2mm LED CBI® Circuit Board Indicator Quad 555-4xxx COLOR PART NO. Anode marked on Top of Housing 1.14 [.045] 10.29 [.405] GENERAL PURPOSE 5.08 [.200] 555-4001 555-4301 555-4401 3.18 [.125] 2.03 [.080] 6.35 [.250] CATHODE 3.43 [.135] Red Green Yellow INTEGRAL RESISTOR, 5 VOLTS 1.35 [.053] .686 [.027] MAX 2.54 [.100] 1.02 [.040] 2.54 [.100] 2.54 [.100] 0.965 ±.05 [.038 ±.002] 555-4003 555-4007 555-4009 555-4303 555-4403 .254 [.010] Red Red Red Green Yellow RECOMMENDED PC BOARD LAYOUT Dimensions in mm [inches] Features • Multiple CBIs form horizontal LED arrays on 2.54mm (0.100”) center-lines • High Contrast, UL 94 V-0 rated, black housing Custom Combinations • Contact factory for information on custom color combinations • Oxygen index: 31.5% • Polymer content: PBT, 0.280 g • Housing stand-offs facilitate PCB cleaning Tolerance note: As noted, otherwise: • Solderability per MIL-STD-202F, method 208F • LEDs are safe for direct viewing per IEC 825-1, EN-60825-1 • Compatible with: 555-2xxx Single Block • LED Protrusion: ±0.04 mm [±0.016] • CBI Housing: ±0.02mm[±0.008] See LED data sheet for additional information See Page 3-17 and 3-18 for Reference Only LED Drive Circuit Examples See Page 3-19 for Pin Out Typical Operating Characteristics (TA = 25°C) GENERAL PURPOSE Part Number Color Peak Wavelength nm IV mcd VF Volts Test Current (mA) Viewing Angle 2Θ Θ1/2 LED Data sheet Page # 555-4001 555-4301 555-4401 Red Green Yellow 650 565 583 1.2 1 2 1.6 2.4 2.2 20 20 20 40° 40° 40° 2ND-9412 2ND-9414 2ND-9416 3-14 3-14 3-14 IV mcd 1.9 .9 .6 2.5 2.1 IF mA 6 3 1 4.7 4.7 Test Voltage 5 5 5 5 5 Viewing Angle 2Θ Θ1/2 40° 40° 40° 40° 40° LED Data sheet 2RD-9614 2RD-9613 2RD-9618 2RD-9615 2RD-9616 Page # 3-15 3-15 3-15 3-15 3-15 INTEGRAL RESISTOR, 5 VOLTS Part Number 555-4003 555-4007 555-4009 555-4303 555-4403 3-8 Color Red Red Red Green Yellow Peak Wavelength nm 650 650 650 565 583 Dialight Corporation • 1501 Route 34 South • Farmingdale, NJ 07727 • TEL: (732) 919-3119 • FAX: (732) 751-5778 •www.dialight.com 2mm General Purpose Diffused 2ND-xxxx TYPE COLOR 2ND-9412* 2ND-9414* 2ND-9416* * NOT A VALID PART NUMBER. THIS SHEET IS FOR REFERENCE ONLY. Red Green Yellow Red Green Yellow -9412 -9414 -9416 Power Dissipation (mW) Derating (mW/°C) From 25°C 80 1.1 80 1.1 80 1.1 Forward Current (mA) 40 25 25 Peak Current (mA) 250 250 250 Operating Temperature (°C) -55/+100 -55/+100 -55/+100 Storage Temperature (°C) -55/+100 -55/+100 -55/+100 ABSOLUTE MAXIMUM RATINGS (TA=25°C) Pulse width = 1 µs Soldering Temperature 260°C, 5 seconds, 1.6 mm from case OPERATING CHARACTERISTICS (TA=25°C) Red Green Yellow -9412 -9414 -9416 Luminous Intensity (mcd) IF=20mA Min. Typical 1 1.2 .5 1 .6 2 Peak Wavelength (nm) λ Peak Typical 650 565 583 Viewing Angle (2Θ Θ1/2) Typical 40° 40° 40° Forward Voltage (V) IF=20mA Typical Max. 1.6 2 2.4 3 2.2 3 Reverse Voltage (V), IR=10µA Min. 3 3 3 Θ ¼2is the off axis angle at which the luminous intensity is half the axial luminous intensity 1 3-14 Dialight Corporation • 1501 Route 34 South • Farmingdale, NJ 07727 • TEL: (732) 919-3119 • FAX: (732) 751-5778 •www.dialight.com 2mm Integral Resistor, 5 Volts Diffused 2RD-9613 thru 2RD-9618 TYPE 2RD-9613* 2RD-9614* 2RD-9615* 2RD-9616* 2RD-9618* * NOT A VALID PART NUMBER. THIS SHEET IS FOR REFERENCE ONLY. COLOR Red Red Green Yellow Red 3 ABSOLUTE MAXIMUM RATINGS (TA=25°C) Forward Voltage (V) Red Red Green Yellow Red -9613 -9614 -9615 -9616 -9618 6 6 6 6 6 Operating Temperature (°C) -55/+100 -55/+100 -55/+100 -55/+100 -55/+100 Storage Temperature (°C) -55/+100 -55/+100 -55/+100 -55/+100 -55/+100 Soldering Temperature 260°C, 5 seconds, 1.6 mm from case OPERATING CHARACTERISTICS (TA=25°C) - Red Red Green Yellow Red 9613 -9614 -9615 -9616 -9618 Luminous Intensity (mcd) VF=5V Min. Typical .4 .9 .8 1.9 .8 2.5 1.3 2.1 .3 .6 Peak Wavelength (nm) λ Peak Typical 650 650 565 583 650 Viewing Angle (2Θ1/2) Typical 40° 40° 40° 40° 40° Forward Current (mA) VF=5V Typical Max. 3 4 6 8 4.7 6.7 4.7 6.7 1 2.6 Reverse Voltage (V), IR=100µA Min. 6 6 6 6 6 Dialight Corporation • 1501 Route 34 South • Farmingdale, NJ 07727 • TEL: (732) 919-3119 • FAX: (732) 751-5778 •www.dialight.com 3-15