DATA SHEET ECG015 BROADBAND HIGH OIP3 AMPLIFIER 1800 - 2500 MHz Features Applications 1800 to 2500 MHz Highly Reliable InGaP HBT Excellent Stability Multi-carrier Systems High Linearity Amplifiers Cellular, PCS, WLL Package Available (-B) SOT-89 Package Description RF in Gnd The ECG015 is a high reliability, high OIP3 amplifier in a low cost SOT-89 package, optimized for the commercial communications market. The device is manufactured using advanced Indium Gallium Phosphide Heterojunction Bipolar Transistor (InGaP HBT) technology. The amplifier can be matched to achieve low VSWR and high OIP3 over the 1800 to 2500 MHz range. Typical OIP3 at 2140 MHz is +41 dBm. The ECG015 operates from a single 8 volt power supply. Gnd RFout SOT-89 (Top View) Electrical Specifications o Test Conditions: Ta = 25 C, Vd = 5.0 V SYMBOL LIMITS PARAMETER MIN. TYP. MAX. UNIT TEST CONDITION F Frequency G Gain (Small Signal) f = 2140 MHz f = 2450 MHz 13.5 . 15.0 14.0 dB P1dB Output Power @ 1 dB Compression f = 2140 MHz f = 2450 MHz 22.0 . 24.0 23.0 dBm OIP3 Output Third Order Intercept f = 2140 MHz f = 2450 MHz 37.5 . 41 42 dBm Note 1 RL IN Input Return Loss, 50 Ohm f = 2100 MHz 15.0 17.0 dB Note 2 RL IN Input Return Loss, 50 Ohm 1800 to 2500 MHz 15.0 dB Output Return Loss, 50 Ohm 1800 to 2500 MHz 10.0 dB NF Noise Figure f = 2140 MHz f = 2450 MHz 5.0 5.0 dB Ic Supply Current RL OUT 85 Output Mismatch without Spurs Rth, j-l Thermal Resistance 2500 1800 100 135 MHz mA Note 2 10:1 Junction to Lead 85 °C/W Note 1: OIP3 = Pout (by power meter, total 2-tone power) + (IM3 (dBc)) / 2 - 3 dB Note 2: Tested at Vcc= 8.0V Rs= 30 ohms on an eval board with recommended matching circuit CAUTION! SENSITIVE ELECTRONIC DEVICE EiC Corp. A Subsidiary of EiC Enterprises, Ltd. www.eiccorp.com 45738 Northport Loop West, Fremont, CA 94538 Phone: (510) 979-8999 Fax: (510) 979-8902 SS-000145-000 Rev F 1 DATA SHEET ECG015 BROADBAND HIGH OIP3 AMPLIFIER 1800 - 2500 MHz Absolute Maximum Ratings Device Voltage Device Current RF Power Input Operating Temperature Storage Temperature Junction Temperature 6.0 220 12 -40 to +85 -65 to +150 200 V mA dBm °C °C °C SYMBOL Package Outline A B B1 C D D1 E E1 e E1 F H Inches MIN. MAX. .055 .063 .017 .022 .014 .019 .014 .017 .173 .181 .064 .072 .090 .102 .084 .090 .059 .118 .035 .047 .155 .167 Pin Definitions Pin # Pin 1 RFin 2, 4 Gnd The two ground connections s hould be directly connec ted together to the ground plane on the PCB. The ground connection als o serves as a heatsink. RFout DC bias is applied to this pin through a RF chok e. A bypass capacitor (1.0 m ic ro farad) on the DC side of the choke is recomm ended for low frequency m odulation signal. 