Embedded Power for Business-Critical Continuity Rev. 05.23.07 AIF Series 1 of 2 AIF Series RoHS 600 Watts Total Power: 600 Watts (12V@50Amps) Input Voltage: 300V # of Outputs: Single Electrical Specifications Input Special Features • 600W Continuous power at 100°C baseplate temperature • 108W/in3 (6.6W/cm3) • High efficiency - up to 90% • Low output ripple and noise • Positive and Negative enable function • Excellent transient response • OVP, OCP, V Adj control with ALPTM analog mode linear control, or through I2C bus with digital mode control. • Paralleable with accurate current sharing • EU Directive 2002/95/EC compliant for RoHS 250 - 420 VDC 450V / 100ms 90%@5.0V (Typical) Output Load Regulation Line Regulation Noise / Ripple Remote sense 0.2% typical down to no load 0.2% typical 100mV typical (below 5V); 2% typical (5V and above) Up to 0.5V Output voltage adjust range +/-20% for 5V and above; +10%/ -50% for below 5V Transient Response 5% max for 3.3V and above, 150mV for 1.8V, deviation with 25% to 75% full load 250 μS (max) recovery 3% typical 115% Vo (nominal) 115% Io maximum Current Share Accuracy Overvoltage Protection Current Limit Control Voltage Adjust 80 to 120% Vo linear programming for 12V, 15V, 24V, 48V 50% to 110% for 1.8V - 5.0V Enable TTL compatible (positive & negative enable options) Current Limit Adjust 20 to 100% Io linear programming or digital mode control Clock Input (external sync) 3.3 to 5.5Vp-p @ 800KHz ±10% Clock Output (internal clock) 4.5Vp-p typical@ 800KHz ±5% Power Good Identification High (Vo) = power good Temperature Monitor Output 10mV/°K (2.73 = 0°C) Current Monitor Output 0 to 1mA (1mA = 100% Io rated) Over Voltage Protection Adjust Safety UL cUL TUV CE Input range Input surge Efficiency 110 to 150% Vo linear programming by voltage or resistor, or digital mode control Notes 60950 Recognized 60950 Recognized EN60950 Licensed CE Mark Nominal values apply with sense pins connected and other control pin unconnected. ALP: Astec Linear Programming Embedded Power for Business-Critical Continuity Americas Environmental Specifications Operating temperature Start up temperature Storage temperature Overtemperature protection Input Voltage Output Voltage Efficiency 300V 1.8V @ 120A 80% (Typ) 300V 3.3V @ 120A 87% (Typ) 300V 5.0V @ 80A 90% (Typ) 300V 12V @ 50A 90% (Typ) 300V 15V @ 40A 90% (Typ) 300V 24V @ 25A 90% (Typ) 1. For Negative enable, add suffix “-N”. 2. For Non-thread hole, add suffix “-NT”. 3. For RoHS 6, add suffix “-L”. Default is RoHS 5. Mechanical Drawing 5810 Van Allen Way Carlsbad, CA 92008 USA Telephone: +1 760 930 4600 Facsimile: +1 760 930 0698 -20°C to +100°C (case temperature) -40°C to +100°C (case temperature) -40°C to +125°C 110°C max Europe (UK) Pin Assignments Ordering Information Model Number AIF120Y300 AIF120F300 AIF80A300 AIF50B300 AIF40C300 AIF25H300 Input (AC) Rev. 05.23.07 AIF Series 2 of 2 Output (DC) 31. Positive 21. Positive 32. Negative 22. Positive Control Pins 1. +Sense 2. Temp Mon Waterfront Business Park Merry Hill, Dudley West Midlands, DY5 1LX United Kingdom Telephone: +44 (0) 1384 842 211 Facsimile: +44 (0) 1384 843 355 23. Positive 24. Positive 25. Negative 3. C Mon 4. C Share 5. Clk Out 26. Negative 6. Clk In Asia (HK) 27. Negative 28. Negative 7. PG/ID 8. C Lim Adj 9. OVP Adj 10. V Adj 11. Enable 12. -Sense 16th - 17th Floors, Lu Plaza 2 Wing Yip Street, Kwun Tong Kowloon, Hong Kong Telephone: +852 2176 3333 Facsimile: +852 2176 3888 For global contact, visit: www.astecpower.com www.artesyn.com [email protected] [email protected] While every precaution has been taken to ensure accuracy and completeness in this literature, Emerson Network Power assumes no responsibility, and disclaims all liability for damages resulting from use of this information or for any errors or omissions. Emerson Network Power. The global leader in enabling business-critical continuity. AC Power Connectivity DC Power Embedded Power Inbound Power Integrated Cabinet Solutions Outside Plant Precision Cooling Site Monitoring and Services EmersonNetworkPower. com Emerson Network Power and the Emerson Network Power logo are trademarks and service marks of Emerson Electric Co. ©2005 Emerson Electric Co.