05179 PPC3100EB . . . engineered solutions for the transient environment™ BIDIRECTIONAL THYRISTOR SURGE SUPPRESSOR APPLICATIONS ✔ T1/E1 Trunk & Line Card ✔ SLIC Line Card ✔ DBX Branch Exchange Switches ✔ FCC Part 68 Customer Premise Equipment ✔ Line Interface Modem ✔ xDSL Architecture Interface ✔ ISDN Architecture Interface TO-92 IEC COMPATIBILITY (EN61000-4) ✔ 61000-4-2 (ESD): Air - 15kV, Contact - 8kV ✔ 61000-4-4 (EFT): 40A - 5/50ns ✔ 61000-4-5 (Surge): 24A, 8/20µs - Level 2(Line-Gnd) & Level 3(Line-Line) DEVICE SYMBOL (BIDIRECTIONAL) FEATURES ✔ Complies with: FCC Part 68, UL 1459, Bellcore 1089, ITU-K.20 & K.21 ✔ Peak Off-State Voltage 275 Volts ✔ Surge Current Capability (See Table 1) ✔ ESD Protection > 40 kilovolts ✔ Low Capacitance for T1/E1 Trunk & Line Card Applications MECHANICAL CHARACTERISTICS ✔ Molded TO-92 Package ✔ Weight 0.18 grams (Approximate) ✔ Flammability Rating UL 94V-0 ✔ Device Marking: Logo & Marking Code TABLE 1 - SURGE RATINGS PART NUMBER IPP 2 X 10µs AMPS IPP 10 X 160µs AMPS IPP 10 X 700µs AMPS IPP 10 X 1000µs AMPS ITSM 60 Hz AMPS di/dt AMPS/µs (See Note 1) dv/dt AMPS/µs (See Note 1) PPC3100EB 300 150 160 75 32 500 2000 Note 1: Critical Rate of Rise for On-State Current (di/dt) and Off-State Voltage (dv/dt). 05179.R0 8/02 1 www.protekdevices.com PPC3100EB DEVICE CHARACTERISTICS MAXIMUM RATINGS @ 25°C Unless Otherwise Specified SYMBOL VALUE UNITS ITSM 60 Amps Junction Temperature Tj -40 to 150 °C Storage Temperature TSTG -55 to 150 °C Thermal Resistance (Junction) Rθjc 28 °C/Watt Thermal Resistance (Ambient) Rθjc 90 °C/Watt PARAMETER Surge Current - 50/60 Hz ELECTRICAL CHARACTERISTICS PER LINE @ 25°C Unless Otherwise Specified PART NUMBER DEVICE MARKING CODE PPC3100EB HB SWITCHING VOLTAGE MINIMUM HOLDING CURRENT VDRM VOLTS @100V/µs VS VOLTS di/dt = 1A/ms IH mA 275 350 150 REPETITIVE PEAK OFF-STATE VOLTAGE SWITCHING CURRENT MAXIMUM OFF-STATE VOLTAGE (See Fig. 3) MAXIMUM ON-STATE VOLTAGE (See Fig. 3) IS mA @VDRM IDRM µA @IT VT VOLTS IT AMPS @2V, 1 MHz C pF 800 5 5 1.0 30 ON-STATE CURRENT TYPICAL CAPACITANCE (See Note 1) Note 1: Capacitance imbalance between positive and negative polarities is typically < 15pF. 05179.R0 8/02 2 www.protekdevices.com PPC3100EB GRAPHS FIGURE 1 PULSE WAVE FORM FIGURE 2 V-I CHARACTERISTIC CURVE IPP - Peak Pulse Current - % of IPP 100 TEST WAVEFORM PARAMETERS tf = 10µs td = 1,000µs tf Peak Value IPP IPP ITSM IT IS IH VS td = t I /2 PP 50 IDRM VT VDRM e-t 0 0 1 2 3 t - Time - µs FIGURE 3 ON-STATE CURRENT VS SURGE CURRENT DURATION Non-Repetitive On-State Current (ITSM) - Amps 100 PPC3100EB 10 1 1 05179.R0 8/02 10 100 Surge Current Duration - Full Cycles 3 1,000 www.protekdevices.com PPC3100EB PACKAGE OUTLINE & DIMENSIONS PACKAGE OUTLINE TO-92 TC MEASURING POINT A N DIMENSIONS DIM A B D E F G H J K L M N B PIN 1 PIN 3 E M H G L F D MILLIMETERS MIN MAX 4.47 12.70 2.41 3.81 1.16 3.43 2.23 4.47 2.23 0.38 0.33 - 4.98 2.67 1.37 3.68 2.44 4.73 2.44 0.51 0.43 1.52 INCHES MIN MAX 0.176 0.500 0.095 0.150 0.046 0.135 0.088 0.176 0.088 0.015 0.013 - 0.196 0.105 0.054 0.145 0.096 0.186 0.096 0.020 0.017 0.060 NOTES: 1. All leads insulate from case. Case is electrically nonconductive. K J 06031 Rev 0 - 4/02 PART NUMBER SUFFIXES USED FOR TAPE & REEL/BULK ORDERING: Surface mount product is taped and reeled in accordance with EIA-481. Suffix-T13 = 13 Inch Reel - 3,000 pieces per reel i.e: PPC3100EB -T13 ProTek Devices 2929 South Fair Lane, Tempe, AZ 85282 Tel: 602-431-8101 Fax: 602-431-2288 E-Mail: [email protected] Web Site: www.protekdevices.com COPYRIGHT © ProTek Devices 2001 SPECIFICATIONS: ProTek reserves the right to change the electrical and or mechanical characteristics described herein without notice (except JEDEC). DESIGN CHANGES: ProTek reserves the right to discontinue product lines without notice, and that the final judgement concerning selection and specifications is the buyer’s and that in furnishing engineering and technical assistance, ProTek assumes no responsibility with respect to the selection or specifications of such products. 05179.R0 8/02 4 www.protekdevices.com