CAPACITORS ALUMINIUM ELECTROLYTIC LOW IMPEDANCE DJ4X Low impedance for high frequency SECTION 1 Radial type for switching power supplies Up to 3000 hours load life at 105°C SPECIFICATION Item Performance Characteristics Operating Temperature Range -40° to +105°C Rate Working Voltage Range 6.3 to 100V Nominal Capacitance Range 4.7 to 15000µF Capacitance Tolerance -20 to +20% Leakage Current (+20˚C) I = 0.01 CV(µA) or 3µA Whichever is greater. ( Measurements shall be Made After a 2 Minute Charge at Rated Working Voltage ) Dissipation Factor Working voltage [VDC] 6.3 10 16 25 35 50 63 80 100 (120Hz, +20˚C) D.F. Max. (%) 15 14 12 10 10 8 8 7 7 For capacitor whose capacitance exceeds 2000µF. The value of D.F(%) is increased by 2% for every addition of 1000µF. Load Life 3000 Hours at 105°C Assured with Full Rated Maximum Ripple Current Applied 5 x 11 to 10 x 12 : Life = 2000 Hours 10 x 15 or Higher : Life = 3000 Hours Shelf Life (a)Capacitance Change : Within 20% of Initial Value (b) Dissipation Factor : NotExceed200% of Initial Requirement (c)Leakage Current : NotExceed the Initial Requirement 1000 Hours, No Voltage Applied, at 105°C (a)Capacitance Change : Within 20% of Initial Value (b) Dissipation Factor : NotExceed200 % of Initial Requirement (c)Leakage Current : NotExceed200% of Initial Requirement ORDERING INFORMATION DJ4X 100 16 TA Range Capacitance µf Voltage Options TA = Tape/Ammo Blank = Loose TA = 5mm pitch For others add pitch e.g. TA 2mm = 2mm pitch. 51 Fax: 01371 875075 www.dubilier.co.uk Tel: 01371 875758 CAPACITORS ALUMINIUM ELECTROLYTIC LOW IMPEDANCE DJ4X SECTION 1 OUTLINE DRAWING L + 1 max. 15 min. 5 min. F ± 0.5 Safety Device Dø 5 6.3 8 F 2.0 2.5 3.5 dø 0.5 Rubber end seal Vinyl Sleeve 10 13 16 5.0 5.0 7.5 0.6 D ± 0.5 18 22 7.5 10.0 0.8 52 Fax: 01371 875075 www.dubilier.co.uk Tel: 01371 875758 CAPACITORS ALUMINIUM ELECTROLYTIC LOW IMPEDANCE DJ4X MAXIMUM IMPEDANCE (UNITΩ, 100 KHz AT 20˚C) UF/Volts 6.3v 10v 16v 25v 35v 50v 63v 100v UF/ Volts 0.47uf 16v 25v 35v 50v 63v 100v 1.0uf 2.2uf 2.2uf 3.3uf 3.3uf 4.7uf 5x11 5x11 5x11 5x11 10uf 5x11 5x11 5x11 6.3x11 22uf 5x11 5x11 5x11 6.3x11 8x12 33uf 5x11 5x11 6.3x11 6.3x11 8x16 47uf 5x11 5x11 6.3x11 6.3x11 8x12 10x16 100uf 5x11 5x11 6.3x11 6.3x11 8x12 8x16 10x12 13x20 220uf 6.3x11 8x12 8x12 8x15 10x20 10x20 13x20 16x25 330uf 8x12 8x12 8x16 10x15 10x20 13x20 13x20 16x32 470uf 8x12 8x16 10x15 10x16 13x25 13x25 13x25 18x36 10x17 10x20 10x25 13x20 2200uf 13x21 13x25 13x25 13x36 3300uf 13x30 13x30 16x25 16x36 4700uf 10v 0.47uf 1.0uf 1000uf 6.3v 16x25 16x25 18x26 16x25 18x40 16x25 4.7uf 1.2 2 2.2 2 10uf 0.9 1.7 1.85 1.5 22uf 0.51 0.58 0.7 1.2 0.79 33uf 0.58 0.58 0.6 0.096 0.59 0.58 0.58 0.37 0.52 0.7 0.35 47uf 16x36 18x40 18x36 100uf 0.58 0.58 0.37 0.22 0.14 0.25 0.344 0.16 220uf 0.32 0.22 0.14 0.1 0.08 0.06 0.128 0.071 330uf 0.22 0.14 0.1 0.08 0.044 0.045 0.128 0.049 470uf 0.13 0.1 0.082 0.06 0.046 0.06 0.064 0.038 1000uf 0.08 0.05 0.046 0.038 0.03 0.039 0.036 2200uf 0.043 0.047 0.028 0.022 0.019 0.025 3300uf 0.035 0.026 0.024 0.019 4700uf 0.028 0.028 0.024 0.019 FREQUENCY COEFFICIENT MAXIMUM RIPPLE CURRENT (UNIT mA, rms, 100 KHz AT 105˚C) UF/ Volts 6.3v 10v 16v 25v 35v 50v 63v 100v 0.47uf 1.0uf 2.2uf 3.3uf 4.7uf 115 115 115 120 10uf 140 140 140 200 22uf 60 190 200 115 300 33uf 100 200 295 115 145 210 150 250 295 232 550 47uf 100uf 210 150 250 250 450 550 288 730 220uf 250 300 550 750 800 1220 690 1400 330uf 400 550 750 865 1050 1690 690 1550 470uf 550 750 800 1210 1300 1400 1550 1700 1790 1000uf 865 1100 1250 1450 1700 1900 2200uf 1450 1330 2000 2740 1960 2800 3300uf 1700 2000 2200 2550 4700uf 1800 2200 2770 2800 Frequency (Hz) 50 120 300 1K 10K 100K 4.7uF 0.30 0.40 0.50 0.70 0.80 100 5.6 to 33uF 0.40 0.50 0.60 0.80 0.90 100 34 to 330uF 0.60 0.70 0.80 0.90 0.95 100 331 to 1000uF 0.65 0.80 0.90 0.98 1.00 100 1200uF Higher 0.85 0.90 0.95 0.98 1.00 100 TEMPERATURE COEFFICIENT Temperature ( C ) 65 85 105 Factor 1.80 1.50 1.00 53 Fax: 01371 875075 www.dubilier.co.uk Tel: 01371 875758 SECTION 1 CASE SIZE TABLE (mm)