3 De finition This pin has a non-z ero DC potential, requiring a DC blocking capacitor. Input m atching is required to achieve a low VSW R. EiC Corp. A Subsidiary of EiC Enterprises, Ltd. www.eiccorp.com 45738 Northport Loop West, Fremont, CA 94538 Phone: (510) 979-8999 Fax: (510) 979-8902 SS-000145-000 Rev F 2 DATA SHEET ECG015 BROADBAND HIGH OIP3 AMPLIFIER 1800 - 2500 MHz Evaluation Board Layout 1.9GHz R1 R2 R3 L1,L2 L3 --C1 C2 C3 C4,C5 C7,C10 ------U1 1 J1 J2,J3 1 ECG015 2.14GHz R1 R2 R3 L1,L2 L3 --C1 C2 C3 C4,C5 --C8 C10 --U1 1 J1 J2,J3 1 2.45GHz R1 R2 R3 L1,L2 --L3 C1 C2 C3 C4,C5 --C9 ----U1 1 J1 J2,J3 1 VALUE 30 Ω 390 Ω 220 Ω 15 nH 3.3 nH 0Ω 1.0 uF 1000pF 18 pF 56 pF 1.2 pF 1 pF 0.7 pF ----------- DESCRIPTION RESISTOR, 2512 1W RESISTOR, 0805 RESISTOR, 0805 INDUCTOR, 0805 INDUCTOR, 0805 RESISTOR, 0805 CAPACITOR, 0603 CAPACITOR, 0603 CAPACITOR, 0603 CAPACITOR, 0603 CAPACITOR, 0603 CAPACITOR, 0603 CAPACITOR, 0603 C6, 11, 12 IC, ECG015 HEATSINK CONN, 4 POS CONN, SMA PCB MANUFACTURER &P/N ROHM MCR100JW300 ROHM MCR10JW391 ROHM MCR10JW22 TOKO LL1608-F15NK TOKO LL1608-FH3N3S ROHM MCR10JW000 PANASONIC ECJ-1VF1A105Z ROHM MCH185C102KK ROHM MCH185A180JK ROHM MCH185A560JK ROHM MCH185A1R2CK ROHM MCH185A010CK NOVA N0R7C500NT NOT LOADED EiC Corp EiC Corp MD-000290-000 SULLINS ELEC PZC04SGAN CDI 5260CC EiC Corp 60-000288-000C NOTE 1 NOTE 1 NOTE 1 NOTE 1 NOTE 1 NOTE 1 NOTE 1 NOTE 1 NOTE 1 NOTE 1 NOTE 1 NOTE 1 NOTE 1 NOTE 1. EiC RECOMMENDED COMPONENTS ARE SHOWN. EQUIVALENT COMPONENTS MAY BE USED. NOTE UNLESS OTHERWISE SPECIFIED EiC Corp. A Subsidiary of EiC Enterprises, Ltd. www.eiccorp.com 45738 Northport Loop West, Fremont, CA 94538 Phone: (510) 979-8999 Fax: (510) 979-8902 SS-000145-000 Rev F 3 DATA SHEET ECG015 BROADBAND HIGH OIP3 AMPLIFIER 1800 - 2500 MHz 1.9GHz Schematic 2.14GHz Schematic EiC Corp. A Subsidiary of EiC Enterprises, Ltd. www.eiccorp.com 45738 Northport Loop West, Fremont, CA 94538 Phone: (510) 979-8999 Fax: (510) 979-8902 SS-000145-000 Rev F 4 DATA SHEET ECG015 BROADBAND HIGH OIP3 AMPLIFIER 1800 - 2500 MHz 2.45GHz Schematic Recommended Bias Resistor Values R = (Vcc-Vde)/Icc = (Vcc-5.0)/0.10 A pprox im ate S upply V oltage (V c c ) bas ed on s tandard values for R 1 R 1 (O hm s ) 7 8 10 12 20 30 51 68 EiC Corp. A Subsidiary of EiC Enterprises, Ltd. www.eiccorp.com 45738 Northport Loop West, Fremont, CA 94538 Phone: (510) 979-8999 Fax: (510) 979-8902 SS-000145-000 Rev F 5 DATA SHEET ECG015 BROADBAND HIGH OIP3 AMPLIFIER 1800 - 2500 MHz Figure 1 ACPR1 and ACPR2 vs. Pout vs. Temperature at 1.9GHz (See note below) 100 ACPR1 85°C ACPR2 85°C ACPR1 -40°C ACPR2 -40°C ACPR1 25°C ACPR2 25°C dBc 80 60 40 20 0 11 13 15 17 Average power out(dBm) Figure 2 ACPR1 and ACPR2 vs. Temperature vs. Pout at 2.14GHz (See note below) 100 ACPR1 25°C ACPR2 25°C ACPR1 -40°C ACPR2 -40°C ACPR1 85°C ACPR2 85°C dBc 80 60 40 20 0 11 13 15 17 Average power out(dBm) Note: (IS95) ACPR1 measured at 750KHz ACPR2 at 1.98MHz Forward 9 Channel Signal Generator:HP E4432B EiC Corp. A Subsidiary of EiC Enterprises, Ltd. www.eiccorp.com 45738 Northport Loop