BTCPower TM Broadband TelCom Power, Inc. Redefining “Current” Limits In Power Conversion 2EE Series 15W DC-DC Converters Features • • • • • • 15W Isolation output 2:1 Input Range Six-sided Shield Remote On/Off Control Efficiency To 84% 200KHz switching frequency Model Number 2EE-01 2EE-02 2EE-03 2EE-04 2EE-05 2EE-06 2EE-07 2EE-08 2EE-11 2EE-12 2EE-13 2EE-14 2EE-15 2EE-16 2EE-17 2EE-18 2EE-21 2EE-22 2EE-23 2EE-24 2EE-25 2EE-26 2EE-27 2EE-28 Input Voltage 9-18 VDC 18-36 VDC 36-72 VDC Output Voltage Output Current Input Current No Load Full Load 5 VDC 3000 mA 12 VDC 1250 mA 15 VDC 1000 mA ±12 VDC ±625mA ±15 VDC ±500mA 5/±12 VDC 1500/±310 mA 5/±15 VDC 1500/±250 mA +5/+12/-5 VDC 1500/310/500 mA 20 20 20 35 35 30 30 30 5 VDC 3000 mA 12 VDC 1250 mA 15 VDC 1000 mA ±12 VDC ±625mA ±15 VDC ±500mA 5/±12 VDC 1500/±310 mA 5/±15 VDC 1500/±250 mA +5/+12/-5 VDC 1500/310/500 mA 5 VDC 3000 mA 12 VDC 1250 mA 15 VDC 1000 mA ±12 VDC ±625mA ±15 VDC ±500mA 5/±12 VDC 1500/±310 mA 5/±15 VDC 1500/±250 mA +5/+12/-5 VDC 1500/310/500 mA mA mA mA mA mA mA mA mA % Efficiency 1700 mA 1600 mA 1600 mA 1520 mA 1520 mA 1600 mA 1600 mA 1470 mA 77 78 78 82 82 78 78 78 25 mA 25 mA 25 mA 25 mA 25 mA 25 mA 25 mA 25 mA 810 mA 780 mA 780 mA 750 mA 750 mA 780 mA 780 mA 715 mA 77 80 80 84 84 80 80 80 10 10 10 15 15 15 15 15 410 mA 390 mA 390 mA 380 mA 380 mA 380 mA 380 mA 350 mA 77 80 80 82 82 82 82 82 mA mA mA mA mA mA mA mA Case E E E Note: Nominal Input Voltage 12, 24, 28 or 48VDC Broadband TelCom Power, Inc. – 1719 S. Grand Avenue, Santa Ana, CA 92705 U.S.A. Tel.: 714-259-4888 • Fax: 714-259-0840• www.btcpower.com • Email: [email protected] DS LP 2EE Rev2 16-1-04 2EE Series BTCPower 15W DC-DC Converters TM Specifications Input Specifications: Input Voltage Range…………….……12V……...………………..9-18V 24V……………………..18-36V 48V…………………......36-72V Input Filter………………………………………………………..Pi Type Output Specifications: Voltage Accuracy Single output………………………..…………………….+/- 1.0 % max. Daul output………………………………………………..+/- 3.0 % max. Triple, 5V………………………………………………….+/- 2.0 % max. 12V/15V…………………………………………..………+/- 3.0 % max. Voltage Balance ( Dual )………………………………...+/- 1.0 % max. External trim Adj. Range……………………………..…………+/- 10% Ripple & Noise, 20 MHz BW……………………….… 75 mV p-p max. Temperature Coeffcient………………………… +/- 0.02 % / ºC max. Short Circuit Protection………………………………..……Continuous Line Regulation ¹ Single / Dual Output………….……..+/- 0.2 % max. Triple………………………….………..+/- 1.0% max. Load Regulation ² Single / Dual Output…………….….+/- 1.0 % max. Triple………………………..…………+/- 5.0 % max. General Specifications : Efficiency………………………………………………..……..see table Isolation Resistance…………………………………………..100Mohm Switching Frequency……………………………………..200 KHz, min. Operating Temperature Range…………………………-25ºC ~ +71ºC Case Temperature………………………………………….100 ºC max. Cooling……………………………………………….Free air convection Storage Temperature Range……………………..…..-55 ºC ~ +105ºC Isolation Voltage………………………….………………..500VDC min. EMI/RFI…………………………………….....Six-sided continus shield Dimensions…………………2.65” x3” x 0.83 “(65 x 76.2 x 21.1 mm) Case Material……..Black Coated Copper with Non-conducted base Triple output loading table Ouput (pin no.) 6 3&5 3&5 3&5 Voltage (V) +5 +12 or -12 +15 or -15 +12 or -5 Amperes Min. (2) Nom. 0.25 1.5 0.1 0.31 0.1 0.25 0.1/0.1 0.31/0.5 Note: 1. measured from high lin to low line 2. measured from full load to ¼ load 3. maximum total power from all outputs is limited to 15W but no output should be allowed to exceed its maximum current 4. minmum current on each output is required to maintain specified regulation Outline Information and Pin-out Pin Connection Pin 1 2 3 4 5 6 7 8 Single +Input -Input No pin Trim No pin +Output -Output Dual Triple +Input +Input -Input -Input +Output +Output Common Common -Output -Output No pin +5V output No pin No pin Remote On/Off Control Remote On/Off Control Logic compatibility CMOS or Open collector TTL Ec-0n >5.5 Vdc or open circuit Ec-Off <1.8 Vdc Shutdown Idle current 10mA Input resistance 100K ohms (Ein 0Vdc to 9Vdc) Control common referenced to Input minus External Output Trimming Output may optionally be externally trimmed (+/-10%) with a fixed resistor or an external trimpot as shown. Broadband TelCom Power, Inc. – 1719 S. Grand Avenue, Santa Ana, CA 92705 U.S.A. Tel.: 714-259-4888 • Fax: 714-259-0840• www.btcpower.com • Email: [email protected] DS LP 2EE Rev2 16-1-04