ETC 40120

TEMPIL°, INC.
2901 Hamilton Blvd.
South Plainfield, NJ 07080
PHONE: 908-757-8300
MATERIAL SAFETY DATA SHEET
MSDS NO: TS - 115°C - 120C
DATE: June 10, 2000
EMERGENCY NO: 800-424-9300
FAX: 908-757-9273
SECTION 1 MATERIAL IDENTIFICATION
PRODUCT NAME: TEMPILSTIK 115°C/ 239°F , 120°C/248°F
GENERIC NAME OR FAMILY: Temperature Indicating Paint
SHIPPING NAMES:
DOT: Non-regulated
IATA: Non-regulated
HAZARDOUS COMPONENTS OF MIXTURE
WEIGHT %
OSHA PEL
ACGIH TLV
(PPM)
(PPM)
Non applicable
CAS Number
SECTION 313 SUPPLIER NOTIFICATION
This product contains the following toxic chemical (s) subject to the reporting requirements of section 313 of the
Emergency Planning and Community Right-to-Know Act of 1986 and of CFR 372:
Chemical Name
Non applicable
%
CAS Number
SECTION 2 PHYSICAL DATA
SPECIFIC GRAVITY (H2O = 1): N.E.
PERCENT VOLATILE BY VOLUME (%) : N.A.
EVAPORATION RATE (N-Butyl Acetate = 1) : N.A.
VOLATILE ORGANIC COMPOUNDS (VOC) : N.A.
BOILING POINT (°F): N.E.
VAPOR PRESSURE (mm Hg.) : N.E.
VAPOR DENSITY (AIR =1): N.E.
SOLUBILITY IN WATER: Negligible
APPEARANCE AND ODOR: Crayon like solid stick
SECTION 3 FIRE AND EXPLOSION HAZARD DATA
FLASH POINT ( and Method): N.E.
FLAMMABLE LIMITS
LOWER
N.E.
UPPER
N.E.
______________________________________________________________________________________________
_
EXTINGUISHING MEDIA: Water, CO2 , dry chemical, foam
______________________________________________________________________________________________
_
SPECIAL FIRE FIGHTING PROCEDURES: Wear self contained breathing apparatus and protective clothing.
______________________________________________________________________________________________
_
UNUSUAL FIRE AND EXPLOSION HAZARDS: None known.
______________________________________________________________________________________________
_
SECTION 4 - REACTIVITY HAZARD DATA
CONDITIONS TO AVOID: Not applicable
STABILITY: Stable
Incompatibility (Materials to Avoid): Strong oxidizing agents or strong mineral acids.
O:\MSDS’s\msdsform
Page 1 of 3
______________________________________________________________________________________________
_
Hazardous Decomposition Products: Carbon monoxide, carbon dioxide
HAZARDOUS POLYMERIZATION: Will not occur
CONDITIONS TO AVOID: Not applicable
SECTION 5 - CONTROL AND PROTECTIVE MEASURES
Respiratory Protection (Specify Type): NIOSH approved respirator if ventilation is insufficient.
______________________________________________________________________________________________
_
Protective Gloves: Rubber
Eye Protection: Safety glasses
______________________________________________________________________________________________
_
VENTILATION TO
Local Exhaust
Mechanical(general): If local ventilation is insufficient.
BE USED
Other Protective Clothing & Equipment: Not normally required.
Hygienic Work Practices: Wash hands thoroughly after using this product.
SECTION 6 - HEALTH HAZARD DATA
Inhalation
Skin Absorption
PRIMARY ROUTES
OF ENTRY
Acute: May cause eye, skin or respiratory tract irritation.
HEALTH
HAZARDS
Signs & Symptoms of Exposure: Skin irritation, vapors may cause headache, dizziness, nausea.
Target Organ Information: Unknown
EMERGENCY FIRST AID PROCEDURES - Seek medical assistance for further treatment, observation and support if
necessary.
Eye Contact: Flush with water for 15 minutes.
Skin Contact: Wash with soap and water.
Inhalation: Remove to fresh air. If breathing is difficult,
Ingestion: Obtain immediate medical attention.
obtain medical attention.
SECTION 7 - PRECAUTIONS FOR SAFE HANDLING AND USE
Steps to be taken if Material Is Spilled or Released: Sweep up and place in bag for waste disposal.
______________________________________________________________________________________________
_
Waste Disposal Methods: Dispose of in accordance with all Federal, State and local laws.
______________________________________________________________________________________________
_
Precaution to be taken in Handling & Storage: Store in cool, dry area. Avoid skin contact. Avoid breathing vapors.
______________________________________________________________________________________________
_
Other Precautions and/or Special Hazards: Not applicable.
HMIS rating: 0= Minimal hazard
1= Slight hazard
Health:
O:\MSDS’s\msdsform
1
2= Moderate hazard 3= Serious hazard
Flammability:
Page 2 of 3
1
Reactivity:
0
4= Severe hazard
This information contained herein is furnished without warranty of any kind. Employers should use this information only as a supplement to other
information gathered by them and must make independent determinations of suitability and completeness of information from all sources to assure
proper use of these materials and the safety and health of employees.
O:\MSDS’s\msdsform
Page 3 of 3