West, Fremont, CA 94538 Phone: (510) 979-8999 Fax: (510) 979-8902 SS-000145-000 Rev F 6 DATA SHEET ECG015 BROADBAND HIGH OIP3 AMPLIFIER 1800 - 2500 MHz Figure 3 dBc ACPR1 and ACPR2 vs. Pout vs. Temperature at 2.45GHz (See note below) 90 80 70 60 50 40 30 20 10 0 ACPR1 85°C ACPR2 85°C ACPR1 -40°C ACPR2 -40°C ACPR1 25°C ACPR2 25°C 11 13 15 Average power out(dBm) 17 Note: (IS95) ACPR1 measured at 750KHz ACPR2 at 1.98MHz Forward 9 Channel Signal Generator:HP E4432B Figure 4 Ssg, OIP3 and P1dB vs. Temperature @ 1.96GHz 45 40 35 30 Ssg OIP3 P1dB 25 20 15 10 5 0 -40°C EiC Corp. A Subsidiary of EiC Enterprises, Ltd. 25°C 85°C www.eiccorp.com 45738 Northport Loop West, Fremont, CA 94538 Phone: (510) 979-8999 Fax: (510) 979-8902 SS-000145-000 Rev F 7 DATA SHEET ECG015 BROADBAND HIGH OIP3 AMPLIFIER 1800 - 2500 MHz Figure 5 Ssg, OIP3, & P1dB vs. Temperature at 2.14GHz 45 40 35 30 25 20 15 10 5 0 Ssg OIP3 P1dB -40°C 25°C 85°C Figure 6 Ssg, OIP3 and P1dB vs. Temperature at 2.45GHz 45 40 35 30 Ssg OIP3 25 20 P1dB 15 10 5 0 -40°C EiC Corp. A Subsidiary of EiC Enterprises, Ltd. 25°C 85°C www.eiccorp.com 45738 Northport Loop West, Fremont, CA 94538 Phone: (510) 979-8999 Fax: (510) 979-8902 SS-000145-000 Rev F 8 DATA SHEET ECG015 BROADBAND HIGH OIP3 AMPLIFIER 1800 - 2500 MHz Typical S-Parameters: Temperature 25°C Icc = 100mA Frequency (MHz) S11 (Mag) S11 (Ang) S21 (Mag) S21 (Ang) S12 (Mag) S12 (Ang) S22 (Mag) S22 (Ang) 1800 0.4608 80.0624 6.2554 24.0160 0.0376 -25.6613 0.5428 156.1157 1900 0.4134 67.1564 6.1195 15.5415 0.0353 -35.7847 0.5669 156.1202 2000 0.3726 53.7253 6.0751 7.9044 0.0311 -38.1532 0.5911 155.5997 2100 0.3214 34.6829 5.9753 -1.3626 0.0266 -45.7697 0.6233 155.0311 2200 0.2869 13.1058 5.9269 -9.8045 0.0229 -59.9888 0.6535 153.7677 2300 0.2592 -24.6928 5.6506 -21.6446 0.0142 -85.0285 0.6888 150.5728 2400 0.2854 -55.4509 5.4222 -31.6562 0.0092 -105.6268 0.7253 147.3149 2500 0.3492 -86.3300 5.0840 -43.6624 0.0079 162.1633 0.7557 142.2291 EiC Corp. A Subsidiary of EiC Enterprises, Ltd. www.eiccorp.com 45738 Northport Loop West, Fremont, CA 94538 Phone: (510) 979-8999 Fax: (510) 979-8902 SS-000145-000 Rev F 9 DATA SHEET ECG015 BROADBAND HIGH OIP3 AMPLIFIER 1800 - 2500 MHz APPLICATION NOTES Please visit our website at www.eiccorp.com to view or download the following documents. You may also call our Customer Service to request a hardcopy. Document # Description AP-000145-000 ECG015: Reduction of out of band gain AP-000192-000 Discussion of Technology and Reliability Enhancements AP-000194-000 Biasing and Performance Enhancements AP-000487-000 Tape and Reel Specifications and Package Drawings AP-000515-000 Voltage Spike Suppression AP-000516-000 Application Note Index EiC Corp. A Subsidiary of EiC Enterprises, Ltd. www.eiccorp.com 45738 Northport Loop West, Fremont, CA 94538 Phone: (510) 979-8999 Fax: (510) 979-8902 SS-000145-000 Rev F 10