Displays ANDpSi121GAOS-HB-KIT 12.1” XGA Color p-Si TFT LCD Module The ANDpS121GAOS-HB-KIT is 1024 x 768 Color TFT display that utilizes new poly-silicon (p-Si) technology to provide a brighter, thinner and lighter display with high-resolution. The p-Si TFT technology allows the row and column LCD drivers to be fabricated directly on the LCD glass. This eliminates the need for discrete TAB drivers and also reduces the thickness, weight and overall size of the display. The 12.1” XGA resolution expands applications in such areas as electronics books and personal digital-picture viewers. Electrical Characteristics (Ta = 25°C) Features • • • • • • • • High Luminance Built-in Long Life Lamps (MTTF: 50,000 h) Replaceable structure of lamp units Analog scaling board attachable to LCD backward Recommendable inverter attachable to LCD backward XGA (1024 x 768 pixels color display) Reverse Scan function Applications: electronic books and personal digital-picture viewers Mechanical Characteristics Item Specification Unit Outline Dimensions 278.3 (H) x 209.0 (V) x 12.0 max (D) mm Number of Pixels 1024 (H) x 768 (V) pixels Active Area 245.8 (H) x 184.3 (V) mm Viewing Area 247.8 (H) x 186.3 (V) Pixel Pitch Backlight mm 685 gram Twin CCFL, Sidelight type – Absolute Maximum Ratings Symbol Min. Item Supply Voltage FL Driving Frequency 4.0 V VFL 0 2.0 kV(rms) fFL (0) (100) kHz -0.3 VDD + 0.3 V Operating Ambient Temp. Top 0 50 °C 0 60 °C Tstg -20 60 °C – 10 90 %(RH) Operating Temp. for Panel Storage Humidity (Max. Wet bulb temp = 39°C) 7/27/07 Unit -0.3 VIN Storage Temperature Max. VDD Input Signal Voltage Symbol Min. Typ. Max. Unit VDD 3.0 3.3 3.6 V VFL TBD (580) TBD V(rms) FL Start Voltage (Ta = 0°C) – 1400 – – V(rms) Differential Input Voltage VID 100 _ 600 mV Common Mode Input Voltage VCM 1.0 – 2.4(VID)/2 V IDD * – (220) TBD mA IFL ** 3.0 – 6.0 mA(rms) P – (7.7) – W Supply Voltage IFL=6.0mA(rms) Current Consumption Pwr Consumption IFL=6.0mA(rms) *: 8 color bars pattern **: Except the efficiency of FL inverter Optical Characteristics (Ta = 25°C) 0.24 (H) x 0.24 (V) Weight (approx.) Item Item Contrast Ratio Sym. CR Min. Typ. Max. Unit 100 250 – – Viewing Angle (CR ≥ 10) (Upper+Lower) TBD 100 – ° (Left+Right) TBD 120 – ° Response Time (tON) ton – – 50 ms (tOFF) toff – – 50 ms Luminance IFL=6.0mA(rms) L (280) (350) – cd/m2 Lamp Life Time (Notes 1,2) MTBF 50,000 h Note 1: Conditions: Ta = 25°C, IFL=6.0mA(rms), continuous lighting Note 2: Definitions of failure: a) LCD luminance becomes half of the minimum value. b) Lamp doesn’t light normally. Product specifications contained herein may be changed without prior notice. It is therefore advisable to contact Purdy Electronics before proceeding with the design of equipment incorporating this product. Purdy Electronics Corporation • 720 Palomar Avenue • Sunnyvale, CA 94085 Tel: 408.523.8216 • Fax: 408.733.1287 • [email protected] www.purdyelectronics.com 1 Displays ANDpSi121GA0S-HB-KIT Dimensional Outline Front View 2 Unit: mm Standard Tolerance: 0.5mm Purdy Electronics Corporation • 720 Palomar Avenue • Sunnyvale, CA 94085 Tel: 408.523.8216 • Fax: 408.733.1287 • [email protected] www.purdyelectronics.com 7/27/07 Displays ANDpSi121GA0S-HB-KIT Timing Specifications (see Notes below) Item Symbol Min Typ Max Unit th 1334 x tc 1344 x tc – clock H-sync Pulse Width thw 4 x tc 136 x tc – clock Horizontal Front Porch thfp 4 x tc 24 x tc – clock Horizontal Back Porch thbp 24 x tc 160 x tc – clock Horizontal Data Sync Period thds 32 x tc 296 x tc – clock Horizontal Display Term thd 1024 x tc 1024 x tc 1024 x tc clock tv 778 x th 806 x th 860 x th line Horizontal Scanning Term Frame Period V-sync Pulse Width tvw 2 x th 6 x th – line V-sync Set up Time (to H-sync) tvsu 8 x tc – – clock V-sync Hold Time tvhd (thbp+16) x tc – – clock Vertical Front Porch tvfp 1 x th 3 x th – line Vertical Back Porch tvbp 2 x th 29 x th – line Vertical Data Sync Period tvds 8 x th 35 x th – line Vertical Display Time tvd 768 x th 768 x th 768 x th line Clock Period tc 15.0 15.38 – ns Notes: Refer to “Timing Chart” below. If DE is fixed to “H” or “L” level for certain period while NCLK is supplied, the panel displays black w/some flicker. If NCLK is fixed to “H” or “L” level for certain period while DE is supplied, the panel may be damaged. Please adjust LCD operating signal timing and FL driving frequency, to optimize the display quality. There is a possibility that flicker is observed by the interference of LCD operating signal timing and FL driving condition (especially driving frequency), even