-ROM (Manual, Driver, Utility) Online Download www.advantech.com/products Operating Temp. ETT Embedded Service OS WinCE 0 ~ 60° C (optional) WinCE -20 ~ 80° C (optional) WinCE -40 ~ 85° C (optional) Value-Added Software Services Software API: An interface that defines the ways by which an application program may request services from libraries and/or operating systems. Provides not only the underlying drivers required but also a rich set of user-friendly, intelligent and integrated interfaces, which speeds development, enhances security and offers add-on value for Advantech platforms. It plays the role of catalyst between developer and solution, and makes Advantech embedded platforms easier and simpler to adopt and operate with customer applications. Software APIs Control GPIO SMBus I2C Monitor General Purpose Input/Output is a flexible parallel interface that allows a variety of custom connections. It allows users to monitor the level of signal input or set the output status to switch on/off a device. Our API also provides Programmable GPIO, which allows developers to dynamically set the GPIO input or output status. SMBus is the System Management Bus defined by Intel® Corporation in 1995. It is used in personal computers and servers for low-speed system management communications. The SMBus API allows a developer to interface a embedded system environment and transfer serial messages using the SMBus protocols, allowing multiple simultaneous device control. I2C is a bi-directional two wire bus that was developed by Philips for use in their televisions in the 1980s. The I2C API allows a developer to interface with an embedded system environment and transfer serial messages using the I2C protocols, allowing multiple simultaneous device control. Display Watchdog Hardware Monitor Hardware Control A watchdog timer (WDT) is a device that performs a specific operation after a certain period of time if something goes wrong and the system does not recover on its own. A watchdog timer can be programmed to perform a warm boot (restarting the system) after a certain number of seconds. The Hardware Monitor (HWM) API is a system health supervision API that inspects certain condition indexes, such as fan speed, temperature and voltage. The Hardware Control API allows developers to set the PWM (Pulse Width Modulation) value to adjust fan speed or other devices; it can also be used to adjust the LCD brightness. Power Saving Make use of Intel SpeedStep technology to reduce power power consumption. The system will automatically adjust the CPU Speed depending on system loading. The Brightness Control API allows a developer to interface with an embedded device to easily control brightness. Brightness Control CPU Speed The Backlight API allows a developer to control the backlight (screen) on/off in an embedded device. System Throttling Backlight Refers to a series of methods for reducing power consumption in computers by lowering the clock frequency. These APIs allow the user to lower the clock from 87.5% to 12.5%. Software Utilities BIOS Flash The BIOS Flash utility allows customers to update the flash ROM BIOS version, or use it to back up current BIOS by copying it from the flash chip to a file on customers’ disk. The BIOS Flash utility also provides a command line version and API for fast implementation into customized applications. Embedded Security ID The embedded application is the most important property of a system integrator. It contains valuable intellectual property, design knowledge and innovation, but it is easily copied! The Embedded Security ID utility provides reliable security functions for customers to secure their application data within embedded BIOS. Monitoring The Monitoring utility allows the customer to monitor system health, including voltage, CPU and system temperature and fan speed. These items are important to a device; if critical errors happen and are not solved immediately, permanent damage may be caused. eSOS The eSOS is a small OS stored in BIOS ROM. It will boot up in case of a main OS crash. It will diagnose the hardware status, and then send an e-mail to a designated administrator. The eSOS also provides remote connection: Telnet server and FTP server, allowing the administrator to rescue the system. Flash Lock Flash Lock is a mechanism that binds the board and CF card (SQFlash) together. The user can “Lock” SQFlash via the Flash Lock function and “Unlock” it via BIOS while booting. A locked SQFlash cannot be read by any card reader or boot from other platforms without a BIOS with the “Unlock” feature. Embedded Single Board Computers All product specifications are subject to change without notice Last updated : 09-Nov-2009