H HiTRON 2008/03/31 CHASSIS-MOUNT UNIVERSAL INPUT MEDICAL APPLICATION AC-DC GREEN POWER ENCAPSULATED MODULAR POWER SUPPLIES 10 WATTS MULTIPLE OUTPUT HASM10G-S &HASM10-D/T SERIES FEATURES: CHASSIS-MOUNT AC/DC MODULAR POWER SUPPLIES UNIVERSAL AC INPUT RANGE GREEN POWER DESIGN MEET MEDICAL STANDARD EN60601-1/UL60601-1 EMI MEETS CISPR PUB.22/FCC CLASS B CE MARKING COMPLIANCE SPECIFICATION INPUT SPECIFICATION OUTPUT SPECIFICATION Input Voltage: 90-264Vac typical. Input Frequency: 47-63 Hz. (Nominal 50/60Hz.). Input Current: 0.16A @115Vac./0.1A @230Vac typical. Inrush Current: 4.2Arms@230Vac typical. Input Fuse: Use external fuse. Dielectric Withstand: Meet IEC60601-1. 4,000Vac-Output/Input. 2,000Vac-Input/GND. 1,000Vac-Output/GND. EMI: Meet CISPR PUB. 22/FCC Class B. Hold-up time: Typ. 22.4 mS @115Vac, 130mS @230Vac. Green Power: 0.25W@132Vac, 0.51W@230Vac for single. Earth Leakage: Less than 0.16mA @230Vac. Remote ON/OFF: ON(Enable)=Open. OFF(Disable)=Short. Output Voltage: See Ratings Chart. Output Current: See Ratings Chart. Output Wattage: 10 Watts typical. Line Regulation: Various with output voltage. Typ.±0.1% . Load Regulation: Various with output voltage. Main VO1 ± 0.1-2.0% typical. Aux.VO2 ± 0.7-1.2% typical. Aux.VO3 ± 0.1% typical. Total Regulation: 0.1-1.9% typical. Noise & ripple: 1.0% typical peak to peak. Typ. 100mV for 3.3V/5V. OVP: Built-in on main output VO1. Adjustability: Available at main output VO1. Overload Protection (OLP): Fully protected against output overload and short circuit. Typical 125-150% of rating output load. Con2sult the factory for special OLP setting. GENERAL SPECIFICATION Efficiency: 70-80% typical various with output voltage. Switching Frequency: 80K Hz. Circuit Topology: Fixed Frequency Flyback circuit. Transient Response: Peak deviation on 70mV, Recovery time <0.2mSec.@ 25%step load change. Case: Impact resistant thermo-plastic enclosure. Safety Standard: EN60601-1/ UL60601-1 Class I. Power Density: 1.22 Watts. / Cubic inch. Operating Temperature: 0°C to +50°C range. @ full load without derating. From+50°C derating linearly to half load @+70°C (Refer to the Derating Chart). Storage Temperature: -20°C to +85°C. Temperature Coefficient: ±0.03% /°C. Cooling: Convection cooling for +50°C @ full load. Medical Grade only. NOTE: (1) All measurements are at nominal input, full load, and +25°C unless otherwise specified. (2) Load Regulation measured from Full-Load (F-L) to Half-Load (H-L) at nominal input and others loaded at half load. (3) Due to requests in market and advances in technology, specifications subject to change without notice. OUTPUT VOLTAGE/ CURRENT RATINGS CHART DUAL OUTPUT SINGLE OUTPUT MODEL NO. HASM10G-S033250 HASM10G-S050200 HASM10G-S090111 HASM10G-S120085 HASM10G-S150067 HASM10G-S240041 VO1 TYP. 2.50A 2.00A 1.11A 0.85A 0.67A 0.41A ★@ VOLT. +3.3V +5.0V +9.0V +12.0V +15.0V +24.0V VO1 ★@ TYP. VOLT. 1.00A +5V 1.00A +5V 0.42A +12V 0.34A +15V 1.51A +3.3V MODEL NO. HASM10-D050E HASM10-D050I HASM10-D120I HASM10-D150K HASM10-D033E TYP 1.00A 0.42A 0.42A 0.34A 1.00A VO2● VOLT. -5V +12V -12V -15V -5V TRIPLE OUTPUT MODEL NO. HASM10-T033II HASM10-T050II HASM10-T050KK VO1 @ ★ VO2 ● TYP. TYP. VOLT. VOLT. 1.51A 0.10A +3.3V +12V 1.50A 0.10A +5.0V +12V 1.40A 0.10A +5.0V +15V "@" Adjustable. "●" Installed with Post Regulator (P.R.). VO3 ● TYP. VOLT. 0.10A -12V 0.10A -12V 0.10A -15V Symbols: "★" OVP built-in. Note: (1) Max. (maximum load) is the continuous operating load of each rail, but the max. load of each rail can not be drawn from all outputs at the same time. MECHANICAL DIMENSIONS: MM [INCHES] WEIGHT: 177.5g ( 6.26Oz.) PIN ASSIGNMENT PIN NO. P1-1 P1-3 P1-2 P2-2 P2-3 SINGLE O/P L N G REMOTE ON/OFF DC COM DC COM DUAL O/P(-VO2) L N G REMOTE ON/OFF VO2 DC COM DUAL O/P(+VO2) L N G REMOTE ON/OFF DC COM DC COM TRIPLE O/P L N G REMOTE ON/OFF +VO1RET +VO1 P2-4 VO1 DC COM VO1 +VO3 P2-5 VO1 VO1 VO2 DC COM P2-6 NC NC NC VO2 P2-1 DERATING CHART