if the condition satisfies above timing specifications and recommended operating conditions. Do not make tv, tvhd and tvds fluctuate. If tv, tvhd, and tvds are fluctuate, the panel display black. In case of using the long frame period, the deterioration of display quality, noise, etc. may be occurred. NCLK count of each Horizontal Scanning Time should be always the same. V-Blanking period should be ‘n’ X “Horizontal Scanning Time”. (n:integer) Frame period should be always the same. Timing Chart tv tvw VSYNC tvsu tvhd th HSYNC tv p tvbp tvd tvds DE 1023 1 1024 2 th thw HSYNC thbp thfp thds thd DE 1024 pixel 1 2 3 4 CLK 7/27/07 Purdy Electronics Corporation • 720 Palomar Avenue • Sunnyvale, CA 94085 Tel: 408.523.8216 • Fax: 408.733.1287 • [email protected] www.purdyelectronics.com 3 Displays ANDpSi121GA0S-HB-KIT Connector Pin Assignment for Interface CN1 Input Signal (see Notes below) DF19L-20P-1H / Hirose Electric Co., Ltd. Terminal Symbol No. 1 2 3 4 5 VDD Power Supply: +3.3V VDD Power Supply: +3.3V VSS Ground VSS Ground RxIN06 Recommended Inverter: 8 Neg. LVDS differential data input (R0-R5, G0) RxIN0+ Pos. LVDS differential data input (R0-R5, G0) VSS 7 Function Ground RxIN1- Neg. LVDS differential data input (G1-G5, B0-B1) RxIN1+ Pos. LVDS differential data input (G1-G5, B0-B1) 9 10 Block Diagram 11 VSS Ground RxIN212 13 14 15 Neg. LVDS differential data input (B1-B5,HS,VS,DE) RxIN2+ Pos. LVDS differential data input (B1-B5,HS,VS,DE) VSS Ground CLK- Clock Signal (-) CLK+ Clock Signal (+) VSS Ground U/D Vert. Rev. (“L” level or Open; Normal, “H” level: Rev.) 18 L/R Horiz. Rev. (“L” level or Open; Normal, “H” level: Rev.) VSS Ground 20 VSS Ground 16 17 19 CN2 CCFL Power Source BHR-04VS-1/Japan Solderless Terminal Mfg. Co., Ltd 1) Drivers are fabricated on the LCD glass Terminal No. Symbol 1 VFLH1 CCFL Power Supply (High Voltage) 2 VFLH2 CCFL Power Supply (Low Voltage) 3 NC 4 VFLL Function Non Connection (open) CCFL Power Supply (Low Voltage) 2) Connectors CN1: DF19L-20P-1H / Hirose Electric Co., Ltd. Mating Connector - DF19G-20S-1F (FPC) / DF19G-20S-1C (Cable) Notes: Please connect GND pin to ground. Don’t use it as no-connect nor connection with high impedance. NC terminal should be open. Take away terminal No. 3 of the mating connector. If does not take away, it CN2: BHR-04VS-1/Japan Solderless Terminal Mfg. Co., Ltd. may cause smoke burn of electrical parts by high voltage. Mating Connector - SM04(4.0)B-BHS-1 / JST 4 Purdy Electronics Corporation • 720 Palomar Avenue • Sunnyvale, CA 94085 Tel: 408.523.8216 • Fax: 408.733.1287 • [email protected] www.purdyelectronics.com 7/27/07 Displays ANDpSi121GA0S-HB-KIT Note (2): 256K colors are displayed by the combinations of 18 data bits. Display Basic Color R5 R4 R3 R1 R0 G5 G4 G3 G2 G1 G0 B5 B4 B3 B2 B1 B0 Gray Scale Level Black L L L L L L L L L L L L L L L L L L – Blue L L L L L L L L L L L L H H H H H H – Green L L L L L L H H H H H H L L L L L L – Lt. Blue L L L L L L H H H H H H H H H H H H – Red H H H H H H L L L L L L L L L L L L – Purple H H H H H H L L L L L L H H H H H H – Yellow H H H H H H H H H H H H L L L L L L White H H H H H H H H H H H H H H H H H – – Black L L L L L L L L L L L L L L L L L L L0 Dark L L L L L H L L L L L L L L L L L L L1 L L L L H L L L L L L L L L L L L L L2 Gray Scale of Red : : : : : : H H H H L Light H H H H Red H H H H L3~L60 H L L L L L L L L L L L L H L L L L L L L L L L L L L H H L L L L L L L L L L L L L61 L62 Red L63 Black L L L L L L L L L L L L L L L L L L L0 Dark L L L L L L L L L L L H L L L L L L L1 L L L L L L L L L L H L L L L L L L L2 Gray Scale of Green : : : : : : L L L L L L H H H H L Light L L L L L L H H H H Green L L L L L L H H H H L3~L60 H L L L L L L H L L L L L L L H H L L L L L L L61 L62 Green L63 Black L L L L L L L L L L L L L L L L L L L0 Dark L L L L L L L L L L L L L L L L L H L1 L L L L L L L L L L L L L L L L H L L2 Gray Scale of Blue : : : : : : L3~L60 L L L L L L L L L L L L H H H H L Light L L L L L L L L L L L L H H H H H L Blue L L L L L L L L L L L L H H H H H H H L61 L62 Blue L63 Black L L L L L L L L L L L L L L L L L L L0 Dark L L L L L H L L L L L H L L L L L H L1 L L L L H L L L L L H L L L L L H L L2 Gray Scale of White & Black 7/27/07 R2 : : : : : : H H H H L H H H H H L Light H H H H White H H H H H L H H H H H H H H H H L3~L60 H H H H H L H L H H H H H L H H H H H H H H Purdy Electronics Corporation • 720 Palomar Avenue • Sunnyvale, CA 94085 Tel: 408.523.8216 • Fax: 408.733.1287 • [email protected] www.purdyelectronics.com H L61 L62 White L63 5